Characterization and dispersion modeling of odors from a piggery facility

Piggeries are known for their nuisance odors, creating problems for workers and nearby residents. Chemical substances that contribute to these odors include sulfurous organic compounds, hydrogen sulfide, phenols and indoles, ammonia, volatile amines, and volatile fatty acids. In this work, daily mean concentrations of ammonia (NH3) and hydrogen sulfide (H2S) were measured by hand-held devices. Measurements were taken in several places within the facility (farrowing to finishing rooms). Hydrogen sulfide concentration was found to be 40 to 50 times higher than the human odor threshold value in the nursery and fattening room, resulting in strong nuisance odors. Ammonia concentrations ranged from 2 to 18 mL m(-3) and also contributed to the total odor nuisance. Emission data from various chambers of the pig farm were used with the dispersion model AERMOD to determine the odor nuisance caused due to the presence of H2S and NH3 to receptors at various distances from the facility. Because just a few seconds of exposure can cause an odor nuisance, a "peak-to-mean" ratio was used to predict the maximum odor concentrations. Several scenarios were examined using the modified AERMOD program, taking into account the complex terrain around the pig farm.     

The effect of biofuel production on swine farm methane and ammonia emissions

Methane (CH) and ammonia (NH3) are emitted to the atmosphere during anaerobic processing of organic matter, and both gases have detrimental environmental effects. Methane conversion to biofuel production has been suggested to reduce CH4 emissions from animal manure processing systems. The purpose of this research is to evaluate the change in CH4 and NH3 emissions in an animal feeding operation due to biofuel production from the animal manure. Gas emissions were measured from swine farms differing only in their manure-management treatment systems (conventional vs. biofuel). By removing organic matter (i.e., carbon) from the biofuel farms' manure-processing lagoons, average annual CH4 emissions were decreased by 47% compared with the conventional farm. This represents a net 44% decrease in global warming potential (CO2 equivalent) by gases emitted from the biofuel farms compared with conventional farms. However, because of the reduction of methanogenesis and its reduced effect on the chemical conversion of ammonium (NH4+) to dinitrogen (N2) gas, NH3 emissions in the biofuel farms increased by 46% over the conventional farms. These studies show that what is considered an environmentally friendly technology had mixed results and that all components of a system should be studied when making changes to existing systems.     

Ammonia emissions from Swine waste lagoons in the Utah great basin

In animal production systems (poultry, beef, and swine), current production, storage, and disposal techniques present a challenge to manage wastes to minimize the emissions of trace gases within relatively small geographical areas. Physical and chemical parameters were measured on primary and secondary lagoons on three different swine farming systems, three replicates each, in the Central Great Basin of the United States to determine ammonia (NH3) emissions. Nutrient concentrations, lagoon water temperature, and micrometeorological data from these measurements were used with a published process model to calculate emissions. Annual cycling of emissions was determined in relation to climatic factors and wind speed was found the predominating factor when the lagoon temperatures were above about 3 degrees C. Total NH3 emissions increased in the order of smallest to largest: nursery, sow, and finisher farms. However, emissions on an animal basis increased from nursery animals being lowest to sow animals being highest. When emissions were compared to the amount of nitrogen (N) fed to the animals, NH3 emissions from sows were lowest with emissions from finisher animals highest. Ammonia emissions were compared to similar farm production systems in the humid East of the United States and found to be similar for finisher animals but had much lower emissions than comparable humid East sow production. Published estimates of NH3 emissions from lagoons ranged from 36 to 70% of feed input (no error range) compared to our emissions determined from a process model of 9.8% with an estimated range of +/-4%.     

