基于碳捕集的富氧燃煤烟气联合脱硫脱硝试验研究

富氧燃煤烟气压缩液化CO2的高压低温工况为NO氧化为易溶于水的NO2提供了十分有利的条件.基于小型高压吸收试验装置,采用配制的富氧燃煤模拟烟气,在高压常温下进行了NO、SO2、O2与H2O的吸收反应试验.根据反应前后的气液产物分析,测定了不同组分比例与不同压力下混合气体中NO与SO2的转化率.NO氧化与吸收试验表明,NO转化为HNO3的比率随压力升高而增加,在0.5 ～2 MPa之间增加很快,在2 ～3 MPa之间增速趋丁平缓,压力达3 MPa以上时,90％以上的NO均转化为稀硝酸,且初始NO浓度越高,NO的转化率越大.混合气体中同时存在5O2与NO的联合吸收试验发现,只有少量的NO转化成了NO3-,SO2向H2SO4的转化率随压力升高而增加,初始SO2浓度越大,转化率越高.分析表明,SO2与NO同时存在时SO2先行转化为SO3,NO充当了催化剂,但SO2转化为SO3的一次转化率小于35％,反应酸液产物的多次循环能使SO2的转化率达到90％以上.建议的工艺流程中需采用两座吸收反应塔顺序脱除SO2与NO并回收稀酸溶液,有望在富氧燃煤发电捕集CO2系统中降低脱硫脱硝成本,部分地弥补富氧燃烧机组发电成本的增加.     

次氯酸钠湿法烟气脱硝及同时脱硫脱硝技术研究

采用NaClO作氧化吸收剂,在鼓泡反应装置进行了湿法烟气脱硝实验研究,考察了NaIO、NO浓度、液相温度、气体流量、pH对脱硝效率的影响以及SO2对同时脱硫脱硝效率的影响,并结合液相产物分析探讨了同时脱硫脱硝反应机理.研究结果表明,pH值是影响活性成分HClO存在形式的重要因素,同时也是影响氧化吸收的关键因素;在一定范...     

冶炼厂SO2烟气化学催化吸收扩大试验研究

在单层塔板泡沫吸收塔中的ＳＯ２液相催化氧化进行了扩在试验研究,当ＳＯ２净化效率（单板效率）为５０％时,得到１６％（Ｗｔ）Ｈ２ＳＯ４,硫酸生成速率为１８％／ｈ,ＳＯ２吸收最佳敢化５Ｌ／Ｎｍ＾３,添加表面活性剂Ａｌ２（ＳＯ４）３及鼓氧操作对ＳＯ２液相催化氧化有明显促进作用,冶炼烟气ＳＯ２浓度波动吸收效率影响不大。     

Vaporization reduction characteristics of aqueous ammonia solutions by the addition of ethylene glycol, glycerol and glycine to the CO2 absorption process

Aqueous ammonia (NH₃) solution can be used as an alternative absorption for the control of CO₂ emitted from flue gases due to its high absorption capacity, fast absorption rate and low corrosion problem. The emission of CO₂ from iron and steel plants requires much attention, as they are higher than those emitted from power plants at a single point source. In the present work, low concentration ammonia liquor, 9 wt.%, was used with various additives to obtain the kinetic properties using the blast furnace gas model. Although a solution with a high ammonia concentration enables high CO₂ absorption efficiency, ammonium ions are lost as ammonia vapor, resulting in reduced CO₂ absorption due to the lower concentration of the ammonia absorbent. To decrease the vaporization of ammonia, ethylene glycol, glycerol and glycine, which contain more than one hydroxyl radical, were chosen. The experiments were conducted at 313 K similar to the CO₂ absorption conditions for the blast furnace gas model.     

液相氧化-吸收脱除模拟烟气中NOx的研究

分别采用Na Cl O2和Na2SO3溶液作为氧化液和吸收液,在自行设计的鼓泡塔反应系统进行了液相氧化-吸收脱除模拟烟气NOx的研究,考察了气相SO2浓度、Na Cl O2和Na2SO3投加量以及p H值等因素对NO氧化和NOx脱除的影响.结果表明,SO2会优先于NO与氧化剂反应,从而增大氧化剂消耗量.偏酸性条件有利于NO氧化,但酸性太强会导致Na Cl O2分解为Cl O2逸出.碱性吸收液对NO几乎不具吸收脱除效果,但共存NO2能促进NO的吸收脱除.SO2对NO2吸收脱除具有促进作用.     

