一株降解活性染料菌株的筛选和鉴定

活性染料广泛用于印染工业,其分子是由母体染料和活性基两个主要部分构成。母体染料有偶氮、蒽醌、酞菁结构类型的染料;活性基有三氯氰、四氯嘧啶、二氯均三嗪、乙烯砜氯乙酰等。这类染料属于亲水性染料,在废水中呈溶解状态,用凝聚沉淀的方法不易除去。据报道,某针织厂用碱式氯化铝沉淀处理活性染料印染废水,脱色率只有50％。用活性污泥法处理效果也不理想。 这类染料在水中可透过细菌细胞壁为细胞所吸收。又可通过细菌的生命活动——氧     

铁阳极电凝聚法处理活性红241染料废水能耗分析

对铁阳极电凝聚处理活性红241染料废水过程影响电能消耗的影响因素进行了考察.结果表明:电流密度、染料废水初始pH、染料废水温度、电解质浓度以及染料浓度的变化均能对能耗和脱色效率产生较大影响;电流效率受电流密度、染料废水初始pH、电解质浓度的影响较大,受染料废水温度和初始浓度影响不大;对于浓度为50 mg/L的活性红241染料废水,在电流强度为12.5 A/m2、电解温度为25 ℃、硫酸钠浓度为0.01 mol/L、pH为7.53、电解时间为60 min的实验条件下,染料废水脱色率达92.7%,电能消耗为1.53kWh/kg dye,电流效率为94.2%.     

粉煤灰对阴离子水溶性混合染料的吸附动力学

以燃煤废弃物粉煤灰作为吸附剂,对活性红23与活性蓝4、活性黄4、酸性黑1、酸性蓝193的混合染料溶液进行吸附性能研究.结果表明,在不同的混合体系中,活性红23的脱色率基本保持在60%~70%;体系中酸性染料的脱色率均超过90%;活性蓝4的脱色率高达85%;活性黄4的脱色率仅为50%.准二级吸附动力学能够更好地描述粉煤灰对水溶性混合染料的吸附过程.染料在溶液中的外扩散系数均为10-4cm·s-1数量级,染料在粉煤灰颗粒的内扩散系数为10-8cm2·s-1数量级.根据BN数,水溶性染料在粉煤灰上的竞争吸附是外扩散控制的吸附过程.     

Kinetic study on photocatalytic degradation of Acid Orange 52 in a baffled reactor using TiO2 nanoparticles

In this study, a baffled photocatalytic reactor was used for the treatment of colored wastewater containing the azo dye of Acid Orange 52(AO52). A study on the active species of the photocatalytic process using TiO_2 nanoparticles indicated that hydroxyl radical and superoxide have the greatest contribution to the dye degradation process respectively.Given that a level of biological oxygen demand/chemical oxygen demand(BOD5/COD) equal to 0.4 was achieved after about 5 hr from the beginning of the experiment, the reactor seems to be capable of purifying the wastewater containing AO52 dye after this time in order to discharge into a biological treatment system to continue the treatment process.The results of the liquid chromatography-mass spectrometry(LC-MS) test showed that during the first 4 hr of the experiment, with the breakdown of the azo bond, the contaminant was decomposed into the benzene annular compounds with less toxicity indicating a reduction in the toxicity of wastewater after removing the dye agent. The study on the kinetics of these reactions followed the pseudo-first-order kinetic model in all conditions and corresponded well to Langmuir–Hinshelwood model. According to the kinetic model for the simultaneous occurrence of possible pathways, the kinetic constant of production and degradation of intermediate products in optimal conditions was estimated to be between 0.0029 and 0.0391 min~(-1).     

Effects of glucose on the decolorization of Reactive Black 5 by yeast isolates

The cometabolic roles of glucose were investigated in decolorization of an azo dye, Reactive Black 5, by yeast isolates, Debaryomyces polymorphus and Candida tropicalis. The results indicated that the dye degradation by the two yeasts was highly associated with the yeast growth process and glucose presence in the medium. Color removal of 200 mg dye/L was increased from 76.4% to 92.7% within 60 h to 100% within 18-24 h with the increase of glucose from 5 to 10 g/L, although the activity of manganese dependent peroxidase （MnP） decreased by 2-8 times in this case. Hydrogen peroxide of 233.3 μg/L was detected in 6 h in D. polymorphus culture. The cometabolic functions of glucose and hydrogen peroxide could be also confirmed by the further color removals of 95.8% or 78,9% in the second cycle of decolorization tests in which 7 g glucose/L or 250 μg H202/L was superadded respectively together with 200 mg dye/L.     

