超细CaCO3惰化剂对铝合金抛光伴生粉尘爆炸的防控效果*

为探究超细粉体惰化剂对铝合金抛光伴生粉尘爆炸特性的影响规律,利用标准化实验装置及自行搭建的实验平台,在对爆炸基本参数进行测试的基础上,分别研究超细CaCO3粉体对抛光废弃物粉尘点燃敏感度的钝化作用以及对爆炸火焰传播进程的惰化效果,并在相同条件下与同等粒径高纯度铝粉的实验效果进行比对。研究结果表明:铝合金抛光废弃物粉尘最小点火能量为280 mJ,而同等粒径高纯度铝粉最小点火能量为35 mJ;在铝合金抛光废弃物粉尘质量浓度为300 g/m3条件下,发生爆炸的火焰传播速度峰值为7.4 m/s,约为高纯度铝粉的57%,铝合金抛光废弃物粉尘的爆炸敏感度及猛烈度均低于高纯度铝粉;当超细CaCO3粉体的惰化比为30%时,可将铝合金抛光废弃物粉尘的最小点火能量钝化至约1 J,爆炸火焰失去持续传播能力,惰化作用效果充分显现。     

不同含水率煤尘在瓦斯爆炸诱导下爆炸传播规律研究

为了探究不同含水率煤尘在瓦斯爆炸诱导下的爆炸传播规律,利用自行搭建的直管瓦斯爆炸诱导煤尘二次爆炸实验系统,从冲击波压力和火焰传播速度2个方面,研究了不同含水率沉积煤尘在瓦斯爆炸诱导下的爆炸传播规律和原因。研究结果表明:当煤尘含水率小于40%时,管道内沉积煤尘会在瓦斯爆炸诱导下产生二次爆炸,同时沉积煤尘总量一定时,沉积煤尘二次爆炸产生的冲击波超压峰值和火焰传播速度随着煤尘含水率的增加先增大后减小;当沉积煤尘含水率为20% 时,煤尘二次爆炸产生的冲击波超压峰值、火焰传播速度峰值达到最大值,分别为1.657 MPa和468.060 m/s;当沉积煤尘含水率大于40%时,沉积煤尘无法产生二次爆炸,此时爆炸产生的威力小于单一瓦斯爆炸,火焰传播速度衰减较无煤尘的瓦斯爆炸更快,沉积煤尘起到抑制瓦斯爆炸传播的作用。研究结果可以为防治煤尘二次爆炸提供理论依据。     

Experimental study on the inhibition of methane/air explosion by modified attapulgite powder

In order to explore the influence of attapulgite powder on the methane explosion, a small-size semi-closed visual explosion experiment platform was built, and experiments were carried out. The effect of spraying powder on the whole process of methane explosion was studied when methane concentration was 7%, 8%, 9.5%, 11% and 12%, respectively. When the methane concentration was 11%, the maximum explosion overpressure dropped by modified spraying attapulgite powder was as high as 33.26%, and at the same time, the reduction rate of flame propagation velocity reached the maximum value of 36.65%. Furthermore, when the methane concentration was 9.5%, the experimental results when the powder spraying amount of modified attapulgite was 120 mg, 160 mg, 200 mg, 240 mg and 280 mg showed that when the powder spraying was 240 mg, the maximum explosive overpressure decreased by 33.14%, and the reduction rate of the peak flame propagation velocity reached the maximum value of 33.73%. Through the video images recorded by the high-speed camera, the flame structure, shape, color, etc. Were analyzed. The characterization analysis illustrated that the modified attapulgite powder has a small particle size, relatively large porosity and specific surface area. Also, it has a high weight loss rate. Combined with the results of characterization analysis, the explosion suppression mechanism of modified attapulgite powder was discussed. It was found that the modified attapulgite powder could effectively absorb the active free radicals generated in the explosion, and the modified new chemical components have a better thermal decomposition and endothermic effect and a better suppression of methane explosions.     

