Desulphurization of coal via low temperature atmospheric alkaline oxidation

Different from other options which usually required strict conditions, a method combining atmospheric oxidization and chemical cleaning with alkali solutions was employed to desulphur coals at temperature around 90 degrees C. The data show that 66% organic sulphur, 44% sulphide sulphur, and 15% pyrite sulphur were lost when the coal was treated in 0.25M NaOH at 90 degrees C, while the solution being aerated at the flow rate of 0.136m3h(-1). The rate increased to 73% for organic sulphur, 83% for sulphide sulphur and 84% for pyrite sulphur when the previous coal was further treated in acidic solution containing HCl at pH 1 for another hour. The mechanism of desulphurization was explored using inductively coupled plasma mass spectrometry, X-ray photoelectron spectroscopy and infrared. It was found out that the bond of -CS was broken by atmospheric oxygen in basic environment, leading to the lost of organic sulphur in coal. Scanning electron microscope data show that the physical structure of the coal was not adversely affected by the treatment and thermogravimetric analysis results prove that the pyrolysis behavior remained unchanged, indicating that the burning process of the coal would not be adversely affected. Unlike other oxidizing methods, this technique does not lower the heating value of the coal which was manifested by relevant data.     

Pilot-scale study of the effect of selective catalytic reduction catalyst on mercury speciation in Illinois and Powder River Basin coal combustion flue gases

A study was conducted to investigate the effect of selective catalytic reduction (SCR) catalyst on mercury (Hg) speciation in bituminous and subbituminous coal combustion flue gases. Three different Illinois Basin bituminous coals (from high to low sulfur [S] and chlorine [Cl]) and one Powder River Basin (PRB) subbituminous coal with very low S and very low Cl were tested in a pilot-scale combustor equipped with an SCR reactor for controlling nitrogen oxides (NOx) emissions. The SCR catalyst induced high oxidation of elemental Hg (Hg0), decreasing the percentage of Hg0 at the outlet of the SCR to values <12% for the three Illinois coal tests. The PRB coal test indicated a low oxidation of Hg0 by the SCR catalyst, with the percentage of Hg0 decreasing from approximately 96% at the inlet of the reactor to approximately 80% at the outlet. The low Cl content of the PRB coal and corresponding low level of available flue gas Cl species were believed to be responsible for low SCR Hg oxidation for this coal type. The test results indicated a strong effect of coal type on the extent of Hg oxidation.     

pH、接种量及固形物含量对氧化亚铁硫杆菌LX5煤炭生物脱硫的影响

高硫煤燃烧释放SO2污染环境。采用摇瓶实验,以FeS2驯化的嗜酸性氧化亚铁硫杆菌(Acidithiobacillus ferrooxidans)LX5为供试菌株,研究了pH、接种量及煤粉数量对菌株LX5进行生物脱硫的影响。实验结果表明,在15 d的反应周期中反应液的起始pH为2.0、2.5、3.0和4.0时,菌株LX5的脱硫效率分别为43.1%、73.3%、61.9%和37.3%;将菌株LX5的接种量控制为5%、10%及15%时,其脱硫效率分别为44.2%、68.1%及72.2%;将煤粉含量调整为5%、10%及15%时,LX5的脱硫效率分别为73.1%、72.2%及56.3%。摇瓶实验确定的最合适的生物脱硫条件是:培养液起始pH为2.5,LX5接种量为培养液体积的10%,煤粉加入量为培养液质量的10%。在5 L序批式反应器进行煤炭生物脱硫的启动实验,研究表明,反应15 d后煤炭脱硫率达到69.2%,而煤中黄铁矿硫的脱硫率可达78%。     

Selenium fractions in organic matter from Se-rich soils and weathered stone coal in selenosis areas of China

