Removal of polycyclic aromatic hydrocarbons from manufactured gas plant-contaminated soils using sunflower oil: laboratory column experiments

Laboratory column experiments were performed to remove PAHs (polycyclic aromatic hydrocarbons) from two contaminated soils using sunflower oil. Two liters of sunflower oil was added to the top of the columns (33 cm x 21 cm) packed with 1 kg of PAH-contaminated soil. The sunflower oil was applied sequentially in two different ways, i.e. five additions of 400 ml or two additions of 1l. The influence of PAH concentration and the volume of sunflower oil on PAH removal were examined. A soil respiration experiment was carried out and organic carbon contents of the soils were measured to determine degradability of remaining sunflower oil in the soils. Results showed that the sunflower oil was effective in removing PAHs from the two soils, more PAHs were removed by adding sunflower oil in two steps than in five steps, probably because of the slower flow rate in the former method. More than 90% of total PAHs was removed from a heavily contaminated soil (with a total 13 PAH concentration of 4721 mg kg(-1)) using 4 l of sunflower oil. A similar removal efficiency was obtained for another contaminated soil (with a total 13 PAH concentration of 724 mg kg(-1)), while only 2l was needed to give a similar efficiency. Approximately 4-5% of the sunflower oil remained in the soils. Soil respiration curves showed that remaining sunflower oil was degraded by allowing air exchange and supplying with nutrients. Organic carbon content of the soil was restored to original level after 180 d incubation. These results indicated that the sunflower oil had a great capacity to remove PAHs from contaminated soils, and sunflower oil solubilization can be an alternative technique for remediation of PAH contaminated soils.     

Photo-oxidation of biodegraded crude oil and toxicity of the photo-oxidized products

We investigated the physicochemical changes resulting from irradiation by sunlight of biodegraded crude oil. An Arabian light crude oil sample was first subjected to microbial degradation. n-Alkanes and aromatic compounds such as naphthalenes, fluorenes, dibenzothiophenes and phenanthrenes possessing short, alkyl side chain(s) were almost completely degraded, while the contents of the saturated and aromatic fractions were reduced by 70% and 40%, respectively. This biodegraded oil was then suspended in seawater and exposed to sunlight irradiation for several weeks. The most remarkable change caused by the irradiation was a substantial decline in the aromatic fraction with a concomitant increase in the resin and asphaltene fractions. A 13C-nuclear magnetic resonance (NMR) spectroscopic analysis showed that the aromaticity of the biodegraded oil was significantly lower in the irradiated sample. A field desorption-mass spectrometric (FD-MS) analysis showed that sunlight irradiation reduced the average molecular weight of the oil components and formed oxygenated compounds. Consistent with this observation is that the oxygen content in the oil increased as the irradiation was prolonged. The bioavailability of the biodegraded oil was increased by the photo-oxidation: the growth of seawater microbes was minimal when the non-irradiated biodegraded oil was used as the source of carbon and energy; however, growth was significant when irradiated biodegraded oil was used. The concentration of dissolved organic carbon (DOC) increased linearly during the sunlight irradiation of the biodegraded oil, and this increase was matched by an increase in ultraviolet-absorptive materials in the seawater. The photochemically formed, water-soluble fraction (WSF) showed acute toxicity against the halophilic crustacean, Artemia.     

木屑处置漏油事故的室内模拟

用锯木屑作为吸附材料,0#柴油为吸附对象进行室内模拟实验,研究了木屑对纯油、水中浮油的吸附以及吸油后的木屑在水中的漂浮性能;并以木屑粒径、木屑投加量、振荡频率、油膜厚度为研究指标,设计了5因素4水平的正交实验,考察了各因素对0#柴油的吸附量、去除率以及木屑漂浮率的影响并对优化条件进行了讨论。结果表明,在实验研究范围内,木屑对水中柴油的吸附速度极快,1min即可达到饱和,饱和吸附量为8．08g／g;木屑在水中漂浮性能良好,静态时经72h漂浮,漂浮率维持在92％左右;振荡频率为150r／min时,72h内漂浮率维持在68％以上;最佳吸油条件组合为吸附剂粒径10～20目,振荡频率120r／min,木屑投加量0．7g,油膜厚度1．65mm。     

