复合材料与高温合金螺栓连接结构高温振动防松试验研究

目的 针对温度补偿垫块和碟形垫片2种防松形式的复合材料与高温合金螺栓连接结构,进行高温振动环境下的防松试验研究。方法 推导连接结构预紧力与固有频率的关系,表明固有频率的变化可作为连接结构是否松动的判据。研究常温环境下螺栓预紧力对复合材料连接结构固有频率的影响,以及在常温、高温振动环境下温度补偿垫块和碟形垫片2种防松形式的热防松效果。结果 在常温振动环境下,2种防松形式的防松效果接近,在高温振动环境下,温度补偿垫块方案的防松效果优于碟形垫片方案。结论 复合材料与高温合金螺栓2种材料的热膨胀系数不一致引起的热适配问题是导致的螺栓松动的主要原因。     

高速动能弹撞击装甲结构引起的螺栓连接失效及部件过载损伤研究

目的 验证和揭示高速动能弹对装甲结构的损伤机理。方法 聚焦高速动能弹打击装甲目标时,弹道冲击造成的靶标结构连接失效及部件过载损伤这2种损伤效应,以典型螺栓连接为研究对象,采用高速球形弹丸撞击螺栓连接结构的小尺寸试验对数值模拟方法和材料模型参数进行校验。在此基础上,采用数值模拟和冲击响应谱分析方法对高速动能弹打击全尺寸坦克进行模拟分析,获得撞击过程螺栓连接失效特征、主要影响因素及坦克典型位置部件的冲击加速度曲线和冲击响应谱曲线。结果 在小尺寸试验中,动能输入为0.042MJ时,螺栓连接未发生失效;但25.6MJ动能输入全尺寸坦克时,螺栓发生断裂而使连接失效。数值模拟结果揭示了螺栓发生断裂的主要原因。结论 输入动能大小、连接螺栓直径、模拟设备部件质量和撞击位置为螺栓是否断裂的主要影响因素。坦克某些位置的冲击响应谱曲线高于军用标准给出的临界曲线的下限甚至上限,表明这些位置的部件因高过载损伤导致失效的概率较高。     

热采卡箍螺拴断裂事故原因分析

在对发生断裂的卡箍紧固连接螺栓进行质量检测和强度校核的基础上,指出螺栓发生断裂的主要原因是预紧力太大,并提出了相应的整改措施,解决了工程中存在的问题.     

镦粗过程中塑性变形的发生和发展

塑性变形过程中,变形区不同位置处的点具有不同的应力状态,且同一点在塑性变形过程中的不同时刻,其应力状态也不相同.应力状态的变化必然造成弱区(或相对的弱区)位置的变化.因而变形发生的部位也是不断变化的.通过数值模拟,从等效应变和等效应变率两个方面,对镦粗过程中塑性变形的发生和发展进行了研究.     

基于数值仿真的全表面轮毂弯曲疲劳试验及疲劳寿命分析

目的 预测钢制全表面轮毂易产生疲劳破坏的危险区域,并分析其弯曲疲劳寿命。方法 针对全表面轮毂的弯曲疲劳试验工况,建立有限元分析模型,综合考虑螺栓拧紧方式、螺栓预紧力以及材料非线性特征的影响,通过在加载轴末端建立局部坐标系,实现载荷的分解,并最终实现弯矩的动态加载。在此基础上,进行轮毂的受力分析,然后构造适用于轮毂的应力寿命曲线,并使用名义应力法进行疲劳寿命预测。结果 动态弯矩的加载方向变化会显著影响轮辐表面的应力分布特点,螺栓预紧力施加后,螺栓孔附近区域的应力显著增大,在计算中应考虑其影响。在获得各节点载荷历程后,以高应力幅和平均应力为标准,筛选出了轮毂的危险节点。结论 基于数值仿真的本型全表面轮毂弯曲疲劳试验,危险节点位置均位于轮辐通风孔的内圆角附近区域,可有针对性地对该区域进行相应的优化设计,以进一步提高轮毂的弯曲疲劳寿命。分析得到当前轮辋弯曲疲劳寿命约7.6万次,符合国家标准的要求。     

分子动力学中应变分析的统计矩方法及应用

分子动力学模拟研究金属的力学性质,需要采用合适的应变分析方法研究金属的变形特征及其演化规律.金属材料复杂变形的局部应变特征缺乏简便有效的分析手段,整体变形也没有合适的描述方法.本文提出分子动力学中应变分析的统计矩方法,通过统计矩建立了微观量和宏观应变的关联.在单晶单轴加载、纳米多晶剪切和冲击加载下的应用表明,矩应变分析方法可以很好的描述和评估材料的局部变形和整体变形特征,并通过应变不均匀度鉴别材料的局部塑性变形和弹性变形,是深入研究复杂结构材料变形机理的一种有效的通用分析方法.     

