工业余热拆卸废旧电路板

电路板插槽元器件、通孔元器件、大元器件和小元器件的拆卸是废旧电路板资源化的第一步。前三者的拆卸率对后续的电路板粉碎有较大影响,是决定拆卸效果的重要参数。为探究工业余热拆卸废旧电路板方法中通气温度、加热时间和喷吹次数对元器件拆卸率的影响,找出最优的拆卸参数组合,进行了废旧电路板拆卸的正交实验。对元器件拆卸率、关键元器件总拆卸率的极差分析和方差分析表明,通气温度和加热时间的增大有利于元器件拆卸率增大;增加喷吹次数,有利于大元器件和小元器件的拆卸,但过多次数喷吹将造成插槽、通孔元器件引脚弯曲,拆卸率减小;通气温度、加热时间对元器件拆卸的影响不具显著性,喷吹次数仅对大元器件拆卸有显著性影响。综合分析关键元器件的拆卸率:通气温度350℃、加热时间5 min和喷吹6次是最优的拆卸参数组合,关键元器件总拆卸率达到98.6%。     

超临界CO2回收线路板工艺研究

用正交试验设计进行了超临界CO2回收废弃印刷线路板的实验。以温度、压强、时间和夹带剂为实验因素,通过对实验前后样本在重量、厚度、弯曲强度和断裂强度四方面变化的分析考察了各实验因素对实验效果的影响。实验结果表明,影响超临界CO2法回收印刷线路板的最主要因素为温度、时间和夹带剂,超临界CO2法回收废弃印刷线路板的最佳工艺条件：温度270℃,压强大于7．38MPa,时间3h,夹带剂（水）160mL。实验进一步验证了压强对实验结果的非显著性影响。     

高温袋式除尘器金属滤袋脉冲喷吹清灰性能分析

为解决高温袋式除尘器在应用中因压缩空气温度偏低导致金属滤袋糊袋,以及因清灰参数选取不当导致滤袋残余阻力上升和除尘器运行阻力升高的问题,使用滤料微观模型分析过滤状态下颗粒在清洁金属和有机纤维层的穿透过程;并结合物理模型与数值模拟正交实验研究不同因素对不锈钢金属滤袋脉冲喷吹清灰过程的影响;以传统有机滤袋做对照,通过数值模拟实验研究在高温状况下脉冲喷吹清灰气流对金属滤袋袋口区域结露的影响。结果表明,在相同的颗粒粒径条件下,清洁金属滤料纤维的颗粒穿透量和穿透距离更大,拦截效应低于有机纤维滤料。滤袋清灰效果整体呈现上部>底部>中部的趋势,且金属滤袋清灰评价指标测试值整体低于传统有机滤袋;显著影响滤袋清灰的因素均为喷吹压力和喷吹孔径,金属滤袋最佳喷吹距离为200 mm,喷吹时间为100 ms。当脉冲喷吹气流温度为0℃时,滤袋袋口0.5～2 m处有结露风险,升高至50℃可有效防止工业窑炉烟气滤袋袋口区域结露现象的产生。该研究结果可为高温袋式除尘器金属滤袋的喷吹参数设计和结构优化提供参考。     

超临界CO2回收线路板工艺研究

采用正交试验设计进行了超临界CO₂回收废弃印刷线路板的实验。以温度、压强、时间和夹带剂为实验因素,通过对实验前后样本在重量、厚度、弯曲强度和断裂强度四方面变化的分析考察了各实验因素对实验效果的影响。实验结果表明,影响超临界CO₂法回收印刷线路板的最主要因素为温度、时间和夹带剂,超临界CO₂法回收废弃印刷线路板的最佳工艺条件：温度270℃,压强大于7.38 MPa,时间3 h,夹带剂(水)160 mL。实验进一步验证了压强对实验结果的非显著性影响。     

用光伏污泥焚烧灰渣制备轻集料

针对工业污泥焚烧灰渣处置难的现状,以光伏污泥焚烧灰渣为主要原料制备轻集料。确定轻集料烧制的最佳条件为,黏土投加量为70%,MgO投加量为5%,污泥焚烧灰渣投加量为25%,预热温度为450℃,预热时间为15 min,焙烧温度为1 050℃,焙烧时间分别为10 min,所制备出的轻集料的抗压强度为9.52 MPa,堆积密度为867 kg·m~(-3),烧失量为0.12%,1 h吸水率为1.94%。所制得的轻集料强度高,吸水率小,符合《轻集料及其实验方法.第二部分:轻集料实验方法》(GB/T 17431.2-2010)的要求,可为光伏污泥焚烧灰渣资源化提供理论指导。     

