Carbon, nitrogen balances and greenhouse gas emission during cattle feedlot manure composting

Carbon and N losses reduce the agronomic value of compost and contribute to greenhouse gas (GHG) emissions. This study investigated GHG emissions during composting of straw-bedded manure (SBM) and wood chip-bedded manure (WBM). For SBM, dry matter (DM) loss was 301 kg Mg(-1), total carbon (TC) loss was 174 kg Mg(-1), and total nitrogen (TN) loss was 8.3 kg Mg(-1). These correspond to 30.1% of initial DM, 52.8% of initial TC, and 41.6% of initial TN. For WBM, DM loss was 268 kg Mg(-1), TC loss was 154 kg Mg(-1), and TN loss was 1.40 kg Mg(-1), corresponding to 26.5, 34.5, and 11.8% of initial amounts. Most C was lost as CO2 with CH4 accounting for <6%. However, the net contribution to greenhouse gas emissions was greater for CH4 since it is 21 times more effective at trapping heat than CO2. Nitrous oxide (N2O) emissions were 0.077 kg N Mg(-1) for SBM and 0.084 kg N Mg(-1) for WBM, accounting for 1 to 6% of total N loss. Total GHG emissions as CO2-C equivalent were not significantly different between SBM (368.4 +/- 18.5 kg Mg(-1)) and WBM (349.2 +/- 24.3 kg Mg(-1)). However, emission of 368.4 kg C Mg(-1) (CO2-C equivalent) was greater than the initial TC content (330.5 kg Mg(-1)) of SBM, raising the question of the net benefits of composting on C sequestration. Further study is needed to evaluate the impact of composting on overall GHG emissions and C sequestration and to fully investigate livestock manure management options.     

Chemical and physical changes following co-composting of beef cattle feedlot manure with phosphogypsum

Nitrogen (N) loss during beef cattle (Bos taurus) feedlot manure composting may contribute to greenhouse gas emissions and increase ammonia (NH(3)) in the atmosphere while decreasing the fertilizer value of the final compost. Phosphogypsum (PG) is an acidic by-product of phosphorus (P) fertilizer manufacture and large stockpiles currently exist in Alberta. This experiment examined co-composting of PG (at rates of 0, 40, 70, and 140 kg PG Mg(-1) manure plus PG dry weight) with manure from feedlot pens bedded with straw or wood chips. During the 99-d composting period, PG addition reduced total nitrogen (TN) loss by 0.11% for each 1 kg Mg(-1) increment in PG rate. Available N at the end of composting was significantly higher for wood chip-bedded (2180 mg kg(-1)) than straw-bedded manure treatments (1820 mg kg(-1)). Total sulfur (TS) concentration in the final compost increased by 0.19 g kg(-1) for each 1 kg Mg(-1) increment in PG rate from 5.2 g TS kg(-1) without PG addition. Phosphogypsum (1.6 g kg(-1) P) addition had no significant effect on total phosphorus (TP) concentration of the final composts. Results from this study demonstrate the potential of PG addition to reduce overall N losses during composting. The accompanying increase in TS content has implications for use of the end-product on sulfur-deficient soils. Co-composting feedlot manure with PG may provide an inexpensive and technologically straightforward solution for managing and improving the nutrient composition of composted cattle manure.     

Fate of coliform bacteria in composted beef cattle feedlot manure

The link between livestock production, manure management, and human health has received much public attention in recent years. Composting is often promoted as a means of sanitizing manure to ensure that pathogenic bacteria are not spread to a wider environment during land application. In a two-year study (1998 and 1999) in southern Alberta, we examined the fate of coliform bacteria during windrow composting of cattle (Bos taurus) manure from feedlot pens bedded with cereal straw or wood chips. Numbers of total coliforms (TC) and Escherichia coli declined as the composting period progressed. In 1998, TC levels (mean of both bedding types) were log10 7.86 cells g(-1) dry wt. for raw manure on Day 0, log10 3.38 cells g(-1) by Day 7, and log10 1.69 cells g(-1) by Day 14. More than 99.9% of TC and E. coli was eliminated in the first 7 d when average windrow temperatures ranged from 33.5 to 41.5 degrees C. The type of bedding did not influence the numbers of TC or E. coli. Dessication probably played a minor role in coliform elimination, since water loss was low (< 0.07 kg kg(-1)) in the first 7 d of composting. However, total aerobic heterotroph populations remained high (> 7.0 log10 CFU g(-1) dry wt., where CFU is colony forming units) throughout the composting period, possibly causing an antagonistic effect. Land application of compost, with its nondetectable levels of E. coli compared with raw manure, should minimize environmental risk in areas of intensive livestock production.     