城市生活垃圾填埋场恶臭污染与周边限建区划分探讨

随着我国城市垃圾状况和城市建设的变化,填埋场气体问题日益突出。探讨环境影响评价中如何合理确定垃圾填埋场周边建设的控制距离,科学设置垃圾填埋场的防护距离,已成为解决恶臭污染问题的有效途径之一。文章将恶臭污染影响作为限制性因素,提出垃圾填埋场周边限建区的概念,并探讨了划分思路和原则,最后文章从恶臭污染控制因子选取、恶臭污染影响计算模式及参数选取等对恶臭污染防护距离进行了讨论,在此基础上对垃圾填埋场周边限建区的划分方法进行了具体说明。文章探讨的基于垃圾填埋场恶臭污染影响的限建区划分方法,对垃圾填埋场环境影响评价及垃圾填埋场周边建设项目规划具有一定的参考意义。     

Odor and gas release from anaerobic treatment lagoons for swine manure

Odor and gas release from anaerobic lagoons for treating swine waste affect air quality in neighboring communities but rates of release are not well documented. A buoyant convective flux chamber (BCFC) was used to determine the effect of lagoon loading rate on measured odor and gas releases from two primary lagoons at a simulated wind speed of 1.0 m s(-1). Concentrations of ammonia (NH3), hydrogen sulfide (H2S), carbon dioxide (CO2), sulfur dioxide (SO2), and nitric oxide (NO) in 50-L air samples were measured. A panel of human subjects, whose sensitivity was verified with a certified reference odorant, evaluated odor concentration, intensity, and hedonic tone. Geometric mean odor concentrations of BCFC inlet and outlet samples and of downwind berm samples were 168 +/- 44 (mean +/- 95% confidence interval), 262 +/- 60, and 114 +/- 38 OU(E) m(-3) (OU(E), European odor unit, equivalent to 123 microg n-butanol), respectively. The overall geometric mean odor release was 2.3 +/- 1.5 OU(E) s(-1) m(-2) (1.5 +/- 0.9 OU s(-1) m(-2)). The live mass specific geometric mean odor release was 13.5 OU(E) s(-1) AU(-1) (animal unit = 500 kg live body mass). Overall mean NH3, H2S, CO2 and SO2 releases were 101 +/- 24, 5.7 +/- 2.0, 852 +/- 307, and 0.5 +/- 0.4 microg s(-1) m(-2), respectively. Nitric oxide was not detected. Odor concentrations were directly proportional to H2S and CO2 concentrations and odor intensity, and inversely proportional to hedonic tone and SO2 concentration (P < 0.05). Releases of NH3, H2S, and CO2 were directly proportional (P < 0.05) to volatile solids loading rate (VSLR).     

Functional classification of swine manure management systems based on effluent and gas emission characteristics

Gaseous emissions from swine (Sus scrofa) manure storage systems represent a concern to air quality due to the potential effects of hydrogen sulfide, ammonia, methane, and volatile organic compounds on environmental quality and human health. The lack of knowledge concerning functional aspects of swine manure management systems has been a major obstacle in the development and optimization of emission abatement technologies for these point sources. In this study, a classification system based on gas emission characteristics and effluent concentrations of total phosphorus (P) and total sulfur (S) was devised and tested on 29 swine manure management systems in Iowa, Oklahoma, and North Carolina in an effort to elucidate functional characteristics of these systems. Four swine manure management system classes were identified that differed in effluent concentrations of P and S, methane (CH4) emission rate, odor intensity, and air concentration of volatile organic compounds (VOCs). Odor intensity and the concentration of VOCs in air emitted from swine manure management systems were strongly correlated (r2 = 0.88). The concentration of VOC in air samples was highest with outdoor swine manure management systems that received a high input of volatile solids (Type 2). These systems were also shown to have the highest odor intensity levels. The emission rate for VOCs and the odor intensity associated with swine manure management systems were inversely correlated with CH4 and ammonia (NH3) emission rates. The emission rates of CH4, NH3, and VOCs were found to be dependent upon manure loading rate and were indirectly influenced by animal numbers.     

Nitrous oxide and ammonia fluxes in a soybean field irrigated with swine effluent