废弃印刷线路板最佳分离参数的实验研究

为研究废弃印刷线路板的热解特性,确定金属和非金属分离的热解最佳参数,用差热-热重联用分析仪对FR-4型印刷线路板进行了热失重分析,并对影响废弃印刷线路板中金属和非金属分离效果的升温速率、颗粒尺寸、热解终温和保温时间等主要因素进行了实验研究。结果表明,FR-4型线路板在320~360℃区间热失重速率达到最大值;升温速率越高,热解起始温度、终止温度和失重峰温也越高,显著失重过程持续的时间越长;当热解终温相同时,升温速率对FR-4型线路板的热失重率影响很小。综合考虑FR-4型废弃印刷线路板中金属和非金属的分离效果、热解装置的设计、热解过程的能耗以及运行过程的控制等因素,最佳热解参数建议设定为升温速率为10℃/min,热解终温为500℃,保温时间取30 min为宜。     

废弃印刷线路板碘化法浸金研究

针对碘化法从废弃印刷线路板中提取金的工艺设计,分别考察了碘的质量分数、n(I₂)/n(I^-)比值、固液比、双氧水的质量分数、pH值、浸出时间和浸出温度对金浸出率的影响。结合正交设计优化实验方法,提出了从废弃印刷线路板中碘化法浸取金的最佳工艺条件：碘的质量分数为1.1％,n(I₂)∶n(I^-)=1∶10,双氧水的质量分数为1.5％,浸出时间4 h,固液比为1∶10,浸出温度为常温（25℃）,溶液pH值为中性,此时金浸出率可达97.5％。     

柴油机微粒捕集器臭氧再生法离线再生

由R175型柴油机、微粒捕集器(Φ90 mm×150 mm)、CF-G10型臭氧发生器组成实验系统,进行了臭氧再生法离线再生研究。研究表明,在190℃温度下,再生气从DPF上游侧进气再生时,臭氧可以有效再生DPF,再生效率可达90%以上,再生效率达到65%左右时发生臭氧穿透,臭氧利用率下降;穿透时间点随微粒捕集时的柴油机载荷增大而提前,随微粒捕集时间增加而提前;臭氧供给量不变,再生气流量越大,再生效果越明显;再生气从DPF下游侧进气再生时,臭氧穿透时间点较上游侧进气再生滞后,但发生穿透后DPF几乎不再再生,总再生效率低于70%。结果表明,微粒捕集器臭氧再生法是可行的,对于如何提高臭氧利用率需进一步研究。     

真空碳热还原法无害化处理废弃阴极射线管锥玻璃的研究

危险电子废物阴极射线管(cathode ray tube,CRT)是当前我国电子垃圾处理处置中首要必须解决的难题,其关键在于含铅锥玻璃的处珲处置.本研究探讨了真空碳热还原法从CRT锥玻璃中分离并回收有害重会属铅的同时同收钾和钠的规律.结果表明,铅、钾和钠的回收率随温度的升高、压力的降低、碳加入量的增加及保持时间的延长而增大;当温度为1 000℃、系统压力为10 Pa时,加入10%的碳粉并保持4 h,铅回收率接近100%,钠和钾的回收率分别为65.04%和50.55%.该方法为废弃阴极射线管玻璃的无害化和资源化提供了理论依据和实验数据.     

生物滴滤器处理间二氯苯废气的性能分析

从土壤中筛选1株能够降解间二氯苯能力的菌株,鉴定为土壤短芽孢杆菌(Brevibacillus agri),该优势菌最佳生长条件为:降解时间48 h,菌液接种量10%,pH=7,温度25℃。以间二氯苯为模拟有机废气,采用生物滴滤器接种土壤短芽孢杆菌的方法对其进行生物处理。结果表明,在空床停留时间为90 s、进气浓度为1 000 mg·m~(-3)、进气负荷为60 g·(m~3·h)~(-1)条件下,间二氯苯的去除率可以维持在85%以上。生物滴滤器稳定运行后,菌体表面官能团发生改变,通过傅里叶红外光谱和X射线光电子能谱分析发现,菌株通过逐步加氧羧化后开环降解间二氯苯;对菌株再进行16S rRNA基因序列的同源性分析发现,生物膜中Brevibacillus agri占比达69.39%,并可以良好生长。研究可为间二氯苯的工业化处理提供参考。     

Chloroaromatic pollutants in mussels incubated in two finnish watercourses polluted by industry

