河湖疏浚淤泥的表征、絮凝和脱水

以无锡锡山湿地公园河道淤泥及太湖贡湖湾疏浚底泥为研究对象,对比分析了两种淤泥的矿物组成、粒径分布及泥微粒表面基团、ζ电位等理化特性。以聚丙烯酰胺类聚合物(polyacrylamide,PAM)为絮凝剂,对比分析了其在2种底泥絮凝分离、真空抽滤脱水过程中的作用特征,并对相关影响因素进行了探讨。结果表明,两种淤泥样具有相近的主体矿物组分、有机基团及ζ电位值,但有机质含量稍高的淤泥样中大颗粒所占比例相对较高。相比阳离子型PAM,阴离子型PAM在较少用量下即可获得较大絮团,但上清液浊度较高。絮凝泥在抽滤过程受絮团尺寸影响较大,PAM不同类型基团间的差异对其影响较小,但对趋于平衡后的泥饼含水率略有影响。     

超磁分离污泥与剩余污泥协同水解酸化

以超磁分离污泥作为研究对象,用2种不同的剩余污泥作为接种污泥,维持温度在30℃,探究了剩余污泥对超磁分离污泥厌氧水解酸化产物及产率的影响。结果表明:随着剩余污泥接种量的增加,混合污泥SCOD的析出量也逐渐增加;接种剩余污泥量的增加促进了混合污泥VFAs的生成;各种污泥产VFAs中,乙酸均具有明显优势,并会促进丙酸的累积;混合污泥较之于超磁分离和剩余污泥具有快速、高效的产酸优势,且随着剩余污泥接种量的增加,加快了水解酸化的速率并且加深了酸化的程度,但会延长其达到最大值的时间。污泥产酸发酵获得内碳源的同时,还存在着N元素的释放,且随着剩余污泥接种量的增加,这种伴随现象更明显。对比2种剩余污泥(W1、W2)发现,W1作为接种污泥时,并没有明显的P元素的释放;当W2作为接种污泥时,伴随着比较明显的P元素的释放。综合考虑剩余污泥对于超磁分离污泥水解酸化效果的影响发现,当剩余污泥接种量W1为12.2%,W2为13.6%时,既可以为系统提供更多的SCOD,又可以避免过高的氮负荷。     

污泥性质对污泥水解酸化效果的影响

采用3组构造一致的完全混合流态水解酸化反应器,分别以同等浓度的絮凝污泥、初沉污泥和剩余污泥作为底物污泥,在温度35℃,初始p H=10的反应条件下,研究污泥性质的差异对污泥水解酸化产物及产率的影响。实验结果表明:与初沉污泥、剩余污泥相比,絮凝污泥更易水解产酸发酵,至第9天水解产SCOD达到最大值2 713.2 mg/L,第7天酸化产VFAs达到峰值1 392.7 mg/L。3种污泥酸化产VFAs的主要组分均为乙酸和丙酸,但絮凝污泥VFAs组分中乙酸、丙酸这种优势更加明显,其所占比例分别高达48.9%和27.2%。此外,3种污泥水解酸化产碳源的同时均伴随着氮、磷元素的释放,整体而言,絮凝污泥产酸发酵中氮、磷元素的释放量及释放率均较低。     

Adsorption/desorption of copper by a sandy soil amended with various rates of manure, sewage sludge, and incinerated sewage sludge

