袋式除尘器和旋风除尘器的性能及其应用的比较

文章简要介绍了袋式除尘器和旋风除尘器的产生背景和发展历史,说明了两种除尘器的一般结构和工作原理。重点介绍了袋式除尘器和旋风除尘器的性能及其影响因素,并对两者在实际中的应用做了比较,比较结果显示:旋风除尘器主要优点表现在受含尘气体的浓度、温度限制小,对于粉尘的物理性质无特殊要求;压力损失中等,动力消耗不大,运转、维护费用较低;袋式除尘器的主要优点是除尘效率高,特别是对微细粉尘的处理能达到较为理想的效果。由此分析预测了两种除尘器在中国的应用及其发展趋势。     

旋风除尘器的选型和使用

旋风除尘器具有构造简单、价格便宜、体积小、收尘效率高(一般效率达80％～90％,高者可达90％以上)的特点,适合安装在各种扬尘场所。由于桨风除尘器风速较快、筒壁易磨损,因而,最近几年又出现了用陶瓷材料制     

接地极雾化电晕放电旋风除尘器的实验研究

静电旋风除尘器的除尘效率高,占地面积小,安装方便,得到了广泛的应用。比较了接地极雾化电晕放电旋风除尘器,静电旋风除尘器和传统旋风除尘器的放电特性、捕集效率、分割粒径、分级效率和对高比电阻的适应能力。研究表明:首先,流量为80 m L/min时,接地极雾化电晕放电旋风除尘器的起晕电压和放电电流均优于静电旋风除尘器;其次,接地极雾化电晕放电旋风除尘器的分割粒径和分级效率都明显优于静电旋风除尘器,而分级效率更是较传统旋风除尘器提高了15%以上。最后,当粉尘的比电阻增大时,接地极雾化电晕放电旋风除尘器的收集效率保持稳定,几乎不随工作时间改变,而静电旋风除尘器的效率则随着工作时间的增加而降低。因此,接地极雾化电晕放电技术更有利于高比电阻粉尘的捕集,应用前景广阔。     

旋风除尘器压力损失的试验研究

分析了旋风除尘器压力损失的成因,通过系统的试验考查了压力损失与进口气流平均速度的关系,探讨了粉尘含量对旋风除尘器压力损失的影响和灰斗的压力分布,总结了排气芯管截面积与入口截面积 A0/Ai之比的大小对除尘器压力损失的影响,从而为旋风除尘器的优化设计及操作性能的改善提供了重要的参考价值。     

锅炉应用旋风除尘器除尘的影响因素分析

通过对旋风除尘器结构和运行原理的分析,找出锅炉应用旋风除尘器除尘效果不佳的影响因素,提出了锅炉应用旋风除尘器提高除尘效率的措施.     

荷电水雾改造旋风除尘器的试验研究

本文介绍在旋风除尘器的前端加荷电水雾系统后使旋风子捕尘效率提高的试验结果及其机理分析。试验结果表明,当荷电水雾系统的喷水量在烟气温度可将其全部蒸发时,可使 XCX 型旋风子对粒经小于5μm 粉尘的除尘效率由10.1%提高到26%左右,适当加大水量后可提高到49.8%。此外,本文还指出了用荷电水雾改造旋风子时需要进一步研究的问题。     

电旋风除尘器除尘效率主要增益因子分析

利用高压静电技术提高旋风除尘器除尘效率，是改进这种至今仍广泛利用的中低效干式除尘器的一种有效手段，但对电旋风主要提次增益因子的分析始终是一个薄弱环节，本文从分析电旋风主要增益因子出发，探索进一步提高除尘效率的可能途径灵开发新的电旋风除尘器提供理论依据，作者在半工业性试验系统上进行的试验结果证明了上述理论分析。     

旋风除尘器设计中压力降模型的研究

从理论上探讨了旋风除尘器压力降的成因及影响因素,构造了旋风除尘器压力降的数学模型,解决了旋风除尘器设计过程中压力降的计算问题,将所得模型与实际工业型旋风除尘器的数据进行了比较,结果吻合良好。模型对旋风除尘器的设计有较大的参考价值。     

XW（L）F型旋风除尘器

一、概述 XW(L)F型旋风除尘器是1982年设计的,并于当年安装和投入运行。其独特之处,是增设并改进了减阻圆锥排出芯管和反射屏装置,使螺旋形斜底板的尺寸配置更合理。经过多年使用,证明其性能超过现使用的其它旋风除尘器,适用于冶矿、电力、机械制造、石化、建材、制药等行业含尘气的净化及回收;对粘性尘,则并不适用。二、结构特点和工作原理 XW(L)F型旋风除尘器主要由进口、蜗壳、螺旋形斜底板、长锥牛角弯头(或长直锥体)、减阻园锥芯管、反射屏(板)等组成(图1)。其独特之处是增设并改进了减阻园锥芯管和反射屏装置,使螺旋形斜底板尺寸配置较合理。与其它旋风除尘器相比,净化效率较高。冷态平均净化效率为92％以上,热态平均净化效率为94.37％(见表1)。     