Bedding and seasonal effects on chemical and bacterial properties of feedlot cattle manure

Nutrients, soluble salts, and pathogenic bacteria in feedlot-pen manure have the potential to cause pollution of the environment. A three-year study (1998-2000) was conducted at a beef cattle (Bos taurus) feedlot in southern Alberta, Canada to determine the effect of bedding material [barley (Hordeum vulgare L.) straw versus wood chips] and season on the chemical and bacterial properties of pen-floor manure. Manure was sampled for chemical content (N, P, soluble salts, electrical conductivity, and pH) and populations of four groups of bacteria (Escherichia coli, total coliforms, and total aerobic heterotrophs at 27 and 39 degrees C). More chemical parameters of manure were significantly (P < or = 0.05) affected by season (SO4, Na, Mg, K, Ca, sodium adsorption ratio [SAR], total C, NO3-N, NH4-N, total P, and available P) than by bedding (K, pH, total C, C to N ratio, NH4-N, and available P). Bedding had no significant (P > 0.05) effect on the four bacterial groups whereas season affected all four groups. Numbers of E. coli and total coliforms (TC) were significantly higher by 1.72 to 2.02 log10 units in the summer than the other three seasons, which was consistent with a strong positive correlation of E. coli and TC with air temperature. The low ratio of bedding to manure in the pens was probably the major cause of the lack of significant bedding effects. Bedding material and seasonal timing of cleaning feedlot pens and land application of manure may be a potential tool to manage nutrients, soluble salts, and pathogens in manure.     

Fresh, stockpiled, and composted beef cattle feedlot manure: nutrient levels and mass balance estimates in Alberta and Manitoba

The fate of manure nutrients in beef cattle (Bos taurus) feedlots is influenced by handling treatment, yet few data are available in western Canada comparing traditional practices (fresh handling, stockpiling) with newer ones (composting). This study examined the influence of handling treatment (fresh, stockpiled, or composted) on nutrient levels and mass balance estimates of feedlot manure at Lethbridge, Alberta, and Brandon, Manitoba. Total carbon (TC) concentration of compost (161 kg Mg(-1)) was lower (P < 0.001) than stockpiled (248 kg Mg(-1)), which was in turn lower (P < 0.001) than fresh manure (314 kg Mg(-1)). Total nitrogen (TN) concentration was not affected by handling treatment while total phosphorus (TP) concentration increased with composting at Lethbridge. The percent inorganic nitrogen (PIN) was lower (P < 0.01) for compost (5.1%) than both fresh (24.7%) and stockpiled (28.9%) manure. Composting led to higher (P < 0.05) dry matter (DM) losses (39.8%) compared to stockpiling (22.5%) and higher (P < 0.05) total mass (water + DM) losses (65.6 vs. 35.2%). Carbon (C) losses were higher (P < 0.01) with composting (66.9% of initial) than with stockpiling (37.5%), as were nitrogen (N) losses (46.3 vs. 22.5%, P < 0.05). Composting allowed transport of two times as much P as fresh manure and 1.4 times as much P as stockpiled manure (P < 0.001) on an "as is" basis. Our study looked at one aspect of manure management (i.e., handling treatment effects on nutrient concentrations and mass balance estimates) and, as such, should be viewed as one component in the larger context of a life cycle assessment.     

Weed seed viability in composted beef cattle feedlot manure

Manure composting has gained increased acceptance by the beef cattle (Bos taurus) feedlot industry in southern Alberta, Canada. Unlike fresh manure, compost is often promoted as being "weed-free." Studies were conducted with five weed species in 1997 and thirteen in 1999 to examine the effect of feedlot manure composting on weed seed viability. Weed seeds were buried in open-air compost windrows and recovered at various times during the thermophilic phase of composting. Windrow temperature and water contents were also measured. Germinability was zero for all composted weed seeds at all sampling times in 1997. However, some seeds remained viable (positive tetrazolium test denoting respiration) on Day 70. In 1999, only one of the thirteen species retained germinability on Day 21 and only two species had respiring seeds on Day 42. Time-viability relationships during composting were defined by exponential decay models. Lethal temperatures to eliminate viability was species-dependent. In 1999, four weed species were killed in the initial 7 d of composting at a lethal temperature of 39 degrees C while temperatures of > 60 degrees C were required for two species. Regression analysis on weed seed viability versus windrow temperature resulted in significant R2 values, which showed that only 17 to 29% of the variation in viability was accounted for by temperature. The lack of definitive relationships between temperature and weed seed viability demonstrated that factors other than temperature may play a role in eliminating weed seeds during composting.     