Experimental investigation on explosion flame propagation of wood dust in a semi-closed tube

In order to explore flame propagation characteristics during wood dust explosions in a semi-closed tube, a high-speed camera, a thermal infrared imaging device and a pressure sensor were used in the study. Poplar dusts with different particle size distributions (0–50, 50–96 and 96–180 μm) were respectively placed in a Hartmann tube to mimic dust cloud explosions, and flame propagation behaviors such as flame propagation velocity, flame temperature and explosion pressure were detected and analyzed. According to the changes of flame shapes, flame propagations in wood dust explosions were divided into three stages including ignition, vertical propagation and free diffusion. Flame propagations for the two smaller particles were dominated by homogeneous combustion, while flame propagation for the largest particles was controlled by heterogeneous combustion, which had been confirmed by individual Damköhler number. All flame propagation velocities for different groups of wood particles in dust explosions were increased at first and then decreased with the augmentation of mass concentration. Flame temperatures and explosion pressures were almost similarly changed. Dust explosions in 50–96 μm wood particles were more intense than in the other two particles, of which the most severe explosion appeared at a mass concentration of 750 g/m³. Meanwhile, flame propagation velocity, flame propagation temperature and explosion pressure reached to the maximum values of 10.45 m/s, 1373 °C and 0.41 MPa. In addition, sensitive concentrations corresponding to the three groups of particles from small to large were 500, 750 and 1000 g/m³, separately, indicating that sensitive concentration in dust explosions of wood particles was elevated with the increase of particle size. Taken together, the finding demonstrated that particle size and mass concentration of wood dusts affected the occurrence and severity of dust explosions, which could provide guidance and reference for the identification, assessment and industrial safety management of wood dust explosions.     

含NaCl超细水雾抑制甲烷爆炸实验研究

为研究含NaCl添加剂超细水雾对甲烷爆炸的影响,在自制的半封闭透明管道内,进行含NaCl添加剂超细水雾抑制甲烷爆炸试验,通过检测和分析在不同NaCl浓度情况下超细水雾的粒径和甲烷爆炸的平均火焰传播速度、爆炸超压以及平均升压速率,探究NaCl浓度对超细水雾粒径及其对抑制甲烷爆炸有效性的影响。研究结果表明:NaCl浓度对超细水雾粒径影响较小;对于体积分数为9.5%的甲烷,相比于纯甲烷爆炸,其平均火焰传播速率、最大爆炸超压以及平均升压速率分别下降了53.7%,63.4%和60.7%,相比于超细纯水雾,其平均火焰传播速率、最大爆炸超压以及平均升压速率分别下降了38.6%,58%,56%;在通雾量相同的条件下,浓度为2.5%NaCl超细水雾对体积分数为9.5%的甲烷爆炸抑制性能最佳;含NaCl添加剂超细水雾的物理化学共同作用可以有效抑爆甲烷。     

铝粉尘云燃烧火焰形态分析实验研究

为探索铝粉尘云燃烧火焰形态和灾变演化,基于改造的竖直开口实验管道,借助高速摄像仪和离子探针,研究火焰结构及变化,分析粒径因素对铝粉火焰前锋形态的影响。实验结果表明:铝粉燃烧能量的释放和空间束缚使燃烧转为爆燃,火焰前锋下方存在大片的燃烧反应区;铝粉粒径越小,颗粒氧化层破裂需要的热应力越小,越容易被点燃;随着铝粉粒径减小,热膨胀对火焰传播速度的影响明显增强。     

不同封闭情况下T型管道中瓦斯爆炸传播规律实验研究*

为研究不同封闭情况下T型管道中瓦斯爆炸的传播规律,在90°分岔管道中进行瓦斯爆炸实验,管道封闭情况为弱封闭（双PVC薄膜弱封闭）和强封闭（直管封闭或支管封闭）。实验结果表明:在瓦斯浓度为9.5%时,管道中各点处的瓦斯爆炸压力、火焰传播速度和火焰锋面振荡幅度最大,11%次之,8%最小。T型管道中,弱封闭端瓦斯爆炸压力不断减小;火焰传播速度先缓慢增大后减小,随后又快速增大。强封闭端,瓦斯爆炸压力增大;火焰传播速度先缓慢增大后略微下降,随后快速增大后又大幅度下降,甚至出现火焰锋面振荡现象。不同封闭管道中各测点的瓦斯最大爆炸压力和火焰传播速度大小比较可知,直管封闭管道＞双PVC薄膜弱封闭管道＞支管封闭管道。     