袋式除尘器传统结构的设计改进

袋式除尘器是现代煤粉工业中常用的一项除尘设备．在以往的煤粉工业生产过程中起到了至关重要的作用。随着近些年科学技术的进步。袋式除尘器也得到了不小的发展和改进。传统的袋式除尘器在处理粉尘过程中,其效率仍然有待提高．其结构也限制了袋式除尘器向最经济的方向发展。本文结合对袋式除尘器传统结构中的设计的研究．从其清灰方式等发面．研究改进袋式除尘器的相关策略。从而有效地提高袋式除尘器的工作效率。     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Isolation and preliminary characterization of a 3-chlorobenzoate degrading bacteria

A study was conducted to compare the diversity of 2-, 3-, and 4-chlorobenzoate degraders in two pristine soils and one contaminated sewage sludge. These samples contained strikingly different populations of mono-chlorobenzoate degraders. Although fewer cultures were isolated in the uncontaminated soils than contaminated one, the ability of microbial populations to mineralize chlorobenzoate was widespread. The 3- and 4-chlorobenzoate degraders were more diverse than the 2-chlorobenzoate degraders. One of the strains isolated from the sewage sludge was obtained. Based on its phenotype, chemotaxonomic properties and 16S rRNA gene, the organism S-7 was classified as Rhodococcus erythropolis. The strain can grow at temperature from 4 to 37℃. It can utilize several （halo）aromatic compounds. Moreover, strain S-7 can grow and use 3-chlorobenzoate as sole carbon source in a temperatures range of 10-30℃ with stoichiometric release of chloride ions. The psychrotolerant ability was significant for bioremediation in low temperature regions. Catechol and chlorocatechol 1,2-dioxygenase activities were present in cell free extracts of the strain, but no （chloro）catechol 2,3- dioxygenase activities was detected. Spectral conversion assays with extracts from R. erythropolis S-7 showed accumulation of a compound with a similar UV spectrum as chloro-cis,cis-muconate from 3-chlorobenzoate. On the basis of these results, we proposed that S-7 degraded 3-chlorobenzoate through the modified ortho-cleave pathway.     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.     

Organochlorine pesticides in soils under different land usage in the Taihu Lake region, China

A field study was conducted in the Taihu Lake region, China in 2004 to reveal the organochlorine pesticide concentrations in soils after the ban of these substances in the year 1983. Thirteen organochlorine pesticides (OCPs) were analyzed in soils from paddy field, tree land and fallow land. Total organochlorine pesticide residues were higher in agricultural soils than in uncultivated fallow land soils. Among all the pesticides, ΣDDX (DDD, DDE and DDT) had the highest concentration for all the soil samples, ranging from 3.10 ng/g to 166.55 ng/g with a mean value of 57.04 ng/g and followed by ΣHCH, ranging from 0.73 ng/g to 60.97 ng/g with a mean value of 24.06 ng/g. Dieldrin, endrin, HCB and α-endosulfan were also found in soils with less than 15 ng/g. Ratios of p,p'-(DDD DDE)/DDT in soils under three land usages were: paddy field ＞ tree land ＞ fallow land, indicating that land usage inlfuenced the degradation of DDT in soils. Ratios of p,p'-(DDD DDE)/DDT ＞1, showing aged residues of DDTs in soils of the Taihu Lake region. The results were discussed with data from a former study that showed very low actual concentrations of HCH and DDT in soils in the Taihu Lake region, but according to the chemical half-lives and their concentrations in soils in 1980s, the concentration of DDT in soils seemed to be underestimated. In any case our data show that the ban on the use of HCH and DDT resulted in a tremendous reduction of these pesticide residues in soils, but there are still high amounts of pesticide residues in soils, which need more remediation processes.     

Alterations of organ histopathology and metallolhionein mRNA expression in silver barb, Puntius gonionotus during subchronic cadmium exposure

Common silver barb,Puntius gonionotus,exposed to the nominal concentration of 0.06 mg/L Cd for 60 d,were assessed for histopathological alterations(gills,liver and kidney),metal accumulation,and metallothionein(MT)mRNA expression.Fish exhibited pathological symptoms such as hypertrophy and hyperplasia of primary and secondary gill lamellae,vacuolization in hepatocytes,and prominent tubular and glomerular damage in the kidney.In addition,kidney accumulated the highest content of cadmium,more than gills and liver.Expression of MT mRNA was increased in both liver and kidney of treated fish.Hepatic MT levels remained high after fish were removed to Cd-free water.In contrast,MT expression in kidney was peaked after 28 d of treatment and drastically dropped when fish were removed to Cd-free water.The high concentrations of Cd in hepatic tissues indicated an accumulation site or permanent damage on this tissue.