城市下水污泥焚烧过程中二次污染物排放特性的试验研究

在0.15 MWt循环流化床燃烧试验台上进行了城市下水污泥与煤的混烧试验,分析了烟气中的二次污染物排放特性.分析结果表明,利用循环流化床焚烧城市下水污泥时,添加辅助燃料(如煤)及改变焚烧条件,不仅可以达到稳定燃烧的目的,而且有利于抑制焚烧中二次污染物(如CO及二恶英等有机污染物)的生成.分析了焚烧污泥污染物的排放特性,为采用焚烧方式处理城市下水污泥提供了基础性试验数据.     

城市下水污泥焚烧过程中二次污染物排放特性的试验研究

在0．15MWt循环流化床燃烧试验台上进行了城市下水污泥与煤的混烧试验，分析了烟气中的二次污染物排放特性。分析结果表明，利用循环流化床焚烧城市下水污泥时，添加辅助燃料（如煤）及改变焚烧条件，不仅可以达到稳定燃烧的目的，而且有利于抑制焚烧中二次污染物（如CO及二恶英等有机污染物）的生成。分析了焚烧污泥污染物的排放特性。为采用焚烧方式处理城市下水污泥提供了基础性试验数据。     

Reduction in greenhouse gas emissions from sludge biodrying instead of heat drying combined with mono-incineration in China

Sludge is an important source of greenhouse gas (GHG) emissions, both in the form of direct process emissions and as a result of indirect carbon-derived energy consumption during processing. In this study, the carbon budgets of two sludge disposal processes at two well-known sludge disposal sites in China (for biodrying and heat-drying pretreatments, both followed by mono-incineration) were quantified and compared. Total GHG emissions from heat drying combined with mono-incineration was 0.1731 tCO₂e t^?1, while 0.0882 tCO₂e t^?1 was emitted from biodrying combined with mono-incineration. Based on these findings, a significant reduction (approximately 50%) in total GHG emissions was obtained by biodrying instead of heat drying prior to sludge incineration.

Implications: Sludge treatment results in direct and indirect greenhouse gas (GHG) emissions. Moisture reduction followed by incineration is commonly used to dispose of sludge in China; however, few studies have compared the effects of different drying pretreatment options on GHG emissions during such processes. Therefore, in this study, the carbon budgets of sludge incineration were analyzed and compared following different pretreatment drying technologies (biodrying and heat drying). The results indicate that biodrying combined with incineration generated approximately half of the GHG emissions compared to heat drying followed by incineration. Accordingly, biodrying may represent a more environment-friendly sludge pretreatment prior to incineration.     

Assessing potential risks to wildlife and sportsmen from exposure to dioxin in pulp and paper mill sludge spread on managed woodlands

Potential human and wildlife exposures to TCDD in landspread pulp and paper mill sludge in the State of Maine were evaluated by means of a human health and an ecological risk assessment methodology. The highest historical concentrations of TCDD reported for these sludges do not present a risk to American woodcock, selected as an indicator species for this analysis. Concentrations of TCDD as high as 50 ppt in soil are not likely to produce adverse effects in the embryonic/hatchling stage of the woodcock. This soil concentration of TCDD does not present a significant risk to sportsmen and their families that may consume birds which inhabit these sites.     

Vitrification Process for Treatment of Sewage Sludge and Incineration Ash

ABSTRACT

Vitrification processes, in which the operating temperature is higher than the melting point of the silica compounds contained in sewage sludge that turns into slag, are studied in this paper. The dried sludge and the incineration ash are injected into a furnace with auxiliary fuel and flux. The flux is the material used to control basicity of the ash content. Crushed limestone is used as the flux in this test. Almost all ashes in the sludge are vitrificated into slag. The flow of molten slag from the tap is smooth. After the slag is treated, it can be used as wall tile, interlocking tile, insulating material, and slag wool. This technology conforms to resource recycling.     

苏州市生活垃圾两种处置方法的生命周期影响评价

采用生命周期评价的方法,比较了苏州市垃圾填埋和垃圾焚烧2种处置方法对环境的影响。研究的系统范围主要包括垃圾收集、垃圾运输、垃圾填埋或焚烧以及发电等几个部分。采用收集的垃圾组分数据,利用IPCC推荐的模型等,计算了垃圾填埋和垃圾焚烧时CO₂等气体污染物的排放量。根据对垃圾渗滤液的实测数据,计算了水污染物的排放量。环境影响评价采用日本开发的AIST-LCA Ver4计算机软件进行。计算结果表明：垃圾填埋的生态币值要大得多,可见垃圾焚烧对环境的影响比垃圾填埋的影响要小。所获得的结论较为客观地反映了对环境的影响,可以作为中国城市垃圾处置决策的参考依据。     

