Decolorization of synthetic dyes by the Fenton reagent and the Cu/pyridine/H2O2 system

Representative azo, triphenylmethane, heterocyclic and polymeric synthetic dyes have been decolorized by two biological non-ezymatic systems, copper/pyridine/H2O2 and the Fenton reagent. With the former system, intensive decolorization measured after 1 h was obtained with phenol red (89%), tropaeolin 00 (58%), Evans blue (95%), eosin yellowish (84%), and Poly B-411 (92%). The rate of decolorization was not affected by pH in the range of 3-9 and increased with increasing temperature. The use of the radical scavengers thiourea and superoxide dismutase showed that hydroxyl radicals rather than superoxide anions are involved in the reaction. Omission of pyridine led to a substantial decrease in the extent of decolorization (20-50% decolorization). The use of organic peroxide instead of H2O2 resulted in slightly slower decolorization, similar values of decolorization being obtained only after a 2-h incubation. Decolorization of the dyes by the Fenton reagent was also very effective but slower than that obtained with the first system. Except for phenol red and eosin yellowish, (decolorization 8% and 52%, respectively) the dyes were decolorized up to 99% after 1-day incubation.     

亚铁羟基络合物还原转化水溶性偶氮染料

偶氮染料是印染工艺中应用最广泛的一类染料,目前染料废水脱色是污水处理难题。亚铁混凝处理染料废水过程中可能存在亚铁的还原作用,本实验制备了比溶解态亚铁更具还原反应活性的亚铁羟基络合物(ferrous hydroxycomplex,FHC),以5种不同类型的水溶性偶氮染料为目标污染物,研究FHC还原水溶性偶氮染料的脱色性能。实验结果表明,FHC对活性艳红X-3B、酸性大红GR和阳离子红X-GRL有较好的还原脱色效果,仅投加含铁89.6 mg/L的FHC,染料脱色率达到90%以上,继续增大FHC投加量可以完全脱色;中性枣红GRL的FHC还原脱色效果较差,需加入313.6 mg/L的FHC才能达到90%以上脱色率;134.4 mg/L的FHC能够将直接耐酸大红4BS完全脱色,但其脱色主要以混凝沉淀为主;溶液pH对FHC的还原性能产生重要影响,FHC还原染料脱色的适宜的pH值范围为4～10。该研究为亲水性染料脱色提供了一种新的技术,也为FHC运用于印染废水脱色提供了理论基础。     

Decolorization of synthetic dyes using a copper complex with glucaric acid

Selected azo, acridine, triphenyl methane, anthraquinone and thiazine-based dyes were decolorized using a catalytic system consisting of Cu(II)/glucaric acid/H(2)O(2). More than 90% decolorization was obtained with 100 ppm Acridine Orange, Azure B, Chicago Sky Blue, Crystal Violet, Methyl Orange, Poly B-411, Reactive Black 5, Reactive Blue 2, and Remazol Brilliant Blue R within 24 h. Seventy to eighty percent decolorization was achieved within the first 6 h. The decolorizaton was not affected by pH. The involvement of hydroxyl radicals produced in the system in the decolorization of the dye molecules was confirmed by electron spin resonance study.     

Potential of immobilized bitter gourd (Momordica charantia) peroxidases in the decolorization and removal of textile dyes from polluted wastewater and dyeing effluent

Immobilized peroxidases from Momordica charantia were highly effective in decolorizing reactive textile dyes compared to its soluble counterpart. Dye solutions, 50-200 mg/l, were treated with soluble and immobilized bitter gourd peroxidases (specific activity of 99.0 EU per mg protein). The decolorization of dyes with soluble and immobilized enzyme was maximum in the range of pH 3.0-4.0. The effect of different temperatures on the dye decolorization was monitored and it was observed that all the dyes were maximally decolorized at 40 degrees C. In order to examine the operational stability of the immobilized preparation, the enzyme was repeatedly exploited for the decolorization of the dyes from fresh batch of dye solutions. Even after 10 cycles in each case the immobilized preparation retained nearly 50% of the initial enzyme activity. The immobilized enzyme exhibited more than 90% of the original activity while the soluble enzyme lost 33% of the initial activity when stored for 40 d at room temperature. Mixtures of three, four and eight dyes were prepared and treated with soluble and immobilized bitter gourd peroxidase. Each mixture was decolorized by more than 80% when treated with immobilized enzyme. Dyeing effluent collected from local dyers was treated with both types of enzyme preparations. Immobilized enzyme was capable of removing remarkably high concentration of color from the effluent. TOC content of soluble and immobilized enzyme treated individual dyes, mixture of dyes and dyeing effluent was determined and it was observed that higher TOC was removed after treatment with immobilized enzyme.     