Concentrations of different chlorinated compounds were measured in mussels incubated in two polluted watercourses, a river (the River Kymijoki) and a lake (Lake Vanaja) for four weeks in summer 1995. The sum concentrations of polychlorinated phenols (PCP) and biphenyls (PCB) were both about 1 μg/g lipid weight (lw) in Lake Vanaja mussels, while in the River Kymijoki mussels PCPs were non-detectable and PCBs were measured 120 ng/g lIw. The concentrations of toxic polychlorinated dibenzo-p-dioxin (PCDD) and dibenzofuran (PCDF) congeners ranged between <17 and 370 pg/g Iw in Lake Vanaja mussels and between <38 and 11,000 pg/g lw in the River Kymijoki mussels. Polychlorinated diphenyl ethers (PCDE) were detected in the mussels incubated in the River Kymijoki (0.4–1.1 ng/g Iw), but not in those incubated in Lake Vanaja. Polychlorinated phenoxyanisoles (PCPA) were measured 33 ng/g lw and polychlorinated phenoxyphenols (PCPP) 300 ng/g lw in the mussels incubated in the River Kymijoki. PCPAs were also detected in reference samples, which were sediment and pike from the River Kymijoki and Baltic salmon, seal and white-tailed sea eagle.     

Radionuclides and trace elements in fish collected upstream and downstream of Los Alamos national laboratory and the doses to humans from the consumption of muscle and bone

Abstract

The purpose of this study was to determine radionuclide and trace element concentrations in bottom‐feeding fish (catfish, carp, and suckers) collected from the confluences of some of the major canyons that cross Los Alamos National Laboratory (LANL) lands with the Rio Grande (RG) and the potential radiological doses from the ingestion of these fish. Samples of muscle and bone (and viscera in some cases) were analyzed for ³H, ⁹⁰Sr, ¹³⁷Cs, ^totU, ²³⁸Pu, ^239,240Pu, and ²⁴¹Am and Ag, As, Ba, Be, Cr, Cd, Cu, Hg, Ni, Pb, Sb, Se, and Tl. Most radionuclides, with the exception of ⁹⁰Sr, in the muscle plus bone portions of fish collected from LANL canyons/RG were not significantly (p<0.05) higher from fish collected upstream (San Ildefonso/background) of LANL. Strontium‐90 in fish muscle plus bone tissue significantly (p<0.05) increases in concentration starting from Los Alamos Canyon, the most upstream confluence (fish contained 3.4E‐02 pCi g^‐1 [126E‐02 Bq kg^‐1]), to Frijoles Canyon, the most downstream confluence (fish contained 14E‐02 pCi g^‐1 [518E‐02 Bq kg^‐1]). The differences in ⁹⁰Sr concentrations in fish collected downstream and upstream (background) of LANL, however, were very small. Based on the average concentrations (±2SD) of radionuclides in fish tissue from the four LANL confluences, the committed effective dose equivalent from the ingestion of 46 lb (21 kg) (maximum ingestion rate per person per year) of fish muscle plus bone, after the subtraction of background, was 0.1 ± 0.1 mrem y^‐1 (1.0 ± 1.0 μSv y^‐1), and was far below the International Commission on Radiological Protection (all pathway) permissible dose limit of 100 mrem y^‐1 (1000 μSv y^‐1). Of the trace elements that were found above the limits of detection (Ba, Cu, and Hg) in fish muscle collected from the confluences of canyons that cross LANL and the RG, none were in significantly higher (p<0.05) concentrations than in muscle of fish collected from background locations.     

Book review

The Pesticide Manual ‐ A World Compendium, 8th Edition, C.R. Worthing, Editor and S.B. Walker, Assistant Editor, British Crop Protection Council, BCPC Publications Sales, Bear Farm, Binfield, Bracknell, Berkshire RG12 5QE, England. 1987, 1100 pp., UK £50; Overseas £56. ISBN 0–948404–01–9.     