A high degree of association between Selenium (Se) and organic matter has been demonstrated in natural environments, but Se fractions and speciation in organic matter is unclear. In this study, a method for quantifying organic matter associated with Se (OM-Se) was developed to investigate Se fractions in organic matter in Se-rich soils and weathered stone coal from Enshi, China, where Se poisoning of humans and livestock has been documented. Initially, Se was extracted using water and a phosphate buffer. Subsequently, OM-Se was extracted using NaOH, and then speciated into Se associated with fulvic acids (FA-Se) and humic acids (HA-Se). Both FA-Se and HA-Se were further speciated into the weakly bound and strongly bound fractions using a customized hydride generation reactor. The results show that FA-Se (1.91-479 mg kg⁻¹) is the predominant form of Se in all Se-rich soils and the weathered stone coal samples, accounting for more than 62% of OM-Se (3.07-484 mg kg⁻¹). Weakly bound FA-Se (1.33-450 mg kg⁻¹) was prevalent in the total FA-Se, while weakly bound HA-Se (0.62-26.2 mg kg⁻¹) was variable in the total HA-Se (1.15-32.5 mg kg⁻¹). These data indicate that OM-Se could play a significant source and sink role in the biogeochemical cycling of Se in the supergene environment. Weakly bound FA-Se seems to act as a potential source for bioavailable Se, whereas strongly bound HA-Se is a possible OM-Se sink which is not readily transformed into bioavailable Se.     

Pilot-Scale Study of the Effect of Selective Catalytic Reduction Catalyst on Mercury Speciation in Illinois and Powder River Basin Coal Combustion Flue Gases

Abstract

A study was conducted to investigate the effect of selective catalytic reduction (SCR) catalyst on mercury (Hg) speciation in bituminous and subbituminous coal combustion flue gases. Three different Illinois Basin bituminous coals (from high to low sulfur [S] and chlorine [Cl]) and one Powder River Basin (PRB) subbituminous coal with very low S and very low Cl were tested in a pilot-scale combustor equipped with an SCR reactor for controlling nitrogen oxides (NO_x) emissions. The SCR catalyst induced high oxidation of elemental Hg (Hg⁰), decreasing the percentage of Hg⁰ at the outlet of the SCR to values <12% for the three Illinois coal tests. The PRB coal test indicated a low oxidation of Hg⁰ by the SCR catalyst, with the percentage of Hg⁰ decreasing from ～96% at the inlet of the reactor to ～80% at the outlet. The low Cl content of the PRB coal and corresponding low level of available flue gas Cl species were believed to be responsible for low SCR Hg oxidation for this coal type. The test results indicated a strong effect of coal type on the extent of Hg oxidation.     

The Relationship of Carbon Dioxide Emissions with Coal Rank and Sulfur Content

Carbon dioxide emissions, on an equivalent energy basis, were calculated for 504 North American coals to explore the effects of coal rank and sulfur content on CO₂ emissions. The data set included coals ranging in rank from lignite through low-volatile bituminous from 15 U.S. states and Alberta, Canada. Carbon dioxide emissions were calculated from the carbon content and gross calorific value of each coal. The lowest CO₂ emissions are calculated for the high-volatile bituminous coals (198 to 211 lbs CO₂/MMBtu) and the highest for lignites and subbituminous coals (209 to 224 lbs CO₂/MMBtu). The lower CO₂ emissions from the high-volatile bituminous coals result in part from their generally higher sulfur content. However, even at equivalent sulfur contents the high-volatile bituminous coals give lower CO₂ emissions than the lower-rank coals. On average, the lowerrank coals produce 5 percent more CO₂ upon combustion than the highvolatile bituminous coals, on the basis of gross calorific value. This difference increases to 9 percent on the basis of estimated net calorific value. The net calorific value is better indicator of power plant energy production than the gross calorific value. The difference in CO₂ emissions resulting from the use of high-volatile bituminous coals and lower-rank coals is of the same order of magnitude as reductions expected from near-term combustion efficiency improvements. These results are useful to those interested in current and future CO₂ emissions resulting from coal combustion.     

Use of coal to retard pesticide movement in soil

Abstract

Three different coals and an activated carbon were mixed with prescribed amounts of a sandy loam soil and added to soil columns to test their ability to retard pesticide movement. The pesticides chosen were prometon, prometryn, 2,4‐D, carbofuran, dinoseb, fenamiphos, and two oxidation products of fenamiphos, fenamiphos sulfoxide, and fenamiphos sulfone. These compounds were chosen to represent different chemical classes of pesticides and because they were considered to have a high potential for transport in soils. All the coals were more effective in retaining the pesticides than the soil, however, some were more effective than others. One of the coals was the most effective in retaining the majority of the pesticides with an overall retention of 94.7% in a 4:1 soil/coal ratio compared to the soil only with a retention of 48.5%. The moisture content of the coal appears to have a positive correlation with the ability of the coal to retain the pesticides under the conditions used for this experiment.     