Decolorization of mixtures of different reactive textile dyes by the white-rot basidiomycete Phanerochaete sordida and inhibitory effect of polyvinyl alcohol

We tried to decolorize mixtures of four reactive textile dyes, including azo and anthraquinone dyes, by a white-rot basidiomycete Phanerochaete sordida. P. sordida decolorized dye mixtures (200 mg l-1 each) by 90% within 48 h in nitrogen-limited glucose-ammonium media. Decolorization of dye mixtures needed Mn2+ and Tween 80 in the media. Manganese peroxidase (MnP) played a major role in dye decolorization by P. sordida. Decolorization of dye mixtures by P. sordida was partially inhibited by polyvinyl alcohol (PVA) that wastewaters from textile industries often contain. This was caused by an inhibitory effect of PVA on the decolorization of Reactive Red 120 (RR120) with MnP reaction system. Second addition of Tween 80 to the reaction mixtures in the presence of PVA improved the decolorization of RR120. These results suggest that PVA could interfere with lipid peroxidation or subsequent attack to the dye.     

Decolorization of direct dyes by salt fractionated turnip proteins enhanced in the presence of hydrogen peroxide and redox mediators

The present paper demonstrates the effect of salt fractionated turnip (Brassica rapa) proteins on the decolorization of direct dyes, used in textile industry, in the presence of various redox mediators. The rate and extent of decolorization of dyes was significantly enhanced by the presence of different types of redox mediators. Six out of 10 investigated compounds have shown their potential in enhancing the decolorization of direct dyes. The performance was evaluated at different concentrations of mediator and enzyme. The efficiency of each natural mediator depends on the type of dye treated. The decolorization of all tested direct dyes was maximum in the presence of 0.6mM redox mediator at pH 5.5 and 30 degrees C. Complex mixtures of dyes were also maximally decolorized in the presence of 0.6mM redox mediator (1-hydroxybenzotriazole/violuric acid). In order to examine the operational stability of the enzyme preparation, the enzyme was exploited for the decolorization of mixtures of dyes for different times in a stirred batch process. There was no further change in decolorization of an individual dye or their mixtures after 60 min; the enzyme caused more than 80% decolorization of all dyes in the presence of 1-hydroxybenzotriazole/violuric acid. However, there was no desirable increase in dye decolorization of the mixtures on overnight stay. Total organic carbon analysis of treated dyes or their mixtures showed that these results were quite comparable to the loss of color from solutions. However, the treatment of such polluted water in the presence of redox mediators caused the formation of insoluble precipitate, which could be removed by the process of centrifugation. The results suggested that catalyzed oxidative coupling reactions might be important for natural transformation pathways for dyes and indicate their potential use as an efficient means for removal of dyes color from waters and wastewaters.     

Microbial decolorization of synthetic dyes and reactive dyes of industrial effluents by using a novel fungus Aspergillus proliferans

A decolorizing fungal strain was isolated and identified by the morphology and genotypic characterization as Aspergillus proliferans. The effect of A. proliferans on decolorization of synthetic dyes (70 mg ml(-1)) and colored effluent was evaluated in liquid culture medium. A. proliferans expressed their effective decolorization activity in effectual decolorization of synthetic dyes and industrial effluent. Synthetic dyes were decolorized by 76 to 89% within 6 days of treatment and 73.5% of color was removed in industrial effluent within 8 days. The addition of optimum carbon and nitrogen sources were effectively stimulated the decolorization activity. The high concentration of glucose repressed the decolorization activity and supplementation of yeast extract has significantly enhanced the effluent decolorization at p < 0.05. Laccase enzyme was isolated from liquid state fermentation, which showed significant enzyme activity (10,200 Uml(-1)) at p < 0.005. The crude enzyme decolorizes the dyes aniline blue and congo red in 14 hours (40.9 to 70%) and the effluent in 14 hours (88.6%). Moreover, the culture free supernatant without the fungal biomass has also effectively decolorized the effluent and synthetic dyes. The fungi Aspergillus proliferans was used not only for decolorization but also for better bioremediation of industrial effluent.     