污水处理厂污泥干化焚烧处理可行性分析

以绍兴污水处理厂脱水污泥为研究对象,通过实验分析了污泥进行干化焚烧处理的可行性。对污泥泥质进行分析,采用桨叶式污泥干化机对污泥的热干化特性、干化过程污染排放特性进行研究,使用流化床污泥焚烧试验装置对污泥焚烧工况及焚烧过程中污染物的排放特征进行研究,结果表明,绍兴污水处理厂脱水污泥的泥质特征与大多数污水污泥类似,灰分较高、发热量较低,需干化后才可实现稳定燃烧;污泥在小型桨叶式污泥干化机内的干化速率最高达到0.6kg/(m2·min),并随污泥干化的进行而逐渐降低;干化过程产生的常规污染气体中氨气浓度最高,可达170 mg/Nm3;污泥干化冷凝水的COD高达820 mg/L,氨氮等指标也很高。污泥干化系统的设计需充分考虑污泥热干化过程中气体和液体污染物的排放,设置相应的处理设施。污泥干化至含水率30%时,可在不投加辅助燃料的情况下实现流化床焚烧炉内的焚烧处理,干化污泥焚烧时需关注烟气中常规污染气体和重金属的控制,焚烧灰渣浸出毒性未超过国标限值。     

Comparisons of metal leachability for various wastes by extraction and leaching methods

The objective of this research was to evaluate three extraction tests, i.e., toxicity characteristic leaching procedures (TCLP), extraction procedure (EP), and American Society for Testing and Materials (ASTM) methods, for their ability to extract metals in chemical sludge and incineration bottom ash, in terms of the precision of analytical results. Typical chemical sludges, including the electroplating and dye-stuff sludges, the municipal solid waste incineration bottom ash, the leather debris, and the steel-mill bottom residue containing Cd, Cr, Cu, Pb, and Zn were prepared for the lysimetry test (dynamic testing) to compare with the extraction results. Results show that for bottom residue and dye-stuff sludge, the concentration of metal leached was almost the same between the lysimetry leaching and the TCLP tests. The metal concentration followed the order: TCLP approximately = EP > ASTM. TCLP and EP exhibited almost the same relative standard deviation (RSD) value. Therefore, the results of the TCLP tests for bottom residue and dye-stuff sludge, which have a low metal content and alkalinity, can be used to estimate the metal concentration leached by typical acid rain in Taiwan; whereas the ASTM extraction test may be a better indicator of the lysimetry test.     

Incineration of paper sludge in a prototype vortexing fluidized bed combustor

All experiments were carried out in a prototype vortexing fluidized bed combustor (VFBC). The dimension of the combustion chamber is 0.7 x 1.4 x 2 m, and the freeboard section is 1 m i.d. and 4 m in height. Paper sludge was used as the feeding material. Two types of coal particles were employed as the supplementary fuel. In order to understand the characteristics of the VFBC system for paper sludge incineration, the effect of various operating parameters, such as the primary airflow, excess air ratio, and secondary airflow rates, on temperature distribution, ash elutriation, combustion efficiency, and pollutant emissions were investigated.     

危险废物事故排放的河流水环境健康风险评价

分析了基于水体中污染物迁移转化方程的水质预测模型,并借鉴美国环保局推荐使用的健康风险评价模型,建立了一种危险废物事故排放时水环境对人体健康风险的评价方法。以电镀污泥为例验证了该方法的有效性。结果显示:该方法需要参数少且计算简单;电镀污泥中目标污染物(Cr、Cu、Ni、Zn)所引起的河流水环境非致癌风险(1.67)超过了美国标准中的可接受风险水平1.00,不可接受;致癌风险(0.88E-11)则小于美国标准中的可接受风险水平1.00E-06,风险不明显。     

城市污水污泥处置方式的温室气体排放比较分析

针对我国现在主流的城市污水污泥处置方法:填埋,焚烧,堆肥。用IPCC中推荐的方法和缺省值,对处置过程中产生的温室气体的直接排放、间接排放和替代排放做了计算和分析。填埋过程计算排放的温室气体有CH4,焚烧过程计算排放的有温室气体CO2和N2O,堆肥过程计算的排放的有温室气体CO2和N2O,最终比较的结果都折算成CO2的排放。结果表明,污泥填埋、焚烧、堆肥所产生的CO2的净排放量分别为695.847 kg CO2/t、443.643 kg CO2/t、511.817 kgCO2/t。由于考虑了堆肥以后的有机肥利用,从减排以及污泥资源化的角度分析,得出堆肥是相对好的污泥处置方式。     

Utilization of urban sewage sludge: Chinese perspectives

Purpose

Urbanization and industrialization in China has resulted in a dramatic increase in the volume of wastewater and sewage sludge produced from wastewater treatment plants. Problems associated with sewage sludge have attracted increasing attention from the public and urban planners. How to manage sludge in an economically and environmentally acceptable manner is one of the critical issues that modern societies are facing.

