共查询到19条相似文献,搜索用时 421 毫秒
1.
有机涂层户外失效分析及对策 总被引:1,自引:0,他引:1
我国气候类型复杂,有机涂层在一些典型气候条件下经过一段时间的户外暴露后都会出现粉化、颜色变化、剥落、沾污等明显变化.综合起来分析,当地太阳辐射强度、辐射量、温湿度等是有机涂层失效的主要因素;同时空气中的污染物、沙尘等也加速了有机涂层失效.因此研制新型户外涂料时要确保有机涂层既能起防护作用,又能起装饰作用,以增强有机涂层... 相似文献
2.
太阳辐射是引起有机材料老化的最主要原因,实验室氙弧灯光老化试验具有较高的加速性。本文通过对有机涂层在广州试验站自然暴露试验结果以及实验室氙弧灯光老化试验结果进行对比研究,得到3种常用有机防护涂层的加速倍数,对于1#、2#样品的加速倍数为9,3#样品的加速倍数为6。 相似文献
3.
为了考核评价舰船、舰载机等装备用三种涂层在热带海洋大气环境中的性能退化情况,设计了涂层在实验室模拟热带海洋大气环境中太阳辐射试验、湿热试验和盐雾试验的组合循环试验方法。通过实验室组合循环试验,分别检测了试验前后涂层的形貌、失光率、色差、附着力和电化学阻抗等数据。试验结果表明,随着试验时间的延长,三种涂层均出现不同程度的老化,失光率和色差呈增大趋势,附着力降低;但试验前后其老化机理未发生明显变化,电化学交流阻抗值基本保持在109Ω以上,涂层的厚度基本保持不变。综合三种涂层的性能退化对比,在工程实际应用中推荐优先选用4号或10号涂层。 相似文献
4.
山西省近50年气候变化特征分析 总被引:5,自引:0,他引:5
根据近50年来山西省18个气象基准站1960—2004年间的逐月气温、降水量和山西气象观测台(太原站)1966—2005年的逐月太阳辐射资料的统计,对山西省的气候变化进行了较系统的分析。结果表明,近50年来山西省气温上升趋势明显,而且在1990年有一次明显的跃变(1990年的累积距平等于零),年平均温度以0.25℃/10a的幅度上升;降水的年变化呈下降趋势,平均以18.7mm/10a的幅度下降,在1990年也有一次跃变;年总太阳辐射量亦呈下降趋势,且在1982年有一次明显的突变,年平均太阳辐射总量以每10年238.9204 MJ/m2的幅度下降。1982年以前以正距平为主,1982年后以负距平为主,且跃变的幅度较明显。 相似文献
5.
6.
7.
徐静 《中国环境管理干部学院学报》2011,21(4):36-39
利用近50 a秦皇岛气象资料,对该地区气候资源及农业气候资源特征进行了分析总结。结果表明:秦皇岛地区年降水量650~700 mm左右,呈减少趋势。全年80%保证率的降水量为425 mm,存在供需矛盾。蒸发量较降水量明显偏多,直接决定了该地区土壤在自然状态下绝大部分时段处于干旱状态。年平均气温10℃左右,呈上升趋势。平均年太阳辐射总量为5 154 MJ/m2,太阳辐射资源较丰富。秦皇岛地区农时较长,气温稳定通过10℃期间历时192 d,可以实行短生育期作物一年二熟或套作二熟。 相似文献
8.
为研究在严酷环境下涂层对钢结构的防护性能,本文通过对应用于钢结构外表面、内表面以及钢支架的涂层进行了1年的现场暴露试验以及2000h的模拟加速腐蚀试验,积累了涂层在钢结构的老化数据,获取了涂层的腐蚀等级评级。结果表明:现场暴露1年后,载荷尚未产生明显的影响,所有涂层均未出现失光、变色、粉化、开裂、起泡等老化现象;经过2000h盐雾试验后,涂层表面形貌未发生明显变化,涂层未出现起泡、开裂和出锈等现象,表明涂层具有良好抗盐雾和水汽的渗透能力;经过2000h紫外老化试验后,涂层均未出现严重的老化现象,但都出现了不同程度的变色和粉化现象。 相似文献
9.
10.
11.
对自行研制的电子设备太阳辐射试验系统进行了介绍。设备研制中对试验系统的辐照灯阵进行了优化设计,同时根据环境试验要求,介绍了太阳辐射试验设备研制过程中所遇到的辐射光源选择及强度控制、光谱分布修正和光源启动系统等技术难点,并给出了解决途径。该试验系统研制成功,为考核装备的环境适应性和产品可靠性提供了科学的试验手段。 相似文献
12.
13.
Even though paints and coatings have been very useful in protecting various substrates, their use has been accompanied by a heavy environmental price. There is a need to minimize the use of volatile organic compounds (VOCs) in the formulation of these materials. In the latex paint area, we have implemented a conventional precipitation process in emulsions to form binder particles that contain block copolymers and have softer blocks on the particle surface. The softer surface provides the binder film-forming properties without the need for the use of solvents or VOCs. The covalent connections between the soft blocks and the hard blocks are expected to impart good performance in the resulting dry coatings. Indeed, we have shown that our test coating from these binder particles containing block copolymer have similar properties in most performance categories to those of a semi-gloss control paint that has been formulated with typical amounts of VOCs. 相似文献
14.