Biological decolorization of reactive anthraquinone and phthalocyanine dyes under various oxidation-reduction conditions.

The decolorization of two anthraquinone dyes (Reactive Blue 4 [RB4] and Reactive Blue 19 [RB19]) and two phthalocyanine dyes (Reactive Blue 7 [RB7] and Reactive Blue 21 [RB21]) was investigated at an initial dye concentration of 300 mg/L using an unacclimated, enrichment culture. The culture was fed a mixture of organic compounds and maintained initially under aerobic conditions, and then progressively developed anoxic/ anaerobic conditions. Biotransformation-related decolorization of the dyes did not take place under aerobic conditions, but use of the feed organic mixture and biomass production by the enrichment culture were not affected. Complete ammonia removal occurred in the control and all dye-amended cultures. The development and extent of nitrification were much lower in the latter cultures, in which ammonia removal via air stripping was the dominant mechanism. Prolonged incubation of the culture under anoxic/anaerobic conditions with multiple carbon source additions resulted in a high decolorization extent of anthraquinone dyes (over 84%) and only partial decolorization of phthalocyanine dyes (49 to 66%). Development of significant methanogenic activity took place in the control and, to a lesser extent, in the two phthalocyanine dye-amended cultures, but the anthraquinone dyes severely inhibited the development of methanogenic activity. The RB4 and RB19 decolorization was attributed to nonreversible, microbially mediated dye transformation(s), demonstrated by the accumulation of decolorization products with absorbance maxima in the 420- to 460-nm region. The decolorization of RB4 and RB19 followed Michaelis-Menten kinetics. At an initial dye concentration of 300 mg/L, the observed maximum decolorization rate per unit biomass was 9.1 and 37.5 mg dye/mg volatile suspended solids x day for the RB4 and RB19, respectively. Thus, partial decolorization of reactive phthalocyanine dyes and extensive biological decolorization of reactive anthraquinone dyes is feasible only under anoxic/anaerobic conditions.     

Copper-ligand complex for the decolorization of synthetic dyes

The reaction system containing Cu(II), hydrogen peroxide and D-arabinono-1,4-lactone was found to be effective in the decolorization and reduction of toxicity of azo, thiazine-, triphenylmethane- and anthraquinone-based synthetic dyes. More than 85% decolorization was obtained with 100ppm Acridine Orange, Azure B, Chicago Sky Blue 6B, Crystal Violet, Evans Blue, Poly B-411, Reactive Blue 2, Reactive Blue 5, and Remazol Brilliant Blue R incubated for 24h in the presence of 10mM CuSO(4), 20mM D-arabinono-1,4-lactone and 80 mM H(2)O(2). The rate of decolorization was not affected by pH in the range of 3-9. The rapid decolorization was accompanied by a fast decomposition of H(2)O(2) in the reaction mixture and by a fast production of hydroxyl radicals.     

