Influence of laneway support spacing on methane/air explosion shock wave

A laneway support system provides an available way to solve problems related to ground movements in underground coal mines, but also poses another potential hazard. Once a methane/air explosion occurs in a laneway, inappropriate design parameters of the support system, especially the support spacing, likely have a negative influence on explosion disaster effects. The commercial software package AutoReaGas, a computational fluid dynamics code suitable for gas explosions, was used to carry out the numerical investigation for the methane/air explosion and blast process in a straight laneway with different support spacing. The validity of the numerical method was verified by the methane/air explosion experiment in a steel tube. Laneway supports can promote the development of turbulence and explosion, and also inhibit the propagation of flame and shock wave. For the design parameters in actual laneway projects, the fluid dynamic drag due to the laneway support plays a predominant role in a methane/air explosion. There is an uneven distribution of the peak overpressure on the same cross section in the laneway, and the largest overpressure is near the laneway walls. Different support spacing can cause obvious differences for the distributions of the shock wave overpressure and impulse. Under comparable conditions, the greater destructive effects of explosion shock wave are seen for the laneway support system with larger spacing. The results presented in this work provide a theoretical basis for the optimized design of the support system in coal laneways and the related safety assessments.     

High resolution numerical simulation of methane explosion in bend ducts

In this paper we developed a parallel code, adopting a fifth-order weighted essentially non-oscillatory (WENO) scheme with a third-order TVD Runge-Kutta time stepping method for the two-dimensional reactive Euler equations, to investigate the propagation process of methane explosion in bend ducts. In the simulations, an inverse Lax-Wendroff procedure is adopted to construct a high order boundary in order to treat the complex boundaries. The numerical results show that when the bend angle is 30° and 45°, it cannot inhibit the propagation of the detonation wave; while when the angle reaches 60° and 75°, the detonation wave finally attenuates to the shock wave. It indicates that the propagation of the detonation wave can be inhibited. Furthermore, the temperature and the pressure at the entrance of the bend are low. When the angle arrives at 90°, the detonation wave evolves into cellular detonation when it passes through the bend. When the angle is larger than 90°, the detonation wave dramatically attenuates at the diffracting point, and later some hot spots can be formed, which can ignite the combustible gas nearby. Thus the second explosion occurs and finally the detonation is formed. When the angle is larger than or equal to 90°, the temperature and the pressure at the entrance of the bend is too high that the rescue efforts in the methane explosion accidents will encounter great difficulties. Hence, the laneway with 60° and 75° bend can inhibit the propagation of the detonation wave, and the temperature and the pressure at the entrance of the bend is not too high as well. All the results above can provide an important basis for the design and optimization of the mine laneway.     

不同曲率弯曲巷道爆炸冲击波传播特性数值模拟研究

为研究爆炸冲击波在不同曲率弯曲巷道内的传播规律,采用数值模拟手段建立了不同曲率弯曲巷道爆炸模型,分析了爆炸冲击波在巷道内的传播特性及其变化规律, 并结合冲击波超压对人体的伤害程度分类,研究了不同曲率弯曲巷道内爆炸破坏效应分区。模拟结果表明,弯曲角度改变了巷道内冲击波超压分布,随着巷道弯曲角度的不断增大,壁面反射对冲击波超压峰值分布起主要作用,随着传播距离的增加,冲击波超压峰值衰减显著,体现了超压峰值变化的距离效应。此外,巷道弯曲角度的增加整体减小了爆炸损伤严重程度。研究结果可实现对不同曲率弯曲巷道内冲击波超压分布的预测,并为巷道内爆炸事故预防及应急救援提供借鉴。     

A methodology to predict shock overpressure decay in a tunnel produced by a premixed methane/air explosion

A methodology for estimating the blast wave overpressure decay in air produced by a gas explosion in a closed-ended tunnel is proposed based on numerical simulations. The influence of the tunnel wall roughness is taken into account in studying a methane/air mixture explosion and the subsequent propagation of the resulting shock wave in air. The pressure time-history is obtained at different axial locations in the tunnel outside the methane/air mixture. If the shock overpressure at two, or more locations, is known, the value at other locations can be determined according to a simple power law. The study demonstrates the accuracy of the proposed methodology to estimate the overpressure change with distance for shock waves in air produced by methane/air mixture explosions. The methodology is applied to experimental data in order to validate the approach.     