In the United States, swine (Sus scrofa) operations produce more than 14 Tg of manure each year. About 30% of this manure is stored in anaerobic lagoons before application to land. While land application of manure supplies nutrients for crop production, it may lead to gaseous emissions of ammonia (NH3) and nitrous oxide (N2O). Our objectives were to quantify gaseous fluxes of NH3 and N2O from effluent applications under field conditions. Three applications of swine effluent were applied to soybean [Glycine max (L.) Merr. 'Brim'] and gaseous fluxes were determined from gas concentration profiles and the flux-gradient gas transport technique. About 12% of ammonium (NH4-N) in the effluent was lost through drift or secondary volatilization of NH3 during irrigation. An additional 23% was volatilized within 48 h of application. Under conditions of low windspeed and with the wind blowing from the lagoon to the field, atmospheric concentrations of NH3 increased and the crop absorbed NH3 at the rate of 1.2 kg NH3 ha(-1) d(-1), which was 22 to 33% of the NH3 emitted from the lagoon during these periods. Nitrous oxide emissions were low before effluent applications (0.016 g N2O-N ha(-1) d(-1)) and increased to 25 to 38 g N2O-N ha(-1) d(-1) after irrigation. Total N2O emissions during the measurement period were 4.1 kg N2O-N ha(-1), which was about 1.5% of total N applied. The large losses of NH3 and N2O illustrate the difficulty of basing effluent irrigation schedules on N concentrations and that NH3 emissions can significantly contribute to N enrichment of the environment.     

Reduction of malodorous compounds from a treated swine anaerobic lagoon

There is a need for treatment technologies that can eliminate environmental problems associated with anaerobic lagoons. These technologies must be able to capture nutrients, kill pathogens, and reduce emissions of ammonia and nuisance odors. To meet these needs, a full-scale wastewater treatment plant was installed as a demonstration project on one of three 4360-pig (Sus scrofa) production units in a finishing farm in Duplin County, North Carolina. Once the treatment plant was operational, flow of raw manure into the unit's corresponding lagoon was discontinued and the lagoon was used to store treated wastewater. Water quality was monitored in the converted lagoon and in the two conventional lagoons. A gas chromatographic method was developed to measure concentration of five selected malodorous compounds (phenol, p-cresol, 4-ethylphenol, indole, and skatole) in liquid lagoon samples. Dramatic improvements in the water quality parameters TKN, NH3-N, solids, COD, and BOD in the converted waste lagoon paralleled reductions in malodorous compounds. Nine months after conversion, identified malodorous compounds in liquid extractions averaged 6.6 and 38.8 ng mL(-1) in water from the converted lagoon and the conventional lagoons, respectively. The reduction was particularly marked for p-cresol, 4-ethylphenol, and skatole, all of which make important contributions to swine waste odors due to their characteristic odors and low detection thresholds.     

Dispersion of odour: a case study with a municipal solid waste landfill site in North London,United Kingdom

Municipal solid waste (MSW) landfills are a potential source of offensive odours that can create annoyance within communities. Dispersion modelling was used to quantify the potential odour strength causing an impact on the community around a particular MSW landfill site north of the London area in the United Kingdom. The case studies were completed with the short-term mode of COMPLEX-I, software developed by the US-EPA. The year 1998 was chosen as a source of baseline data. It was observed that by 2004, when the landfill will progress towards the west and a big band of the area towards the north would be partly/fully restored, the maximum contribution of the new sources giving higher odour concentrations would be in the southwesterly regions away from the landfill. Concentrations as high as 25.0 ou(E)/m(3) were observed with 3 min averaging time in the southwesterly areas as compared to concentrations of 20.0 ou(E)/m(3) at 10 min averaging times. However, the percentage frequency of such critical events occurring would be low. All other surrounding farms and small villages would be exposed to the concentration of 3.0 ou(E)/m(3) on certain occasions. In the year 2008, the majority of the filling fronts would be filled with wastes with no contributions from the active and operational cells. The maximum odour concentration around the landfill site for 1 h averaging time would be approximately 3 ou(E)/m(3) about 1.0 km north and 500 m west of the landfill site. For 3 min averaging time, the stretch of 5 ou(E)/m(3) band would be up to 2.5 km towards the north of the landfill site. It is argued that further analysis of the model calculations considering effects of wind direction, frequency of wind direction, stability of the atmosphere, selected odour threshold, integration time of the model, etc. would form a basis for calculating the separation distances of the landfill site from the surrounding community.     

