Alternative solid carbon source from dried attached-growth biomass for nitrogen removal enhancement in intermittently aerated moving bed sequencing batch reactor

The feasibility of using dried attached-growth biomass from the polyurethane (PU) foam cubes as a solid carbon source to enhance the denitrification process in the intermittently aerated moving bed sequencing batch reactor (IA-MBSBR) during the treatment of low COD/N containing wastewater was investigated. By packing the IA-MBSBR with 8 % (v/v) of 8-mL PU foam cubes saturated with dried attached-growth biomass, total nitrogen removal efficiency of 80 % could be achieved for 10 consecutive cycles of operation when the intermittent aeration strategy of consecutive 1 h of aeration followed by 2 h of non-aeration period during the REACT period of the IA-MBSBR was adopted. Negligible release of ammonium nitrogen (NH₄ ⁺–N) and slow-release of COD from the dried biomass would ensure that the use of this solid carbon source would not further burden the treatment system. The slow-releasing COD was found to have no effect in promoting the assimilation process and would also allow the carbon source to be used for many cycles of operation. The ‘carbon-spent’ PU foam cubes could be reused by merely drying at 60 °C at the end of the operational mode. Thus, the dried attached-growth biomass formed on the PU foam cubes could be exploited as an alternative solid carbon source for the enhancement of denitrification process in the IA-MBSBR.     

Performance change during long-term ozonation aimed at augmenting denitrification and decreasing waste activated sludge

Partial ozonation of return activated sludge for waste sludge minimization and soluble COD production was examined. Two nitrifying sequencing batch reactors, one control and one ozonated, were operated under alternating anoxic/aerobic conditions. During the first steady-state period of 95-136 d of ozonation, the amount of wasted solids decreased with the ozone dose up to 25%, generating soluble COD by cell lysis. However, during a subsequent period of 190-232 d of continuous ozonation, the effect of solids destruction and COD production decreased by 50%. The investigations of extracellular polymers content and floc shape analyses showed that, after prolonged daily ozone treatment, sludge floc structure becomes stronger, denser, and more ozone-resistant. The findings suggest that, for prolonged operation of partial sludge ozonation, an increase in ozone doses may be required to continuously maintain the expected solids destruction level. This in turn will increase the operational costs of the treatment.     

不同碳源添加量对垂直流人工湿地污水处理效果的影响

以垂直流人工湿地小试系统为研究对象,采用碱处理过的千屈菜(Lythrum salicaria)作为反硝化碳源补充材料,探讨了不同碳源添加量对系统COD及氮、磷去除效果的影响。结果表明,一定剂量经过碱处理的千屈菜材料可以为人工湿地系统脱氮提供反硝化所需要的碳源,而且具有缓效持续释放的特点。添加此碳源材料可明显提高系统的脱氮效率,最高可提升30.85%,但随着C/N比的增加,硝态氮去除率逐渐降低,C/N比为3、5、8时分别为91.20%、87.72%和84.19%。添加碳源量达到C/N比为3时系统能够发生最大程度反硝化,此时不仅人工湿地系统脱氮效果得到提高,同时人工湿地除磷能力也有所增强。碱处理过的千屈菜材料在本系统中的最适宜添加量为5 g,即100 g/m2(C/N=3),远低于在进水中为满足反硝化所需调控的C/N比(5～8),可以节约外加碳源成本。     

Dairy manure treatment, digestion and nutrient recovery as a phosphate fertilizer

A combined approach of biological treatment, solids digestion and nutrient recovery was tested on dairy manure. A sequencing batch reactor (SBR) was operated in three modes, in order to optimize nutrient (nitrogen and phosphorus) removals. The highest average removal efficiencies of 91% for NH4-N, 59% for PO4-P and 80% for total chemical oxygen demand (COD) were achieved. Staining experiments suggested the coexistence of glycogen and phosphorus accumulating organisms. Anaerobic digestion of wasted bio-solids was able to produce a PO4-P concentration of 70 mgL-1 in the supernatant. A pilot-scale experiment, designed to recover phosphorus in the supernatant as struvite (magnesium ammonium phosphate), was able to remove 82% of soluble PO4-P.     