Bedding and within-pen location effects on feedlot pen runoff quality using a rainfall simulator

Soluble salts, nutrients, and pathogenic bacteria in feedlot-pen runoff have the potential to cause pollution of the environment. A 2-yr study (1998-1999) was conducted at a beef cattle (Bos taurus) feedlot in southern Alberta, Canada, to determine the effect of bedding material [barley (Hordeum vulgare L.) straw versus wood chips] and within-pen location on the chemical and bacterial properties of pen-floor runoff. Runoff was generated with a portable rainfall simulator and analyzed for chemical content (nitrogen [N], phosphorus [P], soluble salts, electrical conductivity [EC], sodium adsorption ratio [SAR], dissolved oxygen [DO], and pH) and populations of three groups of bacteria (Escherichia coli, total coliforms, total aerobic heterotrophs at 27 degrees C) in 1998 and 1999. Bedding had a significant (P < or = 0.05) effect on NH4-N concentration and load in 1999, SO4 load in 1998, SO4 concentration and load in 1999, and total coliforms in both years; where these three variables were higher in wood than straw pens. Location had a significant effect on EC and concentrations of total Kjeldahl nitrogen (TKN), Na, K, SO4, and Cl in 1998, and total coliforms in both years. These seven variables were higher at the bedding pack than pen floor location, indicating that bedding packs were major reservoirs of TKN, soluble salts, and total coliforms. Significantly higher dissolved reactive phosphorus (DRP), total P, and NH4-N concentrations and loads at the bedding pack location in wood pens in 1998, and a similar trend for TKN concentration in 1999, indicated that this bedding-location treatment was a greater source of nutrients to runoff than the other three bedding-location treatments. Bedding, location, and their interaction may therefore be a potential tool to manage nutrients, soluble salts, and bacteria in feedlot runoff.     

Dissipation of 17β-estradiol in composted poultry litter

The excreted estrogen rate of all livestock in the United States is estimated at 134 kg d. The influence of manure treatment on the fate of estrogens is critical in deciding the recycling of over 300 million dry tons of livestock produced annually. The effects of two common manure management practices, heated composting and ambient temperature decomposition, on the fate of 17β-estradiol in poultry litter were determined. A mixture of poultry litter, wood chips, and straw was amended with [C]17β-estradiol and allowed to undergo decomposition with a laboratory-scale heated composter (HC) or room temperature incubation (RTI) for 24 d. Radiolabel in the finished products was fractionated into water-extractable, acetone-extractable, nonextractable, and mineralized fractions. Total 17β-estradiol radioactive residues in the HC and RTI ( = 2) treatments were not different ( > 0.05), except that statistically less 17β-estradiol was mineralized to CO during HC than RTI (1.1 vs. 10.0% for HC and RTI, respectively). Estrone was the major degradation product in extracts of HC and RTI treatments as determined by liquid chromatography/mass spectrometry analyses. The nonextractable residues indicated no quantitative differences among the humins between the treatments. An estimated 3% of the fortified estrogenicity remained after HC treatment, and 15% of the fortified estrogenicity remained after RTI treatment. If reduction of water-removable, biologically active 17β-estradiol is the treatment goal, then HC treatment would be slightly preferred over ambient temperature degradation. However, unmanaged, ambient temperature litter piles are less costly and time consuming for food animal producers and result in greater mineralization and similar immobilization of estradiol.     