Temporal and spatial distribution of atmospheric antimony emission inventories from coal combustion in China

A multiple-year inventory of atmospheric antimony (Sb) emissions from coal combustion in China for the period of 1980-2007 has been calculated for the first time. Specifically, the emission inventories of Sb from 30 provinces and 4 economic sectors (thermal power, industry, residential use, and others) are evaluated and analyzed in detail. It shows that the total Sb emissions released from coal combustion in China have increased from 133.19 t in 1980 to 546.67 t in 2007, at an annually average growth rate of 5.4%. The antimony emissions are largely emitted by industrial sector and thermal power generation sector, contributing 53.6% and 26.9% of the totals, respectively. At provincial level, the distribution of Sb emissions shows significant variation. Between 2005 and 2007, provinces always rank at the top five largest Sb emissions are: Guizhou, Hunan, Hebei, Shandong, and Anhui.     

Selective redox degradation of chlorinated aliphatic compounds by Fenton reaction in pyrite suspension

Selective redox degradation of chlorinated aliphatics by Fenton reaction in pyrite suspension was investigated in a closed system. Carbon tetrachloride (CT) was used as a representative target of perchlorinated alkanes and trichloroethylene (TCE) was used as one of highly chlorinated alkenes. Degradation of CT in Fenton reaction was significantly enhanced by pyrite used as an iron source instead of soluble Fe. Pyrite Fenton showed 93% of CT removal in 140 min, while Fenton reaction with soluble Fe(II) showed 52% and that with Fe(III) 15%. Addition of 2-propanol to the pyrite Fenton system significantly inhibited degradation of TCE (99% to 44% of TCE removal), while degradation of CT was slightly improved by the 2-propanol addition (80-91% of CT removal). The result suggests that, unlike oxidative degradation of TCE by hydroxyl radical in pyrite Fenton system, an oxidation by the hydroxyl radical is not a main degradation mechanism for the degradation of CT in pyrite Fenton system but a reductive dechlorination by superoxide can rather be the one for the CT degradation. The degradation kinetics of CT in the pyrite Fenton system was decelerated (0.13-0.03 min⁻¹), as initial suspension pH decreased from 3 to 2. The formation of superoxide during the CT degradation in the pyrite Fenton system was observed by electron spin resonance spectroscopy. The formation at initial pH 3 was greater than that at initial pH 2, which supported that superoxide was a main reductant for degradation of CT in the pyrite Fenton system.     

Fly and bottom ashes from biomass combustion as cement replacing components in mortars production: Rheological behaviour of the pastes and materials compression strength

In the present research mortar pastes obtained by replacing a commercial cement with the equivalent mass of 5, 10, 20 and 30 wt.% of fly ash or bottom ash from fir chips combustion, were prepared and rheologically characterized. It was observed that the presence of ash modifies their rheological behaviour with respect to the reference blend due to the presence, in the ashes, of KCl and K₂SO₄ which cause precipitation of gypsum and portlandite during the first hydration stages of the pastes. Hydrated materials containing 5 wt.% of ash display compression strength and absorption at 28 d of same magnitude as the reference composition; conversely, progressive increase of ash cause a continuous decline of materials performances. Conversely, samples tested after 180 d display a marked decline of compression strength, as a consequence of potassium elution and consequent alkali-silica reaction against materials under curing.     

Recovering coal bed methane from deep unmineable coal seams and carbon sequestration

Published data from nearly 2,000 coal samples comprising 250 coal beds from 17 states, representing many of the coal producing horizons in the USA, shows moderate correlation (0.7) between depth and methane content for high volatile coal ranks. Low-volatile rank coals average the highest methane content, 12.74 m3/ton (450 ft3/ton), subbituminous rank coals the lowest, <0.71 m3/ton (<25 ft3/ton). Experimentation under replicated in situ conditions of triaxial stress, pore pressure and temperature on Pittsburgh No. 8 coal indicate permeability decreases with increasing CO₂ pressure, with an increase in strain in the coal associated with its swelling.     