A cascade of anoxic and oxic fluidized bed biofilm reactors for treatment of synthetic municipal wastewater

In this study, a cascade of anoxic and oxic fluidized bed biofilm reactors system was carried out to treat synthetic municipal wastewater. The parameters of the influent flow rates and C/N ratios were discussed. System performance was acceptable for chemical oxygen demand (COD), ammonia, and total nitrogen removal. A decrease of ammonia and total nitrogen removal efficiencies, however, was observed when the influent flow rates increased to 5.04 and 6.12 1 h(-1). Total nitrogen removal decreased at the influent C/N ratio of 3:1. The measured ratios of COD reduction in the anoxic column to nitrogen removal through nitrification-denitrification were 3.7, 3.5, 3.3, and 3.1 g COD/g(-1) N on average when the influent C/N ratios changed from 6:1 to 3:1. The observed sludge yield (Yobs) was 0.169 g VSS g COD(-1) because of perfect denitrification in the anoxic column and the relatively long solids retention time.     

畜禽养殖废水生物处理剩余污泥臭氧减量过程中的重金属释放简

采用臭氧氧化污泥减量法对畜禽养殖废水SBR中的剩余污泥进行处理。当臭氧反应时间控制在30 min时,污泥的溶解比例在30%左右（以 MLSS计）。上清液中一定量的SCOD溶出可为生物处理单元提供充足的碳源,同时在上清液中,TN、TP及水相重金属浓度增加有限,臭氧氧化后的污泥液回流污水处理系统后造成的N、P处理负荷较小,重金属对污泥微生物的活性抑制风险较低。若继续延长臭氧的反应时间,上清液SCOD、TN、TP以及重金属Cu、Pb的释放速率明显增加,同时上清液的C/N降低,臭氧化后的污泥液回流反而不利于生物单元的脱氮处理。综合考虑TN、TP及水相重金属浓度增加的危害性,臭氧反应时间应控制在30 min,臭氧实际投加量应为123.1 mg O₃/g SS。     

Simultaneous nitrification and denitrification of municipal wastewater in aerobic membrane bioreactors.

Simultaneous nitrification-denitrification (SND) of municipal wastewater was investigated in a laboratory-scale membrane bioreactor (MBR) operated at two different hydraulic retention times (HRTs), 0.5 and 1 day, dissolved oxygen 3.0 to 0.5 mg/L, and solids retention time (SRT) between 28 and 120 days. The organic loading rate (OLR) (0.11 to 0.64 kg chemical oxygen demand [COD]/m3/d) and influent soluble COD (SCOD)/ total Kjeldahl nitrogen (TKN) ratio (5 to 19) were varied by the addition of glucose. The ammonia-nitrogen and TKN removals were over 97%, and total nitrogen removal was approximately 89% in the MBR. The maximum specific nitrification rates (98 mg N/d/g VSS) and specific denitrification rates (81 mg N/d/g VSS) occurred at an SCOD/TKN ratio of 9.1. The optimum conditions for maximum total nitrogen removal by SND in a single reactor MBR have been found to be low dissolved oxygen (< 0.6 mg/L) and high OLR (approximately 0.64 kg COD/m3/d) at an HRT of 0.5 day and SRT of approximately 85 days.     