饮食业复合油烟吸收剂的研制开发

分析了饮食油烟的成分 ,结合饮食油烟气的治理方法 ,采用正交设计法进行新型复合油烟吸收剂的实验 ,快速、有效、准确地优化确定了油烟吸收剂的配方和工艺 ,并设计了该吸收剂的油污相溶性、环境毒性、生物降解性实验 ,科学地论证了该产品的性能。结果表明 ,本实验研制的油烟吸收剂能够全面包络、粘合、皂化、附着和分离油烟废气中的油类物质 ,对饮食油烟具有快速、高效、彻底的治理效果 ,而且无毒、易降解。     

Influence of salinity on bioremediation of oil in soil

Spills from oil production and processing result in soils being contaminated with oil and salt. The effect of NaCl on degradation of oil in a sandy-clay loam and a clay loam soil was determined. Soils were treated with 50 g kg(-1) non-detergent motor oil (30 SAE). Salt treatments included NaCl amendments to adjust the soil solution electrical conductivities to 40, 120, and 200 dS m(-1). Soils were amended with nutrients and incubated at 25 degrees C. Oil degradation was estimated from the quantities of CO(2) evolved and from gravimetric determinations of remaining oil. Salt concentrations of 200 dS m(-1) in oil amended soils resulted in a decrease in oil mineralized by 44% for a clay loam and 20% for a sandy-clay loam soil. A salt concentration of 40 dS m(-1) reduced oil mineralization by about 10% in both soils. Oil mineralized in the oil amended clay-loam soil was 2-3 times greater than for comparable treatments of the sandy-clay loam soil. Amending the sandy-clay loam soil with 5% by weight of the clay-loam soil enhanced oil mineralization by 40%. Removal of salts from oil and salt contaminated soils before undertaking bioremediation may reduce the time required for bioremediation.     

秸秆固定化石油降解菌降解原油的初步研究

用秸秆做载体固定嗜碱芽孢杆菌(Bacillus alcalophilus SG)降解原油,其原油去除率为73.88%,高于单纯投加菌液或者菌液与秸秆的混合物的原油去除率.秸秆的最佳投加量(干重)为25.0 g/L,最佳固定化时间为30 h.用预处理过的秸秆固定SG,降低了固定化SG的原油去除率.在固定化培养基中添加无机盐离子,促进了固定化SG对原油的降解.不同初始pH的原油培养基在固定化SG降解原油的过程中逐渐呈中性或偏碱性.固定化SG在pH 6.0～10.0时对原油均有不错的降粘能力.     

含油污泥焦化液相油收率影响因素研究

油田产生的高含油污泥,采用催化焦化的方法进行处理,回收其中的原油,分析了影响含油污泥焦化液相油收率的主要因素,采用正交和单因素实验方法对各因素进行考察,确定了高液相油收率的含油污泥焦化操作条件;处理后的焦化固体产物能够达到农用污泥标准。     

