通风速率对厨余垃圾堆肥NH3和H2S排放及腐熟度影响

为了减少厨余垃圾堆肥过程中NH3和H2S产生,该研究以通风速率0.16m3/h的纯厨余堆肥作为对照,以添加15%玉米秸秆(湿基)的厨余垃圾堆肥作为处理,并设置3个不同的通风速率(0.08、0.16和 0.24m3/h),研究通风速率对NH3和H2S排放及堆肥腐熟度的影响.结果表明:纯厨余垃圾堆肥总氮含量有所下降,添加秸秆后总氮量都有不同程度的提高,通风速率为0.16m3/h的处理效果最好,总氮含量可提高39.05%.与纯厨余堆肥相比,添加秸秆可减排14%~53% 的NH3 和67%~80%的H2S.随着通风速率的增加,NH3累计排放量呈对数增长趋势;H2S排放无明显规律,但过低和过高的通风速率,都会导致较高的H2S排放.堆肥结束后, 4个处理均可达到无害化标准和腐熟要求.综合NH3和H2S控制效果,厨余垃圾堆肥合适通风速率为0.16m3/h.     

添加剂对厨余垃圾堆肥中H_2S和NH_3排放的影响

以大类粗分后的厨余垃圾为研究对象,玉米秸秆作为调理剂,以不添加菌剂的处理作为对照(CK),以添加腐熟堆肥、鼠李糖脂和固体专用菌剂为3个处理,研究菌剂添加对厨余垃圾堆肥过程中H_2S和NH_3排放的影响。研究结果表明:菌剂添加促进了堆肥腐熟;添加腐熟堆肥更能有效地降低厨余垃圾堆肥过程中H_2S排放,而鼠李糖脂的添加更能有效控制NH_3的排放。从恶臭气体控制、堆肥腐熟并结合H_2S和NH_3的检知嗅阈,优选腐熟堆肥作为厨余垃圾堆肥过程中实现H_2S和NH_3同时减排的添加剂。     

Carbon conservation strategy for the management of pig slurry by composting: Initial study of the bulking agent influence

The intensification of the livestock production systems implies a potential environmental risk, associated with the great generation of animal wastes and slurries and their storage and management. Manure management is associated with considerable emissions of ammonia (NH₃) and greenhouse gases (GHG). However, the potential for GHG mitigation is highly dependent on the waste treatment strategy considered. This laboratory study aims to evaluate the influence of the type of bulking agent used on the potential reduction of the carbon dioxide (CO₂) emission, dealing with carbon (C) conservation when the solid fraction of pig (Sus scrofa domesticus) slurry is managed by composting. For this, a composting experiment in batch reactors was run with four mixtures elaborated using the solid fraction of pig slurry (SPS) and different materials (maize (Zea mays) stalks, barley (Hordeum vulgare L.) straw, cotton (Gossypium hirsutum) gin and garden prunings) as bulking agents. The potential C conservation in the mixtures was evaluated by determining the CO₂ emissions; the evolution of the mixtures, the thermal profile developed and the thermodynamics of the process were also studied. The mixtures elaborated with cotton gin and garden prunings showed the fastest temperature development, and also the highest CO₂ emissions. However, the use of maize stalks as bulking agent reduced CO₂ emissions due to its slow degradability: this could constitute a suitable strategy to promote C conservation during the management of pig slurry by composting.     

