大型排架施工安全监控机制研究

以大型排架为研究对象,研究排架从设计开始、搭设过程、排架使用过程、排架拆除等环节,从安全组织、技术措施、监督检查、安全许可等方面严格把关,对工程建设参建各方应该履行的安全生产管理职责、权限、工作内容及工作流程进行梳理和细化,设置控制节点,强化中间环节的安全检查,实现排架全生命过程的安全控制,研究成果以程序文件表现。大型排架施工过程监控程序文件中有工作流程8个,对应安全检查表10个,工作流程环环相扣,安全检查表间相互关联。通过实施大型排架施工过程监控程序文件,严格过程监督管理,保证高排架在搭设与使用中不发生安全生产事故,有效杜绝了类似于高排架垮塌伤人等群体性伤害安全事故。     

作业姿势舒适性评价研究

将人体划分为四个节段,并对每个节段的不同姿势进行编码,实现了维修作业姿势的参数化定义,由12位健康的男性被试者参加,根据主观感觉利用自由模量幅度估计法对这些姿势的舒适性进行了评价和分级,得出了各种作业姿势的舒适级别,实现了对作业姿势舒适性的定量评价。     

Harmful postures and musculoskeletal symptoms among sanitation workers of a fish processing factory in ghana: a preliminary investigation.

This study investigated musculoskeletal symptoms among sanitation workers of a fish-processing factory. The methods used included administration of a questionnaire, walk through observation, interview, task analysis and future workshop. All 27 male participants answered and submitted their questionnaires. Of the 11 operations identified, all except one was considered safe. Bent back, bent legs, and heavy manual handling were observed to impose intolerable health risk on participants. This corresponds with questionnaire results in which musculoskeletal symptoms were mostly prevalent in the neck, the shoulder, the low back, the wrists/hands and the upper back regions. Poor psychosocial complaints were also made on the job. There was no significant correlation (p < .05) between musculoskeletal symptoms and age, working hours and length of service. Neither was any significant correlation observed (p < .05) between psychosocial work factors and musculoskeletal symptoms. Recommendations such as task redesign to eliminate high-risk elements in operations, workplace changes and worker training were suggested.     

泥质软弱破碎矿脉浅眼回采控制爆破试验研究

针对前河金矿泥质软弱破碎矿脉下向进路回采过程中超爆、上下盘围岩大面积垮塌、爆破后支护作业困难等问题,在总结分析软弱破碎岩体爆破特性的基础上,基于减震控制爆破基本理论,提出了“预留顶板充填体减震层、径向不耦合装药、控制边眼装药量、秒延期多段别控制起爆”等系列综合减震控制手段,据此分别针对Ⅳ级和Ⅴ级破碎岩体提出了2种具体的浅眼回采控制爆破技术方案,并进行了现场回采爆破试验。试验结果表明:所提出的2种方案均能够有效的控制回采边界,爆破后进路顶板充填体和上下盘围岩完整性良好,为后续采场出矿、支护等创造了有利的时空条件,且炸药单耗较原方案均有所降低。研究成果可分别在矿区范围内类似条件下推广应用。     

Analysis of postural load during tasks related to milking cows-a case study

The aim of this study was to analyse postural load during tasks related to milking cows of 2 farmers on 2 different farms (one with a manual milk transport system, the other with a fully automated milk transport system) as a case study. The participants were full-time farmers, they were both healthy and experienced in their job. The Ovako Working Posture Analyzing System (OWAS) was used to evaluate postural load and postural risk. Postural load was medium for the farmer on the farm with a manual milk transport system and high for the farmer working on the farm with a fully automated milk transport system. Thus, it can be concluded that a higher level of farm mechanization not always mean that the farmer's postural load is lower, but limitation of OWAS should be considered.     