Use of biomass sorbents for oil removal from gas station runoff

The use of biomass sorbents, which are less expensive and more biodegradable than synthetic sorbents, for oil removal from gas station runoff was investigated. A bench-scale flume experiment was conducted to evaluate the oil removal and retention capabilities of the biomass sorbents which included kapok fiber, cattail fiber, Salvinia sp., wood chip, rice husk, coconut husk, and bagasse. Polyester fiber, a commercial synthetic sorbent, was also experimented for comparison purpose. Oil sorption and desorption tests were performed at a water flow rate of 20 lmin-1. In the oil sorption tests, a 50 mgl(-1) of used engine oil-water mixture was synthesized to simulate the gas station runoff. The mass of oil sorbed for all sorbents, except coconut husk and bagasse, was greater than 70%. Cattail fiber and polyester fiber were the sorbents that provided the least average effluent oil concentrations. Oil selectivity (hydrophobic properties) and physical characteristics of the sorbents are the two main factors that influence the oil sorption capability. The used sorbents from the sorption tests were employed in the desorption tests. Results indicated that oil leached out of all the sorbents tested. Polyester fiber released the highest amount of oil, approximately 4% (mass basis) of the oil sorbed.     

Combined chemical and biological treatment of oil contaminated soil

Combined chemical (Fenton-like and ozonation) and biological treatment for the remediation of shale oil and transformer oil contaminated soil has been under study. Chemical treatment of shale oil and transformer oil adsorbed in peat resulted in lower contaminants' removal and required higher addition of chemicals than chemical treatment of contaminants in sand matrix. The acidic pH (3.0) conditions favoured Fenton-like oxidation of oil in soil. Nevertheless, it was concluded that remediation of contaminated soil using in situ Fenton-like treatment will be more feasible at natural soil pH. Both investigated chemical processes (Fenton-like and ozonation) allowed improving the subsequent biodegradability of oil. Moderate doses of chemical oxidants (hydrogen peroxide, ozone) should be applied in combination of chemical treatment (both, Fenton-like or ozonation) and biotreatment. For remediation of transformer oil and shale oil contaminated soil Fenton-like pre-treatment followed by biodegradation was found to be the most efficient.     

The biodegradation of cable oil components: impact of oil concentration, nutrient addition and bioaugmentation

The effect of cable oil concentration, nutrient amendment and bioaugmentation on cable oil component biodegradation in a pristine agricultural soil was investigated. Biodegradation potential was evaluated over 21 d by measuring cumulative CO₂ respiration on a Micro-Oxymax respirometer and ¹⁴C-phenyldodecane mineralisation using a ¹⁴C-respirometric assay. Cable oil concentration had a significant effect upon oil biodegradation. Microbial respiratory activity increased with increasing cable oil concentration, whereas ¹⁴C-phenydodecane mineralisation decreased. Bioaugmentation achieved the best cable oil biodegradation performance, resulting in increases in cumulative CO₂ respiration, and maximum rates and extents of ¹⁴C-phenyldodecane mineralisation. Generally, nutrient amendment also enhanced cable oil biodegradation, but not to the extent that degrader amendment did. Cable oil biodegradation was a function of (i) cable oil concentration and (ii) catabolic ability of microbial populations. Bioaugmentation may enhance cable oil biodegradation, and is dependent upon composition, cell number and application of catabolic inocula to soil.     

14C-dimethoate residues in olive oil during oil processing

An olive tree was treated twice in the field with 14C-dimethoate (237.7 muCi, 2.4 g) and 14C residues were determined in the olive fruits at harvest. The fruits were crushed and pressed to extract the crude oil, then refined by neutralization, bleaching and deodorization. The crude oil contained 14.1% of the total 14C in the olive fruits. Neutralization resulted in a reduction of 14C by about 50% of the total 14C residues in oil. Bleaching and deodorization processes further reduced the 14C residues and the refined oil contained 31.6% (which corresponds to 4.4% of 14C residues of the total 14C in olive fruits) of the total 14C in the crude oil. Industrially extracted crude oil was fortified with 14C-dimethoate at 1.8 mg kg-1 (0.02 muCi) level and subjected to the same refining process. A sharp decrease in the amount of 14C was observed by neutralization and the amount of 14C remaining in the refined oil was about 7.3% of the total 14C in the crude fortified oil. The data suggest that the 14C residues in the aged and the fortified oil amples were not of the same nature. The terminal 14C residue in the refined oil obtained from the field experiment did not contain dimethoate and/or its oxon.     