管道内瓦斯爆炸传播的试验研究

运用大型试验管道对瓦斯爆炸传播规律进行试验研究,并对瓦斯爆炸压力峰值、火焰速度和呈现时间进行分析,得出:在不出现爆轰的前提下,爆源点附近的压力峰值是全管道的最大值;爆炸压力峰值在沿管道的传播过程中从爆源点附近是先增大后减小,然后再逐渐增大且压力峰值最早呈现在出口附近;火焰传播速度随着传播距离的增大而逐渐增大且在爆炸初期增大速率更快;瓦斯浓度对爆炸压力峰值、火焰传播速度和呈现时间等都有重要影响。     

油气浓度对半开口管道爆炸超压特性与火焰行为的影响

为了研究油气浓度对半开口管道爆炸超压特性与火焰行为的影响,建立半开口透明管道实验台架,采用5种不同初始油气浓度,进行了一系列油气爆炸对比实验。研究结果表明:油气浓度对油气爆炸超压峰值以及升压速率有显著影响,二者都呈现随浓度的增加先增大后减小的变化规律;油气浓度对火焰锋面传播速度有着显著影响,在当量浓度比下,火焰锋面的传播速度最大,并且火焰锋面的传播距离也最远;管道内的火焰行为可以分为4个阶段;油气浓度对火焰传播形态以及传播速度有明显的影响,对火焰传播形态的影响主要体现在破坏变形以及管道外爆炸阶段,随着浓度增加,爆炸半径先增大后减小,火焰传播速度呈现相同的变化规律。     

混合金属粉尘爆炸最小点火能量影响因素研究*

为探究混合金属粉尘爆炸危险性及与单一粉体爆炸特性差异,确保车间安全生产,采用粉尘云点火能量测试系统对车间混合金属粉尘及铝粉最小点火能量在不同影响因素下的变化规律及2种粉尘火焰变化特征进行测试。研究结果表明:混合金属粉尘和铝粉最小点火能量在一定范围内（38~96 μm）与粒径呈正相关性,当混合金属粉尘粒径大于75 μm时,所需最小点火能量大于1 000 mJ,其爆炸敏感性迅速降低,此时铝粉仍有较强爆炸敏感性;2种粉尘最小点火能量随质量浓度增加呈先降低后升高的趋势,最小点火能分别为295,15 mJ,对应的敏感质量浓度为600,1 000 g/m3,混合金属粉尘在质量浓度为500~700 g/m3时具有较大爆炸危险性;同铝粉相比,混合金属粉尘点火能量更高、火焰燃烧时间更短、火焰高度更低、爆炸剧烈程度更弱。     

瓦斯煤尘爆炸特性及抑爆方法研究进展

为探究瓦斯煤尘爆炸特性及抑爆机理,本文通过一系列实验,研究瓦斯、煤尘爆炸的速度和温度等特征,提出利用图像相关系数法和辐射测温原理计算火焰传播速度及温度场变化,定量分析影响煤尘爆炸的因素以及产物变化规律,揭示煤尘爆炸的宏微观机制。结果表明:火焰分形维数可以用来反应瓦斯爆炸强度,即当分形维数更接近2.2937时爆炸反应最为强烈,其爆炸过程中自由基最终生成浓度与CH 4初始浓度呈倒U型关系;当量比对煤粉火焰爆炸压力及速度也有一定影响,在最佳当量比的2倍左右时可以达到最大爆炸压力和最大火焰传播速度。另外本文亦采用泡沫陶瓷对瓦斯的多次爆炸和连续爆炸进行抑爆,发现不同厚度和孔隙的泡沫陶瓷具有不同的抑制效果,孔隙较大的泡沫陶瓷对爆炸能量有较好的抑制作用。     