Manure sampling for nutrient analysis: variability and sampling efficacy

Reliable estimation of nutrient concentrations is required to manage animal manure for protecting waters while sustaining crop production. This study was conducted to investigate sample variability and reliable nutrient analysis for several manure types and handling systems. Serial samples were collected from dairy, swine, and broiler poultry operations while manure was being loaded onto hauler tanks or spreaders for field application. Samples were analyzed for total solids (TS), total nitrogen (N), ammoniacal nitrogen (NH4-N), total phosphorus (P), and potassium (K). The least number of samples needed for reliable testing of total N and P, defined as +/- 10% of the experimental means with 99% probability, was obtained for each farm using a computer-intensive random resampling technique. Sample variability within farms, expressed as the coefficient of variation (CV), was mostly 6 to 8% for farms that used agitation of manure storages but several times higher (20-30%) on farms where no agitation was applied during the sampling period. Results from the random resampling procedure indicated that for farms that used agitation, three to five samples were adequate for a representative composite for reliable testing of total N and P; whereas for farms without agitation, at least 40 samples would be required. Data also suggest that using book values for manure nutrient estimations could be problematic because the discrepancies between book standards and measured farm data varied widely from a small amount to several fold.     

Swine odor analyzed by odor panels and chemical techniques

The National Research Council identified odors as a significant animal emission and highlighted the need to develop standardized protocols for sampling and analysis. The purpose of our study was to compare different odor sampling techniques for monitoring odors emitted from stored swine manure. In our study, odorous headspace air from swine manure holding tanks were analyzed by human panels and analytical techniques. Odorous air was analyzed by human panels using dynamic dilution olfactometry (DDO). Chemical analysis used acid traps for ammonia (NH?), fluorescence for hydrogen sulfide (H?S), and thermal desorption gas chromatography-mass spectrometry for volatile organic compounds (VOCs). Chemical analysis included the use of gas chromatography-olfactometry (GC-O) for determining key odorants. Chemical odorant concentrations were converted to odor activity values (OAVs) based on literature odor thresholds. The GC-O technique used was GC-SNIF. Dilution thresholds measured by different odor panels were significantly different by almost an order of magnitude even though the main odorous compound concentrations had not changed significantly. Only 5% of the key odorous VOCs total OAVs was recovered from the Tedlar bags used in DDO analysis. Ammonia was the only chemical odorant significantly correlated with DDO analysis in the fresh (1 wk) and aged manure. Chemical analysis showed that odor concentration stabilized after 5 to 7 wk and that HS was the most dominant odorant. In aged manure, neither volatile fatty acids (VFAs) nor HS was correlated with any other chemical odorant, but NH, phenols, and indoles were correlated, and phenols and indoles were highly correlated. Correlation of odorant concentration was closely associated with the origin of the odorant in the diet. Key odorants determined by chemical and GC-O included indoles, phenols, NH?, and several VFAs (butanoic, 3-methylbutanoic, and pentanoic acids).     

Quantifying ammonia emissions from a cattle feedlot using a dispersion model

Livestock manure is a significant source of ammonia (NH3) emissions. In the atmosphere, NH3 is a precursor to the formation of fine aerosols that contribute to poor air quality associated with human health. Other environmental issues result when NH3 is deposited to land and water. Our study documented the quantity of NH3 emitted from a feedlot housing growing beef cattle. The study was conducted between June and October 2006 at a feedlot with a one-time capacity of 22,500 cattle located in southern Alberta, Canada. A backward Lagrangian stochastic (bLS) inverse-dispersion technique was used to calculate NH3 emissions, based on measurements of NH3 concentration (open-path laser) and wind (sonic anemometer) taken above the interior of the feedlot. There was an average of 3146 kg NH3 d(-1) lost from the entire feedlot, equivalent to 84 microg NH3 m(-2) s(-1) or 140 g NH3 head(-1) d(-1). The NH3 emissions correlated with sensible heat flux (r2 = 0.84) and to a lesser extent the wind speed (r2 = 0.56). There was also evidence that rain suppressed the NH3 emission. Quantifying NH3 emission and dispersion from farms is essential to show the impact of farm management on reducing NH3-related environmental issues.     