Greenhouse gas emissions during cattle feedlot manure composting

The emission of greenhouse gases (GHG) during feedlot manure composting reduces the agronomic value of the final compost and increases the greenhouse effect. A study was conducted to determine whether GHG emissions are affected by composting method. Feedlot cattle manure was composted with two aeration methods--passive (no turning) and active (turned six times). Carbon lost in the forms of CO2 and CH4 was 73.8 and 6.3 kg C Mg-1 manure for the passive aeration treatment and 168.0 and 8.1 kg C Mg-1 manure for the active treatment. The N loss in the form of N2O was 0.11 and 0.19 kg N Mg-1 manure for the passive and active treatments. Fuel consumption to turn and maintain the windrow added a further 4.4 kg C Mg-1 manure for the active aeration treatment. Since CH4 and N2O are 21 and 310 times more harmful than CO2 in their global warming effect, the total GHG emission expressed as CO2-C equivalent was 240.2 and 401.4 kg C Mg-1 manure for passive and active aeration. The lower emission associated with the passive treatment was mainly due to the incomplete decomposition of manure and a lower gas diffusion rate. In addition, turning affected N transformation and transport in the window profile, which contributed to higher N2O emissions for the active aeration treatment. Gas diffusion is an important factor controlling GHG emissions. Higher GHG concentrations in compost windrows do not necessarily mean higher production or emission rates.     

Effect of poultry diet on phosphorus in runoff from soils amended with poultry manure and compost

Phosphorus in runoff from fields where poultry litter is surface-applied is an environmental concern. We investigated the effect of adding phytase and reducing supplemental P in poultry diets and composting poultry manures, with and without Fe and Al amendments, on P in manures, composts, and runoff. We used four diets: normal (no phytase) with 0.4% supplemental P, normal + phytase, phytase + 0.3% P, and phytase + 0.2% P. Adding phytase and decreasing supplemental P in diets reduced total P but increased water-extractable P in manure. Compared with manures, composting reduced both total P, due to dilution of manure with woodchips and straw, and water-extractable P, but beyond a dilution effect so that the ratio of water-extractable P to total P was less in compost than manure. Adding Fe and Al during composting did not consistently change total P or water-extractable P. Manures and composts were surface-applied to soil boxes at a rate of 50 kg total P ha(-1) and subjected to simulated rainfall, with runoff collected for 30 min. For manures, phytase and decreased P in diets had no significant effect on total P or molybdate-reactive P loads (kg ha(-1)) in runoff. Composting reduced total P and molybdate-reactive P loads in runoff, and adding Fe and Al to compost reduced total P but not molybdate-reactive P loads in runoff. Molybdate-reactive P in runoff (mg box(-1)) was well correlated to water-extractable P applied to boxes (mg box(-1)) in manures and composts. Therefore, the final environmental impact of dietary phytase will depend on the management of poultry diets, manure, and farm-scale P balances.     

Season and bedding impacts on ammonia emissions from tie-stall dairy barns

Federal and state regulations are being promulgated under the Clean Air Act to reduce hazardous air emissions from livestock operations. Few data are available on emissions from livestock facilities in the USA and the management practices that may minimize emissions. The objective of this study was to measure seasonal and bedding impacts on ammonia emissions from tie-stall dairy barns located in central Wisconsin. Four chambers each housed four Holstein dairy heifers (approximately 17 mo of age; body weights, 427-522 kg) for three 28-d trial periods corresponding to winter, summer, and fall. A 4x4 Latin Square statistical design was used to evaluate four bedding types (manure solids, chopped newspaper, pine shavings, and chopped wheat straw) in each chamber for a 4-d ammonia monitoring period. Average ammonia-N emissions (g heifer(-1) d(-1)) during summer (20.4) and fall (21.0) were similar and twice the emissions recorded during winter (10.1). Ammonia-N emissions accounted for approximately 4 to 7% of consumed feed N, 4 to 10% of excreted N, and 9 to 20% of manure ammonical N. Cooler nighttime temperatures did not result in lower ammonia emissions than daytime temperatures. Ammonia emissions (g heifer(-1) d(-1)) from chambers that contained manure solids (20.0), newspaper (18.9), and straw (18.9) were similar and significantly greater than emissions using pine shavings (15.2). Chamber N balances, or percent difference between the inputs feed N and bedding N, and the outputs manure N, body weight N, and ammonia N were 105, 90, and 89% for the winter, summer, and fall trials, respectively. Relatively high chamber N balances and favorable comparisons of study data with published values of ammonia emissions, feed N intake, and manure N excretion provided confidence in the accuracy of the study results.     