Fenton法脱色降解活性黑5模拟废水

本研究对benton试剂脱色降解活性黑5模拟废水进行了初步的实验研究。在恒温条件下,分别以600nm和255nm波长下染料溶液吸光度为主要测定指标,对该种染料的脱色及其芳环结构的氧化降解进行了同步分析。考察了染料溶液初始pH值、Fe^2＋浓度、H2O2投加量、染料浓度等因素的影响。结果表明,在一定实验条件下,活性黑5的脱色效率可达到99％,染料芳环结构的降解可达30％,COD去除率达到57．5％。活性黑5的脱色降解过程分为两个阶段进行。在最佳pH范围内,H2O2投加量、Fe^2＋浓度、染料浓度对染料初始脱色速率影响不大,但对后续的芳环结构降解影响较大。     

蜜环菌漆酶对蒽醌类染料的脱色条件优化

利用蜜环菌发酵所得的漆酶,直接对印染工业中常见的两种蒽醌类染料活性艳蓝KN-R和活性艳蓝X-BR进行催化脱色实验,得出了最佳脱色条件.结果表明,活性艳蓝KN-R最适脱色温度为30℃,最适染料浓度为80 mg.L-1,最适酶量为0.25U.mL-1,最适pH值为5,在最优条件下活性艳蓝KN-R最高脱色率达90%以上.活性艳蓝X-BR的最适脱色温度为30℃,最适染料浓度为50 mg.L-1,最适酶量为0.5 U.mL-1,最适pH值为4,在最优条件下活性艳蓝X-BR最高脱色率达70%以上.本研究利用蜜环菌粗漆酶液直接对印染工业中常见蒽醌类染料进行脱色,结果表明蜜环菌粗漆酶液具有良好的脱色效果,蜜环菌漆酶在印染工业染料废水脱色方面具有潜在的应用价值.     

井式假单胞菌的培养及其脱色酶

本文研究了一株新菌种——井式假单胞杆菌(Pseudomonas wellantypicum)的培养方法.并对由该培养物提取的脱色酶的活性作了试验.脱色速度在12—24小时之间表现最大;脱色最适宜pH为7.0;脱色最适宜温度为45℃;70℃处理后失去脱色活性;半胱氨酸对脱色活性有一定的激活作用.该脱色酶制剂同时具有琼脂水解活性、蛋白质水解活性、淀粉水解活性、木聚糖水解活性和羧甲基纤维素水解活性.     

周期换向电凝聚法处理模拟染料废水的能耗分析

在前期研究获得周期换向电凝聚法处理活性艳蓝X-BR模拟染料废水过程的最佳参数基础上,依据法拉第第一定律,通过考察模拟染料废水过程中溶解的金属数量和精确测量的电子转移数量,确定废水处理过程中的能耗情况。通过研究可知,采用PCEM方式处理活性艳蓝X-BR模拟染料废水时,反应时间为20min时,铁极板消耗的质量为745.88g/kg(dye),铝极板消耗的质量为239.34g/kg(dye),所消耗的电能是1.558w·h,处理单位质量染料电能消耗为:7144.50w·h/kg(dye)。     

Decolorization of azo dyes with high salt concentration by salt-tolerant mixed cultures under anaerobic conditions

Because the lack of detailed study of biological decolorization in high salt dye wastewater, it is still difficult to evaluate the biological treatment on high-salinity dye wastewater. The experiments were carried out to study the salt-tolerant bacteria, which is useful in the treatment of high-salinity colored wastewater. Simulated wastewater containing 5-150 g/L salt （NaCI） and 50-2000 mg/L Reactive Brilliant Red K-2BP was treated with three salt-tolerant mixed cultures （CAS, TAS, DSAS）, which were under a gradually acclimated procedure. With the increase of concentrations of salt and dye, the decolorization became low. The abilities of decolorization of dyes wastewater by three mixed cultures （CAS, TAS, DSAS） were studied, CAS and DSAS mixed cultures showed more active for the treatment of high-salinity colored wastewater than TAS mixed cultures. The results suggested that there might be a simple process for the high salt wastewater treatment, which could be incorporated into conventional activated sludge plants.     

Kinetics of Solvent Blue and Reactive Yellow removal using microwave radiation in combination with nanoscale zero-valent iron

We investigated the efficiency and kinetics of the degradation of soluble dyes over the p H range 5.0–9.0 using a method employing microwave radiation in combination with nanoscale zero-valent iron(MW–n ZVI). The n ZVI particles(40–70 nm in diameter) were prepared by a liquid-phase chemical reduction method employing starch as a dispersant.Compared to the removal of Solvent Blue 36 and Reactive Yellow K-RN using only n ZVI,more rapid and efficient dye removal and total organic carbon removal were achieved using MW–n ZVI. The dye removal efficiency increased significantly with decreasing p H, but was negligibly affected by variation in the microwave power. The kinetics of dye removal by MW–n ZVI followed both an empirical equation and the pseudo first-order model, while the kinetics of dye removal using n ZVI could only be described by an empirical equation. It was also concluded that microwave heating of the dye solutions as well as acceleration of corrosion of n ZVI and consumption of Fe(II) were possible reasons behind the enhanced dye degradation.     

