Recycling phosphorus and calcium from aquaculture waste as a precursor for hydroxyapatite (HAp) production: a review

Environmental Science and Pollution Research - Water contaminated with phosphorus needs to be managed efficiently to ensure that clean water sources will be preserved. Aquaculture plays an...     

Microwave-assisted synthesis of hydroxyapatite for the removal of lead(II) from aqueous solutions

Purpose

This study has the objective to evaluate the lead(II) removal capacity of hydroxyapatite powder synthesized by microwave as an alternative method to decrease production time and cost.

Methods

Hydroxyapatite (HA) was synthesized by a microwave-assisted precipitation method using calcium nitrate and ammonium hydrogen phosphate as calcium and phosphorus sources, respectively. X-ray diffraction and Fourier transform infrared results clearly revealed that the resulting powder was HA with high purity and crystallinity. The obtained powder was used for the removal of lead(II) from aqueous solutions. The effects of pH, amount of adsorbent, initial lead(II) concentration, and contact time were studied in batch experiments.

Results

In the adsorption experiments, maximum lead(II) retention was obtained at pH 6. Adsorption equilibrium was established after 40 min. It was found that the adsorption of lead(II) on HA was correlated well (R ²?=?0.958) with the Freundlich equation for the concentration range studied. Both ion exchange and adsorption process were thought to exist in the removal process.

Conclusions

This study indicates that easily and rapidly synthesized HA by microwave-assisted precipitation method could be used as an efficient adsorbent for removal of lead(II) from aqueous solutions.     

Recycling lead from a zinc plant residue (ZPR) using brine leaching and cementation with aluminum powder

Environmental Science and Pollution Research - This research investigated the treatment process of an Iranian zinc plant residue for recycling lead utilizing brine leaching and cementation with...     

利用厌氧菌发酵产物处理含铅废水及机理研究

针对传统方法去除废水中重金属铅的缺陷,利用4株厌氧微生物的发酵产物,在不同投加量、pH、温度和反应时间下研究该产物的除铅效果。通过正交实验确定了微生物发酵产物对含铅废水处理的最佳反应条件为：发酵产物投加量为0.5 g,反应时间为20 min,pH=6,温度20℃,铅的去除率99.4%以上,并用蓄电池厂的实际废水进行验证实验,获得相同的效果;同时通过扫描电子显微镜和X-射线能量散射光谱分析厌氧细菌代谢的混合物成分,对去除机理进行了初步探讨,为生物技术处理含铅废水提供了一种新方法和理论依据。     

高炉渣吸附废水中的铅

为探讨高炉渣去除水中铅的机理,采取等温吸附实验研究了高炉渣吸附铅的热力学特征,应用傅里叶红外光谱(FTIR)、X射线衍射(XRD)技术相结合的方法比较了吸附前后谱图的变化。实验结果表明,高炉渣吸附铅的平衡时间约为120 min;Freundlich方程可以很好地拟合不同温度下的吸附过程;平衡吸附量随温度升高有所减小,吉布斯自由能变化量为负值,吸附反应为一个自发放热过程。谱图分析显示,红外光谱980~1 100 cm-1和515 cm-1处波峰变化较为明显,X射线衍射谱在衍射角等于25°和35°附近出现了新峰;说明高炉渣内的Si—O—Si是主要吸附位点,参与反应的主要是炉渣内的硅氧键。     

Primary biosorption mechanism of lead (II) and cadmium (II) cations from aqueous solution by pomelo (Citrus maxima) fruit peels

Environmental Science and Pollution Research - The present work investigates the primary adsorption mechanisms of lead (II) and cadmium (II) cations onto pomelo fruit peel (PFP) from aqueous...     

A review on adsorptive removal of dyes from wastewater by hydroxyapatite nanocomposites

Environmental Science and Pollution Research - Dye removal from wastewater is of prominence due to its hostile effects on human health and the environment. The complex structure of the dye molecule...     

隔膜电解法回收利用电厂锅炉EDTA清洗废水研究

以涂Ir/Sn钛网板作阳极,以不锈钢网板作阴极,采用隔膜电解法处理电厂锅炉EDTA清洗废水.实验结果表明,电流、阴极电解液初始pH值和Fe/EDTA摩尔比对粉末铁析出速率影响较大,粉末铁电解析出的适宜条件是电解电流为1.0 A、阴极电解液初始pH值为5.6、阴极电解液Fe/EDTA摩尔比足够高.采用隔膜电解结合反渗透膜系统处理电厂锅炉EDTA清洗废水,可同时高效回收纳米级粉末铁和EDTA.     