Optimization and treatment of wastewater of crude oil desalting unit and prediction of scale formation

In this article, one of Iran’s southwest oil fields that produces 3200 barrels per day (bbl/d) of wastewater from oil and gas processing was investigated. Experimental analysis of oil reservoir water and desalting wastewater disposal of crude oil desalting unit was performed. First, water was treated with a reverse osmosis membrane. As a result, the purified water, with lower total dissolved solids (TDS) and pH, was a suitable candidate for injection into the adjacent wells of the crude oil desalting unit. The effectiveness and compatibility of this wastewater to the formation water of the oil field wells were simulated. Finally, we studied and identified the formation, the amount, and the type of mineral scale deposits. These are the most important problems during water injection into the wells. The analysis shows that the refined water from the reverse osmosis (RO) process was a suitable and low-cost economical option for injection in onshore and offshore fields, due to the low amount of salts, the concentration of susceptible ions in scaling formation, and the appropriate pH. This oil field, which is in the second half of life, requires enhanced oil recovery methods (EOR) for the maintenance of pressure and an increase in oil recovery.

     

石油降解菌的筛选及其降解能力的研究

从广州石化污水处理厂废水中自行分离出 30株除油菌 ,用市售的 90 # 柴油作为油品进行筛选 ,所得菌种用于处理石化厂物理隔油后的废水。通过研究含油量和接种量对除油率、COD的去除率和pH值的影响以及酸、碱、盐对除油率和COD去除率的影响来比较这些菌种对石化废水的处理效果。结果表明 ,6 # 菌株除油和去除有机物的效果都比较好 ,除油率约在 70 %左右 ,最高为 83.6 7% ,COD去除率约为 5 5 %左右 ,最高为 6 0 .0 1% ;5 # 菌株对环境要求较高 ,在碱性环境下表现出较好的除油和去除有机物的能力 ,除油率和COD去除率分别为 5 5 %和 5 0 %左右。实验菌株在消除石化废水的异味方面也有一定的效果。     

Toxicity of crude oil to the mayfly, Hexagenia bilineata (Ephemeroptera: Ephemeridae)

Effects of crude oil on survival and behavior of the mayfly Hexagenia bilineata were evaluated in laboratory studies. Mayfly nymphs were exposed to the water soluble and oil residue fractions of crude oil. Mayfly survival was not reduced by a 96-h exposure to either the water soluble fraction or the oil residue mixed with sediment. However, significant mortality did result from a 21-day exposure to oil residue mixed with sediment at concentrations as low as 500 microg g(-1). Survival was also reduced after a 21-day exposure to oil-contaminated sediments (1905 microg g(-1)) collected 6 weeks after a crude oil spill in the Chariton River, Missouri. In a behavioral test measuring habitat exclusion, organisms did not avoid contact with sediment containing oil residue (50-800 microg g(-1)). Collectively, results from these studies indicate that exposure to oil residue in sediment will reduce survival of H. bilineata in the laboratory and may reduce survival in the environment for 6 weeks or more after an oil spill.     

西北黄土地区现场石油污染土壤生物修复研究

通过在陕北安塞油田某废弃油井建立中试试验基地,以实验室中筛选分离得到的高效降解石油的优势菌为添加的高效菌,研究土壤石油初始浓度、营养物质和高效菌对石油降解的影响.结果表明:(1)在各土壤石油初始浓度下,石油降解率总体均随降解时间的延长而升高.在土壤石油初始质量浓度为15.34 g/kg下,72 d时石油降解率为47.8...     