Occupational injury rates among Norwegian farmers: A sociotechnical perspective

Introduction: This study addressed relative injury risk among Norwegian farmers, who are mostly self-employed and run small farm enterprises. The aim was to explore the relative importance of individual, enterprise, and work environment risks for occupational injury and to discuss the latent conditions for injuries using sociotechnical system theory. Method: Injury report and risk factors were collected through a survey among Norwegian farm owners in November 2012. The response rate was 40% (n = 2,967). Annual work hours were used to calculate injury rates within groups. Poisson regression using the log of hours worked as the offset variable allowed for the modeling of adjusted rate ratios for variables predictive of injury risk. Finally, safety climate measures were introduced to assess potential moderating effects on risk. Results: Results showed that the most important risk factors for injuries were the design of the workplace, type of production, and off-farm work hours. The main results remained unchanged when adding safety climate measures, but the measures moderated the injury risk for categories of predominant production and increased the risk for farmers working with family members and/or employees. An overall finding is how the risk factors were interrelated. Conclusions: The study identified large structural diversities within and between groups of farmers. The study drew attention to operating conditions rather than individual characteristics. The farmer’s role (managerial responsibility) versus regulation and safety climate is important for discussions of injury risk. Practical Applications: We need to study sub-groups to understand how regulation and structural changes affect work conditions and management within different work systems, conditioned by production. It is important to encourage actors in the political-economic system to become involved in issues that were found to affect the safety of farmers.     

煤矿瓦斯爆炸事故特征与耦合规律研究

分析瓦斯爆炸事故的瓦斯积聚原因、引爆火源和引爆地点等事故特征及其分类,统计并分析1988—2008年发生的563次瓦斯爆炸事故的基本特征和耦合规律,结果表明:通风混乱等通风系统问题导致瓦斯缓慢积聚的瓦斯爆炸事故占90.6%;电火花和放炮火焰引爆瓦斯占事故的78.6%;发生在采掘工作面的瓦斯爆炸事故占69.4%;通风系统问题导致瓦斯积聚的瓦斯爆炸事故主要发生在采掘工作面和巷道,占81.3%;通风系统问题导致瓦斯积聚的事故其引爆火源主要是电火花,占72.8%;电火花和放炮火焰引爆瓦斯主要发生在采掘工作面和巷道,占73.2%。有效预防和控制煤矿瓦斯爆炸事故需切实加强通风管理、电气管理和严格放炮操作与程序。     

煤巷掘进过程中粉尘浓度影响因素分析

为了掌握煤巷掘进过程中粉尘浓度变化的影响因素,根据气固两相流理论,针对矿井掘进工作面的特点,采用计算流体力学的离散相模型（DPM）考察了掘进巷道风速、风筒直径、风筒出风口到掘进工作面距离以及风筒的悬挂高度对粉尘浓度变化的影响。结果发现：当掘进巷道风速为0.25-4 m/s时,提高巷道内的通风风速,可以降低巷道内的粉尘浓度,缩短呼吸性粉尘浓度达到稳定的时间,减小工作面粉尘的危害;有利于通风除尘的风筒相关参数为风筒直径0.4-0.6 m、风筒出风口到掘进工作面距离6-7 m、风筒悬挂高度2.0-2.2 m。     

Risk factors associated with sick leave due to work-related injuries in Dutch farmers: an exploratory case-control study

Using data from an insurance company, the occurrence of sick leave among Dutch farmers due to work-related injuries, and the epidemiological risk factors were investigated. In this case-control study the cases had filed a sick leave claim for work-related injury from 1998–2001 and the controls had not filed any claim in this period. Most (74%) of all injuries were work-related. The most frequent types of injury (63%) were bruises, sprains/strains and fractures. Multivariable logistic regression analysis showed that farmers working in dairy farming (OR=2.6) or pig husbandry (OR=2.7), older farmers (OR=1.48 per 10 years) and smokers (OR=1.7) were at increased risk. Within dairy farming, a significant factor was contact with cows (OR=1.7 per 500 h); within pig husbandry, working > 60 h per week was a significant factor (OR=2.2). The population attributable risk was 24% for elimination of smoking, 23% for halving the number of hours' contact with cows in dairy farming and 18% for elimination of a working duration > 60 h per week in pig husbandry. Effective measures to prevent sick leave might be raising awareness that older farmers and smokers are at increased risk, and a focus on the risks of working with animals.     

