广东省废弃物焚烧行业持久性污染物二噁英排放特点及防控政策研究

本文通过对广东省2013年间废弃物焚烧行业二噁英类持久性有机污染物的污染状况分析,分别从焚烧废物类别、区域分布、和企业焚烧特点进行了分析论述,并提出相关的存在问题和防治对策建议,为下一步推动广东省废弃物焚烧行业二噁英减排提供参考。     

深圳市废弃物焚烧炉飞灰中二噁英含量水平和特征分析

采用同位素稀释的高分辨气相色谱/高分辨磁式质谱联用仪(HRGC/HRMS)对深圳市8所垃圾焚烧厂飞灰中二噁英进行准确定量检测,分析比较不同炉型、不同种类废弃物焚烧厂飞灰中的二噁英浓度水平和分布情况.结果发现8所废弃物焚烧炉飞灰中二噁英浓度差异较大,5所往复炉排生活垃圾焚烧炉样品中二噁英的质量浓度和TEQ浓度平均值都小于热解型医疗垃圾焚烧炉.两所不同的工业危险废物焚烧炉中,以烧废物矿油的立式筒焚烧炉的二噁英含量远大于以焚烧电路板为主的回转窑焚烧炉.不同焚烧炉飞灰中二噁英异构体的浓度分布具有相类似的特征,高氯代二噁英的含量明显高于低氯代二噁英同系物.不同的PCDD/Fs单体对I-TEQ的贡献率在不同的焚烧设备中十分相似,2,3,4,7,8-Pe CDF、1,2,3,7,8-Pe CDD、2,3,4,6,7,8-Hx CDF 3种单体是TEQ浓度的主要贡献单体.在布袋除尘器前喷淋活性炭能有效吸附烟气中二噁英,将其转移到飞灰中.本研究是首次针对深圳市运行中的废弃物焚烧炉进行飞灰中二噁英排放分析,为二噁英排放监控提供重要的基础数据.     

基于污泥掺烧的某生活垃圾焚烧厂烟道气、飞灰及炉渣中的二噁英特征

以我国南方某生活垃圾焚烧厂掺烧10%市政污泥的生活垃圾为研究对象,对前/后口废气、飞灰、炉渣及用于掺烧的污泥中17种二噁英的含量进行了测定,并分析了其指纹分布特征.结合焚烧工况及处理设施,从生成机理角度探讨了二噁英的排放特征、毒性当量浓度主成分特征及主要单体的排放因子线性关系.结果表明:掺烧10%的市政污泥后,废气中二噁英的去除率为99.4%,低于国家排放标准;固体废物中二噁英含量为飞灰炉渣污泥.这说明采用高温焚烧和"活性炭喷射+布袋除尘"装置不会影响掺烧10%污泥的达标排放.指纹分布特征表明,前口废气以1,2,3,4,6,7,8-Hp CDF和OCDD为主,后口废气以OCDD和OCDF为主;飞灰、炉渣及污泥中的主要单体为OCDD、1,2,3,4,6,7,8-Hp CDD、OCDF、1,2,3,4,6,7,8-Hp CDF.主成分分析显示,前口废气和飞灰中的二噁英毒性分布特征相似;炉渣和污泥的毒性分布特征相似;后口废气有自身的特征.这说明在相同工况条件下,经同一设施处理的废物中二噁英排放特征相似.排放因子分析表明,2,3,4,7,8-Pe CDF和1,2,3,6,7,8-Hx CDF、1,2,3,6,7,8-Hx CDD和1,2,3,7,8,9-Hx CDD与总毒性排放因子具有较强的线性关系,且呋喃类(PCDFs)强于二噁英类(PCDDs).     

钢厂烧结机烟气排放对土壤二噁英浓度的影响

为分析钢铁烧结机排放二噁英沉降对土壤污染的影响,根据2016年河北某钢铁厂烧结机头二噁英排放监测数据、土壤监测数据等,建立了基于CALPUFF数值模型的钢铁烧结机排放二噁英类污染物沉降土壤的计算方法.结果显示,该企业烧结机二噁英毒性当量为0.017~0.025ng-TEQ/Nm~3,排放因子为0.044~0.081μg-TEQ/t,3个土壤监测点二噁英浓度结果为0.82~2.4ng/kg,采用CALPUFF模式模拟烧结机二噁英对土壤监测点沉降量结果为1.46~3.44ng/kg,模拟结果与周边土壤监测点实测趋势一致.     