板材弯曲最小相对弯曲半径计算方法探讨

板材在弯曲过程中,外表面的切向拉伸变形程度最大,当外表面的变形程度超过极限变形程度时,板料就会破裂。板料弯曲时的极限变形程度可用最小相对弯曲半径来描述。通过对板料弯曲变形应力应变分析,提出了几种近似计算最小相对弯曲半径的方法。     

PI纤维在空间带电粒子辐照下的力学性能损伤

目的研究聚酰亚胺(PI)纤维在电子辐照、质子辐照、应力耦合质子辐照条件下力学性能的损伤行为。方法采用中国科学院长春应用化学研究所自主合成并纺丝制备的聚酰亚胺纤维,在空间环境模拟设备辐照的条件下,研究空间带电粒子对聚酰亚胺纤维辐照后的力学损伤行为,并通过XQ-1型纤维强度仪对辐照前后的样品进行拉伸试验。结果在低能电子辐照条件下,聚酰亚胺纤维的拉伸强度、模量和断裂伸长率均有所降低,但变化不太显著;高能电子辐照会提高材料的模量;质子辐照后,材料的拉伸强度和断裂伸长率随着辐照注量的增加明显降低;单一施加5%的应变会使聚酰亚胺纤维的拉伸力学性能有一定量下降。与单一应变样品相比,应力耦合质子辐照样品的拉伸强度和断裂伸长率进一步下降,但是与单一质子辐照样品相比,应力耦合辐照样品的拉伸强度和断裂伸长率都更高。结论无论是在低能电子辐照条件下,还是在高能电子辐照条件下,电子辐照对聚酰亚胺纤维力学性能影响均较微弱,而质子辐照会较大程度地降低材料的力学性能,增加应力耦合效应之后,质子辐照对材料的力学性能影响减弱。     

直升机桨叶安装螺栓强度与疲劳寿命计算分析

目的 分析桨叶安装螺栓在不同位移载荷真实试车载荷以及螺牙缺齿情况下的剩余强度以及疲劳寿命。方法 基于有限元方法分析不同载荷下桨叶安装螺栓的对数应变,依据失效应变判定其强度,提取有限元模型的单元应力,通过临界平面法计算最大组合应力平面,运用曲线走势、损伤准则预估桨叶安装螺栓的疲劳寿命。结果 0.36 mm位移载荷下螺栓应变未达到破坏值,真实试车载荷超过4倍情况下,螺栓失效的可能性较高,螺栓断牙超过2个,失效风险较高。依据试车载荷谱,初始长度螺栓寿命为20 794 h,初始长度螺栓断1螺牙寿命为10 912 h,拉伸至29.36 mm螺栓疲劳寿命为7 725 h。结论 在额定载荷状态下,材料结构破坏的可能性小。实际载荷超过4倍、螺栓断牙超过2个情况下,应力应变状态显著恶化,桨叶安装螺栓失效的风险较高,需要预防超载荷过大的情况,还需在修理过程中关注螺栓螺纹的损伤情况,即螺纹的正常磨损可不作为故障进行更换,但出现掉牙、断牙情况则需要更换。     

滨海发射场低温管路法兰连接螺栓环境腐蚀断裂失效机理

针对滨海发射场用于低温管路法兰连接的高强度螺栓的环境腐蚀断裂问题进行失效机理分析.结合螺栓所处"高温、高湿、高盐雾"环境及低温高压工况,讨论分析了盐雾腐蚀、应力作用、微观形貌、化学成分及硬度等影响因素.结果表明,螺栓显微硬度均值(108HRB)超标,材质中C、S、Cr含量异常,螺栓实际受力达到许用应力的60％以上,微观组织裂纹均为典型的应力腐蚀裂纹.在海南"三高"海洋腐蚀环境影响下,耐腐蚀性能较差的螺栓在热应力作用下萌生裂纹,产生应力腐蚀,在热应力和拉应力的作用下进行扩展,发生应力腐蚀开裂,螺栓延迟脆性断裂导致失效.最后,针对螺栓应力腐蚀机理,提出了相应的改进措施.     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Effects of two sludge application on fractionation and phytotoxicity of zinc and copper in the soil