悬浮TiO_2-铂电极体系光电催化降解染料

文章采用悬浮TiO2-铂电极体系,以悬浮TiO2作为光催化剂,在两片铂电极间施加一定的电压,研究了染料Procion Red MX-5B在NaCl和Na2SO4电解质溶液中的光电催化降解。光电催化的效率与NaCl溶液的浓度和外加电压密切相关,在0.3mol/L的NaCl溶液中,外加电压8V的条件下,10min内染料的脱色率达到95%,而同时间内光催化脱色率只能达到35%。当外加电压超过5V时,电降解几乎与光电催化具有相同的染料脱色率,然而电降解并不能使染料降解的中间物矿化。光电催化能够在反应的最初一个小时去除溶液中80%的TOC,相同时间内光催化能够去除50%。光电催化与光催化都不能完全矿化所处理的染料,原因在于溶液中生成了非常稳定的降解产物。在Na2SO4溶液中,外加电压只能轻微的提高染料的脱色率,但却不能促进中间产物的分解。     

Evaluation of antioxidant enzymes activities and identification of intermediate products during phytoremediation of an anionic dye (C. I. Acid Blue 92) by pennywort (Hydrocotyle vulgaris)

The potential of pennywort(Hydrocotyle vulgaris)for phytoremediation of C.I.Acid Blue 92(AB92)was evaluated.The efects of various experimental parameters including pH,temperature,dye concentration and plant weight on dye removal efciency were investigated.The results showed that the optimal condition for dye removal were pH 3.5 and temperature 25°C.Moreover,the absolute dye removal enhanced with increase in the initial dye concentration and plant weight.Pennywort showed the same removal efciency in repeated experiments(four runs)as that obtained from the first run(a 6-day period).Therefore,the ability of the plant in consecutive removal of AB92 confirmed the biodegradation process.Accordingly,a number of produced intermediate compounds were identified.The efect of treatment on photosynthesis and antioxidant defense system including superoxide dismutase,peroxidase and catalase in plant roots and leaves were evaluated.The results revealed a reduction in photosynthetic pigments content under dye treatments.Antioxidant enzyme responses showed marked variations with respect to the plant organ and dye concentration in the liquid medium.Overall,the increase in antioxidant enzyme activity under AB92 stress in the roots was much higher than that in the leaves.Nevertheless,no significant increase in malondialdehyde content was detected in roots or leaves,implying that the high efciency of antioxidant system in the elimination of reactive oxygen species.Based on these results,pennywort was founded to be a capable species for phytoremediation of AB92-contaminated water,may be efective for phytoremediation dye-contaminated polluted aquatic ecosystems.     

废物处理与综合利用 轻工业废物处理与综合利用

X791.03200601051不同结构阳离子染料好氧生物脱色性能的研究/刘正芹(东华大学)…∥环境工程/冶金部建筑研究总院.-2005,23(3).-24~26环图X-26采用好氧驯化活性污泥对5种不同结构阳离子染料的生物脱色效果进行了动态观察,并在不同醋酸浓度下对脱色效果的影响进行了研究,结果表明,在好氧条件下,活性污泥对阳离子染料的脱色率较高,阳离子红GTL和阳离子艳蓝2RL(浓度为20mg/L)的脱色率分别达93%和98%;提高污泥浓度对染料脱色率的影响不明显;醋酸(200~1200mg/L)和染料(20~100mg/L)浓度的改变对阳离子红2GL、阳离子红GTL、阳离子艳蓝2RL、…     

臭氧氧化四种偶氮染料废水的效果研究

以酸性大红、中性枣红、阳离子红、活性黑5四种模拟印染废水开展O3氧化偶氮染料的效果研究.实验中发现O3对染料具有非常好的脱色效果,30 min后除中性枣红外其他三种染料脱色率接近100％,但是单独O3的TOC去除率不高.光谱扫描表明,处理后染料的特征吸收峰很快消失,而紫外光区的吸收峰变化很小,推测O3氧化以直接氧化为主,打开了染料分子的发色基团,但并未将染料分子彻底氧化.还应加强O3氧化能力、彻底矿化去除污染物的研究.     