障碍物对瓦斯爆炸冲击波影响研究

为研究障碍物对瓦斯爆炸冲击波传播规律的影响,利用水平管道式气体——粉尘爆炸实验装置,测试并分析障碍物数量、尺寸和壁面粗糙程度对瓦斯爆炸冲击波超压、冲击波传播规律的影响。结果表明:障碍物对瓦斯爆炸过程中冲击波传播规律具有重要影响。障碍物存在时,改变了爆炸冲击波的传播规律,提高了冲击波超压的最大峰值压力,且随着障碍物数量和尺寸的增加,这种激励作用越明显。随着壁面粗糙程度的增大,瓦斯爆炸冲击波超压明显增大。研究结果对井下巷道瓦斯爆炸冲击波的防治具有一定的指导意义。     

瓦斯爆炸在角联通风管网中的传播特性研究*

为研究真实通风工况下瓦斯爆炸冲击波在复杂管网内的超压演化规律及高温传播规律,采用数值模拟方法,研究角联通风管网模型中各个监测点在不同通风条件下对瓦斯爆炸冲击波超压及高温的影响规律,研究结果表明:瓦斯爆炸冲击波在角联管网传播过程中产生3个局部高压区域,高温气体主要在左、右通路内传播,斜角联分支内只受到微弱影响;管网入口风流的存在,使得爆炸初期冲击波超压经相同距离传播用时更短,峰值更大,破坏力更强;风流的存在使得管网内高温气体传播状态发生改变,斜角联分支与左通路尾部热量发生积聚,温度峰值更大。     

挡气板对综合管廊燃气舱爆炸冲击波传播规律影响研究

为研究挡气板对综合管廊燃气舱爆炸冲击波传播影响规律,采用Fluent模拟软件,研究三维燃气舱模型中不同挡气板间距下燃气爆炸后超压变化规律,探究不同间距挡气板对抑制燃气舱内爆炸冲击波传播效果.结果表明:挡气板对燃气舱中部超压影响较小,对顶部超压变化影响较大,导致燃气舱顶部挡气板处超压峰值激增;当气体填充区长20 m,挡气...     

Experimental study on the feasibility of explosion suppression by vacuum chambers

In view of the invalidity of suppression and isolation apparatus for gas explosion, a closed vacuum chamber structure for explosion suppression with a fragile plane was designed on the base of the suction of vacuum. Using methane as combustible gas, a series of experiments on gas explosion were carried out to check the feasibility of the vacuum chamber suppressing explosion by changing methane concentration and geometric structure of the vacuum chamber. When the vacuum chamber was not connected to the tunnel, detonation would happen in the tunnel at methane volume fraction from 9.3% to 11.5%, with flame propagation velocity exceeding 2000 m/s, maximum peak value overpressure reaching 0.7 MPa, and specific impulse of shock wave running up to 20 kPa s. When the vacuum chamber with 5/34 of the tunnel volume was connected to the flank of the tunnel, gas explosion of the same concentration would greatly weaken with flame propagation velocity declining to about 200 m/s, the quenching distance decreasing to 3/4 of the tunnel length, maximum peak value overpressure running down to 0.1-0.15 MPa and specific impulse of shock wave below 0.9 kPa s. The closer the position accessed to the ignition end, the greater explosion intensity weakened. There was no significant difference between larger section and smaller vacuum chambers in degree of maximum peak value overpressure and specific impulse declining, except that quenching fire effect of the former was superior to the latter. The distance of fire quenching could be improved by increasing the number of the vacuum chambers.     