中国危险废物和医疗废物焚烧处置行业二（口恶）排放水平研究

通过调研全国危险废物和医疗废物焚烧处置设施,对包含二噁英排放水平的设施按处置对象、炉型和处理量分类,并作系统分析和研究.结果表明现有危险废物焚烧设施烟气中二噁英的浓度比医疗废物低,达标率为74.19%;危险废物选用回转窑处置效果较好,达标率为66.67%;而医疗废物选用回转窑或热解炉,要综合考虑处置规模、生产成本和二英排放总量等因素;危险废物介于10~30 t·d-1和医疗废物介于10~20 t·d-1的处置设施要尤其注意二噁英的排放问题;医疗废物焚烧飞灰中二噁英的均值浓度为危险废物6倍以上,仅有16.67%满足填埋要求.二者烟气中二英的浓度分布以1,2,3,4,6,7,8-HpCDF、2,3,7,8-TCDF和OCDD为主.     

我国典型非木浆造纸二噁英排放研究

根据《中国履行〈关于持久性有机污染物的斯德哥尔摩公约〉国家实施计划》,制浆造纸行业是我国开展二英履约减排的六大重点行业之一,需要在规定的时间内达到减排要求.非木浆在我国原生纸浆生产和消费中一直占有重要比例,其生产过程中广泛使用的元素氯漂白工艺被认为是造成制浆造纸行业二噁英产生的重要来源.非木纤维制浆将在我国长期存在,摸清该领域二噁英排放情况,对于我国履约和实施二噁英的减排措施有重要意义.通过对竹子、麦草、芦苇和蔗渣这4种非木纤维的典型制浆企业的漂白全过程开展二噁英排放情况的检测,并结合各企业的浆水平衡数据,得到我国应用氯化碱处理次氯酸盐(CEH)三段漂白典型工艺的草浆、苇浆、竹浆及蔗渣浆生产的外排水所含二噁英的浓度(以I-TEQ计,下同)分别为:41.8、72.7、7.46和19.7 pg.L-1,尽管都在国家规定的新排放标准附近(30 pg.L-1),但随着我国对制浆造纸行业吨耗水要求的日益严格和以上新标准的实施,相关浓度很容易超标.为了实现国内、国际环境管理的要求,认为我国有必要尽快推动该行业研究并应用二噁英减排的最佳可行技术和最佳环境实践(best available techniques/best environmental practices,BAT/BEP).同时,结合监测数据,还初步估算了非木浆元素氯漂白相关的二噁英排放因子,可为联合国环境署补充相关因子提供有意义的参考.     

二噁英催化降解技术在废物焚烧领域的应用

焚烧是常用的废物处置方法,中国每年需要处量理的废物随社会发展和经济增长不断增加,由此产生的二噁英排放问题已引起社会广泛的关注。选择性催化氧化(SCO)技术可降解烟气中二噁英,在国外已有广泛工业应用,是最佳可行技术的重要组成部分,是我国斯德哥尔摩公约履约过程中的关键技术。为落实我国斯德哥尔摩公约履约责任,减少废物焚烧过程中二噁英类污染物的排放,促进行业全面推广应用以选择性催化氧化为代表的最佳可行技术,文章主要从SCO技术的发展、原理和影响因素出发选择合适的催化剂,结合国内工程案例验证分析了SCO技术对二噁英的去除效果,讨论了SCO技术应用的现状和前景,进一步说明在国内的废物焚烧领域推广和普及SCO技术的紧迫性和可行性。     

焦炉烟气中二（口恶）英类物质排放水平研究

二噁英和类二噁英多氯联苯属于《关于持久性有机污染物的斯德哥尔摩公约》规定的非故意产生的持久性有机物,统称为二噁英类物质.焦化生产过程中具备二噁英类物质生成所需的前体物、温度、催化剂等条件,但目前国内外对焦化行业焦炉烟气二噁英类物质排放研究仍属空白,为进一步明确焦化行业排放水平和影响因素,针对性地提出行业减排和控制措施,利用高分辨气相色谱-高分辨质谱法对4个不同规模的典型焦化企业焦炉烟气中二噁英类物质排放情况进行现场采样和实验室分析.结果表明,二噁英类物质毒性当量(以WHO-TEQ计)范围为3.9~30.0 pg·m-3,处于较低水平,检出较多的PCDD/Fs同系物主要是高氯代的.另外,烟气中此类物质的排放量与焦化生产工艺关系密切,捣鼓炼焦、较高的炭化室高度有利于减少二噁英类物质的排放.     

固体废物焚烧中二噁英控制措施探讨

焚烧是解决固体废物污染的1种较有效的方法,但是在焚烧过程中产生的二噁英会对环境造成危害.阐述了二噁英的危害和在固体废物焚烧中的产生途径.从燃烧前、燃烧中、燃烧后3个阶段.论述了二噁英的污染控制技术.提出了控制二噁英的具体措施.     

