城市生活垃圾堆肥试验装置的设计

堆肥装置是研究堆肥过程中各种参数变化和获取优化参数的必不可少的工具.本文从堆肥维持其温度的先决条件出发,并在大量调研的基础上确定了实验室好氧发酵装置的合理尺寸、渗沥水收集和回喷系统、布气系统等.该装置的尺寸为长1 m,宽0.5 m,高0.6 m,堆料的高度为0.48 m;根据垃圾样品的理化性质,确定了渗滤液回喷的时间为116 s、鼓风机的风量为0.055 m3/min,风压为300 Pa,并且对其引入自动控制设备,使通风工作5 min、休息35 min.最后利用生活垃圾堆肥试验验证该装置满足堆肥的一次发酵要求.该装置采用自动控制系统,布水、布气均匀,保温效果好,发酵过程温度测定方便快捷,而且还有功率消耗小、臭气集中易于处理的优点.     

城市生活垃圾堆肥试验装置的设计

堆肥装置是研究堆肥过程中各种参数变化和获取优化参数的必不可少的工具。本文从堆肥维持其温度的先决条件出发，并在大量调研的基础上确定了实验室好氧发酵装置的合理尺寸、渗沥水收集和回喷系统、布气系统等。该装置的尺寸为长1m，宽0．5m，高0．6m，堆料的高度为0．48m；根据垃圾样品的理化性质，确定了渗滤液回喷的时间为116S、鼓风机的风量为0．055m^3／min，风压为300Pa，并且对其引入自动控制设备，使通风工作5min、休息35min。最后利用生活垃圾堆肥试验验证该装置满足堆肥的一次发酵要求。该装置采用自动控制系统，布水、布气均匀，保温效果好，发酵过程温度测定方便快捷，而且还有功率消耗小、臭气集中易于处理的优点。     

Fate of antimony in municipal solid waste incineration

The average antimony concentration in municipal solid waste is estimated to be about 10-60 ppm. Thermodynamical models predict a volatile behavior for antimony compounds, yet literature mass balances show that about 50% of the antimony input remains in the grate ashes. This fact can be explained by the formation of thermally stable antimonates in the fuel bed due to interactions with alkali or earth-alkali metals. Thermogravimetric experiments revealed an increased thermal stability for antimony oxide in presence of oxygen and calcium oxide. Spiking experiments on the test incinerator TAMARA showed that chlorination processes have a strong effect on antimony volatilization whereas high fuel-bed temperatures and addition of antimony oxide only have a moderate effect. In the grate ashes, antimony shows a pH-depending leaching property, which is typical for anionic species. This fact supports the thesis that antimony is present in the grate ashes in an anionic speciation.     

生活垃圾堆肥工艺条件及其反应动力学研究

为了改善堆肥微环境 ,提高生活垃圾堆肥速率 ,研究堆肥工艺条件及其反应动力学是非常必要的。通过控制堆肥工艺条件 ,如初始温度、含水率、C/N比及堆料颗粒大小 ,研究生活垃圾堆肥过程中生物、化学及物理因素的变化。试验结果表明 ,生活垃圾堆肥反应符合一级反应动力学 ;合理控制堆肥初始反应条件 ,能明显提高堆肥效率。     

温度对生活垃圾堆肥效率的影响

温度是堆料中微生物生命活动的重要标志,它直接影响堆肥反应速率,是堆肥能否顺利进行的主要因素。本试验利用可自动加热堆肥反应器,在一定条件下研究不同温度对生活垃圾堆肥效率的影响。通过监测出口气体中O2和CO2气体的浓度,计算堆料中有机物降解速率。试验表明,当反应条件为生活垃圾∶成熟堆肥=80∶20,有机物约为60%,初始含水率为55%,初始C/N比为25,堆肥温度控制在55℃左右时,能加速高温菌繁殖,从而加快垃圾分解速度,大大缩短堆肥腐熟时间。     