稀土冶炼过程草酸沉淀废水资源化处理技术

为了实现稀土生产草沉废水的资源回用,对稀土草酸沉淀废水建立资源回收工艺,回收废水中的草酸和盐酸。研究包括草沉废水水质分析、草沉废水蒸馏分离工艺研究、蒸馏盐酸的回收利用、盐酸蒸发过程中的浓度变化趋势分析、草沉废水草酸回收研究以及工艺经济性分析。结果表明:草沉母液中TOC含量为4 661 mg/L,金属离子总体含量不高;通过常压实沸点蒸馏发现,草沉母液可回收5 mol/L盐酸330 mL/L或1 mol/L盐酸600 mL;蒸发后草酸产率超过16 g/L草沉废水;并且结晶草酸纯度≥99.5%,硫酸根未检出,灼烧残渣≤0.16%,重金属(以Pb计)≤0.000 01%,铁离子≤0.004 5%,氯化物≤0.08%。通过上述研究,为草沉废水资源化处理技术的工业化应用提供了理论依据。     

不饱和聚酯树脂高浓度废水共沸精馏资源化与治理技术

针对不饱和聚酯树脂生产高浓度废水的特点,采用新型共沸精馏技术进行资源化预处理。实验结果表明,共沸精馏几乎将废水中的原料、聚合中间体等有机物全部浓缩于釜液中,釜底浓缩液COD可高达120万mg／L左右,有机物回收率达93％～96％。将COD约120万nq-g／L的釜液以20％比例投入不饱和聚酯树脂合成反应中,制得了一种新型高性能树脂,且树脂的得率由常规生产的93．4％提高至99．77％。对与共沸剂分离后的COD约为1万mg／L的馏出液采用新型多技术协同催化氧化技术进行预处理,使废水B／C由0．021提高至0．3以上;再采用EGSB＋MBBR生化处理和活性炭吸附深度处理,出水可稳定达标排放,并能满足循环冷却水要求。     

多级冷冻工艺对高盐高浓度有机废水的处理效果及去除机理

探索了冷冻结晶工艺去除高盐高浓度模拟有机废水的影响因素,将多级冷冻工艺应用于模拟废水和实际废水。结果表明：在其他因素固定的条件下,结冰率越高,有机物去除率和脱盐率就越低;冷冻温度越低,有机物去除率和脱盐率越低;有机物去除率和脱盐率随初始盐浓度或初始COD的增大而降低;冷冻接触面积越大,有机物去除率和脱盐率越高。初始COD为 8 000.0 mg·L⁻¹,初始盐浓度为8 000.0 mg·L⁻¹的模拟废水在4级冷冻后,COD和含盐量分别降低至240.0 mg·L⁻¹和516.9 mg·L⁻¹,去除率分别为97.0%和93.5%。初始COD为55 690.0 mg·L⁻¹,初始盐浓度为54 648.9 mg·L⁻¹ (以NaCl计)的实际化工废水在经过6级冷冻处理后,COD和含盐量分别降低至491.3 mg·L⁻¹和983.3 mg·L⁻¹,有机物去除率为99.1%,脱盐率为98.2%,可达到市政管网的接管要求。上述研究结果为高盐高浓度有机废水的处理提供了新的解决方案。     

盐度对序批式反应器与间歇曝气膜生物反应器污水处理效果的影响

采用序批式反应器(SBR)与间歇曝气膜生物反应器(IAMBR)处理模拟生活污水,考察了进水盐度对两反应器污水处理效果的影响。研究表明,当进水盐度为0g/L(以NaCl质量浓度计,下同)时,SBR和IAMBR对总有机碳(TOC)、NH4+-N及TN的去除能力相当,IAMBR未表现出明显的优势;当进水盐度为10g/L时,SBR和IAMBR对TOC、NH4+-N及TN的去除产生明显的差异。IAMBR因为膜的截留与微生物富集作用,对污染物的去除无明显变化,依然保持了较高的污染物去除率,而SBR受盐度冲击影响较大,TOC、NH4+-N及TN的去除率均大幅降低,说明IAMBR具有较高的抗盐度冲击性能。     

典型重金属离子对羟基磷酸钙结晶法回收污水中磷的影响

采用羟基磷酸钙(HAP)结晶法回收模拟城镇污水处理厂富磷上清液中的磷,探究了3种典型重金属离子(Cu2+、Cd2+、Zn2+)对HAP结晶体系的单独及联合影响,并结合Visual MINTEQ (Ver3.2)模拟软件进行了分析.结果 表明,单一投加Cu22/Cd2+/Zn2+均会抑制磷的去除,其中Zn2+对磷去除率的...     

废水生物处理出水中溶解性微生物产物的形成机制与特征

废水生物处理出水中的溶解性微生物产物(SMP)主要产生于基质降解和微生物的内源呼吸过程,它的存在是影响生物处理出水水质和有机物去除率的一个重要因素,已引起人们的普遍关注.简单阐述了SMP的定义,详细探讨了废水生物处理出水中溶解性微生物产物的形成机制与特征.     