惰性气体抑制瓦斯爆燃火焰传播特性实验研究*

为研究惰性气体抑制瓦斯爆燃火焰传播特性,在自行搭建的中尺度爆炸激波管道上,采用数据采集系统、压电式传感器、火焰传感器、同步控制系统和激光纹影测试系统,通过对比4种不同喷射压力（0.5,1.5,2.5,3.5 MPa）的实验工况,选用N2做为惰性介质时抑制火焰的传播特性与喷射压力密切相关,火焰传播速度随着喷射压力增加呈现先增加后减弱的趋势。研究结果表明:少量N2在管道中扩散,加剧了未反应预混气体的扰动状态,造成火焰阵面褶皱的卷吸能力增强,进而加速化学反应进程,促进预混气体燃烧;喷射压力为1.5 MPa时,火焰阵面拉升、变形最强,火焰传播速度提高,最高可达到250 m/s;喷射压力为3.5 MPa时,火焰阵面出现明显三维凹陷结构,运动发生明显滞后现象,火焰传播速度大幅度降低至5.4 m/s,惰性气体抑制火焰传播效果明显。     

Scale effect of flame instability mechanisms on propagation velocity

Blast pressure is a major source of the damage caused by an accidental gas explosion. Its magnitude depends on the thermal expansion rate and hence on the flame propagation velocity. This paper discusses the influence of two flame instability mechanisms, i.e., diffusive-thermal and hydrodynamic instabilities, on flame propagation velocity with an emphasis on their scale effects as the flame continuously increases its size during an explosion. The Sivashinsky equation is numerically solved to simulate flame propagation behaviors. It is found that flame propagation velocity, V_f, is independent of flame size under the influence of diffusive-thermal instability, whereas V_f increases with flame size under the influence of hydrodynamic instability. The latter result is understood as a result of flame’s fractal structure. Fractal dimension is determined from the dependency of V_f on flame size, and the obtained fractal dimension is close to the known experimental value.     

含弱约束端面直角管道汽油蒸气爆炸及七氟丙烷抑爆研究*

为研究七氟丙烷对汽油蒸气爆炸抑制作用,搭建含弱约束端面直角管道汽油蒸气爆炸抑制实验系统,开展汽油蒸气爆炸实验研究,并与喷入七氟丙烷抑爆介质进行对比,分析爆炸超压值、火焰强度值和火焰传播速度等爆炸特性参数变化情况。结果表明:在1.3%,1.5%和1.7%汽油蒸气体积分数下,不加抑爆介质时,爆炸超压值、火焰强度和火焰传播速度随着汽油蒸气体积分数的升高而增大;将七氟丙烷作为抑爆介质喷入时,爆炸超压峰值分别下降91.06%,34.57%和50.92%,火焰强度降幅达到99.83%,火焰传播速度几乎降为0,火焰持续时间随之缩短几乎为0,七氟丙烷具有良好的阻隔防爆效果。     

煤尘挥发分及粒径对爆炸火焰长度的影响研究

为研究煤尘挥发分及粒径对爆炸火焰长度的影响及其变化规律,选取挥发分含量不同的四种典型烟煤煤样,分别制备成31.5、44、62.5、81.5、119、>150 μm六种粒径,利用煤尘爆炸性鉴定装置测试其爆炸火焰长度,并对其爆炸火焰长度变化规律进行分析。结果表明:随着挥发分含量的增加,不同粒径级别的煤尘爆炸火焰长度均呈增长趋势;在挥发分含量较低的区间,挥发分含量增加对爆炸火焰长度影响不大;在挥发分含量较高的区间,随着挥发分含量的增加其爆炸火焰长度也急剧增加,并且粒径越小增加的越快。对于同一实验煤样,随着粒径的增大,其爆炸火焰长度逐渐减小,粒径增大到150 μm以上时爆炸火焰几乎消失。爆炸火焰长度随粒径变化的变化率根据实验煤样的不同,呈现出两种变化规律,挥发分含量为18.99%和27.52%煤样的爆炸火焰变化率先增加再减小再增加,挥发分含量为32.20%和39.74%的煤样呈现先增加再减小的趋势,但四组实验煤样的爆炸火焰长度变化率都在44～62.5 μm的粒径变化量时达到最大值。     

Law of variation for low density polyethylene dust explosion with different inert gases