不同碳源农林废弃物与厨余垃圾协同堆肥对腐熟度和臭气排放的影响

针对北京市生活垃圾分类后厨余垃圾含水率高,在堆肥过程中存在酸化严重、升温慢、渗滤液产率高、产品品质差和臭气排放严重等问题,研究了玉米秸秆、园林剪枝和西瓜秧作为外加碳源对厨余垃圾堆肥腐熟度和臭气排放的影响,其中3种辅料添加比例均为15%,采用机械强制连续通风,通风速率为0.5 L/（kg DM·min）。堆肥周期为16 d,每4 d翻堆1次。结果表明:纯厨余垃圾单独堆肥酸化严重,未升温,添加辅料高温期（>55℃）持续时间超过10 d。碳源辅料影响有机质降解难易程度,西瓜秧添加在堆肥前期升温迅速,园林剪枝在堆肥中期温度较高,玉米秸秆在堆肥中后期温度较高。添加玉米秸秆、园林剪枝和西瓜秧可分别减少95%、39%和17%的渗滤液生成。秸秆和西瓜秧处理的种子发芽率指数（GI）第12天达到100%,比园林剪枝缩短4 d。与西瓜秧相比,添加秸秆减少了66.6%硫化氢（H₂S）和86.3%甲硫醚（Me₂S）排放,园林剪枝减少了82.3% Me₂S排放。影响厨余垃圾堆肥腐熟度和臭气排放的主要理化因素为pH和温度。     

采用生物沥浸法和化学法调理深度脱水污泥的堆肥效果:生产性试验

利用生物沥浸法和以添加石灰与三氯化铁为代表的化学法对污泥进行调理,继而采用隔膜厢式压滤机深度脱水是目前在我国应用较为广泛的工艺,但系统比较两种工艺所产生的污泥的堆肥效果的研究还很鲜见.为此,本试验分别对相同来源的污泥用两种方法进行调理后再用机械脱水,将获得的污泥饼进行工程化高温好氧堆肥,并以相同来源的常规脱水污泥(CS,指含水率80%左右的污泥)作为对照,探究其堆肥过程及产品性质的差异.结果表明,采用条垛式堆肥(条垛底宽2.8 m、高1.2 m、长10 m),生物沥浸污泥(BS)和石灰调理污泥(LS)堆肥所需辅料仅为CS的9.1%.尽管BS堆体中的NH+4-N含量始终最高,但其氨气挥发量仅为LS堆体的9.7%和CS堆体的31.4%.42 d时各堆体的CO2释放速率和水溶性C/N相比堆肥前均明显下降,说明堆体均已腐熟.LS堆肥产品的种子发芽指数(GI)仅为57.3%,而BS堆肥产品和CS堆肥产品的GI均为90%左右,显然后两者对种子的毒害已完全消除.此外,BS堆肥产品中的养分含量(N+P2O5+K2O)明显高于LS堆肥产品和CS堆肥产品,总养分分别高出28.5%和73.0%;其速效养分指标WSN亦分别高出40.6%和102%.综上所述,较之LS堆肥或CS堆肥,采用BS高温堆肥不仅可以显著减少辅料的添加量,且其堆肥过程中的氨气损失少,堆肥产品腐熟度好,养分含量高,因此,污泥生物沥浸处理-高温发酵技术是对推动堆肥后土地利用极有帮助的深度脱水工艺和资源化方法.     

Control of hydrogen sulfide emissions using autotrophic denitrification landfill biocovers: engineering applications

Hydrogen sulfide (H₂S) emitted from construction and demolition waste landfills has received increasing attention. Besides its unpleasant odor, longterm exposure to a very low concentration of H₂S can cause a public health issue. In the case of construction and demolition (C&D) waste landfills, where gas collection systems are not normally required, the generated H₂S is typically not controlled and the number of treatment processes to control H₂S emissions in situ is limited. An attractive alternative may be to use chemically or biologically active landfill covers. A few studies using various types of cover materials to attenuate H₂S emissions demonstrated that H₂S emissions can be effectively reduced. In this study, therefore, the costs and benefits of H₂S-control cover systems including compost, soil amended with lime, fine concrete, and autotrophic denitrification were evaluated. Based on a case-study landfill area of 0.04 km², the estimated H₂S emissions of 80900 kg over the 15-year period and costs of active cover system components (ammonium nitrate fertilizer for autotrophic denitrification cover, lime, fine concrete, and compost), ammonium nitrate fertilizer is the most cost effective, followed by hydrated lime, fine concrete, and yard waste compost. Fine concrete and yard waste compost covers are expensive measures to control H₂S emissions because of the large amount of materials needed to create a cover. Controlling H₂S emissions using fine concrete and compost is less expensive at landfills that provide on-site concrete recovery and composting facilities; however, ammonium nitrate fertilizer or hydrated lime would still be more cost effective applications.     