畜禽养殖废水生物处理剩余污泥臭氧减量过程中的重金属释放

采用臭氧氧化污泥减量法对畜禽养殖废水SBR中的剩余污泥进行处理。当臭氧反应时间控制在30min时,污泥的溶解比例在30％左右（以MLSS计）。上清液中一定量的SCOD溶出可为生物处理单元提供充足的碳源,同时在上清液中,TN、TP及水相重金属浓度增加有限,臭氧氧化后的污泥液回流污水处理系统后造成的N、P处理负荷较小,重金属对污泥微生物的活性抑制风险较低。若继续延长臭氧的反应时间,上清液SCOD、TN、TP以及重金属cu、Pb的释放速率明显增加,同时上清液的C／N降低,臭氧化后的污泥液回流反而不利于生物单元的脱氮处理。综合考虑TN、TP及水相重金属浓度增加的危害性,臭氧反应时间应控制在30min,臭氧实际投加量应为123．1mg O3／gSS。     

Dairy Manure Treatment,Digestion and Nutrient Recovery as a Phosphate Fertilizer

A combined approach of biological treatment, solids digestion and nutrient recovery was tested on dairy manure. A sequencing batch reactor (SBR) was operated in three modes, in order to optimize nutrient (nitrogen and phosphorus) removals. The highest average removal efficiencies of 91% for NH₄-N, 59% for PO₄-P and 80% for total chemical oxygen demand (COD) were achieved. Staining experiments suggested the coexistence of glycogen and phosphorus accumulating organisms. Anaerobic digestion of wasted bio-solids was able to produce a PO₄-P concentration of 70 mgL^?1 in the supernatant. A pilot-scale experiment, designed to recover phosphorus in the supernatant as struvite (magnesium ammonium phosphate), was able to remove 82% of soluble PO₄-P.     

A novel design for anaerobic chemical oxygen demand and nitrogen removal from leachate in a semiaerobic landfill

The removal capacity of carbon and nitrogen from an artificial leachate was evaluated by using laboratory-scale columns, and a design was proposed to remove nitrogen more efficiently from a semiaerobic landfill. Five columns (i.e., two artificial municipal waste columns under anaerobic and semiaerobic conditions, an artificial construction waste column under semiaerobic conditions, and two crushed stone columns under anaerobic and semiaerobic conditions) were used. The influent load rates of organics [g chemical oxygen demand (COD)/m3 x day], NH4+, NO3- and aeration conditions for the columns were varied, and the removal capacities of the columns for COD, NH4+-N, and NO3--N were measured. Among the packed column materials, crushed stone was shown to be most effective in removing COD, NH4+ N, and NO3--N from artificial leachate. Average removal rates of crushed column under the semiaerobic condition (column D) for COD and NH4+-N were estimated at about 150 g COD/m3 x day and 20 g COD/m3 x day, while those of crushed column under anaerobic condition (column E) for COD and NO3--N at about 400 and 150 g COD/m3 x day, respectively. It also was found that denitrification and nitrification reactions in column D occurred at the same time, and the ratio of denitrification to nitrification was estimated to be about 80%. Therefore, an anaerobic structure, which could be attached to the bottom of a main pipe in a semiaerobic landfill, is suggested to remove nitrogen and organic substances more effectively.     

Effects of elevated CO2 nitrogen supply and tropospheric ozone on spring wheat. I. Growth and yield

Spring wheat (Triticum aestivum L. cv. Minaret) was exposed to three CO(2) levels, in combination with two nitrogen fertilizer levels and two levels of tropospheric ozone, from sowing to ripening in open-top chambers. Three additional nitrogen fertilizer treatments were carried out at the lowest and the highest CO(2) level, respectively. Plants were harvested at growth stages 31, 65 and 93 and separated into up to eight fractions to gain information about biomass partitioning. CO(2) enrichment (263 microl litre(-1) above ambient levels) drastically increased biomass of organs serving as long-term carbohydrate pools. Peduncle weight increased by 92%, stem weight by 73% and flag leaf sheath weight by 59% at growth stage 65. Average increase in shoot biomass due to CO(2) enrichment amounted to 51% at growth stage 65 and 36% at final harvest. Average yield increase was 34%. Elevated nitrogen application was most effective on biomass of green tissues. Yield was increased by 30% when nitrogen application was increased from 150 to 270 kg N ha(-1). Significant interactions were observed between CO(2) enrichment and nitrogen application. Yield increase due to CO(2) ranged from 23% at 120 kg N to 47% at 330 kg N. Triticum aestivum cv. Minaret was not very responsive to ozone at 1.5 times ambient levels. 1000 grain weight was slightly decreased, which was compensated by an increased number of grains.     