The potential harm of heavy metals is a primary concern in application of sludge to the agricultural land. A pot experiment was conducted to evaluate the effect of two sludges on fractionation of Zn and Cu in soil and their phytotoxicity to pakchoi. The loamy soil was mixed with 0%, 20%, 40%, 60% and 80% (by weight) of digested sewage sludge (SS) and composted sludge (SC). The additions of both sludges caused a significant raise in all fractions, resulting in that exchangeable (EXCH) and organic bound (OM) became predominance of Zn and organic bound Cu occupied the largest portion. There was more available amount of Zn and Cu in SS treatments than SC treatments. During the pot experiment, the concentration of Zn in EXCH, carbonate (CAR) and OM and Cu in EXCH and OM fractions decreased in all treatments, so their bioavailability reduced. Germination rate and plant biomass decreased when the addition rate was high and the best yield appeared in 20% mixtures at the harvest of pakchoi. The two sludges increased tissue contents of Zn and Cu especially in the SS treatments. Zn in pakchoi was not only in relationship to ΔEXCH and ΔCAR forms but also in ΔOM forms in the sludge-soil mixtures. Tissue content of Cu in pakchoi grown on SC-soils could not be predicted by ΔEXCH. These correlation rates between Zn and Cu accumulation in pakchoi and variation of different fractions increased with time, which might indicate that sludges represented stronger impacts on the plant in long-term land application.     

Intraspecific differences in effects of co-contamination of cadmium and

A hydroponic experiment was carried out to study intraspecific differences in the effects of different concentrations of cadmium (Cd)(0-10 mg/L) and arsenate (As(V)) (0-8 mg/L) on the growth parameters and accumulation of Cd and As in six wheat varieties Jing-9428, Duokang-1, Jingdong-11, Jing-411, Jingdong-8 and Zhongmai-8. The endpoints of wheat seedlings, including seed germination,biomass, root length and shoot height, decreased with increasing the Cd and As concentrations. Significant differences in seed germination, biomass, root length, shoot height and the accumulation of Cd and As were observed between the treatments and among the varieties (p ＜ 0.05). The lethal dosage 50% were about 20, 80, 60, 60, 80 and 20 mg As/L for Jing-9428, Duokang-1, Jingdong-11,Jing-411, Jingdong-8 and Zhongmai-8, respectively, and the corresponding values for Cd were about 30, 80, 20, 40, 60 and 10 mg Cd/L, respectively. Among the six varieties, Duokang-1 was found to be the most resistant to Cd and As toxicity, and Zhongmai-8 was the most sensitive to Cd and As co-contamination. The resistance of the six varieties was found dependant on the seedling uptake of Cd and As. Duokang-1 was the most suitable for cultivation in Cd and As co-contaminated soils.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.     

Isolation and preliminary characterization of a 3-chlorobenzoate degrading bacteria

A study was conducted to compare the diversity of 2-, 3-, and 4-chlorobenzoate degraders in two pristine soils and one contaminated sewage sludge. These samples contained strikingly different populations of mono-chlorobenzoate degraders. Although fewer cultures were isolated in the uncontaminated soils than contaminated one, the ability of microbial populations to mineralize chlorobenzoate was widespread. The 3- and 4-chlorobenzoate degraders were more diverse than the 2-chlorobenzoate degraders. One of the strains isolated from the sewage sludge was obtained. Based on its phenotype, chemotaxonomic properties and 16S rRNA gene, the organism S-7 was classified as Rhodococcus erythropolis. The strain can grow at temperature from 4 to 37℃. It can utilize several （halo）aromatic compounds. Moreover, strain S-7 can grow and use 3-chlorobenzoate as sole carbon source in a temperatures range of 10-30℃ with stoichiometric release of chloride ions. The psychrotolerant ability was significant for bioremediation in low temperature regions. Catechol and chlorocatechol 1,2-dioxygenase activities were present in cell free extracts of the strain, but no （chloro）catechol 2,3- dioxygenase activities was detected. Spectral conversion assays with extracts from R. erythropolis S-7 showed accumulation of a compound with a similar UV spectrum as chloro-cis,cis-muconate from 3-chlorobenzoate. On the basis of these results, we proposed that S-7 degraded 3-chlorobenzoate through the modified ortho-cleave pathway.