Real-time quantification of mcrA, pmoA for methanogen, methanotroph estimations during composting

Composting is the controlled biological decomposition of organic matter by microorganisms during predominantly aerobic conditions. It is being increasingly adopted due to its benefits in nutrient recycling, soil reclamation, and urban land use. However, it poses an environmental concern related to its contribution to greenhouse gas production. During composting, activities of methanogenic and methanotrophic communities influence the net methane (CH4) release into the atmosphere. Using quantitative polymerase chain reaction (qPCR), this study was aimed at assessing the changes in the methyl-coenzyme M reductase (mcrA) and particulate methane monooxygenase (pmoA) copy numbers for estimation of methanogenic and methanotrophic communities, respectively. Open-windrow composting of beef cattle (Bos Taurus L.) manure with temperatures reaching > 55 degrees C was effective indegrading commensal Escherichia coli within the first week. Quantification of community DNA revealed significant differences in mcrA and pmoA copy numbers between top and middle sections. Consistent mcrA copy numbers (7.07 to 8.69 log copy number g(-1)) were detected throughout the 15-wk composting period. However, pmoA copy number varied significantly over time, with higher values during Week 0 and 1 (6.31 and 5.41 log copy number g(-1), respectively) and the lowest at Week 11 (1.6 log copy number g(-1)). Net surface CH4 emissions over the 15-wk period were correlated with higher mcrA copy number. Higher net ratio of mrA: pmoA copy numbers was observed when surface CH4 flux was high. Our results indicate that mcrA and pmoA copy numbers vary during composting and that methanogen and methanotroph populations need to be examined in conjunction with net CH4 emissions from open-windrow composting of cattle feedlot manure.     

The effect of phosphogypsum on greenhouse gas emissions during cattle manure composting

Phosphogypsum (PG), a by-product of the phosphate fertilizer industry, reduces N losses when added to composting livestock manure, but its impact on greenhouse gas emissions is unclear. The objective of this research was to assess the effects of PG addition on greenhouse gas emissions during cattle feedlot manure composting. Sand was used as a filler material for comparison. The seven treatments were PG10, PG20, PG30, S10, S20, and S30, representing the rate of PG or sand addition at 10, 20, or 30% of manure dry weight and a check treatment (no PG or sand) with three replications. The manure treatments were composted in open windrows and turned five times during a 134-d period. Addition of PG significantly increased electrical conductivity (EC) and decreased pH in the final compost. Total carbon (TC), total nitrogen (TN), and mineral nitrogen contents in the final composted product were not affected by the addition of PG or sand. From 40 to 54% of initial TC was lost during composting, mostly as CO(2), with CH(4) accounting for <14%. The addition of PG significantly reduced CH(4) emissions, which decreased exponentially with the compost total sulfur (TS) content. The emission of N(2)O accounted for <0.2% of initial TN in the manure, increasing as compost pH decreased from alkaline to near neutral. Based on the total greenhouse gas budget, PG addition reduced greenhouse gas emissions (CO(2)-C equivalent) during composting of livestock manure by at least 58%, primarily due to reduced CH(4) emission.     

Veterinary antimicrobials in feedlot manure: dissipation during composting and effects on composting processes

Composting of manure may lead to the degradation of veterinary antimicrobials, but it is largely unknown if the presence of antimicrobials affects the composting process. Open-air windrow composting of manure from beef cattle (Bos taurus) administered chlortetracycline, sulfamethazine, and tylosin was investigated in a 2-yr study. At windrow construction, chlortetracycline had extensively isomerized to iso-chlortetracycline. Sulfamethazine, tylosin, and iso-chlortetracycline dissipated by first-order kinetics, whereas the dissipation of enol/keto-chlortetracycline was better described by exponential equations. At the end of the composting period, proportions of antimicrobials remaining were as follows: iso-chlortetracycline (< 1%), chlortetracycline (1 to 4.5%), tylosin (6.3%), and sulfamethazine (6.8% [2005], 41% [2006]). Times for 50% dissipation (DT50) decreased in the order: tylosin (20.3 to 43.5 d) > iso-chlortetracycline (13.5 to 26.5 d) > enol/keto-chlortetracycline (5.5 to 9.8 d). The DT50 values for sulfamethazine varied from 26.8 d in 2005 to 237 d in 2006. Treatments with chlortetracycline showed significantly reduced temperature rises (10.1 to 11.0 degrees C) between Days 21 to 28 in 2006 compared with rises of 26.6 to 31.0 degrees C for control and tylosin treatments, suggesting an inhibition of microbial activity. During composting in 2005, manure from cattle administered chlortetracycline at 44 mg kg(-1) of feed lost significantly less dry matter, carbon, and nitrogen than manure from cattle fed 11 mg chlortetracycline kg(-1) of feed, implying that the higher level of chlortetracycline inhibited microbial decomposition of organic matter. The study shows that while composting leads to dissipation of antimicrobials, the microbially driven composting process may be inhibited by their presence.     