聚合物水凝胶的制备以及吸附废水中铅离子

以2-丙烯酸羟乙酯(HEA)和L-半胱氨酸(L-Cys)为单体,采用辐射共聚法制备了对Pb2+具有高效吸附性能的水凝胶,利用改性剂(乙酰胺基-L-半胱氨酸)对共聚物水凝胶进行了改性,应用SEM、FT-IR、XPS等方法表征了水凝胶的性能,研究了改性后水凝胶在不同pH以及不同温度条件下对Pb2+的吸附效果,探讨了水凝胶吸附Pb2+的吸附机理,并且采用EDTA二钠为脱附剂,探索了水凝胶的重复利用能力。     

Long term performance of MBR for biological nitrogen removal from synthetic municipal wastewater

This study monitors the long term performance of membrane bioreactor (MBR) for the treatment of synthetic municipal wastewater at solid retention time (SRT) of 40 and 20d with particular emphasis on simultaneous nitrification-denitrification (SND). SND was greatly influenced by the operating dissolved oxygen (DO). It was found that at an SRT of 20d, nitrogen removal through assimilation into biomass increases as a result of higher biomass yield. The profile of soluble microbial products (SMP) conformed to a cyclical pattern in the MBR with respect to SRT. Decrease in SRT from 40 to 20d resulted in doubling of accumulated SMP concentration (to 56mgl(-1)) in the MBR. This however, was accompanied by a simultaneous drop in percentage of SMP with MW>100kD, from 42.4% to 33%. Also, the sludge filterability decreased by 24-folds despite a decrease in the biomass concentration, following the above reduction in SRT. It was found that the volumetric oxygen transfer coefficient (K(l)a) was a function of biomass concentration in MBR with the ratio of the oxygen transfer coefficient in mixed liquor to that of clean water (alpha) to be 0.2-0.5.     

可拆卸式矿化垃圾生物反应床处理电厂柠檬酸酸洗废水研究

在实验室和现场对电厂柠檬酸酸洗废水进行生石灰前处理和后续可拆卸式三级矿化垃圾生物反应床的生物处理,主要研究了以往采用矿化垃圾反应床处理废水未涉及的反应床级数对废水处理效果的影响,比较了现场试验和实验室试验中的废水处理效果,并探讨了其原因。试验结果表明,本研究中的矿化垃圾反应床的适宜级数为3,第一级反应床的贡献最大,无论是实验室试验还是现场试验,采用本法处理电厂柠檬酸酸洗废水,均可使废水COD达到一级排放标准。     

感应热固定床CWPO处理染料废水的催化剂制备及其性能

感应热固定床(IHFB)作为新型热传递方式下非均相反应器,利用感应加热铁磁材料将热量传递至液相,形成固液界面高温微反应区,实现有机废水低能高效降解。实验以海绵铁为感应内核,淀粉为碳源,0.2 mol/L硝酸镍为浸渍溶液,按照一定固液比采用浸渍焙烧法制备了C包覆表层负载NiO的感应热催化剂(mNiO/C),对mNiO/C材料的形态结构进行了SEM、ES和XRD表征。结果表明,铁碳比(Fe/C)3∶1、浸渍固液比1∶1、500℃下焙烧2 h,重复包覆3次所得的mNiO/C材料结构最稳定、催化活性最大。并以直接紫D-BL模拟废水为进水,考察了流动状态下感应热固定床催化湿式过氧化氢氧化法(CWPO)降解染料废水的性能,在最优条件下,染料降解率高达80%以上。     

软锰矿-污泥活性炭的制备及其对废水中铅离子的吸附

以城市污水处理厂的剩余污泥为原料,掺杂一定量的软锰矿,采用氯化锌活化法制备一种软锰矿-污泥活性炭,并运用比表面积测定、电镜扫描、红外光谱分析及O2-TPO等表征手段对软锰矿-污泥活性炭及纯污泥活性炭进行了结构特性的比较分析,证明添加软锰矿将污泥活性炭的比表面积提高52.33%,是由于在制备过程中软锰矿催化了污泥中有机质的分解,同时也为新生炭提供了更多的骨架,促进了积炭反应的发生。软锰矿-污泥活性炭和纯污泥活性炭对废水中铅离子的吸附实验表明:当Pb2+初始浓度为40 mg/L、pH为5.0、活性炭用量为2 g/L、吸附时间为1 h时,软锰矿-污泥活性炭对废水中Pb2+的去除率可达88%,效果明显优于纯污泥活性炭。常温下软锰矿-污泥活性炭对Pb2+的吸附符合Lang-muir吸附等温式。