Amine reclaiming technologies in post-combustion carbon dioxide capture

Amine scrubbing is the most developed technology for carbon dioxide (CO₂) capture. Degradation of amine solvents due to the presence of high levels of oxygen and other impurities in flue gas causes increasing costs and deterioration in long term performance, and therefore purification of the solvents is needed to overcome these problems. This review presents the reclaiming of amine solvents used for post combustion CO₂ capture (PCC). Thermal reclaiming, ion exchange, and electrodialysis, although principally developed for sour gas sweetening, have also been tested for CO₂ capture from flue gas. The three technologies all have their strengths and weaknesses, and further development is needed to reduce energy usage and costs. An expected future trend for amine reclamation is to focus on process integration of the current reclaiming technologies into the PCC process in order to drive down costs.     

Effect of dry deposition of NOx and SO2 gaseous pollutants on the degradation of calcareous building stones

A laboratory-based atmospheric flow chamber, using realistic presentation rates of SO₂, NO and NO₂ pollutants directed to various dry and wetted surfaces, has been employed to quantify the effects of the individual pollutants and the role of ozone as an oxidant. For the individual pollutant gases reacting with stone surfaces coming to equilibrium with 84% relative humidity (r.h.), chemical reaction in the presence of a moisture film proceeds and the extent of this reaction is related to pollutant gas solubility in the moisture film, i.e. SO₂ > NO₂ > NO. After dissolution in the moisture film, the pollutant gases are oxidized in the presence of catalysts associated with the stones. The additional presence of ozone promotes oxidation of the pollutant gases and thus their reaction with the stones. For SO₂ pollutant, oxidation in the gas phase is not significant compared with that in the moisture film, with enhanced oxidation in the presence of catalysts. Ozone increases oxidation of NO and NO₂ pollutant gases in the gas phase and moisture film; however, the oxidation of SO₂ in the moisture film is more significant than that of NO or NO₂. Wetting of the stone surfaces, in the absence of ozone, reveals the consistently greatest chemical reaction with SO₂ compared with NO and NO₂, which is related to SO₂ solubility, oxidation in the presence of catalysts and production of sulphuric acid. Generally similar behaviour is evident of NO and NO₂, but NO shows a reduced extent of chemical reaction, implying that its oxidation in surface water, in the presence of catalytic species, is slow and hence the reactants are lost in the form of run-off. In the additional presence of ozone, the SO₂ pollutant gas gives rise to enhanced chemical reaction, whereas both NO and NO₂ show lower extents of chemical reaction than for the dry stones. This arises from the relatively slow conversion of N₂O₅ in the liquid phase to nitric acid, allowing loss of reactants in run-off.     

Pilot study on bromate reduction in ozonation of water with low carbonate alkalinities by carbon dioxide

A pilot study was carried out to explore the application of carbon dioxide for pH depression in a bubble column and its ability to inhibit bromate formation for water with a low alkalinity. Results showed that in the absence of ammonia, CO2 was capable of reducing bromate 38.0%–65.4% with one-unit pH depression. CO2 caused a slightly lower bromate reduction (4.2%) than did H2SO4 when the pH was depressed to 7.4, and a more a pronounced lower reduction (8.8%) when the pH was depressed to 6.9. In the presence of 0.20 mg/L-N ammonia, bromate was largely inhibited with 73.9% reduction. When the pH was depressed to 7.4, CO2 and H2SO4 showed an 11.3% and 23.5% bromate reduction respectively, demonstrating that the joint use of CO2 and ammonia might be a plausible strategy of blocking all three bromate formation pathways. CO2 could be applied through the aeration diffuser together with ozone gas, resulting in a similar bromate reduction compared with the premixing method through Venturi mixer.     

Liquid-phase catalytic oxidation of smelting-gases containing SO2 in low concentration

In order to approach an applicable method of purifying smelting-gases containing SO₂ in low concentration, the catalytic oxidation of SO₂ in low concentration in smelting-gas, using Mn⁺², Fe⁺² and Zn⁺² in liquid-phase, was performed separately in a foam absorbing column in a copper smelter. The absorption solution, containing metal ions in an optimal proportion according to an orthogonal test, demonstrates an improved purification capability for smelting-gas. When the concentration of H₂SO₄ in the solution rises to 20%, the removal efficiency of SO₂ in smelting-gas can be still maintained above 85%. The method is demonstrably effective for the waste gas treatment at small and mid-scale smelters of non-ferrous metals.     