Generation of reactive oxygen species in cyanobacteria and green algae induced by allelochemicals of submerged macrophytes

Inhibition of phytoplankton by allelochemicals released by submerged macrophytes is reported to be one of the mechanisms that maintain a clear-water state in shallow lakes. In order to elucidate this mechanism, the ability of six polyphenols and two long-chain fatty acids to induce the generation of reactive oxygen species (ROS) in phytoplankton was studied using the ROS sensitive probe 2′,7′- dichlorodihydrofluorescein diacetate (DCFH-DA). The results showed that only (+)-catechin (CA) and pyrogallic acid (PA) could induce ROS formation in Microcystis aeruginosa and Pseudokirchneriella subcapitata. 25 mg L⁻¹ CA caused 1.2, 1.4 and 1.8 times increase of ROS levels in M. aeruginosa at 1, 2 and 4 h exposure, respectively, and, correspondingly in P. subcapitata cells, these values were 3.7, 6.2 and 7.7, respectively. PA also significantly increased the levels of intracellular ROS in P. subcapitata (P < 0.01); however, significant ROS generation in M. aeruginosa was observed at only 4 h exposure (P < 0.01). Light enhanced ROS generation in CA treated cells, but not in the cells treated with PA. CA and PA may act as redox cyclers after uptake by test organisms and produce ROS successively. These results suggest that the oxidative stress induced by the redox cycling property of allelochemicals may be one of the important causes for the inhibitory effect of some submerged macrophytes towards undesired phytoplankton in natural aquatic ecosystems.     

A Computer Plot for a High Temperature Psychrometric Chart

This paper presents results of multivariate regression models developed to estimate the properties and cost of U.S. coals washed for varying degrees of sulfur removal using commercially available physical coal preparation processes. The models allow washed coal characteristics to be predicted from information on coal origin, heating value, ash, and sulfur content. The models were developed by first "processing" each of the 710 coals in the U.S. Bureau of Mines (USBM) coal washability data base through a coal preparation plant computer model which optimizes plant performance to achieve a desired washed coal quality. Washability data are adjusted to account for the inefficiencies of coal washing equipment, and the actual coal sizes treated by various plant wash streams. Since different plant designs may be capable of achieving a given level of sulfur removal, three nominal levels of plant complexity (Levels 2, 3, 4) were included to identify the most economical alternative. The washed coal characteristics thus derived were then analyzed using standard statistical techniques to develop regression equations linking washed coal properties and cost to raw coal properties for each of 18 geographical regions encompassing the entire U.S. These regression models are incorporated in the Advanced Utility Simulation Model (AUSM) to estimate the economic potential of coal washing as a sulfur abatement strategy, in conjunction with other options available to coal-fired power plants. Modeling results for Pennsylvania showed that washed coals frequently were selected as part of a cost-effective control strategy, accounting for 10 to 30 percent of the total emissions reduction, and that "local coal" restrictions significantly increase the use of washed coal as an SO₂ control strategy. Hypothetical requirements for mandatory coal cleaning, however, were found to be costly and ineffective.     

Dietary exposure of rainbow trout to 8:2 and 10:2 fluorotelomer alcohols and perfluorooctanesulfonamide: Uptake, transformation and elimination

The bioaccumulation of perfluorooctanesulfonamide (PFOSA) and two fluorotelomer alcohols (8:2 FTOH, 10:2 FTOH) by rainbow trout (Oncorhynchus mykiss) through dietary exposure, including depuration rates and metabolism was investigated. Concentrations in the spiked feed ranged from 10.9 μg g⁻¹ wet weight (wet wt) for PFOSA and 6.7 μg g⁻¹ wet wt for 8:2 FTOH to 5.0 μg g⁻¹ wet wt for 10:2 FTOH. Trout was fed at 1.5% body weight per day for 30 d and depuration was followed for up to 30 d following previously published dietary exposure protocols. Perfluorooctanesulfonate (PFOS) was the major perfluoroalkylsulfonate (PFSA) detected in fish following dietary exposure to PFOSA. Half-lives of PFOS and PFOSA were 16.9 ± 2.5 and 6.0 ± 0.4 d, respectively. A biomagnification factor (BMF) of 0.023 was calculated for PFOSA which indicates that dietary exposure to PFOSA does not result in biomagnification in the rainbow trout. PFOS had a BMF of 0.08. The fluorotelomer saturated acids (8:2 FTCA, 10:2 FTCA) and fluorotelomer unsaturated acids (8:2 FTUCA, 10:2 FTUCA) were the major products detected in rainbow trout following dietary exposure to 8:2 FTOH and 10:2 FTOH, respectively. Half-lives were 3.7 ± 0.4, 2.1 ± 0.5, 3.3, and 1.3 d for 10:2 FTCA, 10:2 FTUCA, 8:2 FTCA, and 8:2 FTUCA, respectively. Small amounts of perfluorooctanoate (PFOA) and perfluorodecanoate (PFDA) were also detected in the FTOH exposed fish.     