Patterns of volatile metabolites and nonvolatile trichothecenes produced by isolates of <Emphasis Type="Italic">Stachybotrys,Fusarium, Trichoderma,Trichothecium</Emphasis> and <Emphasis Type="Italic">Memnoniella</Emphasis>

We reported previously that trichodiene, a volatile trichothecene derivative, was produced by a Stachybotrys isolate, also known to produce highly cytotoxic, non-volatile, macrocyclic trichothecenes (satrotoxins). We investigated the relationship between the production of trichodiene and various non-volatile trichothecenes for several molds. Volatile metabolites were concentrated by adsorption on Tenax TA and analyzed by GC/MS, while non-volatile metabolites were separated by HPLC, derivatized and analyzed by GC/MS. Stachybotrys chartarum isolates producing macrocyclic trichothecenes secreted significantly larger amounts of trichodiene and other sesquiterpenes than isolates which only produced simple trichothecenes. The amounts of secreted trichodiene were relatively small in all cases. With the exception of Memnoniella, which excreted small amounts of sesquiterpenes, the other isolates produced varying amounts of sesquiterpenes, including trichodiene, as well as simple tricothecenes, no detectable trichodiene, but large amounts of griseofulvin derivatives. In Stachybotrys there is apparently a correlation between trichodiene and macrocyclic trichothecene production. In the remaining isolates, there was no simple relationship between trichodiene and non-volatile trichothecene synthesis. Trichodiene is produced in larger amounts by Stachybotrys isolates, which also produce satratoxins, but it will be difficult to utilize this metabolite to detect toxic isolates in buildings due to the relatively small amounts excreted.     

Observations on the influence of water and soil pH on the persistence of insecticides

Abstract

The pH‐disappearance rate profiles were determined at ca. 25°C for 24 insecticides at 4 or 5 pH values over the range 4.5 to 8.0 in sterile phosphate buffers prepared in water‐ethanol (99: 1 v/v). Half‐lives measured at pH 8 were generally smaller than at lower pH values. Changes in half lives between pH 8.0 and 4.5 were largest (>1000x) for the aryl carbamates, carbofuran and carbaryl, the oxime carbamate, oxamyl, and the organophosphorus insecticide, trichlorfon. In contrast, half lives of phorate, terbufos, heptachlor, fensulfothion and aldicarb were affected only slightly by pH changes. Under the experimental conditions described half lives at pH8 varied from 1–2 days for trichlorfon and oxamyl to >1 year for fensulfothion and cyper‐methrin. Insecticide persistence on alumina (acid, neutral and basic), mineral soils amended with aluminum sulfate or calcium hydroxide to different pH values and four natural soils of different pH was examined. No correlation was observed between the measured pH of these solids and the rate of disappearance of selected insecticides applied to them. These observations demonstrate the difficulty of extrapolating the pH dependent disappearance behaviour observed in homogeneous solution to partially solid heterogeneous systems such as soil.     

The chemical stability of formulations of some hydrolyzable insecticides in aqueous mixtures with hydrolysis catalysts

Abstract

The active ingredients in commercial formulations of malathion, oxamyl, carbaryl, diazinon, and chlorpyrifos diluted to “spray tank”; concentrations with buffered distilled or natural water of pH 4–9 were stable for at least 24 hr. Formulations of trichlorfon were not stable at pH 7 or above but disappearance rates were slower than for the pure chemical in homogeneous solution. Cupric ion was observed to be an effective catalyst for the hydrolysis of a variety of pure organophosphorus insecticides but did not catalyze hydrolysis of the active ingredients of the formulations examined. Increasing the dilution of the formulation increased the susceptibility of malathion, oxamyl, and carbaryl to hydrolysis.     

Organochlorine compounds in a three-step terrestrial food chain

The concentrations of 15 organochlorine chemicals (PCBs and pesticides) were studied in a Central European oak wood food chain system: Great tit (Parus major), caterpillars (Tortrix viridana, Operophtera brumata, Erannis defoliaria), and oak-leaves (Quercus robur). Juvenile tits receive organochlorines from the mother via egg transfer and, eventually to a greater extent, from the caterpillar food source during nestling period. The concentrations of PCB 153 (2,2′,4,4′,5,5′-hexachlorobiphenyl, the most abundant in this study) was found in leaf material at ca. 1 ng/g, in caterpillars 10 ng/g, and in bird eggs 170 ng/g on an average and on a dry mass basis.     

Radionuclides in deer and elk from Los Alamos national laboratory and the doses to humans from the ingestion of muscle and bone