综合管廊燃气舱结构形式对燃气爆炸超压的影响*

为研究地下综合管廊燃气舱结构形式对燃气爆炸超压的影响,采用数值模拟的方法,改变燃气舱高度,通风分区长度和局部开口大小,分析不同情况下的燃气爆炸超压变化规律。结果表明:冲击波传播速度随燃气舱高度的增加而减小,随着高度的增加,超压峰值曲线由“驼峰状”逐渐变为两端高中间低的“盆形”,爆炸过程产生的最大超压与高度成反比关系。超压峰值在340 m处接近0 kPa,延长通风分区并不会增加超压峰值,可以在考虑防火的要求下根据实际情况适当延长通风分区的长度。局部开口的存在使得爆炸气流能够自由泄压,超压峰值与开口的大小成反比关系。     

不同含水率煤尘在瓦斯爆炸诱导下爆炸传播规律研究

为了探究不同含水率煤尘在瓦斯爆炸诱导下的爆炸传播规律,利用自行搭建的直管瓦斯爆炸诱导煤尘二次爆炸实验系统,从冲击波压力和火焰传播速度2个方面,研究了不同含水率沉积煤尘在瓦斯爆炸诱导下的爆炸传播规律和原因。研究结果表明:当煤尘含水率小于40%时,管道内沉积煤尘会在瓦斯爆炸诱导下产生二次爆炸,同时沉积煤尘总量一定时,沉积煤尘二次爆炸产生的冲击波超压峰值和火焰传播速度随着煤尘含水率的增加先增大后减小;当沉积煤尘含水率为20% 时,煤尘二次爆炸产生的冲击波超压峰值、火焰传播速度峰值达到最大值,分别为1.657 MPa和468.060 m/s;当沉积煤尘含水率大于40%时,沉积煤尘无法产生二次爆炸,此时爆炸产生的威力小于单一瓦斯爆炸,火焰传播速度衰减较无煤尘的瓦斯爆炸更快,沉积煤尘起到抑制瓦斯爆炸传播的作用。研究结果可以为防治煤尘二次爆炸提供理论依据。     

综合管廊燃气舱燃气爆炸冲击波传播特征研究*

为研究综合管廊燃气舱燃气爆炸冲击波的传播特征,采用数值模拟方法研究首次超压峰值和首次流速峰值的变化规律,建立首次流速峰值与首次超压峰值和填充长度的耦合关系,分析不同填充长度情况下燃气爆炸后的超压和水平流速的变化规律。结果表明:燃气爆炸后,燃气舱内存在多个超压峰值,峰值间存在明显的时间差。冲击波到达各测点的时间与燃气填充长度成反比关系。水平流速曲线随着时间的变化以0为基点上下振荡,存在正向峰值和反向峰值。随着燃气填充长度的增加,流速下降趋势变快。首次超压峰值随传播距离的增加先增大后减小再增大,随着填充长度的增加,产生超压峰值最大值的位置由接近填充长度结束的位置转移到燃气舱封闭端。首次流速峰值随传播距离的增加先增大后减小。首次流速峰值与首次超压峰值呈现正比关系,通过拟合得到流速峰值与超压峰值及填充长度的耦合关系。研究结果可为燃气舱燃气爆炸后的流速分布研究以及燃气舱防火分区的设计提供参考。     

Effect of scale on the explosion of methane in air and its shockwave

Explosion experiments using premixed gas in a duct have become a significant method of investigating methane-air explosions in underground coal mines. The duct sizes are far less than that of an actual mine gallery. Whether the experimental results in a duct are applicable to analyze a methane-air explosion in a practical mine gallery needed to be investigated. This issue involves the effects of scale on a gas explosion and its shockwave in a constrained space. The commercial software package AutoReaGas, a finite element computational fluid dynamics (CFD) code suitable for gas explosions and blast problems, was used to carry out the numerical simulation for the explosion processes of a methane-air mixture in the gallery (or duct) at various scales. Based on the numerical simulation and its analysis, the effect of scale on the degree of correlation with the real situation was studied for a methane-air explosion and its shockwave in a square section gallery (or duct). This study shows that the explosion process of the methane-air mixture relates to the scales of the gallery or duct. The effect of scale decreases gradually with the distance from the space containing the methane-air mixture and the air shock wave propagation conforms approximately to the geometric similarity law in the far field where the scaled distance (ratio of the propagation distance and the height (or width) of the gallery section) is over 80.     