碳氮比对人工湿地污水处理效果的影响

采用表面流人工湿地系统静态小试装置,考察了低、中、高3组不同进水COD/N(2,5,10)对系统中氮、磷及COD去除效果的影响。结果表明:进水C/N的变化对COD的去除率影响不大,平均去除率达到94.6%。TN的去除率随着COD/N的增大而逐渐升高,在C/N=5时达到63.8%,继续提高COD/N,TN的去除率变化不大。NH4+-N去除率随着COD/N的增加而降低。随着碳源的增加,释磷菌能够从进水中获得充足的碳源,从而可以比较充分地释磷,因此,磷的去除率随COD/N的增加而提高。     

Enhanced excess sludge hydrolysis and acidification in an activated sludge side-stream reactor process with single-stage sludge alkaline treatment: a pilot scale study

A pilot-scale side-stream reactor process with single-stage sludge alkaline treatment was employed to systematically investigate characteristics of excess sludge hydrolysis and acidification with alkaline treatment and evaluate feasibility of recovering a carbon source (C-source) from excess sludge to enhance nutrient removal at ambient temperature. The resulting C-source and volatile fatty acid specific yields reached 349.19 mg chemical oxygen demand (COD)/g volatile suspended solids (VSS) d⁻¹ and 121.3 mg COD/g VSS d⁻¹, respectively, the process had excellent C-source recovery potential. The propionic-to-acetic acid ratio of the recovered C-source was 3.0 times that in the influent, which beneficially enhanced biological phosphorus removal. Large populations and varieties of hydrolytic acid producing bacteria cooperated with alkaline treatment to accelerate sludge hydrolysis and acidification. Physicochemical characteristics indicated that recovered C-source was derived primarily from extracellular polymeric substances hydrolysis rather than from cells disruption during alkaline treatment. This study showed that excess sludge as carbon source was successfully recycled by alkaline treatment in the process.

     

Aerobic Treatment of a Nitrogen-Limited Chemical Process Waste water

Abstract

Nitrogen transformations and their effect on aerobic suspended growth treatment of an industrial wastewater were studied in three parallel bench-scale reactors operated at 5 "C at mean cell residence times (MCRT) of 15, 30, and 60 days. In normal process wastewater, the bulk of influent nitrogen was in organic form, and the fraction transformed was almost totally incorporated into synthesized biomass. Assimilative control by heterotrophs maintained ammonianitrogen levels below permitted effluent levels, and nitrification was not significant. Although volatile suspended solids had a nitrogen content of only 5% to 8%, effective organics removal was maintained, and total organic carbon and filtered daily average five-day biochemical oxygen demand (BODS) were below permitted effluent levels. A marked improvement in settleability and lower effluent total suspended solids was achieved by adding ammonia-nitrogen to the wastewater in excess of stoichiometric growth requirements.

During a batch production cycle of a cationic chemical, the ratio of nitrogen to chemical oxygen demand and the fraction of the total influent nitrogen in soluble form increased in the wastewater. Reactor effluent ammonia levels increased to above permit levels at all three MCRTs during treatment of wastewater containing cationic production effluents. The magnitude of ammonia increase was greater for longer MCRTs, suggesting that synthesis of cell mass was not capable of assimilating the increased ammonia supply under these non-steady conditions. The experimental results suggest several potential strategies for operating the aerobic process at the treatment facility, including adding nitrogen to improve settleability and discontinuing these additions when wastewater contains a high ratio of nitrogen to chemical oxygen demand and an elevated soluble nitrogen fraction     