The present work aims to evaluate the photocatalytic activity of photo-TiO(2) from various producers (Evonik, Kemira, Kronos, Millennium, Sachtleben and Tayca), in the form of powder pressed films and upon incorporation in a water-based paint, for outdoor NO abatement. The photocatalytic activity of the different samples was evaluated in terms of NO conversion and selectivity towards nitrite and nitrate ions following approximately the ISO 22197-1:2007(E) standard. The highest yields obtained for powder pressed films were achieved with VLP7000 (0.70), followed by VLP7101 (0.55) and UVLP7500 (0.55), all from Kronos. On the other hand, when incorporated in paint films, the highest yields were obtained with PC500 and PC105 from Millennium and UV100 from Sachtleben (ca. 0.15). The paint matrix plays an important role on the photocatalytic activity. In particular, the time for steady state is one or two orders of magnitude higher when the photocatalysts are incorporated in paint films in relation to the powder pressed films. The paint films were activated following the procedure recommended by the above-mentioned standard. However, the photocatalytic activity of films incorporating P25 (Evonik) was displayed only when higher power radiation and higher humidity conditions were used. This allowed for similar levels of photocatalytic activity as the other paint films. 相似文献
15.
The solar radiation data are of high importance to the solar energy systems. Conventional methods to obtain the solar radiation data are from weather stations, solar radiation models, commercial software databases, and field measurements. In the present study, a new daily global solar radiation model is proposed, by combining the quadratic function of sunshine fraction and sine function of the day of the year. The solar radiation model calculated data are then compared with China Meteorological Data Sharing System (CMDSS) data, TRNSYS data, and field-measured data in Northwest China climate. It is found that the newly proposed solar radiation model has better performance than the other nine solar radiation models in the literature. The solar radiation model calculated data fit well with the CMDSS annually average data. The TRNSYS data are a bit larger than the CMDSS annually average data in summer half year and a little smaller than those in winter half year. The solar radiation model and the CMDSS annually average data have the best correlation, whereas the TRNSYS data and the field-measured data have the worst correlation. The solar radiation model calculated data have the best correlation with the other three data sources. 相似文献
16.
Jingjing Fan Qiang Huang David M. Sumner Dingbao Wang 《International Journal of Green Energy》2018,15(9):497-506
Solar radiation is a major sustainable and clean energy resource, and use of solar radiation is expected to increase. The utilization efficiency of solar energy varies with the relative proportions of the direct and diffuse components that compose total solar radiation and with the slope and aspect of the irradiated surface. The purpose of this paper is to develop a simple method for estimating diffuse and direct solar radiation at sites with observation of only total solar radiation. An existing model for estimating diffuse radiation, i.e., a linear relationship between the diffuse fraction (the ratio of diffuse radiation to total solar radiation) and the clearness index (the ratio of total solar radiation to extraterrestrial radiation), is applied to 7 sites across the continental United States with observations of diffuse and total radiation. The linear model shows good monthly performance. The model parameters (slope and interception) show a strong seasonal pattern that exhibits small variation across the 7 sites; therefore, the average values of the two monthly parameters may be used for estimating diffuse radiation for other locations with observations of total radiation. 相似文献
17.
18.
Mert Gürtürk Ahmet Koca Yasin Varol Mehmet Şekerci 《International Journal of Green Energy》2017,14(12):1073-1080
Solar energy is one of the most important renewable energy sources, but it is not available every time and every season. Thus, storing of solar energy is important. One of the popular methods of heat storage is use of phase change materials (PCMs) which have large thermal energy storage capacity. In this study, the heat storage tank in a domestic solar water heating system was chosen as control volume. The experiments were performed in the province of Elaz?g, Turkey, in November when solar radiation was weak due to cloudy sky. The heat storage tank of the system was modified to fill PCM between insulation and hot water part. A few PCMs which are Potassium Fluoride, Lithium Metaborate Dihydrate, Strontium Hydroxide Octahydrate, Barium Hydroxide Octahydrate, Aluminum Ammonium Sulfate, and Sodium Hydrogen Phosphate were analyzed to proper operating conditions using a Differential Scanning Calorimeter (DSC) and the best PCM was obtained with the Aluminum Ammonium Sulfate and Sodium Hydrogen Phosphate mixture. Thus, eutectic PCM was obtained and used in a heat storage tank of the solar water heating system. Energy and exergy analysis of heat storage tank was performed with and without the PCM. Energy and exergy analysis has shown that the heat storage tank with the PCM is more efficient than without the PCM and the maximum exergy efficiency was obtained as 22% with the heat storage tank with the PCM. 相似文献
19.
In the project of the solar systems, the values of the solar radiation of a region must be known. The global solar radiation measurements are performed by the Turkish Meteorological Service in Turkey, while the diffuse solar radiation measurements are unavailable. In this study, some new models for predicting the monthly average daily diffuse solar radiation on a horizontal surface for Erzincan, Turkey are developed using satellite data. The evaluation of the models is carried out with the statistical analysis methods of mean bias error (MBE), root mean square error (RMSE) and correlation coefficient (r). The results are proved that the correlation equations obtained in here can be used to forecast diffuse solar radiation reasonably well. 相似文献