Ripples in a pond: an open system model of the evolution of safety culture.

The development of an effective safety culture is essential to promote safe operations. Previous studies have either identified the characteristics of effective safety culture analytically, inferring them from signs and symbols derived from working practices, or have restricted the study of the development of safety culture to workers within an organisation. This paper describes a large-scale survey-based study in which the factors influencing the evolution of safety culture are identified empirically and, drawing upon open systems theory, are also extended beyond the bounds of the organisation. Three major determinants of safety culture are identified: safety concerns, influences and actions. Sub-components within each of these categories are also identified and the relationship between them is hypothesised.     

非平行壁面采场充填体三维应力分布规律研究*

为研究上下盘非平行壁面倾斜采场充填体应力分布规律,选取倾斜采场中三维水平充填层作为微分计算单元,基于极限平衡法考虑其竖直方向的受力平衡,提出非平行壁面的倾斜采场充填体的三维应力解析解,并分析不同参数对应力分布规律的影响。研究结果表明:三维条件下非平行壁面倾斜采场充填体竖向应力分布形式同平面应变条件下类似,在计算深度较小时竖向应力为近线性分布,随着计算深度的增加竖向应力增加率逐渐减小,但应力数值相对平面应变条件下较低。上盘倾角一定时,下盘倾角越大则拱效应越不明显;采场高度一定时,高宽比越大,拱效应越显著。充填体—围岩界面内摩擦角对充填体内拱效应影响较大,界面黏聚力和充填体抗剪强度参数对充填体应力分布影响相对较小。研究结果可为充填体强度设计提供参考。     

Footedness and Mounting—Short Review and Two Case Studies

Footedness is a personal quality like handedness. Footedness may be associated with moving ability during mounting, dismounting, and jumping movements. Occupational accidents have occurred during movement at different working levels, during the use of access and exit systems, and during the mounting of vehicles. Aging can also affect accident risk and body laterality. For example, falling accidents on stairs are common among the elderly. One reason for accidents may be that the structure of the access system or stair system is unsuitable for individual moving patterns depending partly on body laterality. Footedness and the way the feet are used may be contradictory to the demands of the moving situation, especially during uncommon or rapid situations. This contradiction may trigger disturbance during moving. The aims of this pilot study were (a) to review the literature briefly and (b) to describe the use of the dominant and nondominant foot by farmers and the elderly when mounting a tractor and stairs, respectively. The study also gives ideas for future studies based on both (a) and (b).     

石油野外作业工人体力劳动强度分级调查

据ＧＢ３８６９—８３标准对江汉油田测量、地震、钻井、井下四类野外作业３４名工人、２４个工种进行了体力劳动强度分级调查，其结果：测量作业为Ⅰ～Ⅱ级；钻井作业Ⅱ级占５／８，Ⅲ级占１／４；井下作业Ⅲ级占２／３；地震作业Ⅲ、Ⅳ级各占４／９、２／９。说明前两类基本属中等强度劳动，后两类大部分属重强度劳动。     

高频感应焊接场所电磁曝露的研究

分析了MOSFET(Metal-Oxide-Semiconductor Field-Effect Transistor)管固态电源高频焊机在工作过程中产生电磁场的机理,通过定性分析和实际测量描述了不同工作条件下的高频时变电场特征,与ICNIRP发布的限定值比较,分析了焊接作业人员的高频电磁曝露问题。通过对高频焊接环境电磁辐射的定量描述和认识,对于规范焊接操作,尽可能降低从业人员电磁曝露的影响具有指导意义。     

Perceptions of postural stability after transitioning to standing among construction workers