高铁酸盐对活性及分散染料的脱色研究

采用湿法制备了高铁酸钾(K₂FeO₄)氧化剂,研究了其对染料活性艳红X-3B(X-3B) 和分散蓝2BLN(2BLN)在不同pH条件下的脱色效果,并对Al₂ (SO₄)₃、K₂FeO₄及O₃对活性及分散染料的脱色效果进行了比较。结果表明：高铁酸钾对活性及分散染料的脱色效果明显, X-3B脱色率随pH的增加不断提高,2BLN脱色率在pH 6～10范围内无明显变化,在pH＝5时达到最大值。在X-3B及2BLN浓度同为100 mg／L,pH分别为10、5, K₂FeO₄浓度分别为100 mg／L和200 mg／L时,BLN及X-3B的脱色率分别达到92.3％和87.3％。在相同条件下,K₂FeO₄对活性艳红X-3B的脱色效果好于Al₂(SO₄)₃和O₃; 而K₂FeO₄对分散蓝2BLN的脱色效果虽比Al₂ (SO₄)₃稍差,但比臭氧的脱色效果要好。同时还研究了K₂FeO₄对活性及分散染料的脱色机理,结果表明： 高铁酸钾对X-3B的脱色依赖于K₂FeO₄的氧化作用,而对的2BLN的脱色则以絮凝为主。     

氯甲烷与偶氮染料混合废水的超声脱色

使用40 kHz超声(US)脱色氯甲烷(包括CCl4、CHCl3和CH2Cl2)与偶氮染料(包括甲基橙与铬黑T)混合模拟废水,考察了氯甲烷初始浓度对偶氮染料超声脱色和TOC去除的影响.结果表明:偶氮染料的单独超声脱色速率很慢;而在CCl4与CHCl3存在时超声能使偶氮染料短时间内脱色至无色,但对其TOC的超声去除促进作...     

Degradation and toxicity reduction of textile effluent by combined photocatalytic and ozonation processes

To minimize the environmental impact of textile effluents, mainly related to their high coloration and the presence of toxic or carcinogenic reactive dyes, the efficiency of photochemical and ozonation processes, applied in the form of isolated and combined procedures, were evaluated. The investigation was focused on the reduction of total organic carbon content (TOC), color and acute toxicity (monitoring by inhibition of Escherichia coli respiration). For a reaction time of 60 min, the anatase TiO2-assisted photocatalytic process produces color and TOC reduction of about 90% and 50%, respectively. Meanwhile, the ozonation process gives a decolorization of about 60% but negligible TOC reduction. When the processes were applied in a simultaneous form, the decolorization was almost complete and the TOC reduction was higher than 60%. The three treatments studied yield an acute toxicity reduction of around 50%.     

Semiconductor-assisted photocatalytic degradation of reactive dyes in aqueous solution

This work reports the semiconductor-assisted photochemical degradation of reactive dyes. In an oxygenated-UV-ZnO system almost total decolorization of Remazol Brilliant Blue R, Remazol Black B, Reactive Blue 221 and Reactive Blue 222 was observed in reaction times of about 60 min. Extending the photochemical treatment up to 120 min, mineralization higher than 80% for all the dyes was observed. During the same period, the residual acute toxicity was significantly reduced only for Remazol Black B. A systematic optimization study carried out by factorial design showed that for the reactive dyes tested, the ZnO semiconductor exhibits a better efficiency than that observed with anatase TiO2. A synergistic effect in the coupled TiO2-ZnO system was not observed.     

Phytoremediation of textile effluent and mixture of structurally different dyes by Glandularia pulchella (Sweet) Tronc

Plants of Glandularia pulchella (Sweet) Tronc. performed decolorization of structurally different dyes to varying extent because of induction of different set of enzymes in response to specific dyes. Differential pattern of enzyme induction with respect to time was obtained for lignin peroxidase, veratryl alcohol oxidase, tyrosinase and dichlorophenolindophenol reductase during the decolorization of dye mixture, whose combined action resulted in greater and faster decolorization of dyes. HPLC, FTIR and High Performance Thin Layer Chromatography (HPTLC) analysis confirmed degradation of dyes from textile effluent and mixture. HPTLC demonstrated progressive decolorization of dye mixture along with preferential degradation of the dyes. G. pulchella showed reduction in American Dye Manufacturer's Institute from 405 to 21 and 418 to 22, in case of textile effluent and mixture of dyes respectively. The non-toxic nature of the metabolites of degraded textile dye effluent and mixture of dyes was revealed by phytotoxicity studies.     