To reveal the effects of different inert gases on explosion characteristics during low density polyethylene (LDPE) dust explosion and optimize the explosion-proof process, eight N₂ (CO₂)/air mixed inerting conditions were experimentally studied. Typical inerting conditions with 12 L cylindrical explosive tank were used to study the characteristics on the flame propagation. The thermogravimetric analysis with related theories were used to further explain the mechanism and quantities in low density polyethylene (LDPE) dust explosion with different inert gases. The results showed that the reduction of O₂ concentration could effectively delay the progress of flame growth process and weaken the effect of dust combustion reaction. The flame growth process of condition (N₂/air (18% O₂)) was 2.05 times slower than that of the non-inert condition. The explosion strength was obviously reduced, and the characteristic parameters such as explosion pressure and flame propagation speed were also affected by the decrease of O₂ concentration. For LDPE powder, the smaller the median diameter, the greater the explosion intensity and the lower the limiting oxygen content (LOC). The LOC with CO₂ was usually higher than that with N₂ and the effect of CO₂ was significantly better than N₂ in inerting.     

障碍物对瓦斯煤尘爆炸火焰传播规律的影响

为了进一步探究瓦斯煤尘耦合爆炸火焰的传播规律,用自行搭建的半封闭垂直管道爆炸试验系统,研究障碍物对瓦斯煤尘耦合爆炸火焰传播规律的影响。研究结果表明:障碍物能显著提高瓦斯煤尘爆炸火焰的传播速度,其加速机理主要是障碍物诱导的湍流区会促进火焰的传播;火焰在传播过程中的加速度不是一直增加,随着火焰速度的增加会出现上下波动;煤尘的加入会使瓦斯爆炸产生的火焰传播速度显著增大及速度的最大值距离点火端较远;通过障碍物时爆炸产生的火焰形状发生较大的改变,出现拉伸和褶皱现象。     

Enhancement effects of methane/air explosion caused by water spraying in a sealed vessel

Experiments about the influence of ultrafine water mist on the methane/air explosion were carried out in a fully sealed visual vessel with methane concentrations of 8%, 9.5%, 11% and 12.5%. Water mists were generated by two nozzles and the droplets' Sauter Mean Diameters (SMD) were 28.2 μm and 43.3 μm respectively which were measured by Phase Doppler Particle Anemometer (PDPA). A high speed camera was used to record the flame propagation processes. The results show that the maximum explosion overpressure, pressure rising rate and flame propagation velocity of methane explosions in various concentrations increased significantly after spraying. Furthermore, the brightness of explosion flame got much higher after spraying. Besides, the mist with a larger diameter had a stronger turbulent effect and could lead to a more violent explosion reaction.     

彩虹粉引燃危险性实验研究

为了研究彩虹粉引燃危险性,应用固体燃烧速率试验仪初步甄别了彩虹粉传播燃烧能力,发现堆垛状彩虹粉固体火焰传播危险性较低;采用粉尘爆炸筛选装置,判定彩虹粉具有爆炸性;应用最小点火能测定装置测定彩虹粉粉尘云的最小点火能在24~60 mJ之间,最优爆炸浓度为1 167 g/m3;应用快速筛选量热仪测试,彩虹粉在227℃开始分解;固体自燃点测试仪显示彩虹粉在250℃附近会发生自燃。向彩虹粉内添加不同比例相近粒径分布的食用盐粉体进行抑爆研究,结果证明食用盐对彩虹粉具有明显的抑爆效果。     

多分支管道油气爆炸特性大涡模拟

为了研究油库常见的分支结构空间内发生油气爆炸时火焰和压力的传播特性,建立了基于WALE湍流模型及Zimont预混火焰模型的油气爆炸模型;模拟了6种不同分支管道结构空间内汽油/空气混合物爆炸发生发展过程;研究了分支管道数量及相对设置位置对爆炸超压的影响规律,以及分支管道对火焰传播形态和速度的影响规律;模拟结果与前人相关实验规律进行对比。研究结果表明:分支管道对汽油/空气混合气预混爆炸具有明显的强化激励作用;火焰锋面传播经过分支管道时,经历规则—褶皱—规则的变化过程;主管道内火焰传播速度,在分支管道对流场的突扩作用和湍流作用的共同影响下呈震荡变化的规律。