开敞空间可燃气云爆炸冲击波超压及灾害动力响应研究评述

为了进一步梳理和分析开敞空间可燃云爆炸冲击波超压传播规律及灾害动力响应方面的各项研究成果,推进可燃气体爆炸安全防控,减少人员伤亡和经济损失。在分析现有研究的基础上,总结开敞空间可燃气云爆炸冲击波超压传播规律及灾害动力响应研究等方面存在的不足,提出开敞空间多元混合气体爆炸冲击波超压传播规律研究、多影响参数下可燃气云爆炸冲击波超压传播规律定量分析、基于可燃气云爆炸冲击波超压作用下的承载体动力响应等未来研究的关键技术问题。     

大长径比管道汽油-空气混合气爆炸与抑制实验研究*

为探究狭长受限空间中油气爆炸失控时的发展状态,探索高效环保的油气爆炸抑制方法,利用长径比155的管道开展92号汽油-空气混合气爆炸发展规律和七氟丙烷主动抑爆技术研究。通过测量不同端部开口条件下油气爆炸超压、火焰传播速度、火焰强度等参数,对比研究空爆和抑爆工况下的油气爆炸变化规律,探讨长直管道中的油气爆炸特性,分析七氟丙烷抑爆效果。结果表明:大长径比管道中,端部开口泄爆对降低油气爆炸破坏能力的作用较小,开口与否对最大超压峰值的出现位置有影响;长直管道空爆时,油气爆炸由爆燃发展成爆轰,管道尾部的爆轰波速可达近2 000 m/s;密闭管道中,爆轰发生前火焰传播呈“已燃区-火焰锋面-待燃区-前驱激波-未燃区”的2波3区结构;主动抑爆方式下七氟丙烷抑爆效果良好,最大超压峰值降低幅度可达90%,火焰传播被及时阻断。     

巷道截面积突变情况下瓦斯爆炸冲击波传播规律的研究

瓦斯爆炸冲击波传播规律是研究冲击波的破坏和伤害机理的前提及依据,笔者利用流体动力学、爆炸动力学理论对巷道截面积突变情况下瓦斯爆炸冲击波传播规律进行理论分析,建立巷道截面积突变情况下冲击波传播的数学模型,得到了冲击波波阵面压力和其他空气动力学参数的表达式,从而得到冲击波波阵面压力过巷道截面积突变面时的变化规律。研究成果丰富了瓦斯爆炸冲击波传播规律理论,对井下瓦斯爆炸安全评价以及制定防灾减灾措施提供了理论基础。     

煤与瓦斯突出冲击波及瓦斯气流所致伤害研究

为揭示煤与瓦斯突出过程中冲击波及瓦斯气流传播特性,针对这种突出做功随瓦斯压力、煤的普氏系数和煤的放散初速度变化的特征,运用气体动力学理论,建立冲击波超压、冲击瓦斯流速度与传播距离以及煤层瓦斯压力等参数的关系,计算不同超压下瓦斯气流传播伤害的范围。理论计算与现场测试结果表明,突出冲击波属惰性弱冲击波;波阵面上的超压传播伤害距离与突出时瓦斯膨胀的强度、巷道断面及巷道壁面的摩擦力和局部阻力等因素有关;冲击产生的高压瓦斯气流是造成巷道内大量人员窒息伤亡的主要诱因;突出能量瞬间释放没有补给,冲击波及瓦斯气流会在巷道阻力等因素作用下迅速衰减。     

挡板缓冲下煤与瓦斯突出冲击波传播减能机制研究*

为揭示煤与瓦斯突出冲击波在挡板缓冲条件下能量耗散规律,利用流体动力学理论建立突出冲击波在挡板缓冲下的传播特征分析的数学模型,分析突出冲击波沿巷道衰减的影响因素,基于不同的突出压力条件下煤与瓦斯突出物理模拟试验和数值模拟结果,研究沿着直巷道突出冲击波在挡板缓冲下能量的削弱机制和传播规律。研究结果表明:矿井突出冲击波能量的衰减程度主要与突出压力、输运煤粉做功和巷道横截面积有关,突出压力与冲击波传播超压成正相关关系,巷道横截面积是人为削弱冲击波能量最有效的途径;根据不同的突出压力,突出冲击波超压沿巷道主要表现为急剧增大,然后压力逐渐降低;挡板缓冲下反射冲击波与突出入射冲击波叠加的二次加速作用,导致挡板装置断面前后空间局部能量变大,但总体能量是减弱的,降低了突出冲击波的传播距离;通过理论分析、物理试验和数值模拟所得结果基本一致。     