电晕放电与络合催化联合同时去除烟气中SO_2、NO实验研究

采用电晕放电与液相络合催化协同同时去除烟气中SO2和NO,电压、水流量、乙二胺合钴浓度、pH、SO2和NO初始浓度以及气流量对同时去除SO2和NO效率的影响进行了实验研究.结果表明:NO去除率随着放电电压、水流量、乙二胺合钴浓度、pH的增加而增加,而随SO2和NO初始浓度、烟气流量的增大而减小;SO2去除率也随放电电压,水流量的增加而增加,随烟气流量的增加而下降,但溶液pH,SO2和NO初始浓度和乙二胺合钴浓度对其影响很小.溶液中加入Mn2+和尿素能分别增强SO2和NO的去除效果.最佳条件为:电压25 kV、水流量80 L·h-1,乙二胺合钴浓度0.02 mol·L-1,烟气流量1.0 m3·h-1、尿素浓度0.02 mol·L-1,Mn2+浓度为0.02 mol·L-1时,NO和SO2去除率分别可达68%和94%,对应能量消耗分别为22.2 g·k Wh-1和75.2 g·k Wh-1.     

电厂烟气注入采空区封存的可行性

为了考察将电厂烟气注入采空区实现防火与气体封存的可行性,采用自制的煤大样量吸附装置测定了常温、常压条件下塔山烟煤对各种烟气成分的饱和吸附量,并对烟煤在空气和烟气氛围下对氧气的吸附行为进行了研究. 结果表明:将电厂烟气注入井下采空区,每t煤可封存约1.20 m3的CO₂,烟气中SO₂和NO₂可全部被烟煤封存;在物理吸附阶段,烟煤对CO₂的吸附量分别为对N₂吸附量的13倍,对O₂吸附量的41倍;在常温、常压条件下,烟煤对N₂和CO₂的吸附为物理吸附,12 h已基本达到饱和状态,但烟煤对O₂的吸附随着时间的增加逐渐由物理吸附转变为化学吸附,因此在较长时间内未能达到平衡状态. 通过不同气体氛围下烟煤吸附氧气量的数据分析发现,将电厂烟气注入到采空区,因烟煤对氧气的吸附量降低了29%,可有效抑制其自燃反应的进行. 研究显示,电厂烟气注入采空区可实现节能减排和灾害治理的统一.      

厌氧条件下砂壤水稻土N2、N2O、NO、CO2和CH4排放特征

了解厌氧条件土壤反硝化气体(N2、N2O和NO)、CO2和CH4排放特征,是认识反硝化过程机制的基础,并有助于制定合理的温室气体减排措施.定量反硝化产物组成,可为氮转化过程模型研发制定正确的关键过程参数选取方法或参数化方案.本研究选取质地相同(砂壤土)的两个水稻土为研究对象,通过添加KNO3和葡萄糖的混合溶液,将培养土壤的初始NO-3和DOC含量分别调节到50 mg·kg-1和300 mg·kg-1,采用氦环境培养-气体及碳氮底物直接同步测定方法,研究完全厌氧条件下土壤N2、N2O、NO、CO2和CH4的排放特征,并获得反硝化气态产物中各组分的比率.结果表明,在整个培养过程中,两个供试土壤的N2、N2O和NO累积排放量分别为6~8、20和15~18 mg·kg-1,这些气体排放量测定结果可回收土壤NO-3变化量的95%~98%,反硝化气态产物以N2O和NO为主,其中3种组分的比率分别为15%~19%(N2)、47%~49%(N2O)和34%~36%(NO);但反硝化气体产物组成的逐日动态均显现为从以NO为主逐渐过渡到以N2O为主,最后才发展到以N2为主.以上结果说明,反硝化气体产物组成是随反硝化进程而变化的,在以气体产物组成比率作为关键参数计算各种反硝化气体产生率或排放率的模型中,很有必要重视这一点.     