Product Gudie/1987

A computer program has been written to determine the cost of building and operating wet scrubbers on individual coal fired utilities in the states where emissions are likely to affect the acid rain problem in the eastern United States. The program differs from many other estimates since it calculates the cost for each of 831 individual sites. The capital costs for installing scrubbers on the top fifty sulfur oxide emitting plants will be about $20 billion. This will result in an increase in the cost of electricity on an average of 0.88 cents/kWh and a reduction of sulfur oxide emissions from 1980 of 7,100,000 tons per year. An additional reduction of at least 1,000,000 tons per year can be obtained by requiring all plants burning oil to burn low sulfur oil. These figures assume utilities will use least emissions dispatching and will use local coals containing at least 3.5 percent sulfur. The use of local coals should result in a further saving of at least 0.2 cents/kWh. This should make available a large supply of low sulfur coal which could reduce emissions of sulfur oxides by up to 1,000,000 tons per year. The SO₂ reductions will be continued for at least the next thirteen years and have a very significant effect through the year 2010.     

Investigation of selective catalytic reduction impact on mercury speciation under simulated NOx emission control conditions

Selective catalytic reduction (SCR) technology increasingly is being applied for controlling emissions of nitrogen oxides (NOx) from coal-fired boilers. Some recent field and pilot studies suggest that the operation of SCR could affect the chemical form of mercury (Hg) in coal combustion flue gases. The speciation of Hg is an important factor influencing the control and environmental fate of Hg emissions from coal combustion. The vanadium and titanium oxides, used commonly in the vanadia-titania SCR catalyst for catalytic NOx reduction, promote the formation of oxidized mercury (Hg2+). The work reported in this paper focuses on the impact of SCR on elemental mercury (Hg0) oxidation. Bench-scale experiments were conducted to investigate Hg0 oxidation in the presence of simulated coal combustion flue gases and under SCR reaction conditions. Flue gas mixtures with different concentrations of hydrogen chloride (HCl) and sulfur dioxide (SO2) for simulating the combustion of bituminous coals and subbituminous coals were tested in these experiments. The effects of HCl and SO2 in the flue gases on Hg0 oxidation under SCR reaction conditions were studied. It was observed that HCl is the most critical flue gas component that causes conversion of Hg0 to Hg2+ under SCR reaction conditions. The importance of HCl for Hg0 oxidation found in the present study provides the scientific basis for the apparent coal-type dependence observed for Hg0 oxidation occurring across the SCR reactors in the field.     

Emission factors and particulate matter size distribution of polycyclic aromatic hydrocarbons from residential coal combustions in rural Northern China

Coal consumption is one important contributor to energy production, and is regarded as one of the most important sources of air pollutants that have considerable impacts on human health and climate change. Emissions of polycyclic aromatic hydrocarbons (PAHs) from coal combustion were studied in a typical stove. Emission factors (EFs) of 16 EPA priority PAHs from tested coals ranged from 6.25 ± 1.16 mg kg^?1 (anthracite) to 253 ± 170 mg kg^?1 (bituminous), with NAP and PHE dominated in gaseous and particulate phases, respectively. Size distributions of particulate phase PAHs from tested coals showed that they were mostly associated with particulate matter (PM) with size either between 0.7 and 2.1 μm or less than 0.4 μm (PM_0.4). In the latter category, not only were more PAHs present in PM_0.4, but also contained higher fractions of high molecular weight PAHs. Generally, there were more than 89% of total particulate phase PAHs associated with PM_2.5. Gas-particle partitioning of freshly emitted PAHs from residential coal combustions were thought to be mainly controlled by absorption rather than adsorption, which is similar to those from other sources. Besides, the influence of fuel properties and combustion conditions was further investigated by using stepwise regression analysis, which indicated that almost 57 ± 10% of total variations in PAH EFs can be accounted for by moisture and volatile matter content of coal in residential combustion.     