Antibiotic degradation during manure composting

On-farm manure management practices, such as composting, may provide a practical and economical option for reducing antibiotic concentrations in manure before land application, thereby minimizing the potential for environmental contamination. The objective of this study was to quantify degradation of chlortetracycline, monensin, sulfamethazine, and tylosin in spiked turkey (Meleagris gallopavo) litter during composting. Three manure composting treatments were evaluated: a control treatment (manure pile with no disturbance or adjustments after initial mixing), a managed compost pile (weekly mixing and moisture content adjustments), and vessel composting. Despite significant differences in temperature, mass, and nutrient losses between the composting treatments and the control, there was no difference in antibiotic degradation among the treatments. Chlortetracycline concentrations declined rapidly during composting, whereas monensin and tylosin concentrations declined gradually in all three treatments. There was no degradation of sulfamethazine in any of treatments. At the conclusion of the composting period (22-35 d), there was >99% reduction in chlortetracycline, whereas monensin and tylosin reduction ranged from 54 to 76% in all three treatments. Assuming first-order decay, the half-lives for chlortetracycline, monensin, and tylosin were 1, 17, and 19 d, respectively. These data suggest that managed compositing in a manure pile or in a vessel is not better than the control treatment in degrading certain antibiotics in manure. Therefore, low-level manure management, such as stockpiling, after an initial adjustment of water content may be a practical and economical option for livestock producers in reducing antibiotic levels in manure before land application.     

Laboratory evaluation of dust-control effectiveness of pen surface treatments for cattle feedlots

Emission of particulate matter (PM) is one of the major air quality concerns for large beef cattle feedlots. Effective treatments on the uncompacted soil and manure mixture of the pen surface may help in reducing PM emission from feedlots. A laboratory apparatus was developed for measuring dust-emission potential of cattle feedlot surfaces as affected by pen surface treatments. The apparatus was equipped with a simulated pen surface, four mock cattle hooves, and samplers for PM with equivalent aerodynamic diam. ≤ 10 μm (PM(10)). The simulated pen surface had a layer of dry, loose feedlot manure with a compacted soil layer underneath. Mock hooves were moved horizontally on the manure layer to simulate horizontal action of cattle hooves on the pen surface. High-volume PM samplers were used to collect emitted dust. Effects of hoof speed, depth of penetration, and surface treatments with independent candidate materials (i.e., sawdust, wheat straw, hay, rubber mulch, and surface water application) on PM(10) emission potential of the manure layer were investigated. Our laboratory study showed PM(10) emission potential increased with increasing depth of penetration and hoof speed. Of the surface treatments evaluated, application of water (6.4 mm) and hay (723 g m(-2)) exhibited the greatest percentage reduction in PM(10) emission potential (69 and 77%, respectively) compared with the untreated manure layer. This study indicated application of hay or other mulch materials on the pen surface might be good alternative methods to control dust emission from cattle feedlots.     

Cattle feedlot soil moisture and manure content: I. Impacts on greenhouse gases, odor compounds, nitrogen losses, and dust

Beef cattle feedlots face serious environmental challenges associated with manure management, including greenhouse gas, odor, NH3, and dust emissions. Conditions affecting emissions are poorly characterized, but likely relate to the variability of feedlot surface moisture and manure contents, which affect microbial processes. Odor compounds, greenhouse gases, nitrogen losses, and dust potential were monitored at six moisture contents (0.11, 0.25, 0.43, 0.67, 1.00, and 1.50 g H2O g(-1) dry matter [DM]) in three artificial feedlot soil mixtures containing 50, 250, and 750 g manure kg(-1) total (manure + soil) DM over a two-week period. Moisture addition produced three microbial metabolisms: inactive, aerobic, and fermentative at low, moderate, and high moisture, respectively. Manure content acted to modulate the effect of moisture and enhanced some microbial processes. Greenhouse gas (CO2, N2O, and CH4) emissions were dynamic at moderate to high moisture. Malodorous volatile fatty acid (VFA) compounds did not accumulate in any treatments, but their persistence and volatility varied depending on pH and aerobic metabolism. Starch was the dominant substrate fueling both aerobic and fermentative metabolism. Nitrogen losses were observed in all metabolically active treatments; however, there was evidence for limited microbial nitrogen uptake. Finally, potential dust production was observed below defined moisture thresholds, which were related to manure content of the soil. Managing feedlot surface moisture within a narrow moisture range (0.2-0.4 g H2O g(-1) DM) and minimizing the accumulation of manure produced the optimum conditions that minimized the environmental impact from cattle feedlot production.     