Concentrations of additive arsenic in Beijing pig feeds and the residues in pig manure

The swine industry in China has grown rapidly over last two decades. Great amount of pig manure is generated in China, which can be used as organic fertilizers on agricultural lands. Meanwhile, the organic arsenic compounds have been used as feed additives for swine disease control and weight improvement. Once the excessive additives are released in the environment, arsenic may compromise food safety and environmental quality. There is a growing public concern about the arsenic residues accumulation in pig manure, however, little work has been done to investigate the exact arsenic content in pig feed and the residues in manure in China This study investigates the concentrations of arsenic in 29 pig feed samples and 29 manure samples collected from eight pig farms in the Chaoyang district, Beijing city. The detected rate of arsenic in 29 couples of samples was 100%. The concentrations of arsenic in pig feeds and manures ranged from 0.15 to 37.8 mg/kg and 0.42 to 119.0 mg/kg, respectively. The result showed that arsenic concentration in pig manure will be greatly elevated when the arsenic in pig feed was largely increased. The loading rates of pig manure in fourteen Beijing counties and districts were in the range of 2.7–57.2 t/ha yr. Accordingly, the potential soil arsenic increase rates resulting from land application of pig manure might range between 11.8 and 78.9 μg/kg yr. Despite these findings, it is too early to draw the conclusion that arsenic pollution from pig manure is serious in Beijing farmland; therefore, longitudinal studies about the chemical form transformation and the environmental behaviors of pig manure arsenic are required in order to come up with more definitive conclusions.     

Effects of TiO2 based photocatalytic paint on concentrations and emissions of pollutants and on animal performance in a swine weaning unit

The beneficial effect of a TiO2-based photocatalytic treatment on the indoor air purification of a swine farm has been evaluated in a trial performed in two identical mechanically ventilated traditional weaning units, with 391 animals lodged in each of them. One unit was used as reference, whereas the walls of the second unit (260 m2) were coated with ca. 70 g m(-2) of TiO2 and irradiated with ten UV-A lamps. The environmental parameters (i.e. the ventilation rate, the internal and external temperature and relative humidity), together with NH3, CH4, CO2 and N2O concentrations in the exhaust ducts and PM10 emissions, were monitored in the two units throughout all of the production cycle (75 days). Significant decreases in CH4 concentration (ca. 27%, P < 0.05) and PM10 emission (ca. 17%, P < 0.01) were observed, together with an increase of the piglets' productive performance in the treated unit with respect to the reference one. Indeed, the ADG (Average Daily Gain of piglets) was 424 g vs. 414 g for the piglets lodged in the two units, respectively, with a significantly better feed conversion ratio (FCR, ratio between the food ingested by the animals and their weight gain) of 2.18 vs. 2.44 (P < 0.001). Therefore, the photocatalytic treatment with TiO2 coating had positive effects not only on methane concentration and particulate matter concentration and emission, but also significantly improved the feed conversion ratio of growing piglets, very likely due to the increased quality of indoor air, with positive economic repercussions for the farmer. Internal photocatalytic treatment in swine husbandry could thus be considered as a potential Best Available Technology (BAT).     

On-farm measurement of electrical conductivity for the estimation of ammonium nitrogen concentration in pig slurry

Pig (Sus scrofa domesticus) slurry (PS) is commonly applied as fertilizer to agricultural fields. Knowledge of PS nitrogen content is essential for good management, but PS nitrogen content is highly variable, not only between farms but also within a farm. Laboratory analysis of animal slurries is often expensive and impractical for routine farmer use. Therefore, when slurry is spread on land, its fertilizer value is generally unknown, resulting in the risk of pollution. In this work, two rapid and suitable for field use methods for determining PS ammonium N (NH(4)+-N) concentration (Quantofix and conductimetry) are evaluated. The electrical conductivity of a dilution 1 PS:9 distilled water had better results than Quantofix, did not need reagents, and gave a direct value of NH(4)+-N concentrations (range, 1.0-7.6 kg NH(4)+-N m(-3)). The conductimetry method allows the use of alternative waters with EC <1.9 dS m(-1) for dilution. This method is being introduced to farmers in northeast Spain to improve PS management and has been well received due to its low cost and ease of use.     