Biodegradation of azo dyes by the yeast Candida zeylanoides in batch aerated cultures

A number of simple azo dyes was degraded in liquid aerated batch cultures by a strain of the yeast Candida zeylanoides. The standard decolorization medium contained glucose as a carbon and energy source, and its pH was either controlled to 5.0-5.2, or allowed to decrease to 3.2-2.8, in the course of microorganism growth. The extent of colour removal in the culture medium was assessed through the decrease in dye absorbance of the supernatants. The extent of colour removal ranged from 44 to 90%, after 7 days, for 5 out of 6 dyes studied in shaked cultures, without pH control, and from 46 to 67%, after 22 hours, for 6 out of 8 dyes in batch experiments, at controlled pH.     

白腐真菌F1对染料脱色特性的研究

本研究从我国生物资源中筛选出一株白腐真菌F1,确定了其生长条件 ,实现了扩大培养 ,并研究了F1与黄孢原毛平革菌对 4种难降解染料的脱色效果。试验结果表明 ,F1对中性深黄GRL、酸性媒介漂蓝B和刚果红的脱色效率都超过 90 % ;白腐真菌能在短时间内将有毒染料酸性媒介漂蓝B降低到较低浓度 ;白腐真菌对染料脱色的同时 ,自身能够繁殖生长。     

Decolorization and degradation of dyes with mediated fenton reaction.

A mediated Fenton system has been evaluated for decolorization of several types of dyes. The result shows that the Fenton system with a dihydroxybenzoic acid (DHBA) chelator-mediator effectively reduced the color of a diluted solution of Carta Yellow RW liquid, Carta Yellow G liquid, and Cartasol Red 2GF liquid dye to a colorless level after 90 minutes of treatment with 100 microM iron II (Fe[II]), 100 microM DHBA, and 10 mM hydrogen peroxide (H2O2) at room temperature. Our results show that compared to a neat Fenton process, the mediated Fenton decolorization process increased the production, and therefore the effective longevity, of hydroxyl radical (OH) species to increase the decolorization efficiency. Our results suggest that application of this system would also result in an increase in dissolved oxygen (DO) in solution, which in turn would result in reduction of chemical oxygen demand (COD), biochemical oxygen demand (BOD), and total organic carbon (TOC).     

新生态MnO2吸附剂对酸性媒介染料废水脱色特性研究

本文主要报道了一种用于染料废水处理的新型材料即新生态MnO2 及其对三种酸性媒介染料染色废水的脱色作用及影响脱色效果的主要因素。研究结果表明 ,新生态MnO2 对酸性媒介染料的吸附能力很强 ,当染料浓度为2 0 0mg/L、pH <2时 ,其对酸性媒介黑T、酸性媒介绿G和酸性媒介黄GG的脱色率分别达 98.2 %、94.5 %和 96 .4%。染料吸附效果受体系pH值、MnO2 投加量、吸附时间及温度等因素的影响 ,其中pH值是最主要的影响因素。新生态MnO2 对酸性媒介黄GG的吸附作用符合Langmuir吸附等温式     

Decolorization and biodegradability of photocatalytic treated azo dyes and wool textile wastewater

The photodegradation and biodegradability have been investigated for four non-biodegradable commercial azo dyes, Reactive YellowKD-3G, Reactive Red 15, Reactive Red 24, Cationic Blue X-GRL, an indicator. Methyl Orange, and one industrial wool textile wastewater, using TiO2 suspensions irradiated with a medium pressure mercury lamp. The color removal of dyes solution and dyeing wastewater reached to above 90% within 20-30 min. of photocatalytic treatment. Biochemical oxygen demand (BOD) was found to increase, while chemical oxygen demand (COD), total organic carbon (TOC) decreased, so that the ratio of BOD5/COD of the wastewater increased from original zero up to 0.75. The result implies that photocatalytic oxidation enhanced the biodegradability of the dye-containing wastewater and therefore relationship between decolorization and biodegradability exists. When the color disappeared completely, the wastewater biodegraded normally and could be discharged for further treatment. The experimental results demonstrate that it is possible to combine photocatalysis with conventional biological treatment for the remedy of wastewater containing generally non-biodegradable azo dyes.     

Degradation of azo dyes using low iron concentration of Fenton and Fenton-like system

This study investigated Fenton and Fenton-like reactions at low iron concentration (相似文献