Methods

Sludge treatment systems consist of thickening, dewatering, and several different alternative main treatments (anaerobic digestion, aerobic digestion, drying, composting, and incineration). Agricultural application, landfill, and incineration are the principal disposal methods for sewage sludge in China. However, sewage sludge disposal in the future should focus on resource recovery, reducing environmental impacts and saving economic costs.

Results

The reuse of biosolids in all scenarios can be environmentally beneficial and cost-effective. Anaerobic digestion followed by land application is the preferable options due to low economic and energy costs and material reuse.

Conclusion

It is necessary to formulate a standard suitable for the utilization of sewage sludge in China.     

Incineration of Paper Sludge in a Prototype Vortexing Fluidized Bed Combustor

ABSTRACT

All experiments were carried out in a prototype vortexing fluidized bed combustor (VFBC). The dimension of the combustion chamber is 0.7 x 1.4 x 2 m, and the freeboard section is 1 m i.d. and 4 m in height. Paper sludge was used as the feeding material. Two types of coal particles were employed as the supplementary fuel. In order to understand the characteristics of the VFBC system for paper sludge incineration, the effect of various operating parameters, such as the primary airflow, excess air ratio, and secondary airflow rates, on temperature distribution, ash elutriation, combustion efficiency, and pollutant emissions were investigated.     

Effects of hydroxyapatite addition on heavy metal volatility during tannery sludge incineration

The effectiveness of hydroxyapatite (HAP) on volatilization reducing of heavy metals during incineration of tannery sludge was investigated. The tannery sludge was treated through doped with different content of HAP, and then incinerated in the tube furnace at the temperature of 600 °C and 900 °C. The results showed that the volatilization rates decreased by 10.19 % for Pb, 10.17 % for Zn, 7.40 % for Cu and 5.33 % for Cr at 600 °C when the HAP content was raised to 20 %. At 900 °C, the volatilization rates of Pb, Cr and Cu decreased by about 40.0 %, 24.0 % and 9.0 %, respectively, while volatilization of Zn can be considered nearly unchanged at around 5 %. The heavy metals can be stabilized effectively in the incineration after the pyromorphite-like minerals were formed in the sludge doped with HAP.     

市政污泥与生活垃圾混烧技术验证

对市政污泥与生活垃圾混烧进行了验证研究。结果表明,与生活垃圾单独焚烧相比,污泥与生活垃圾混烧后烟气中NOx、CO和HCl的浓度没有出现明显变化,而SO2浓度出现了下降（从82～93mg／m3下降至41～70mg／m3）;Hg、Pb、Sn、Cr和Zn的浓度均表现为不同程度的上升,但仍然符合GB[g485;二恶英从0．0087μgTEQ／m3降至O．0047μgTEQ／m3。掺烧半干污泥比例为10％、12％和15％时,吨物质的发电量分别为311．8kWh／t、306．7kWh／t和296．1kwh／t。混烧污泥在一定程度上降低了系统的发电量,因此建议混烧污泥的比例不应大于15％。测算的污泥混烧成本约209元／t（80％含水率）。     

Partitioning of nutrients and micropollutants along the sludge treatment line: a case study

A 2-year sampling campaign was conducted in three wastewater treatment plants of various sizes in the Rome area to assess the occurrence of nutrients and micropollutants among primary, secondary and digested sludge. The primary purpose was to evaluate the quality of different sludge types and their suitability for agricultural use. Primary sludge was consistently more polluted than secondary in terms of organic micropollutants, whereas heavy metals partitioned equally among the sludge types. In digested sludge, the heavy metal concentrations were always below limit values proposed for agricultural utilisation. In contrast, organic micropollutants concentrated during anaerobic digestion and affected the quality of the digested sludge. Secondary sludge resulted less polluted and richer in nitrogen and phosphorus (up to three times) than primary sludge and is hence more suitable for agricultural use. Separate processing of primary and secondary sludge might therefore be an innovative option for sludge management that could maximise the possibilities of agricultural use of secondary sludge and limit disposal problems only to primary sludge. In fact, primary sludge could be easily treated and disposed of by conventional processes including thickening, anaerobic digestion, centrifugation and incineration, whereas the difficult digestibility of secondary sludge could be improved by disintegration pre-treatment before stabilisation.     