生活垃圾堆肥分阶段反应动力学研究

根据堆肥不同阶段特点 ,通过接种和不接种堆肥实验 ,分别研究升温 -高温阶段和高温 -降温阶段动力学。从得到的动力学方程分析可知 :接种复合微生物菌剂 ,在升温 -高温阶段最大反应速率比对照组提高约 13 8.7 ;在高温 -降温阶段最大反应速率比对照组大 4.73 g/( h· kg) ,而半速系数 Km比对照组下降了 10 3 g/kg。说明接种复合微生物菌剂不仅使反应速率增大 ,而且使半速系数减小 ,使底物与酶反应更完全 ,有机物分解更迅速、更彻底     

城市固体有机废物堆肥实验装置设计

根据城市固体有机废物的特点和性质 ,设计了一种堆肥的实验装置 ,该设计包括空间结构设计、通风系统设计和搅拌系统设计。空间结构设计的特点是小型的、用于实验室研究的、仓式动态好氧结构 ;通风系统的设计则是以供氧、散热和去除水分所需通风量为基础 ;搅拌系统设计包括搅拌器的结构设计和所需动力设计     

温度对生活垃圾堆肥效率的影响

温度是堆料中微生物生命活动的重要标志，它直接影响堆肥反应速率，是堆肥能否顺利进行的主要因素。本试验利用可自动加热堆肥反应器，在一定条件下研究不同温度对生活垃圾堆肥效率的影响。通过监测出口气体中O2和CO2气体的浓度，计算堆料中有机物降解速率。试验表明，当反应条件为生活垃圾：成熟堆肥=80：20，有机物约为60％，初始含水率为55％，初始C／N比为25，堆肥温度控制在55℃左右时，能加速高温菌繁殖，从而加快垃圾分解速度，大大缩短堆肥腐熟时间。     

翻转式堆肥反应装置设计研究

以复合微生物菌剂降解垃圾的适宜条件为出发点 ,根据堆肥小试实验结果 ,确定进料垃圾特性、合理的工艺参数及一次发酵完成时间 ,结合制备装置材料的保温性、堆肥物料平衡、热量平衡 ,合理确定反应装置容积、供气方式、操作运行条件 ,开发了翻转式堆肥反应装置。该装置具有堆料搅拌均匀、进出料简单、供气均衡等特点     

Spectroscopic characterization of water extractable organic matter during composting of municipal solid waste

This paper aims to characterize the evolution of water extractable organic matter (WEOM) during the composting of municipal solid waste (MSW), and investigate the correlation between maturity and WEOM characteristics. WEOM was extracted at different stages of MSW composting (0, 7, 14, 21, and 51 d) and characterized by FTIR, UV-Vis, and fluorescence spectroscopy. The results obtained show that the composting process decreased aliphatics, alcohols, polysaccharides, as well as protein-like materials, and increased aromatic polycondensation, humification, oxygen-containing functional groups, molecular weight, and humic-like materials. The maturity of MSW during composting was characterized by the presence of the peak with an excitation/emission wavelength pair of 289/421 nm in excitation-emission matrix spectra.     

Effect of inoculating microbes in municipal solid waste composting on characteristics of humic acid

Municipal solid waste (MSW) compost contains a significant amount of humic substances. In this study, the compost consisted of residual MSW with the metal, plastic and glass removed. In order to enhance degradation processes and the degree of composting humification, complex microorganisms (Bacillus casei, Lactobacillus buchneri and Candida rugopelliculosa) and ligno-cellulolytic (Trichoderma and White-rot fungi) microorganisms were respectively inoculated in the composting process. During the MSW composting, humic acid (HA) was extracted and purified. Elements (C, N, H, O) and spectroscopic characteristics of the HA were determined using elementary analyzer, UV, Fourier transform infrared (FTIR), and fluorescence spectroscopy. The elements analysis, UV, FTIR and fluorescence spectra all led to the same conclusion, that is inoculations with microbes led to a greater degree of aromatization of HA than in the control process (CK) with no inoculation microbes. This indicated that inoculation with microbes in composting would improve the degree humification and maturation processes, in the following order: lingo-cellulolytic>complex microorganisms>CK. And mixed inoculation of MSW with complex microorganisms and lingo-cellulolytic during composting gave a greater degree of HA aromatization than inoculation with complex microorganisms or lingo-cellulolytic alone. But comparing with the HA of soil, the HA of MSW compost revealed a lower degree of aromatization.     