点火位置对独头巷道中瓦斯爆炸超压的影响

运用AutoReaGas爆炸仿真模拟器研究了独头巷道中点火位置对瓦斯爆炸后果的影响。结果表明,在本计算条件下,爆炸静态超压随着距离的增加而减小,爆炸动压随着距离的增大而增大,点火位置对爆炸后果有重要影响,点火位置离封闭端越近,各个测点上所得到的超压越大。     

爆炸冲击波及高温耦合引起瓦斯二次爆炸特性研究

在煤矿安全事故中,破坏程度最严重的事故之一就是瓦斯爆炸,而瓦斯爆炸冲击波及火焰锋面可能会二次点爆其他位置积聚瓦斯,加速火焰锋面及冲击波传播,并能产生更高的超压,造成更大的人员伤亡及财产损失。借助详细反应机理GRI Mech 3.0,基于开源化学动力学软件Cantera,研究冲击波强度、瓦斯体积分数和冲击波及高温耦合条件下对瓦斯爆炸特性的影响。结果显示,冲击波诱导瓦斯爆炸中,点火延迟时间随着瓦斯体积分数的增大而出现增大现象,随冲击波强度的增大而降低;同时分析了二氧化碳、一氧化碳和一氧化氮致害物质的浓度随瓦斯体积分数、冲击波强度和冲击波及高温耦合条件下的变化情况。     

Numerical investigation and analysis of indoor gas explosion: A case study of “6·13” major gas explosion accident in Hubei Province,China

Taking the ' 6·13 ′ major gas explosion accident in Shiyan, Hubei Province, China as an example, three problems were studied in this work: (1)The determination of the volume of natural gas involved in the explosion; (2)The propagation process of shock wave inside the building and the damage evolution process of the accident-related building; (3)The overpressure and fragment injury to the person outside the building. Through the numerical simulation in ANSYS/LS-DYNA software, the volume of natural gas involved in the explosion is determined to be 10240 × 1400 × 400 cm (length × width × height) from three perspectives: the damage to the building, the distribution of overpressure inside the building, and the TNT equivalent of the explosion energy. The simulation results are in good line with the accident, which verifies the effectiveness of the scheme and the accuracy of the numerical model. Based on the reasonable filling scheme, the propagation process of shock waves inside the building, the damage evolution process of the building, and the injury ranges of overpressure and fragments outside the building are analyzed. It can be found that the propagation of shock waves in confined space is complex and variable. The explosion shock waves are first reflected and superimposed in the watercourse, resulting in pressure rise. At about 8ms, the shock waves rushed into the first-floor space of the building, and the maximum overpressure was about 0.56 MPa. At about 50 ms, the shock waves rushed into the second-floor space, and the maximum overpressure was about 0.139 MPa. The first and second-floor slabs and infilled walls were almost completely destroyed. The interior walls of the infilled walls are mainly collapsed, and the exterior walls are ejection around the building as the center. The peak displacement and peak velocity of the interior walls of each floor are about 15% of the exterior walls. The fragments which cause fragment injury mainly come from the retaining wall above the watercourse, the maximum velocity is about 89 m/s, and the maximum displacement is 8.9 m. The safety distance of fragment injury is about 8.8 m, while the safety distance of overpressure injury is about 4.6 m. The lethal distance of fragment injury is greater than that of overpressure injury. Compared with the distance between different damage levels of overpressure injury, the difference in fragment injury is small. Therefore, the safety assessment at the engineering level only needs to consider the safety distance of fragment injury. This study can provide suggestions for evaluating the damage of natural gas cloud explosions in confined spaces and is helpful for accident investigation and safety protection.