NaClO2海水溶液强化烟气脱硝效果的实验研究

海水中富含多种盐类,具有一定碱性,是天然的缓冲剂,在脱硫脱硝方面具有良好的应用前景.利用不同浓度的NaClO_2溶液进行废气循环喷淋脱硝实验.结果表明,NaClO_2模拟海水溶液与NaClO_2淡水溶液都能将NO完全脱除,且当NO完全被脱除时,模拟海水溶液的持续时间比淡水溶液更长,模拟海水中所含有的少量HCO_3~-和OH~-是造成这种差异的主要原因.滴定实验结果显示0.066 mmol的HCl就可使NaClO_2淡水溶液的pH值降到7,而NaClO_2模拟海水溶液的pH值降到7需要0.114 mmol的HCl;在循环喷淋脱硝过程中NaClO_2模拟海水溶液的pH值基本维持在7以上.离子色谱检测结果显示脱硝后溶液中主要阴离子为Cl~-和NO_3~-.基于质量平衡计算结果,当NaClO_2浓度为20 mmol·L~(-1)时,在脱硝过程中淡水溶液中NaClO_2的利用率为56%,而模拟海水溶液中NaClO_2的利用率可达67.25%,提高幅度为20.1%.     

A denuder technique for the measurement of nitrous acid in urban atmospheres

A new denuder set-up for the measurement of nitrous acid in polluted atmospheres is described here. The set-up is composed of one tetrachloromercurate-coated denuder for the removal of SO₂ and two downstream sodium carbonate-coated denuders for the determination of nitrous acid by the differential technique [Febo et al., 19, 1517–1530 1990]. The removal of SO₂ is necessary in order to avoid the formation of artifact nitrite on the sulfite layer which results from the interaction between atmospheric SO₂ and the Na₂CO₃ coating. Because of this mechanism, the measurement of HONO by means of the previously used NaClNa₂CO₃Na₂CO₃ denuder set-up is heavily biased in all cases when SO₂ and NO₂ are present at high concentration levels (e.g. urban environments).     

Absorption characteristics of new solvent based on a blend of AMP and 1,8-diamino-p-menthane for CO2 absorption

Aqueous 1,8-diamino-p-menthane (KIER-C3) and commercially available amine solutions were tested for CO₂ absorption. A 2-amino- 2-methyl-1-propanol (AMP) solution with an addition of KIER-C3 showed 9.3% and 31.6% higher absorption rate for CO₂ than the AMP solution with an addition of monoethanolamine (MEA) and ammonia (NH₃), respectively. The reaction rate constant for CO₂ absorption by the AMP/KIER-C3 solution was determined by the following equation: k_2,AMP/C3 = 7.702×10⁶ exp (-2248.03/T). A CO₂ loading ratio of the AMP/KIER-C3 solution was also 2 and 3.4-times higher than that of the AMP/NH3 solution and the AMP/MEA solution, respectively. Based on the experimental results, KIER-C3 may be used as an excellent additive to increase CO₂ absorption capability of AMP.     

Effects of amine, amine salt and amide on the behaviour of carbon dioxide absorption into calcium hydroxide suspension to precipitate calcium carbonate

The amount of carbon dioxide （CO2） absorption and calcium ion （Ca^2＋） concentration besides the pH of aqueous solution were observed during the COz absorption to precipitate calcium carbonate （CaCO3） from calcium hydroxide （Ca（OH）2）. A reaction rate-limiting effect of an amount of CO2 absorption without any organic additives in the early stage of the precipitation was observed, which was attributed to an interruption effect of bicarbonate ion （HCO3） on the precipitation of CaCO3. The improvement for the reaction rate was achieved not only by amine additives but also by neutral additives such as ε-caprolactam or amine salt. When the hexamethylene diamine was dissolved in the solution, successive change of crystal forms of CaCO3 aragonite to calcite in aqueous suspensions, confirmed by Ca^2＋ concentration change and X-ray diffraction, was concluded that a local environment around the amine group in aqueous solution and an interaction of the diamine with precipitated CaCO3 particles were important factors for these reactions.     

硝酸还原酶介导的NO合成参与SO2引发的拟南芥气孔运动的调节

以拟南芥为材料,研究了硝酸还原酶(NR)途径在植物适应SO2胁迫中的作用.结果表明:SO2胁迫可诱导4周龄拟南芥植株叶片NR活性增强、一氧化氮(NO)水平提高,NR活性和NO水平与SO2暴露时间呈正相关.NR抑制剂叠氮化钠(NaN3)可缓解SO2诱发的NO水平升高.RT-PCR检测发现,SO2熏气72 h时拟南芥NR途径关键基因Nia1、Nia2和NiR1均转录上调.研究还发现,SO2可诱发拟南芥野生型、突变体nia2、nia1nia2的气孔关闭,NaN3和NO清除剂c-PTIO可阻止SO2诱发的野生型和nia2气孔关闭,说明通过NR途径合成的NO参与了SO2胁迫诱发的拟南芥气孔运动调节.研究结果表明,NR活性的增强介导了SO2胁迫期间拟南芥叶片NO水平的升高,后者参与胁迫期间拟南芥气孔运动的调控,以增强拟南芥植株对SO2胁迫的适应性.     