Biphasic reduction model for predicting the impacts of dye-bath constituents on the reduction of tris-azo dye Direct Green-1 by zero valent iron(Fe~0)

Influence of common dye-bath additives, namely sodium chloride, ammonium sulphate,urea, acetic acid and citric acid, on the reductive decolouration of Direct Green 1 dye in the presence of Fe~0 was investigated. Organic acids improved dye reduction by augmenting Fe~0 corrosion, with acetic acid performing better than citric acid. Na Cl enhanced the reduction rate by its ‘salting out' effect on the bulk solution and by Cl~-anion-mediated pitting corrosion of iron surface.(NH_4)_2SO_4induced ‘salting out' effect accompanied by enhanced iron corrosion by SO_4~(2-)anion and buffering effect of NH+4 improved the reduction rates.However, at 2 g/L(NH_4)_2SO_4concentration, complexating of SO_4~(2-)with iron oxides decreased Fe~0 reactivity. Urea severely compromised the reduction reaction, onus to its chaotropic and‘salting in' effect in solution, and due to it masking the Fe~0 surface. Decolouration obeyed biphasic reduction kinetics(R~2 0.993 in all the cases) exhibiting an initial rapid phase,when more than 95% dye reduction was observed, preceding a tedious phase. Maximum rapid phase reduction rate of 0.955/min was observed at p H 2 in the co-presence of all dye-bath constituents. The developed biphasic model reckoned the influence of each dye-bath additive on decolouration and simulated well with the experimental data obtained at p H 2.     

Recent advances based on the synergetic effect of adsorption for removal of dyes from waste water using photocatalytic process

The problem of textile dye pollution has been addressed by various methods,mainly physical,chemical,biological,and acoustical.These methods mainly separate and/or remove the dye present in water.Recently,advanced oxidation processes(AOP)have been focused for removal of dye from waste water due to their advantages such as ecofriendly,economic and capable to degrade many dyes or organic pollutant present in water.Photocatalysis is one of the advance oxidation processes,mainly carried out under irradiation of light and suitable photocatalytic materials.The photocatalytic activity of the photocatalytic materials mainly depends on the band gap,surface area,and generation of electron–hole pair for degradation dyes present in water.It has been observed that the surface area plays a major role in photocatalytic degradation of dyes,by providing higher surface area,which leads to the higher adsorption of dye molecule on the surface of photocatalyst and enhances the photocatalytic activity.This present review discusses the synergic effect of adsorption of dyes on the photocatalytic efficiency of various nanostructured high surface area photocatalysts.In addition,it also provides the properties of the water polluting dyes,their mechanism and various photocatalytic materials;and their morphology used for the dye degradation under irradiation of light along with the future prospects of highly adsorptive photocatalytic material and their application in photocatalytic removal of dye from waste water.     

废物处理与综合利用 轻工业废物处理与综合利用

X791.03200700569偶氮染料的光还原脱色及其染色废水的回用研究/董永春…(天津工业大学材料科学与化学工程学院)∥工业水处理/天津化工研究设计院.-2006,26(8).-52~54环图TQ-80用还原脱色剂对水溶性偶氮染料进行光还原脱色降解,重点考察了还原脱色剂、辐射光以及染料浓度等对还原脱色反应的影响,并将脱色后的染色废水回用于棉织物染色中.结果表明,以适当比例的引发剂和促进剂组成的还原脱色剂具有较强的脱色降解能力,辐射光对染料的还原脱色反应具有明显的促进作用,染料浓度的提高不利于染料的脱色降解反应.脱色废水可以回用于棉织物的活…     

优势菌处理印染废水的工艺及脱色机理研究

采用不完全厌氧－好氧工艺处理印染废水，工程运行前在水解池中投入了主要用于脱色的优势菌群，经３年多的运行，系统的脱色率均稳定在９０％以上。从池中取菌进行分离鉴定，并进行各单株菌脱色能力实验，对其中具有最佳脱色能力的菌株进行偶氮染料活性黑ＫＮＢ的脱色产物的化学分析，从而探讨水解池中染料的脱色机理。结果发现：分离到的１０株菌对试验染料有较好脱色效果，高效液相色谱检测发现产物只有苯胺类物质的存在。该菌的脱     

Photocatalytic degradation of L-acid by TiO2 supported on the activated carbon

Introduction Aromatic sulfonic acid, which is produced in large amounts in chemical industry since the end of 19th century, has been widely applied in many industrial processes, including the various steps of procedure (Alonso and Barcelo, 2000). Naphthalene- sulfonic acids are of importance as dye intermediates and commonly used in the textile auxiliary industry employing many azo dyes and pigments. Among them, 1-naphthol-5-sulphonic acid (L-acid) is widely used in the printing as the raw ma…