温度对木质纤维素水解与挥发性脂肪酸累积的影响

木质纤维素厌氧消化过程产生的挥发性脂肪酸（VFAs）可作为外加碳源投加到人工湿地,解决人工湿地反硝化碳源不足的问题,但温度对木质纤维素厌氧消化生产VFAs过程的影响还有待深入探明。考察上述木质纤维素厌氧消化过程中有机碳源、糖与VFAs的变化规律,试图探明温度（10-55℃）对木质纤维素水解与VFAs累积的影响。研究结果表明,温度升高对木质纤维素的水解具有促进作用,对VFAs产量的影响显著。35℃时是生物质发酵产酸的最优条件,VFAs累积量不仅最早（第10天）达到最高值154mgCOD／g生物质,而且碳源的数量和品质均达到较高的水平。     

碳源类型及进水量分配对CMICAO工艺脱氮除磷的影响

研究了分别以葡萄糖和乙酸钠为碳源时多点交替进水阶式A2/O(CMICAO)工艺氮磷的去除效果,以及在不同进水C/N比时各进水量分配对脱氮除磷效果的影响.结果表明,在相同的进水COD浓度下,乙酸钠比葡萄糖更适合作为碳源,更能提高脱氮除磷效率.以葡萄糖为碳源时,COD为200 mg/L、C/N比为5、缺氧池与厌氧池进水配比为1∶2时,出水COD、TN、氨氮和TP浓度分别为28.5、10.8、2.1和0.5 mg/L,均达到国家一级A排放标准.若采用葡萄糖作为碳源,投加量以使进水C/N比为5～7.5为宜,外加碳源时缺氧池与厌氧池进水分配比可统一采用1∶1.     

以剩余污泥水解酸化液为外加碳源的污水生物脱氮

为解决低碳氮比污水生物脱氮过程反硝化碳源不足的问题,利用剩余污泥水解酸化液为外加碳源,通过具有曝气段与非曝气段的一体化曝气生物滤池（BAF）,研究低碳氮比污水生物脱氮的性能与工艺条件。实验结果表明,预处理后的水解酸化液VFAs为3134．9～5251．4mg／L、ThODVFAs／COD为59．87％～91．85％,适合作为生物脱氮的外加碳源;水解酸化液的投配量、进水TN浓度对系统生物脱氮效果的影响较大,气水比、曝气段与非曝气段比例对系统的硝化和反硝化性能有重要的影响;在温度为25±1℃,水解酸化液COD平均为7555．1mg／L,进水TN、NH4-N和COD分别平均为43．88mg／L、39．04mg／L和56．8mg／L,碳源与污水投配的流量比为1：75的条件下,当BAF水力停留时间（HRT）为8h、曝气段与非曝气段比例为3：3、气水比为10：1、回流比为2：1时,NH4-N和TN的去除率分别超过98％和75％,出水COD平均为28．6mg／L。研究指出,剩余污泥水解酸化液经过预处理后可用作低碳氮比污水生物脱氮的外加碳源,有效地提高了反硝化效果,并不会造成二次污染,同时又可以实现剩余污泥的减量化和资源化。     

Micro-electrolysis/retinervus luffae-based simultaneous autotrophic and heterotrophic denitrification for low C/N wastewater treatment

Nitrogen bioremediation in organic insufficient wastewater generally requires an extra carbon source. In this study, nitrate-contaminated wastewater was treated effectively through simultaneous autotrophic and heterotrophic denitrification based on micro-electrolysis carriers (MECs) and retinervus luffae fructus (RLF), respectively. The average nitrate and total nitrogen removal rates reached 96.3 and 94.0% in the MECs/RLF-based autotrophic and heterotrophic denitrification (MRAHD) system without ammonia and nitrite accumulation. The performance of MRAHD was better than that of MEC-based autotrophic denitrification for the wastewater treatment with low carbon nitrogen (COD/N) ratio. Real-time quantitative polymerase chain reaction (qPCR) revealed that the relative abundance of nirS-type denitrifiers attached to MECs (4.9%) and RLF (5.0%) was similar. Illumina sequencing suggested that the dominant genera were Thiobacillus (7.0%) and Denitratisoma (5.7%), which attached to MECs and RLF, respectively. Sulfuritalea was discovered as the dominant genus in the middle of the reactor. The synergistic interaction between autotrophic and heterotrophic denitrifiers played a vital role in the mixotrophic substrate environment.     