FeCl3-生化耦合技术调控未知诱因的污泥膨胀

丝状菌污泥膨胀是影响污水处理厂出水水质的常见问题.现有的调控技术存在见效慢、耗时长和通用性差等弊端.提高COD和DO浓度,投加FeCl_3和交替曝气是目前调控丝状菌膨胀的主要方法,这些方法的耦合技术调控未知诱因的污泥膨胀的效果鲜有报道.实验设计三段A/O反应器应急性运行SBR工艺,交替曝气时提高DO至(7. 45±0. 49) mg·L~(-1),COD初始浓度提高至(332. 73±106. 06) mg·L~(-1),沉淀工序中投加FeCl_3,使之在混合液中质量浓度为120 mg·L~(-1),形成的FeCl_3-生化耦合技术快速调控未知诱因的Candidatus Saccharibacteria为主要菌属的污泥膨胀,污泥体积指数14 d从274 m L·g~(-1)稳定至56 m L·g~(-1). FeCl_3-生化耦合技术有效抑制Candidatus Saccharibacteria的繁殖,其属水平相对丰度从97. 64%降低至32. 67%.调控过程出水COD和PO_4~(3-)-P浓度均稳定达到一级A标准,NH_4~+-N去除率从65. 33%增长至74. 65%.表明FeCl_3-生化耦合技术调控未知诱因的污泥膨胀具有良好效果.     

生活垃圾堆肥接种技术

以复合微生物菌剂、马粪、成熟堆肥、果园土、污泥为接种剂,采用在线监测堆肥设备,通过温度传感器、出口气体O₂-H₂S监测仪,研究堆肥过程中温度、耗氧速率、有机物分解速率、H₂S气体浓度变化.试验结果表明,添加接种剂堆肥与对照组比,堆料能达到理想的温度,且高温停留时间长,堆肥反应速率加快及堆肥腐熟时间缩短,并能很好地控制出口H₂S气体浓度.特别是以复合微生物菌剂或马粪作为接种剂,能明显加速堆料的腐熟进程,其腐熟时间分别比对照组提前210h和180h.     

菌渣-发酵床废弃垫料堆肥中温室气体排放及与微生物的关系

堆肥是处理农业废弃物最适宜的技术之一,但堆肥产生的有害和温室气体排放导致环境污染问题.本研究以生猪养殖发酵床废弃垫料及菌渣为原料,利用强制通风静态堆肥技术研究垫料和菌渣不同配比及添加EM菌剂对堆肥过程温室气体排放和微生物区系的影响.结果表明,不同堆肥处理温室气体排放通量以堆肥前20 d较大,堆肥中后期降低;微生物总量和种类在不同堆肥处理间没有发生显著性变化;CO_2和N_2O排放速率与细菌、真菌和甲烷氧化菌间具有显著的正相关关系.整个堆肥期间,以菌渣为主料并添加EM菌剂的堆肥处理温室气体减排效果最佳,相对其他3个处理温室气体减排0.7%~10.2%.由此认为,以菌渣为主料和通过添加EM菌剂的堆肥方式可以作为降低菌渣-发酵床废弃垫料堆肥过程温室气体排放的策略.     

纳米膜覆盖对畜禽粪便好氧堆肥进程及恶臭气体排放的影响

好氧堆肥是处理畜禽粪便的重要途径,但传统堆肥存在效率低和恶臭气体污染严重等问题.为了加快畜禽粪便堆肥进程,减少恶臭气体排放,探究了覆盖纳米膜对提升畜禽粪便堆肥效率的作用机制.设置槽式好氧堆肥发酵实验,通过堆肥过程中堆体物料的理化性质,酶活性和排放的恶臭气体来评估纳米膜对畜禽粪便堆肥效果的影响.结果表明,覆盖纳米膜能够加快升温,降低堆体物料的pH、有机质（OM）和氨氮（NH₄⁺-N）,提高电导率（EC）,增强脲酶、蛋白酶、纤维素酶、木聚糖酶和过氧化物酶的活性,并且NH₃、H₂S和TVOC的总累积排放量分别减少了58%、100%和61%.相关性分析显示,大多数酶活性易受温度（T）、EC、OM和C/N的影响.在一定范围内,NH₃的排放速率与T呈极显著正相关,与pH呈极显著负相关,TVOC的排放速率与多种理化性质显著相关.覆盖纳米膜能够加快堆体腐熟,减少恶臭气体的排放,是一种无害化、低排放的技术手段,能够有效解决畜禽粪便堆肥发酵带来的污染物排放难题,促进养殖业的绿色可持续发展,为推动生物质废弃物的资源化利用提供技术支撑.     