不同光源下TiO2/ACF同时脱硫脱硝实验研究

实验室制备了负载型二氧化钛光催化剂TiO₂/ACF,利用自行设计的光催化反应器,在紫外和可见2种光源下进行了同时脱硫脱硝试验,确定了最佳的试验条件,比较了2种不同光源下的脱除效率.结果表明,烟气中氧含量、反应温度、烟气含湿量、光照强度等是影响光催化的主要因素,在紫外光源的照射下,负载型TiO₂/ACF光催化剂脱除SO₂和NO的效率分别达到99.7%和64.3%,在可见光源的照射下,负载型TiO₂/ACF光催化剂脱除SO₂和NO的效率分别达到97.5%和49.6%, 5次平行试验结果表明,平行数据的标准偏差S较小.通过反应后吸收液的离子色谱分析,推测了2种不同光源下同时脱硫脱硝的反应机制.     

Response surface method for modeling the removal of carbon dioxide from a simulated gas using water absorption enhanced with a liquid-film-forming device

This paper presents the results from using a physical absorption process to absorb gaseous CO_2mixed with N_2using water by producing tiny bubbles via a liquid-film-forming device(LFFD)that improves the solubility of CO_2in water.The influence of various parameters—pressure,initial CO_2concentration,gas-to-liquid ratios,and temperature—on the CO_2removal efficiency and its absorption rate in water were investigated and estimated thoroughly by statistical polynomial models obtained by the utilization of the response surface method(RSM)with a central composite design(CCD).Based on the analysis,a high efficiency of CO_2capture can be reached in conditions such as low pressure,high CO_2concentration at the inlet,low gas/liquid ratio,and low temperature.For instance,the highest removal efficiency in the RSM–CCD experimental matrix of nearly 80%occurred for run number 20,which was conducted at 0.30 MPa,CO_2concentration of 35%,gas/liquid ratio of 0.71,and temperature of 15°C.Furthermore,the coefficients of determination,R~2,were 0.996 for the removal rate and 0.982 for the absorption rate,implying that the predicted values computed by the constructed models correlate strongly and fit well with the experimental values.The results obtained provide essential information for implementing this method properly and effectively and contribute a promising approach to the problem of CO_2capture in air pollution treatment.     

H2O2和NO互作调控SO2诱导的胡杨细胞死亡

二氧化硫(SO_2)是一种常见的大气污染物,目前关于SO_2对木本植物的毒害作用及相关机制并不清楚.本文以木本植物胡杨的愈伤细胞为材料,研究SO_2衍生物对胡杨细胞的致死效应,以及过氧化氢(H_2O_2)与一氧化氮(NO)在SO_2诱导胡杨细胞死亡中的信号调节作用.研究发现:SO_2衍生物处理(1~5 mmol·L-1)可诱发胡杨细胞死亡,且SO_2衍生物浓度越大、处理时间越长,细胞死亡率越高.2 mmol·L-1SO_2衍生物处理胡杨细胞后,胞内H_2O_2和NO水平显著升高,且H_2O_2水平的升高先于NO.一定浓度的外源H_2O_2或NO供体SNP能够提高SO_2胁迫下胡杨细胞的死亡率;而使用H_2O_2清除剂CAT和ASA、NO清除剂c PTIO、NO合成抑制剂钨酸钠后,SO_2诱导的细胞死亡率明显降低.进一步实验发现,外源H_2O_2可以提高SO_2胁迫下胡杨细胞的硝酸还原酶(NR)活性,促进胞内NO产生;而利用CAT和ASA清除H_2O_2后,细胞NR活性和NO产生均受到明显抑制.此外,SO_2胁迫下,外源SNP能够抑制抗氧化酶(CAT和APX)活性,增加胡杨细胞内的H_2O_2水平,而一定浓度的c PTIO和钨酸钠均可提高CAT和APX活性,降低胞内H_2O_2水平.结果表明:SO_2胁迫下,胡杨细胞快速产生的H_2O_2能够激活硝酸还原酶活性,促进NO生成,同时NO能够通过抑制抗氧化酶活性而提高H_2O_2水平.H_2O_2与NO互作调控SO_2诱导的胡杨细胞死亡.