广州市生活垃圾高温有氧静态堆肥的生命周期分析

运用生命周期分析(LCA)方法,对广州市生活垃圾高温有氧静态堆肥系统进行分析,计算出全生命周期的资源消耗和环境影响潜值,同时与垃圾焚烧典型工艺的LCA数据进行对比。结果表明,堆肥处理的环境影响负荷为0.023PET90,资源消耗系数为9.238mPET90。环境影响类型中光化学臭氧合成造成的影响最大,占环境总影响的43.8%。与焚烧处理方式相比,高温有氧静态堆肥的环境总影响较小,环境影响负荷相比于焚烧减少20.3%,在降低酸化的影响方面有较为显著的作用。     

重力翻板式有机生活垃圾快速堆肥中试研究

采用自行研制的一套新型快速堆肥装置——重力翻板式垃圾快速堆肥装置,对易腐有机物含量80%左右,含水率73%左右的生活垃圾进行快速发酵中试研究。生活垃圾在4 d的间歇动态初级发酵期内,能保持70℃以上温度3 d以上,无害化、减量化及节能减耗效果好。     

Residues of organochlorine pesticides and PCBs in some Brazilian municipal solid waste compost

Persistent organic pollutants (POPs), organochlorine pesticides and polychlorinated biphenyls (PCBs), listed as per the Stockholm Convention (alpha -HCH, beta -HCH, gamma -HCH, p,p'-DDT, o,p'-DDT, p,p'-DDD, p,p'-DDE, aldrin, endrin, dieldrin, PCBs 28, 52, 118, 138, 153, and 180), were analyzed in municipal solid waste (MSW) compost samples from three different Brazilian composting plants located in three S?o Paulo State cities: Araras, Araraquara and S?o Paulo (Vila Leopoldinha). Quantitative and qualitative analyses were carried out using gas chromatography electron capture detection (GC-ECD) and gas chromatography mass spectrometry (GC-MS) (Ion Trap, electron impact ionization), respectively. The samples were analyzed in triplicate and the target POPs were not detected by GC-ECD. Twelve pollutants were identified in two samples when qualitative analysis (GC-MS) was used (beta -HCH, gamma -HCH, p,p'-DDT, o,p'-DDT, p,p'-DDD, and p,p'-DDE, PCBs 28, 118, 138, 153 and 180). The composting process has advantages such as urban solid waste reduction and landfill life-span increase, however the MSW compost quality, which can be utilized for agricultural purposes, should be evaluated and be controlled. This kind of study is the first step in making available information to answer questions regarding MSW compost for sustainable agricultural use, such as the pollutants accumulation in soil and in groundwater, and plants uptake.     

Residues of organochlorine pesticides and PCBs in some Brazilian municipal solid waste compost

Persistent organic pollutants (POPs), organochlorine pesticides and polychlorinated biphenyls (PCBs), listed as per the Stockholm Convention (α -HCH, β -HCH, γ -HCH, p,p′-DDT, o,p′-DDT, p,p′-DDD, p,p′-DDE, aldrin, endrin, dieldrin, PCBs 28, 52, 118, 138, 153, and 180), were analyzed in municipal solid waste (MSW) compost samples from three different Brazilian composting plants located in three São Paulo State cities: Araras, Araraquara and São Paulo (Vila Leopoldinha). Quantitative and qualitative analyses were carried out using gas chromatography electron capture detection (GC-ECD) and gas chromatography mass spectrometry (GC-MS) (Ion Trap, electron impact ionization), respectively. The samples were analyzed in triplicate and the target POPs were not detected by GC-ECD. Twelve pollutants were identified in two samples when qualitative analysis (GC-MS) was used (β -HCH, γ -HCH, p,p′-DDT, o,p′-DDT, p,p′-DDD, and p,p′-DDE, PCBs 28, 118, 138, 153 and 180). The composting process has advantages such as urban solid waste reduction and landfill life-span increase, however the MSW compost quality, which can be utilized for agricultural purposes, should be evaluated and be controlled. This kind of study is the first step in making available information to answer questions regarding MSW compost for sustainable agricultural use, such as the pollutants accumulation in soil and in groundwater, and plants uptake.     