Organic amendments are sometimes applied to agricultural soils to improve the physical, chemical, and microbiological properties of the soils. The organic fractions in these soil amendments also influence metal reaction, particularly the adsorption and desorption of metals, which, in turn, determine the bioavailability of the metals and hence their phytotoxicities. In this study, a Quincy fine sandy (mixed, mesic, Xeric Torripsamments) soil was treated with 0 to 160 g kg(-1) rates of either manure, sewage sludge (SS), or incinerated sewage sludge (ISS) and equilibrated in a greenhouse at near field capacity moisture content for 100 days. Following the incubation period, the soil was dried and adsorption of copper (Cu) was evaluated in a batch equilibration study at either 0, 100, 200, or 400 mg L(-1) Cu concentrations in a 0.01M CaCl2 solution. The desorption of adsorbed Cu was evaluated by three successive elutions in 0.01M CaCl2. Copper adsorption increased with an increase in manure rates. At the highest rate of manure addition (160 g kg(-1) soil), Cu adsorption was two-fold greater than that by the unamended soil at all rates of Cu additions. With increasing rates of Cu additions, the adsorption of Cu decreased from 99.4 to 77.6% of Cu applied to the 160 g kg(-1) manure amended soil. The desorption of Cu decreased with an increase in rate of manure amendment. Effects of sewage sludge amendments on Cu adsorption were somewhat similar to those as described for manure additions. Likewise, the desorption of Cu was the least at the high rate of SS addition (160 g kg(-1)), although at the lower rates there was not a clear indication of the rate effects. In contrast to the above two amendments, the ISS amendment had the least effect on Cu adsorption. At the highest rate of ISS amendment, the Cu adsorption was roughly 50% of that at the similar rate of either manure or SS amendments, across all Cu rates.     

4-硝基酚的污泥减量化作用及对污泥性质的影响

为了有效减少活性污泥法中剩余污泥的产生,采用解偶联剂4-硝基酚对活性污泥工艺中的剩余污泥进行减量化研究。研究了4-硝基酚对污泥的增长速率、基质去除率以及污泥性质的影响。结果表明:4-硝基酚对污泥的减量化作用明显,在对微生物解偶联的过程中并不影响微生物对基质的利用能力;对出水中的氨氮影响甚小,总氮、总磷浓度有轻微的升高。4-硝基酚能够刺激污泥中微生物的活性,比耗氧速率增加,促进能量解偶联,从而降低污泥产率。4-硝基酚使污泥中微生物的群落结构发生了轻微的变化,但对污泥的松散程度和絮凝沉降性能影响甚小。     

Phosphorus release from ash, dried sludge and sludge residue from supercritical water oxidation by acid or base

Leaching of ash and dried sewage sludge were investigated and compared with the leaching results of sludge residue from supercritical water oxidation (SCWO). This article focuses on how the composition of ash and sludge residues influences the extraction of phosphate and heavy metals and if different treatment temperatures of the sludge effect the leachability. Results showed that acid leaching gave a higher release of phosphate than alkaline leaching for all ash and sludge residue samples. Also, alkaline leaching dissolved phosphate with a lower metal contamination than acid leaching. Furthermore, it was found that iron had a low release at both alkaline and acid leaching from ash and from SCWO residue. The difference in composition of ash and sludge residue samples had no significant influence on release of phosphate at high concentrations of acid. Phosphate release from ash, dried sludge at 300 degrees C and SCWO residue showed similar results at 1M acid leaching. However, it seems to be easier to release phosphate from the SCWO residue than from the ash at low acid concentrations. SCWO residue showed higher release than the other ashes at 0.5M HCl. Results for alkaline leaching showed higher release from ash at 1M NaOH than from SCWO residue or from dried sludge at 300 degrees C. The leaching of phosphate from dried sludge seems to be temperature dependent, as the dried sludge treated at higher temperature showed less release of phosphate. It was found that the pre-treatment of the ash may be important for better release of phosphate.     

给水厂与污水厂污泥制陶粒技术研究

对天津凌庄自来水厂的给水厂污泥和天津东郊污水处理厂的污水厂污泥的成分进行了分析,在此基础上根据焙烧陶粒的原理,设计了以2种污泥为原料焙烧陶粒的工艺流程。通过实验,研究了其工艺过程中的影响因素并确定了工艺参数。性能检验结果表明,添加量为30％的混合污泥陶粒,在1 140℃焙烧5 min,可得到强度标号为40 MPa的高强陶粒。因此,以2种污泥为原料烧制陶粒的处置方法可行,并能带来一定的经济效益、社会效益和环境效益。得到的产品符合国标中高强陶粒的要求,可广泛应用于建筑行业中的承重结构。     