Effect of phosphogypsum and dicyandiamide as additives on NH3, N2O and CH4 emissions during composting

A laboratory scale experiment of composting in a forced aeration system using pig manure with cornstalks was carried out to investigate the effects of both phosphogypsum and dicyandiamide (DCD, C2H4N4) as additives on gaseous emissions and compost quality. Besides a control, there were three amended treatments with different amounts of additives. The results indicated that the phosphogypsum addition at the rate of 10% of mixture dry weight decreased NH₃ and CH₄ emissions significantly during composting. The addition of DCD at the rate of 0.2% of mixture dry weight together with 10% of phosphogypsum further reduced the N₂O emission by affecting the nitrification process. Reducing the phosphogypsum addition to 5% in the presence of 0.2% DCD moderately increased the NH₃ emissions but not N₂O emission. The additives increased the ammonium content and electrical conductivity significantly in the final compost. No adverse effect on organic matter degradation or the germination index of the compost was found in the amended treatments. It was recommended that phosphogypsum and DCD could be used in composting for the purpose of reducing NH₃, CH₄ and N₂O emissions. Optimal conditions and dose of DCD additive during composting should be determined with different materials and composting systems in further study.     

张红玉,张玉冬,顾军,李国学,袁京

为了降低厨余垃圾堆肥过程中H₂S和NH₃这2种恶臭物质的排放,通过向堆肥原料中添加玉米秸秆、木本泥炭和木屑3种调理剂,同时以厨余垃圾单独堆肥作为对照,研究调理剂添加对H₂S和NH₃排放的影响.结果表明,3种调理剂的添加均促进了有机物的降解和堆体的快速升温,与对照相比,使堆肥进入高温期的时间提前了3~4d;从电导率和发芽率指数来看,添加玉米秸秆处理的堆肥产品达到完全腐熟的要求,而添加木本泥炭和木屑处理的堆肥产品只是达到了无害化的要求;3种调理剂的添加均不同程度减少了厨余垃圾堆肥中H₂S和NH₃的排放,与对照相比,添加玉米秸秆、木本泥炭和木屑使厨余垃圾堆肥中H₂S的累积排放量分别降低了78.7%,50.3%和89.8%,NH₃的累积排放量分别降低了53.8%、87.7%和63.9%,可见木屑更能有效控制H₂S的排放,而木本泥炭更能有效控制NH₃的排放.     

厨余垃圾堆肥过程中恶臭物质分析

恶臭污染已成为生活垃圾堆肥过程中的主要环境问题.以大类粗分后的厨余垃圾作为研究对象,利用嗅觉测定法和GC-MS分析了不同阶段堆肥尾气的臭气浓度和恶臭化合物的种类及其排放浓度,并对不同堆肥阶段臭气浓度和恶臭物质排放浓度的相关性进行分析.结果表明,厨余垃圾堆肥过程中共检测到43种挥发性有机物,其中含硫臭气物质5种,烃类化合物22种,芳香烃类化合物11种,其它物质5种.通过相关性分析,发现硫化氢、甲硫醇、1,3-二甲基苯和邻二甲苯与臭气浓度极显著相关(P<0.01),二甲二硫和对二甲苯与臭气浓度显著相关(P<0.05),因此在厨余垃圾堆肥过程中要对这6种臭气物质进行重点监测和控制.     