Microbial activity in a combined UASB-activated sludge reactor system

A combined upflow anaerobic sludge bed-activated sludge (UASB-AS) reactor system with consistently wasting of excess biomass was used to treat suspended-solids pre-settled piggery wastewater (COD=2000 mg l(-1), total Kjeldahl nitrogen TKN=400 mg l(-1), suspended solids=250-400 mg l(-1)). Thus, the activity of nitrogen-related microbial groups in each individual bioreactor was investigated. When the granules retention time (GRT) of 20-50 d in the UASB reactor, the solids retention time (SRT) of 10-25 d in the AS reactor and the recycle-to-influent ratio (Re) of 1 were maintained, the combined system removed 95-97% of chemical oxygen demand (COD), 100% of TKN and 54-55% of total nitrogen (TN). Denitrification and methanogenesis occurred in the UASB reactor so that both biochemical processes contributed to most of the COD removal and, complete nitrification (most of the TKN removal) occurred in the AS reactor. Compact granules with good settling abilities developed in the UASB reactor, and rapid rates of granulation of break-up granules in the UASB reactor were confirmed by experiments. The activity of nitrifiers and denitrifiers (an=0.68-0.87; adn=0.55-0.70) and the calculated specific nitrification and denitrification rates (qn=0.26-0.47 mg NH4+ -N mg VSS(-1)d(-1); qdn=0.046-0.076 mg NOx- -N mg VSS(-1)d(-1)) significantly increased with decreasing SRT and GRT, respectively. Accordingly, the combined UASB-AS reactor system should be regarded a promising alternative for the removal of organic carbon and nitrogen from piggery wastewater.     

Kinetics of chemoheterotrophic microbially mediated reduction of ferric EDTA and the nitrosyl adduct of ferrous EDTA for the treatment and regeneration of spent nitric oxide scrubber liquor.

Biomass from a prototype reactor was used to investigate the kinetics of chemoheterotrophic reduction of solutions of ferric ethylenediaminetetraacetic acid (EDTA) and solutions containing the nitrosyl adduct of ferrous EDTA using ethanol as the primary electron donor and carbon source. A series of batch experiments were conducted using biomass extracted from the scrubber solution treatment and regeneration stage of a prototype iron EDTA-based unit process for the absorption of nitric oxide with subsequent biological treatment. Using a linear-sweep voltammetric method for analysis of the ferric EDTA concentration, iron-reducing bacteria were found to behave according to the Monod kinetic model, at initial concentrations up to 2.16 g chemical oxygen demand (COD) as ethanol per liter, with a half-velocity constant of 0.532 g COD as ethanol/L and a maximum specific utilization rate of 0.127 mol/L of ferric ethylenediamine-tetraacetic acid [Fe(III)EDTA]*(g volatile suspended solids [VSS]/L)d(-1). Based on batch analyses, biomass yield and endogenous decay values of iron-reducing bacteria were estimated to be 0.055 g VSS/g COD and 0.017 L/d, respectively. An average of 1.64 times the theoretical (stoichiometric) demand of ethanol was used to complete reduction reactions. Kinetics of the reduction of the nitrosyl adduct of ferrous EDTA are summarized by the following kinetic constants: half-velocity constant (Ks) of 0.39 g COD/L, maximum specific utilization rate (k) of 0.2 mol/L [NO x Fe(II)EDTA(2-)](g VSS/L)d(-1), and inhibition constant (K(I)) of 0.33 g COD/L, as applied to the modified Monod kinetic expression described herein. Based on batch analyses, the biomass yield of nitrosyl-adduct-reducing bacteria was estimated to be 0.259 g VSS/g COD, endogenous decay was experimentally determined to be 0.0569 L/d, and an average of 1.26 times the stoichiometric demand of ethanol was used to complete reduction reactions.