Improved computational model (AQUIFAS) for activated sludge, integrated fixed-film activated sludge, and moving-bed biofilm reactor systems, part III: analysis and verification

Research was undertaken to analyze and verify a model that can be applied to activated sludge, integrated fixed-film activated sludge (IFAS), and moving-bed biofilm reactor (MBBR) systems. The model embeds a biofilm model into a multicell activated sludge model. The advantage of such a model is that it eliminates the need to run separate computations for a plant being retrofitted from activated sludge to IFAS or MBBR. The biofilm flux rates for organics, nutrients, and biomass can be computed by two methods-a semi-empirical model of the biofilm that is relatively simpler, or a diffusional model of the biofilm that is computationally intensive. Biofilm support media can be incorporated to the anoxic and aerobic cells, but not the anaerobic cells. The model can be run for steady-state and dynamic simulations. The model was able to predict the changes in nitrification and denitrification at both pilot- and full-scale facilities. The semi-empirical and diffusional models of the biofilm were both used to evaluate the biofilm flux rates for media at different locations. The biofilm diffusional model was used to compute the biofilm thickness and growth, substrate concentrations, volatile suspended solids (VSS) concentration, and fraction of nitrifiers in each layer inside the biofilm. Following calibration, both models provided similar effluent results for reactor mixed liquor VSS and mixed liquor suspended solids and for the effluent organics, nitrogen forms, and phosphorus concentrations. While the semi-empirical model was quicker to run, the diffusional model provided additional information on biofilm thickness, quantity of growth in the biofilm, and substrate profiles inside the biofilm.     

A-O工艺污泥疏水比率与污泥活性的关系

通过A-O工艺对印染废水的降解处理,研究了不同污泥活性下微生物疏水比率和COD去除率的变化规律.结果表明,污泥活性指标ATP浓度与微生物疏水性之间存在一定关系,并对COD去除率产生一定的影响.缺氧污泥的活性指标ATP浓度在0.38～0.77 mg/L范围时,污泥微生物的疏水性最好且疏水比率最高值为84％,COD的去除率最高,为70.01％;好氧污泥的活性指标ATP浓度在0.86～2.17 mg/L范围时,污泥微生物的疏水性最好,疏水比率最高值为75％,COD的去除率最高为96.2％.     

污泥施入黄土后重金属Cu、Zn、Cd的淋滤迁移

污泥土地利用是目前国内外污泥处置的主要方式和鼓励方向,在中国西北黄土地区更有前景和意义.污泥富含有机质和营养元素可弥补黄土的贫瘠缺陷,改善黄土肥力、增加植物产量.污泥施入黄土后,灌溉水对污泥重金属的淋滤迁移和污染风险是值得研究的课题之一.研究旨在了解重金属Cu、Zn、Cd在黄土层中的淋滤迁移特征,为黄土地区污泥的土地利用及重金属污染控制提供实验依据.实验选择污泥中含量或毒性大的Cu、Zn、Cd 3种重金属作为研究对象,通过室内模拟土柱对表层堆肥污泥中2种源强的重金属进行1年灌溉用水量的淋滤对比实验,测定淋滤前后土柱中和渗出液的Cu、Zn、Cd总量、有机质及pH值,以期分析重金属在黄土中的淋滤、迁移特征.结果表明,淋滤作用可使堆肥污泥Cu、Zn、Cd发生少量迁移并富集于土柱中、上部,大部分或绝大部分重金属仍滞留于耕作层(0～20 cm);淋滤使堆肥污泥Cd与Cu向下迁移约30 cm,Zn向下迁移约20 cm;渗出液呈弱碱性,其中Cu、Zn、Cd 3种重金属的浓度较入渗水均有增多,但随渗出液从黄土柱中溶出的重金属量极少.实验表明,耕作层重金属源强对Cu、Zn、Cd在土柱剖面中的淋滤、迁移和滞留作用以及溶出量均有不同程度的影响,堆肥污泥土地利用可以明显改善黄土肥力,灌溉对耕作层污泥有机质的淋滤损失量较小.并得出,堆肥污泥在黄土地区的土地利用是可行的.     