Impact assessment of waste management options in Singapore

This paper describes the application of life cycle assessment for evaluating various waste management options in Singapore, a small-island city state. The impact assessment method by SimaPro is carried out for comparing the potential environmental impacts of waste treatment options including landfilling, incineration, recycling, and composting. The inventory data include gases and leachate from landfills, air emissions and energy recovery from incinerators, energy (and emission) savings from recycling, composting gases, and transport pollution. The impact assessment results for climate change, acidification, and ecotoxicity show that the incineration of materials imposes considerable harm to both human health and the environment, especially for the burning of plastics, paper/cardboard, and ferrous metals. The results also show that, although some amount of energy can be derived from the incineration of wastes, these benefits are outweighed by the air pollution (heavy metals and dioxins/furans) that incinerators produce. For Singapore, landfill gases and leachate generate minimal environmental damage because of the nation's policy to landfill only 10% of the total disposed wastes. Land transportation and separation of waste materials also pose minimal environmental damage. However, sea transportation to the landfill could contribute significantly to acidification because of the emissions of sulfur oxides and nitrogen oxides from barges. The composting of horticultural wastes hardly imposes any environmental damage. Out of all the waste strategies, the recycling of wastes offers the best solution for environmental protection and improved human health for the nation. Significant emission savings can be realized through recycling.     

Congener-specific accumulation and environmental risk assessment of polybrominated diphenyl ethers in diverse Korean sewage sludge types

Industrial, domestic wastewater, and livestock sludge samples were collected from 23 wastewater treatment plants in Korea and analyzed for polybrominated diphenyl ethers (PBDEs). The concentrations of Σ₁₉PBDE ranged from 4.01 to 10,400 ng/g dry weight. The average Σ₁₉PBDE concentrations in industrial, domestic wastewater, and livestock sludge were 1,560?±?3,610, 402?±?148, and 27.6?±?50.4 ng/g dry weight, respectively. The composition of PBDEs differed according to the type of sludge. Among the PBDE congeners, BDE 209 was dominant in all sludge samples. After BDE 209, relatively high levels were found for BDE 28 and 47 from industrial sludge, BDE 47 and 99 from domestic wastewater sludge, and BDE 206, 207, and 208 from livestock sludge. Using hierarchical cluster analysis, sludges were divided into three groups according to PBDE congener composition. A risk assessment of PBDEs in sludge used for soil amendment was carried out. Preliminary results indicated that the potential risk of soil exposed to PBDEs in sludge was relatively low.     

Environmental risk assessment of musk ketone and musk xylene in the Netherlands in accordance with the EU-TGD

An environmental risk assessment has been carried out for musk ketone and musk xylene according to the EU Technical Guidance Document for Environmental Risk Assessment for New and Existing Substances [1]. Musk ketone and musk xylene are used in fragrances for cosmetics and household products. For the fragrance industry these are important fragrance ingredients because of their excellent substantivity as well as for their unique smell, which determines largely the odor of a product.

The initial environmental risk assessment is based on information provided by the fragrance industry as represented in the Netherlands by its association NEA, by the Research Institute for Fragrance Materials (RIFM) and data reported in the international open literature. The risk assessment includes an evaluation of the risks for aquatic organisms in surface water and sediment and for soil organisms in soil after application of sewage sludge. Secondary poisoning of fish-eating birds and mammals is considered as well. For each compartment the Predicted Environmental Concentration (PEC) is compared to the Predicted No Effect Concentration (PNEC) to obtain PEC/PNEC ratios. Since monitoring data are available in water, sediment and fish, similar ratios are obtained with measured concentrations instead of the predicted ones.

For both substances, PEC/PNEC ratios are at or below 0.1 for organisms in the aquatic environment, including sediment organisms. PEC/PNEC ratios for fish-eating predators are 0.01. Ratios based on monitoring data are below 0.01 for all of these organisms. For soil organisms the PEC/PNEC ratio is 0.5 for musk ketone and 1.3 for musk xylene. Although in the Netherlands (as well as in some other European countries), sewage sludge presently finds no application as fertilizer on agricultural soil, the aim of environmental policy is to upgrade the sludge quality to enable future applications on agricultural and grassland. The reliability of the predicted soil concentrations can be greatly improved by obtaining experimental data on fate and behaviour of musk ketone and musk xylene in digested sludge and soil.

The risk assessment provides reassurance for the aquatic compartment while pointing the way for obtaining aditional data for the soil compartment.     

Applying waste management scenarios in the Peloponnese region in Greece: a critical analysis in the frame of life cycle assessment

The aim of this paper is to apply life cycle assessment in the waste management sector, in order to compare the environmental performance of different waste management methods. The methods that are studied are: landfilling, aerobic and anaerobic biological treatment, incineration and recycling, focusing on mass and energy balances and the environmental performance of each applied scenario. The Peloponnese Region in Greece was selected as a case for the application of this methodology and more specifically its largest municipalities, where a significant amount of waste is presented. The conducted LCA study proves the necessity of the adoption of an integrated waste management system and indicates its principal objectives by measuring environmental impacts. Thermal scenario contributes significant to the mitigation on the Greenhouse Gases. On the other hand, separation at source and recycling practices provides significant benefits to the abiotic depletion impact.