In situ phytoremediation of arsenic- and metal-polluted pyrite waste with field crops: effects of soil management

Sunflower, alfalfa, fodder radish and Italian ryegrass were cultivated in severely As-Cd-Co-Cu-Pb-Zn-contaminated pyrite waste discharged in the past and capped with 0.15 m of unpolluted soil at Torviscosa (Italy). Plant growth and trace element uptake were compared under ploughing and subsoiling tillages (0.3 m depth), the former yielding higher contamination (∼30%) in top soil.Tillage choice was not critical for phytoextraction, but subsoiling enhanced above-ground productivity, whereas ploughing increased trace element concentrations in plants. Fodder radish and sunflower had the greatest aerial biomass, and fodder radish the best trace element uptake, perhaps due to its lower root sensitivity to pollution. Above-ground removals were generally poor (maximum of 33 mg m⁻² of various trace elements), with Zn (62%) and Cu (18%) as main harvested contaminants. The most significant finding was of fine roots proliferation in shallow layers that represented a huge sink for trace element phytostabilisation.It is concluded that phytoextraction is generally far from being an efficient management option in pyrite waste. Sustainable remediation requires significant improvements of the vegetation cover to stabilise the site mechanically and chemically, and provide precise quantification of root turnover.     

Use of whole-body and subcellular Cu residues of Lumbriculus variegatus to predict waterborne Cu toxicity to both L. variegatus and Chironomus riparius in fresh water

We tested the use of whole-body and subcellular Cu residues (biologically-active (BAM) and inactive compartments (BIM)), of the oligochaete Lumbriculus variegatus to predict Cu toxicity in fresh water. The critical whole-body residue associated with 50% mortality (CBR₅₀) was constant (38.2-55.6 μg g⁻¹ fresh wt.) across water hardness (38-117 mg L⁻¹ as CaCO₃) and exposure times during the chronic exposure. The critical subcellular residue (CSR₅₀) in metal-rich granules (part of BIM) associated with 50% mortality was approximately 5 μg g⁻¹ fresh wt., indicating that Cu bioavailability is correlated with toxicity:subcellular residue is a better predictor of Cu toxicity than whole-body residue. There was a strong correlation between the whole-body residue of L. variegatus (biomonitor) and survival of Chironomus riparius (relatively sensitive species) in a hard water Cu co-exposure. The CBR₅₀ in L. variegatus for predicting mortality of C. riparius was 29.1-45.7 μg g⁻¹ fresh wt., which was consistent within the experimental period; therefore use of Cu residue in an accumulator species to predict bioavailability of Cu to a sensitive species is a promising approach.     

Lactate oxidation in pyrite suspension: a Fenton-like process in situ generating H2O2

Pyrite is a common mineral at many mining sites. In this study, the mineral pyrite was studied as a Fenton-like reagent for environmental concerns. We selected lactate as a model target molecule to evaluate the Fenton-like catalytic efficiency of pyrite upon organic oxidation. A complete set of control experiments in both aerobic and anaerobic atmospheres unequivocally established that the pyrite in aqueous solution could spontaneously in situ generate OH and H₂O₂, serving as a Fenton-like reagent to catalyze the oxidation of lactate to pyruvate with no need for additional H₂O₂. We called it the pyrite-only Fenton-like (PF) reagent. Monitoring concentration changes of lactate and pyruvate with the time indicated that the pyrite mediated the favorable pyruvate formation at pH 4.5, 60 °C, under air atmosphere. The PF reaction could be stimulated by visible light illumination. Under the optimum conditions, up to 50% of lactate was degraded within 10 d. The results suggest that pyrite and its Fenton-like processes may be potentially practical in wastewater treatment.