厌氧、好氧、厌氧/好氧交替状态对活性污泥性质的影响

实验采用活性污泥处理模拟印染废水,研究厌氧、好氧、厌氧/好氧交替3种条件对活性污泥性质的影响。3种实验条件下,污泥沉降比(SV%)均基本保持在18%~25%之间,污泥容积指数(SVI)保持在62~66 m L/g之间。活性污泥混合液中胞外聚合物(EPS)除EPSB-蛋白质浓度持续升高外,其余形式均呈现积累、达到最大值后下降的趋势,其中厌氧/好氧交替条件下EPS浓度最高而好氧条件下最小。在整个实验期间,活性污泥的脱氢酶活性基本呈上升状态,在厌氧/好氧间歇曝气条件下脱氢酶活性最高、好氧条件次之、厌氧条件最低,最终3种条件下的脱氢酶活性分别为31.27、26.63和24.37 mg/(g·h)。活性污泥中ATP浓度基本呈现先增加后减小、再趋于稳定的变化趋势。实验结果表明,活性污泥表观产率系数顺序是好氧厌氧厌氧/好氧交替运行,厌氧/好氧交替实现了系统内污泥减量,微生物的产率系数和能量状态密切相关。脱氢酶活性对污染物的降解影响明显,而实验条件下微生物能量状态和污泥减量并不对污染物降解产生影响。     

低剂量臭氧的直接通加对活性污泥的活性、微生物种群及污泥减量化的影响

研究构建了2个容积为1.1 L的好氧活性污泥反应器（即1号和2号反应器）1,号反应器每天直接通加低剂量臭氧（投加量为0.01 g O3/g TSS）,不加臭氧的2号反应器作为对照平行运行,均采用每天换一次人工污水的充/排式操作。运行71 d的结果表明2,个反应器对人工污水COD的处理效果基本相同。反应器运行40 d后1,号反应器的污泥浓度比2号反应器的污泥浓度低1 400～1 700 mg/L并可稳定在8 200 mg/L,污泥减量化效果明显。低剂量臭氧的直接通加明显降低了胞内ATP浓度,并影响了微生物的抗氧化活性,2号反应器的平均超氧化物歧化酶和过氧化氢酶酶活比1号反应器分别高了24.3%和9.5%。PCR-DGGE对两反应器微生物种群的分析结果表明：Uncultured gammaproteobacteria bacteri-um、Nannocystis exedens和Uncultured actinobacterium为1号反应器的主要种群;而2号反应器的主要种群为Uncultured bacte-rium和Uncultured gammaproteobacteria bacterium。     

污泥的粘度与浓度、温度三者关系式的实验推导

通过融合污泥粘度与污泥浓度关系式、污泥粘度与温度关系式,得到一个新的关系式:污泥粘度与污泥浓度、温度的关系式,并通过实验数据拟合出各项参数,拟合效果比较理想.得出的污泥粘度与污泥浓度、温度的关系式对了解污泥的粘度变化非常有帮助,同时,该关系式也将为污泥处理、处置方案的制定提供参考依据.     

Improved computational model (AQUIFAS) for activated sludge, integrated fixed-film activated sludge, and moving-bed biofilm reactor systems, Part I: Semi-empirical model development