Concentrations of organochlorine insecticides in edible oils from different regions of India

In this study, organochlorine insecticides (OCPs), DDT metabolites and HCH isomers were quantified in mustard, groundnut and sunflower oils collected from different regions of India. The maximum level of 222.0 ng g(-1) and minimum level of 0.2 ng g(-1) of SigmaDDT were detected in mustard oil from Deoria and Varanasi while those of SigmaHCH i.e., 1500 ng g(-1) and 8.0 ng g(-1) in mustard oil from Deoria and Kanpur, respectively. However, the maximum total concentration of alpha-, beta- and gamma-HCH was in mustard oil, whereas maximum delta-HCH was in groundnut oil. However, the maximum percentage of p,p'-DDT was in mustard oil while maximum p,p'-DDE was in groundnut oil. The study calls for periodical monitoring to ensure safe supply of edible oils to consumers.     

Tween-80和H2O2对Burkholderia cepacia降解油脂的影响

油脂废水是一种重要的水污染源。研究了表面活性剂和H₂O₂对洋葱伯克霍尔德氏菌(Burkholderia cepacia)降解油脂的影响。结果表明：适量的表面活性剂和H₂O₂促进油脂的降解。表面活性剂可以增强油脂在水相中的溶解度，提高油脂在水中的乳化程度从而增加其生物可利用性。当Tween-80浓度600mg/L时，油脂降解率达到91%。低浓度H₂O₂不仅能刺激微生物生长，而且使培养液中的pH值保持相对稳定，提高了微生物对油脂的降解率。H₂O₂在浓度为400mg/L时，能使油脂降解率达到90%。     

Anti-oxidative property of crude rice oil extracted from cadmium-contaminated rice

Local residents who habitually consume cadmium-contaminated rice (Oryza sativa L.) can be exposed to cadmium toxicity in Mae Sot District, Tak Province, Thailand. This study aimed to investigate an alternative for utilizing cadmium-contaminated rice without compromising their health with hazard risks. First, cadmium (Cd) concentration in rice grain and crude rice oil was determined (0.203 ± 0.030 and 0.007 ± 0.002 mgCd/kg dry weight, respectively). Then crude rice oil extracted from cadmium-contaminated rice grain was studied for its anti-oxidative property using the 2,2-diphenyl-1-picrylhydrazyl (DPPH) free radical scavenging approach. Next, quantitative analysis of γ-oryzanol in crude rice oil was conducted. Results indicated that the level of cadmium concentration in the rice grain could cause adverse effects on human health. However, the amount of cadmium in the crude rice oil was safe for consumption. In crude rice oil anti-oxidative property, crude rice oil extracted from cadmium-contaminated rice was significantly higher than the control (P < 0.05). The concentration of γ-oryzanol in crude rice oil extracted from cadmium-contaminated rice was significantly higher than that in the control crude rice oil (P < 0.05). This study demonstrates an alternative way to use the rice grown in cadmium-contaminated areas for crude rice oil production for its anti-oxidative properties.     

Pyrolysis of oil sludge in a fluidised bed reactor

The oil sludge of tanker cleaning was pyrolysed in fluidised bed reactors. Three experiments were conducted in a laboratory plant and two on a technical plant. Separation of oil from the solids and distribution of the oil products were investigated at temperatures from 460 degrees C to 650 degrees C. Between 70% and 84% of the oil could be separated from the solids. Distribution of the oil products depended on the feed material and the pyrolysis conditions. The higher the temperature the more the oil was cracked into low boiling compounds. Under the conditions of pyrolysis carbon reduced gridiron to iron. Thus some solid fractions were pyrophoric and oxidised with high heat generation. Therefore the solid products have to be turned into inert substances. The fluidised bed pyrolysis is an adequate process to recycle oil sludge with high yields.     

核桃壳过滤器与超滤对宁化排水的除油研究

采用核桃壳过滤器与超滤组合工艺的中试装置处理宁夏石化总排放水,考察了该工艺对石化废水中油分的处理效果,并且使用模拟废水考察了该工艺对油污染负荷的抗冲击能力.实验结果表明,核桃壳过滤器与超滤组合工艺对石化总排水中油以及油类造成的COD都有较好的处理效果,并且具备一定的抗污染冲击能力.