陕西省大气污染源二噁英排放量估算研究

在结合实际确定陕西省二噁英的主要排放源及其排放因子基础上,采用国际通用的气体排放量计算法估算了陕西省2000年-2008年的二噁英年排放量,并就排放量的构成和变化趋势进行分析。结果显示:二噁英的年排放总量呈增长趋势,介于27.67 98.39 g TEQ之间;能源消耗产生的二噁英居于首位,其排放量约占总排放量的50%。工业燃料燃烧和工业生产过程所排放的二噁英占年排放量的60%以上,控制工业污染源的二噁英排放势在必行。     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Isolation and preliminary characterization of a 3-chlorobenzoate degrading bacteria

A study was conducted to compare the diversity of 2-, 3-, and 4-chlorobenzoate degraders in two pristine soils and one contaminated sewage sludge. These samples contained strikingly different populations of mono-chlorobenzoate degraders. Although fewer cultures were isolated in the uncontaminated soils than contaminated one, the ability of microbial populations to mineralize chlorobenzoate was widespread. The 3- and 4-chlorobenzoate degraders were more diverse than the 2-chlorobenzoate degraders. One of the strains isolated from the sewage sludge was obtained. Based on its phenotype, chemotaxonomic properties and 16S rRNA gene, the organism S-7 was classified as Rhodococcus erythropolis. The strain can grow at temperature from 4 to 37℃. It can utilize several （halo）aromatic compounds. Moreover, strain S-7 can grow and use 3-chlorobenzoate as sole carbon source in a temperatures range of 10-30℃ with stoichiometric release of chloride ions. The psychrotolerant ability was significant for bioremediation in low temperature regions. Catechol and chlorocatechol 1,2-dioxygenase activities were present in cell free extracts of the strain, but no （chloro）catechol 2,3- dioxygenase activities was detected. Spectral conversion assays with extracts from R. erythropolis S-7 showed accumulation of a compound with a similar UV spectrum as chloro-cis,cis-muconate from 3-chlorobenzoate. On the basis of these results, we proposed that S-7 degraded 3-chlorobenzoate through the modified ortho-cleave pathway.     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.     

Organochlorine pesticides in soils under different land usage in the Taihu Lake region, China

A field study was conducted in the Taihu Lake region, China in 2004 to reveal the organochlorine pesticide concentrations in soils after the ban of these substances in the year 1983. Thirteen organochlorine pesticides (OCPs) were analyzed in soils from paddy field, tree land and fallow land. Total organochlorine pesticide residues were higher in agricultural soils than in uncultivated fallow land soils. Among all the pesticides, ΣDDX (DDD, DDE and DDT) had the highest concentration for all the soil samples, ranging from 3.10 ng/g to 166.55 ng/g with a mean value of 57.04 ng/g and followed by ΣHCH, ranging from 0.73 ng/g to 60.97 ng/g with a mean value of 24.06 ng/g. Dieldrin, endrin, HCB and α-endosulfan were also found in soils with less than 15 ng/g. Ratios of p,p'-(DDD DDE)/DDT in soils under three land usages were: paddy field ＞ tree land ＞ fallow land, indicating that land usage inlfuenced the degradation of DDT in soils. Ratios of p,p'-(DDD DDE)/DDT ＞1, showing aged residues of DDTs in soils of the Taihu Lake region. The results were discussed with data from a former study that showed very low actual concentrations of HCH and DDT in soils in the Taihu Lake region, but according to the chemical half-lives and their concentrations in soils in 1980s, the concentration of DDT in soils seemed to be underestimated. In any case our data show that the ban on the use of HCH and DDT resulted in a tremendous reduction of these pesticide residues in soils, but there are still high amounts of pesticide residues in soils, which need more remediation processes.     

Alterations of organ histopathology and metallolhionein mRNA expression in silver barb, Puntius gonionotus during subchronic cadmium exposure

Common silver barb,Puntius gonionotus,exposed to the nominal concentration of 0.06 mg/L Cd for 60 d,were assessed for histopathological alterations(gills,liver and kidney),metal accumulation,and metallothionein(MT)mRNA expression.Fish exhibited pathological symptoms such as hypertrophy and hyperplasia of primary and secondary gill lamellae,vacuolization in hepatocytes,and prominent tubular and glomerular damage in the kidney.In addition,kidney accumulated the highest content of cadmium,more than gills and liver.Expression of MT mRNA was increased in both liver and kidney of treated fish.Hepatic MT levels remained high after fish were removed to Cd-free water.In contrast,MT expression in kidney was peaked after 28 d of treatment and drastically dropped when fish were removed to Cd-free water.The high concentrations of Cd in hepatic tissues indicated an accumulation site or permanent damage on this tissue.