Research was undertaken to develop a model for activated sludge, integrated fixed-film activated sludge (IFAS), and moving-bed biofilm reactor (MBBR) systems. The model can operate with up to 12 cells (reactors) in series, with biofilm media incorporated to one or more cells, except the anaerobic cells. The process configuration can be any combination of anaerobic, anoxic, aerobic, post-anoxic with or without supplemental carbon, and reaeration; it can also include any combination of step feed and recycles, including recycles for mixed liquor, return activated sludge, nitrates, and membrane bioreactors. This paper presents the structure of the model. The model embeds a biofilm model into a multicell activated sludge model. The biofilm flux rates for organics, nutrients, and biomass can be computed by two methods--a semi-empirical model of the biofilm that is relatively simpler, or a diffusional model that is computationally intensive. The values of the kinetic parameters for the model were measured using pilot-scale activated sludge, IFAS, and MBBR systems. For the semiempirical version, a series of Monod equations were developed for chemical oxygen demand, ammonium-nitrogen, and oxidized-nitrogen fluxes to the biofilm. Within the equations, a second Monod expression is used to simulate the effect of changes in biofilm thickness and fraction nitrifiers in the biofilm. The biofilm flux model is then linked to the activated sludge model. The diffusional model and the verification of the models are presented in subsequent papers (Sen and Randall, 2008a, 2008b). The model can be used to quantify the amount of media and surface area required to achieve nitrification, identify the best locations for the media, and optimize the dissolved oxygen levels and nitrate recycle rates. Some of the advanced features include the ability to apply different media types and fill fractions in cells; quantify nitrification, denitrification, and biomass production in the biofilm and mixed liquor suspended solids; and perform dynamic simulations.     

污泥的粘度与浓度、温度三者关系式的实验推导

通过融合污泥粘度与污泥浓度关系式、污泥粘度与温度关系式，得到一个新的关系式：污泥粘度与污泥浓度、温度的关系式，并通过实验数据拟合出各项参数，拟合效果比较理想。得出的污泥粘度与污泥浓度、温度的关系式对了解污泥的粘度变化非常有帮助，同时，该关系式也将为污泥处理、处置方案的制定提供参考依据。     

干化床和芦苇床稳定污泥过程中的腐殖化特征

通过现场实验,考查污泥干化床和污泥干化芦苇床稳定污泥过程中的腐殖质变化特征,重点分析了污泥腐殖化率和污泥腐殖化指数的变化情况。系统运行了3年,包括前2年的污泥负荷期和第3年的自然稳定期,检测分析在第3年进行。实验结果表明,污泥腐殖质含量历月变化不大,基本在1．1％～2．1％范围;总体上污泥的腐殖化率具有上升趋势,同一时间样品芦苇床中污泥的腐殖化率略高于干化床;污泥腐殖化指数呈上升趋势,但芦苇床略低于传统于化床;4-11月,干化床中的污泥腐殖化指数从0．079升高到0．742,芦苇床从0．042升高到0．715。经过3Y的稳定化处理,污泥的腐殖化程度和腐熟度得到有效提高。     

干化床和芦苇床稳定污泥过程中的腐殖化特征简

通过现场实验,考查污泥干化床和污泥干化芦苇床稳定污泥过程中的腐殖质变化特征,重点分析了污泥腐殖化率和污泥腐殖化指数的变化情况。系统运行了3年,包括前2年的污泥负荷期和第3年的自然稳定期,检测分析在第3年进行。实验结果表明,污泥腐殖质含量历月变化不大,基本在1.1%~2.1%范围;总体上污泥的腐殖化率具有上升趋势,同一时间样品芦苇床中污泥的腐殖化率略高于干化床;污泥腐殖化指数呈上升趋势,但芦苇床略低于传统干化床;4—11月,干化床中的污泥腐殖化指数从0.079升高到0.742,芦苇床从0.042升高到0.715。经过3 y的稳定化处理,污泥的腐殖化程度和腐熟度得到有效提高。     

不同性状城市污水污泥在草坪生产中的应用研究

将城市污水污泥的生污泥和腐熟污泥施用于土壤,对该土壤上生长的高羊茅的生物量、土壤的理化特性等进行测定,并将污泥肥效与鸡粪进行了对照.结果表明,腐熟污泥对高羊茅生长的抑制作用主要表现在地上部分,对于其地下部分的生长存在着促进作用,而生污泥对高羊茅生长的促进作用主要表现在地上部分,施用量较大时会对其地下部分的生长产生轻微的...