Effect of C/N ratio, aeration rate and moisture content on ammonia and greenhouse gas emission during the composting

Gaseous emission (N₂O, CH₄ and NH₃) from composting can be an important source of anthropogenic greenhouse gas and air pollution. A laboratory scale orthogonal experiment was conducted to estimate the effects of C/N ratio, aeration rate and initial moisture content on gaseous emission during the composting of pig faeces from Chinese Ganqinfen system. The results showed that about 23.9% to 45.6% of total organic carbon (TOC) was lost in the form of CO₂ and 0.8% to 7.5% of TOC emitted as CH₄. Most of the nitrogen was lost in the form of NH₃, which account for 9.6% to 32.4% of initial nitrogen. N₂O was also an important way of nitrogen losses and 1.5% to 7.3% of initial total nitrogen was lost as it. Statistic analysis showed that the aeration rate is the most important factor which could affect the NH₃ (p = 0.0189), CH₄ (p = 0.0113) and N₂O (p = 0.0493) emissions significantly. Higher aeration rates reduce the CH₄ emission but increase the NH₃ and N₂O losses. C/N ratio could affect the NH₃ (p = 0.0442) and CH₄ (p = 0.0246) emissions significantly, but not the N₂O. Lower C/N ratio caused higher NH₃ and CH₄ emissions. The initial moisture content can not influence the gaseous emission significantly. Most treatments were matured after 37 days, except a trial with high moisture content and a low C/N ratio.     

污泥堆肥及其土地利用全过程的温室气体与氨气排放特征

目前我国污泥堆肥及其土地利用全过程的温室气体(N2O、CH4)与氨气(NH3)排放数据极其缺乏,难以满足温室气体减排和氮素保存的需求.本研究通过原位观测,首次开展污泥堆肥及其土地利用全过程温室气体和氨气排放特征的研究.结果表明,基于机械翻堆条垛(turning windrow,TW)工艺的全过程温室气体排放因子(eCO2/干污泥,196.21 kg·t-1)是基于强制通风+机械翻堆条垛(aerated turning pile,ATP)工艺的1.61倍.N2O主要来自土地利用过程,CH4主要来自堆肥过程.ATP工艺的温室气体排放当量(eCO2/干污泥,12.47 kg·t-1)远低于TW工艺(eCO2/干污泥,86.84 kg·t-1).TW工艺的氨气排放因子(NH3/干污泥,6.86 kg·t-1)略高于ATP工艺(NH3/干污泥,6.63 kg·t-1).NH3是全过程最主要的N素损失形式,其中TW和ATP堆肥工艺因NH3排放造成的氮素损失相当,均约占堆料TN损失量的30%.而N2O和CH4带来的N、C元素的损失可以忽略不计.这些结果表明ATP是一种环境友好的污泥堆肥工艺.     

Fe/Zn-TMS体系吸收去除催化裂化干气中H2S的性能

本研究采用FeCl3·6H2O、ZnCl2和环丁砜(TMS)复配形成的Fe/Zn-TMS体系脱除催化裂化(FCC)干气中的H2S,并用30%H2O2氧化再生Fe/Zn-TMS体系.同时,研究了各活性成分比例、吸收液体积浓度、吸收液pH值等对脱硫效率的影响,以及H2O2用量、吸收富液pH值对Fe2+氧化率的影响.结果表明,n(FeCl3·6H2O)∶n(ZnCl2)∶n(TMS)为0.45∶0.55∶1,吸收液pH为0.75,体积浓度(W)为50%的条件下能长时间高效脱硫,最高脱硫率达99.9%;在n(Fe2+)∶n(H2O2)为2∶1,吸收富液pH为0.65的条件下,Fe2+氧化率达96.7%.体系可循环使用3次,且能耗低、操作简单.     

生物滴滤塔净化多组分废气的研究

通过生物滴滤塔(biotrickling filter,BTF)净化硫化氢(H2S)、四氢呋喃(THF)、二氯甲烷(DCM)混合废气,研究其挂膜启动和稳定运行条件下的降解性能.结果表明,混合废气H2S、THF、DCM浓度分别为200、100和100 mg·m-3,空床停留时间(empty bed retention time,EBRT)50～20 s的条件下,H2S和THF的去除率分别能够维持在99%和60%左右,而DCM的去除率随EBRT的缩短从90%逐渐降低至37%左右.利用Michaelis-Menten动力学模型分析得到,理论降解效果为H2S>THF>DCM.     