Olfactory response to mushroom composting emissions as a function of chemical concentration

Odor pollution is a major problem facing mushroom [Agaricus bisporus (Lange) Imbach] compost production. Techniques for quantifying mushroom composting odors are needed to assess the effectiveness of odor control measures. Odor samples were obtained in nalophane bags from 11 mushroom composting sites. Samples were collected 0.2 m downwind from the pre-wetting heaps (aerated or unaerated) of raw composting ingredients (wheat straw, poultry and horse manures, and gypsum) and subsequent Phase I composting windrows or aerated tunnels. The odor concentrations (OCs) of the samples were assessed using serial dilution olfactometry and the chemical composition of the samples was determined using gas chromatography-mass spectrometry (GC-MS), both 24 h after sampling. Gas detector tubes were used for on-site measurement of gaseous compounds. Odorants that exceeded their published olfactory detection thresholds by the greatest order of magnitude, in decreasing order, were: H2S, dimethyl sulfide (DMS), butanoic acid, methanethiol, and trimethylamine. Concentrations of NH3 were not significantly correlated with OC, and they were not significantly affected by the use of aeration. Aeration reduced the OC and the combined H2S + DMS concentrations by 87 and 92%, respectively. There was a very close correlation (r = 0.948, P < 0.001) between the OC of bag samples and the combined H2S + DMS concentrations, measured on-site with detector tubes. This relationship was unaffected by the NH3 concentration or the type of compost: aerated or unaerated, pre-wet or Phase I, poultry manure-based or horse and poultry manure-based compost. Prediction of the OC will enable rapid and low-cost identification of odor sources on mushroom composting sites.     

Influence of thymol and a urease inhibitor on coliform bacteria, odor, urea, and methane from a swine production manure pit

Pathogens, ammonia, odor, and greenhouse gas emissions are serious environmental concerns associated with swine production. This study was conducted in two manure pits (33,000 L each) to determine the influence of 1.5 or 3.0 g thymol L(-1) and 80 mg L(-1) urease inhibitor amendments on urea accumulation, coliform bacteria, odor, and methane emission. Each experiment lasted 18 or 19 d, during which time 30 to 36 250-mL samples (six per day) were withdrawn from underneath each pit and analyzed for urea, thymol, volatile fatty acids, coliform bacteria, and Campylobacter. At the end of each experiment, six 50-g samples from each pit were placed in serum bottles, and gas volume and composition were determined periodically for 28 d. Compared with the control pit, volatile fatty acids production was reduced 64 and 100% for the thymol amendments of 1.5 and 3.0 g L(-1), respectively. Viable coliform cells were reduced 4.68 and 5.88 log10 colony-forming units kg(-1) of slurry for the 1.5 and 3.0 g thymol L(-1), respectively, and Escherichia coli were reduced 4.67 and 5.01 log10 colony-forming units kg(-1) of slurry, respectively. Campylobacter was not detected in the pits treated with thymol, in contrast to 63% of the samples being positive for the untreated pit. Urea accumulated in the treated pits from Day 3 to 6. Total gas production from serum bottles was reduced 65 and 76% for thymol amendments of 1.5 and 3.0 g L(-1), respectively, and methane was reduced 78 and 93%, respectively. These results suggest that thymol markedly reduces pathogens, odor, and greenhouse gas emissions from a swine production facility. The urease inhibitor produced a temporary response in conserving urea.     

An economic evaluation of livestock odor regulation distances

Setback regulations-legislated distances that livestock production facilities must be removed from surrounding properties-are meant to mitigate odor impacts. If the setback length is too short, then there is evidence that surrounding properties and people suffer uncompensated damages. If, on the other hand, setback lengths are too long, then livestock producers may be paying more than that required to compensate for odor-related environmental damages. The purpose of this study is to assess the impact of Kentucky's livestock production facility setbacks on the value of surrounding properties and farm financial management decisions. This paper develops a model of the benefits of livestock odor reduction and the livestock odor abatement cost associated with setback lengths paid by producers. The results of this investigation indicate that the mandated setback lengths for Kentucky are too short. Livestock production firms are worse off under longer setback lengths, but the losses to surrounding home owners far exceed the firm gains at the mandated setbacks. A finding of this study is that the firm has no incentive to completely protect the legislated setback length. Livestock producers in compliance with the relevant setback length may feel protected from odor lawsuits despite damage being done to surrounding property. This suggests that the perceived threat of lawsuit is currently low in the state of Kentucky. Both industry and public goals could be met from further research including location and economic impact of livestock production.     

建设项目恶臭污染和治理的现状

介绍了建设项目恶臭的分类与来源,简述了恶臭处理的主要方法,尤其是生物治理技术的发展,并对未来的发展趋势进行了预测。