不同腐熟度猪粪、奶牛粪在小白菜和香瓜上施用的农学效应研究

进行猪粪和奶牛粪自然高温堆肥发酵,分别在15、25、35、50 d取样,获得了不同腐熟程度堆肥产物,分别进行了小白菜和香瓜种子发芽与田间应用试验,以期获得不同腐熟堆肥在蔬菜上施用的农学效应,旨在从堆肥农田施用的农学效应角度,为制订堆肥腐熟度标准提供科学依据。结果表明：牛粪堆肥过程中的最高温度高于猪粪,且高温期也长于猪粪;两种处理在35d有机碳含量均显著降低,全氮含量为先降低后升高趋势;两种堆肥在35d后,均达到无害化标准。不同腐熟程度堆肥对小白菜株高和主根长及香瓜苗重和主根长均没有明显抑制作用,对小白菜和香瓜出苗率、根系活力及小白菜单株鲜重和生物产量影响较大,尤其是猪粪腐熟25d,奶牛粪腐熟15d的堆肥表现出显著抑制作用。将堆肥理化参数与小白菜、香瓜生长指标进行相关分析表明：pH值、全氮含量和C/N这3种指标均与小白菜和香瓜各项生物性状无显著相关性;有机碳和DOC与各项生物性状指标均表现出显著或极显著相关性;铵/硝与小白菜和香瓜的GI和根系活力均表现极显著或显著的相关性,其结果与现行的堆肥腐熟度指标并不一致。因此,在制订堆肥腐熟度标准时,应关注堆肥产物农田施用后不同作物所表现出的不同农学效应。     

Phosphorus accumulation in cultivated soils from long-term annual applications of cattle feedlot manure

Historically, manure has been recognized as an excellent soil amendment that can improve soil quality and provide nutrients for crop production. In areas of high animal density, however, the potential for water pollution resulting from improper storage or disposal of manure may be significant. The objective of this study was to determine the P balance of cultivated soils under barley (Hordeum vulgare L.) production that have received long-term annual manure amendments. Nonirrigated soils at the study site in Lethbridge, AB, Canada, have received 0, 30, 60, or 90 Mg manure ha(-1) (wet wt. basis) while irrigated plots received 0, 60, 120, and 180 Mg ha(-1) annually for 16 yr. The amount of P removed in barley grain and straw during the 16-yr period was between 5 and 18% of the cumulative manure P applied. There was a balance between P applied in manure and P recovered in crops and soils (to the 150-cm depth) of nonirrigated plots during the 16-yr study. In irrigated plots, as much as 1.4 Mg P ha(-1) added (180 Mg ha(-1) yr(-1) treatment) was not recovered over 16 yr, and was probably lost through leaching. The risk of ground water contamination with P from manure was greater in irrigated than nonirrigated plots that have received long-term annual manure amendments. Manure application rates should be reduced in nonirrigated and irrigated plots to more closely match manure P inputs to crop P requirements.     

Global Warming Impact of Electricity Generation from Beef Cattle Manure: A Life Cycle Assessment Study

We compare calculated greenhouse gas emissions for a North American beef feedlot operation, which includes biogas production by anaerobic digestion with subsequent electricity generation (the AD case), to the emissions for a “business as usual” case, which includes both a feedlot and an equivalent amount of grid-generated electricity. Anaerobic digestion, biogas production and electricity production are the major sources of differences in emissions. Fertilizer production, crop production, manure collection and spreading, as well as the associated transport stages are also considered within the LCA system boundaries; impacts on life cycle emissions from these sources are lower. Running a feedlot and producing electricity using typical grid power plants produces 3,845 kg CO_2?eq/MWh while running a feedlot, which generates biogas to produce electricity, produces 2,965 kg CO_2?eq/MWh. This savings of 880 kg CO_2?eq/MWh arises because the net power generation in the AD case emits about 90% less life cycle GHG emissions compared to grid-average electricity. The high overall emission levels arise due to emissions associated with enteric fermentation in beef cattle as the main source of GHG emissions in both the “business as usual” and the AD cases. It contributed 57% of total emissions for the feedlot /biogas /electricity system and 44% of total emissions for the feedlot /grid electricity system.