Interactions of sulfuric acid with common atmospheric bases and organic acids: Thermodynamics and implications to new particle formation

Interactions of the three common atmospheric bases, dimethylamine ((CH₃)₂NH), methylamine (CH₃NH₂), ammonia (NH₃), all considered to be efficient stabilizers of binary clusters in the Earth's atmosphere, with H₂SO₄, the key atmospheric precursor, and 14 common atmospheric organic acids (COAs) (formic, acetic, oxalic, malonic, succinic, glutaric acid, adipic, benzoic, phenylacetic, pyruvic, maleic acid, malic, tartaric and pinonic acids) have been studied using the density functional theory (DFT) and composite high-accuracy G3MP2 method. The thermodynamic stability of mixed (COA)(H₂SO₄), (COA)(B1), (COA)(B2) and (COA)(B3) dimers and (COA)(H₂SO₄)(B1), (COA)(H₂SO₄)(B2) and (COA)(H₂SO₄)(B3) trimers, where B1, B2 and B3 refer to (CH₃)₂NH, CH₃NH₂ and NH₃, respectively, have been investigated and their impacts on the thermodynamic stability of clusters containing H₂SO₄ have been studied. Our investigation shows that interactions of H₂SO₄ with COA, (CH₃)₂NH, CH₃NH₂ and NH₃ lead to the formation of more stable mixed dimers and trimers than (H₂SO₄)₂ and (H₂SO₄)₂(base), respectively, and emphasize the importance of common organic species for early stages of atmospheric nucleation. We also show that although amines are generally confirmed to be more active than NH₃ as stabilizers of binary clusters, in some cases mixed trimers containing NH₃ are more stable thermodynamically than those containing CH₃NH₂. This study indicates an important role of COA, which coexist and interact with that H₂SO₄ and common atmospheric bases in the Earth atmosphere, in formation of stable pre-nucleation clusters and suggests that the impacts of COA on new particle formation (NPF) should be studied in further details.     

碳氮比对厨余垃圾堆肥腐熟度的影响

以厨余垃圾和玉米秸秆作为堆肥原料,采用好氧堆肥的方法,探讨了不同C/N比对堆肥腐熟度的影响。结果表明:从温度、pH、电导率(EC)、腐植酸光学特性(E4/E6)、固相C/N和发芽率指数(GI)来看,只有C/N为21(T4)的处理没有达到无害化和腐熟的要求,其余3个处理均达到腐熟;建议采用C/N为17的方案,厨余垃圾和秸秆按照湿基质量9∶1的比例进行堆肥;如果秸秆资源比较丰富,可采用C/N为19的方案,此时厨余垃圾和秸秆湿基比例为5.7∶1。     

Ambient air temperature Effects on the temperature of sewage sludge composting process

Using data obtained with a full-scale sewage sludge composting facility, this paper studied the effects of ambient air temperature on the composting temperature with varying volume ratios of sewage sludge and recycled compost to bulking agent. Two volume ratios were examined experimentally, 1 ： 0 ： 1 and 3 ： 1 ： 2. The results show that composting temperature was influenced by ambient air temperature and the influence was more significant when composting was in the temperature rising process： composting temperature changed 2.4-6.5℃ when ambient air temperature changed 13℃. On the other hand, the influence was not significant when composting was in the high-temperature and/or temperature falling process： composting temperature changed 0.75-1.3℃ when ambient air temperature changed 8-15℃. Hysteresis effect was observed in composting temperature＇s responses to ambient air temperature. When the ventilation capability of pile was excellent（at a volume ratio of 1：0：1）, the hysteresis time was short and ranging 1.1-1.2 h. On the contrary, when the proportion of added bulking agent was low, therefore less porosity in the substrate（at a volume ratio of 3：1：2）, the hysteresis time was IonQ and ranging 1.9-3.1 h.