Abstract

This paper summarizes radionuclide concentrations (³H, ⁹⁰Sr, ¹³⁷Cs, ²³⁸Pu, ^239,240Pu, ²⁴¹Am, and ^totU) in muscle and bone tissue of mule deer (Odocoileus hemionus) and Rocky Mountain elk (Cervus elaphus) collected from Los Alamos National Laboratory (LANL), Los Alamos, New Mexico, lands from 1991 through 1998. Also, the committed effective dose equivalent (CEDE) and the risk of excess cancer fatalities (RECF) to people who ingest muscle and bone from deer and elk collected from LANL lands were estimated. Most radionuclide concentrations in muscle and bone from individual deer (n = 11) and elk (n = 22) collected from LANL lands were either at less than detectable quantities (where the analytical result was smaller than two counting uncertainties) and/or within upper (95%) level background (BG) concentrations. As a group, most radionuclides in muscle and bone of deer and elk from LANL lands were not significantly higher (p<0.10) than in similar tissues from deer (n = 3) and elk (n = 7) collected from BG locations. Also, elk that had been radio collared and tracked for two years and spent an average time of 50% on LANL lands were not significantly different in most radionuclides from road kill elk that have been collected as part of the environmental surveillance program. Overall, the upper (95%) level net CEDEs (the CEDE plus two sigma for each radioisotope minus background) at the most conservative ingestion rate (50 lbs of muscle and 13 lbs of bone) were as follows: deer muscle = 0.22 mrem y^‐1 (2.2 μSv y^‐1), deer bone = 3.8 mrem y^‐1 (38 μSv y^‐1), elk muscle = 0.12 mrem y^‐1 (1.2 μSv y^‐1), and elk bone = 1.7 mrem y^‐1 (17 μSv y^‐1). All CEDEs were far below the International Commission on Radiological Protection guideline of 100 mrem y^‐1 (1000 μSv y^‐1), and the highest muscle plus bone net CEDE corresponded to a RECF of 2E‐06, which is far below the Environmental Protection Agency upper level guideline of 1E‐04.     

Radionuclides in pinon pine (Pinus edulis) nuts from los alamos national laboratory lands and the dose from consumption

Abstract

One of the dominant tree species growing within and around the eastern portion of Los Alamos National Laboratory (LANL), Los Alamos, NM, lands is the pinon pine (Pinus edulis). Pinon pine is used for firewood, fence posts, and building materials and is a source of nuts for food—the seeds are consumed by a wide variety of animals and are also gathered by people in the area and eaten raw or roasted. This study investigated the (1) concentration of ³H, ¹³⁷Cs, ⁹⁰Sr, ^totU, ²³⁸Pu, ^{239, 240}Pu, and²⁴¹ Am in soils (0‐ to 12‐in. [31 cm] depth underneath the tree), pinon pine shoots (PPS), and pinon pine nuts (PPN) collected from LANL lands and regional background (BG) locations, (2) committed effective dose equivalent (CEDE) from the ingestion of nuts, and (3) soil to PPS to PPN concentration ratios (CRs). Most radionuclides, with the exception of ³H in soils, were not significantly higher (p < 0.10) in soils, PPS, and PPN collected from LANL as compared to BG locations, and concentrations of most radionuclides in PPN from LANL have decreased over time. The maximum net CEDE (the CEDE plus two sigma minus BG) at the most conservative ingestion rate (10 lb [4.5 kg]) was 0.0018 mrem (0.018 μSv); this is far below the International Commission on Radiological Protection (all pathway) permissible dose limit of 100 mrem (1000 μSv). Soil‐to‐nut CRs for most radionuclides were within the range of default values in the literature for common fruits and vegetables.     

Degradation and sorption of imidacloprid in dissimilar surface and subsurface soils

Degradation and sorption/desorption are important processes affecting the leaching of pesticides through soil. This research characterized the degradation and sorption of imidacloprid (1-[(6-chloro-3-pyridinyl)-methyl]-N-nitro-2-imidazolidinimine) in Drummer (silty clay loam) and Exeter (sandy loam) surface soils and their corresponding subsurface soils using sequential extraction methods over 400 days. By the end of the incubation, approximately 55% of imidacloprid applied at a rate of 1.0 mg kg^?1 degraded in the Exeter sandy loam surface and subsurface soils, compared to 40% of applied imidacloprid within 300 days in Drummer surface and subsurface soils. At the 0.1 mg kg^?1 application rate, dissipation was slower for all four soils. Water-extractable imidacloprid in Exeter surface soil decreased from 98% of applied at day 1 to > 70% of the imidacloprid remaining after 400 d, as compared to 55% in the Drummer surface soil at day 1 and 12% at day 400. These data suggest that imidacloprid was bioavailable to degrading soil microorganisms and sorption/desorption was not the limiting factor for biodegradation. In subsurface soils > 40% of ¹⁴C-benzoic acid was mineralized over 21 days, demonstrating an active microbial community. In contrast, cumulative ¹⁴CO₂ was less than 1.5% of applied ¹⁴C-imidacloprid in all soils over 400 d. Qualitative differences in the microbial communities appear to limit the degradation of imidacloprid in the subsurface soils.