Falls are a leading cause of fatal and nonfatal injuries in the construction trades. This study explored construction workers’ self-reports of postural stability upon standing after working in different postures. One hundred and eighty-nine workers in 10 construction trades provided stability ratings by completing a written questionnaire. Additional data collected included age, gender, years of experience, and rating of overall balance. Construction workers rated their overall balance as high, furthermore, no difference was found between trades or age groups. Significant differences in stability ratings were provided for the various postures. The most commonly used non-erect postures (bent over at waist, squatting, and forward kneeling) resulted in the largest self-reports of instability. Sitting on elevated surface and sitting on level surface resulted in the highest levels of self-reported stability and are recommended when maintaining balance is a concern. Differences associated with construction trade and age were also found, but were thought to be attributed to differences in tasks performed since no differences were found when each posture was analyzed separately. The results suggest that the working posture used to complete a task affects the postural stability upon standing regardless of construction trade and age of worker. Findings may lead to recommendations for redesign of tasks or tools to reduce the use of certain working postures, particularly in high-risk environments such as construction.     

Bystander injury evaluation of children from midwestern agricultural operations

Background

With more than a million youth living on agricultural operations, it is important for parents to understand the consequences of bystander injuries that children experience in these environments. We identified the childhood injuries for bystander status and compared the severity of these injuries to the working children in the Regional Rural Injury Study-II (RRIS-II).

Methods

RRIS-II followed 16,546 children (∼ 85% of eligible) from rural communities in the Midwest for two six-month recall periods in 1999 and 2001. Demographic, injury, and exposure data were collected through comprehensive computer-assisted telephone interviews. Child injuries were cataloged using narrative scenarios into four categories: (a) directly work-related; (b) indirectly work-related; (c) non-working accomplice; and (d) non-working attendant; the latter three all being bystander categories. Poisson regression modeling was used to calculate rates of bystander injuries. Frequencies were used for comparison of severity measures.

Results

Among the 463 child injuries (aged < 20 yrs), 102 were bystander injuries. Of the bystander-related injuries, 14 were identified as indirectly work-related (working bystanders), 27 as non-working accomplice (passengers/tag-alongs), and 60 as non-working attendant (playing on the operation). The overall rate of bystander injuries was 6.4 per 1,000 people, 95% CI (5.0, 8.1). Males, compared with females, had more than twice the injury rate (8.7; 95% CI 6.4-11.8, and 3.9; 95% CI 2.7-5.7, per 1,000 people, respectively). Bystanders in this population had more severe injuries with 4% having life-threatening circumstances; of these, 4% of the accomplices and 2% of the attendants subsequently died.

Conclusions

Children who live or work on agricultural operations are vulnerable to many hazards. Therefore, this study examined child injuries and found a clear difference in the consequences of these injuries between working-related and bystanding-related injuries.

Impact on Industry

Unlike occupations such as construction and mining, where laws and organizations have been created for the protection of bystanders, agricultural bystanders have remained unprotected and have had to face the consequent injury and death outcomes. As public health professionals considering these risks, it is necessary that we work to develop more intervention studies and continue to propose suggestive guidelines for child safety in these environments so as to challenge family traditions and possibly spark public policies that will give further protection to this population.     

开采引起的覆岩冒落及地表沉陷的机理与防护

本文根据覆岩的实际受力情况，对开采引起的覆岩冒落和地表沉陷机理进行了研究。即首先是岩层离层与弯曲，接着岩体移动，从而导至上覆岩层冒落，出现地表沉陷，并给出了相应的预防和维护措施。     

高温户外环境电网作业人员热应激预测评价*

为了预测分析户外高温环境下电网作业人员热安全风险,采用预测热应激（Predicted Heat Strain,PHS）模型,考虑人体基础代谢率个体差异性和人体移动与风速对服装热阻和湿阻的影响,应用改进后的预测热应激模型对多种户外高温作业环境工况和不同劳动强度下电网作业人员的核心体温、出汗量等生理参数和最大允许暴露时长进行计算分析。结果表明:在户外高温环境中,随着环境温度、相对湿度和新陈代谢率的升高,电网作业人员的核心体温也随之升高,湿热环境中风速的增加会加剧电网作业人员的热应激;当电网作业人员从事代谢率为240 W/m2高劳动强度工作时,可接受的最大工作时长相比代谢率为190 W/m2中度劳动强度工作时长减小50%以上。研究结果可为电网公司夏季户外工作组织策略制定和作业人员热安全防护提供参考支持。