城市生活垃圾堆肥过程控制技术的现状和发展

介绍了堆肥处理过程的特点 ,叙述了国内外城市生活垃圾过程控制技术的发展现状 ,指出了该技术今后的主要发展方向及发展趋势 ,并讨论了垃圾堆肥过程控制面临的理论与实际问题。     

城市生活垃圾与园林废弃物的共热解特性

为实现城市生活垃圾减量化、无害化和资源化,采用热重分析天平和实验室固定床热解反应器进行城市生活垃圾（MSW）与园林废弃物共热解实验,研究了不同热解终温、松树枝和柳树枝添加比例对热解产物产率影响,并利用气质联用色谱分析仪（GC-MS）对热解油进行表征分析。实验结果表明：MSW、松树枝和柳树枝的热解过程均可以分为3个阶段,主要包括脱水、热解、炭化;MSW、松树枝和柳树枝单独热解时最大失重速率分别出现在321.48、358.23和377.83℃;MSW与松树枝共热解DTG曲线在热解反应第2阶段有2个析出峰,分别在342.32℃和471.48℃,比MSW单独热解时,失重率增加了7.29%。当城市生活垃圾与松树枝、柳树枝的添加量分别为3：1时,热解液体产物产率明显升高,热解油中醇类、羧酸类、醛类等含氧有机物的含量降低,热值增加,热解油中氧含量降低,且松树枝对共热解焦油的脱氧效果更为显著,热解油品质得到提升。     

生活垃圾堆肥浸提液组成及其演化规律

堆肥浸提液与渗滤液组成相似,研究生活垃圾堆肥浸提液组成与演化特征可以为堆肥过程污染控制和堆肥质量改善提供科学依据。通过基本理化指标和三维荧光光谱分析,研究了生活垃圾堆肥浸提液的组成和转化特性。结果显示,在堆肥一次和二次发酵过程中,浸提液pH由5.43上升至9.24,无机阴离子无显著变化,电导率(EC)稳定在7.50 mS/cm上下波动,ORP为正值,总氮从611.08 mg/L下降至177.43 mg/L,NH4+-N和NO3--N浓度变化不明显,NO2--N从未检出到后期达10.28 mg/L,有机氮从246.64 mg/L下降至172.52 mg/L。溶解性有有机物含量(DOC)从7 419.00 mg/L降至5 569.00 mg/L,其中的有机物发生降解和转化,生成胡敏酸和富里酸等物质。浸提液中重金属Fe、Cd、Cu、Zn、Cr、Mn、Ni和 As浓度升高。通过研究发现,在堆肥中添加木屑等填料可以降低浸提液中NH4+-N的浓度,具有除臭作用,同时对pH值、EC和ORP均有调节作用,能提高堆肥的土地可利用性。     

高效堆肥菌种的筛选及在城市污泥堆肥上的应用

分离筛选出了4株猪粪堆肥菌种,初步的分类鉴定表明它们均属于芽孢杆菌属.利用这些菌种制成混合菌剂,并进行城市污泥堆肥对比试验,结果显示,接菌处理在各项堆肥指标上明显优于未接菌的空白处理,自制菌与酵素菌在堆肥过程中具有非常相似的发酵能力,均能加快堆肥的升温速度,提高堆肥的最高温度,加快物料含水率的下降.说明自制菌不但可以应用于猪粪的堆肥发酵,在城市污泥高温堆肥方面也有很好的应用潜力.     

下吸式气化炉处理城市生活垃圾

下吸式气化炉具有原料适应性好，燃气中焦油含量少的特点。使用下吸式气化炉对广州城市生活垃圾进行了空气气化实验，并对燃气成分、焦油含量和灰渣重金属含量进行了分析。分析结果表明：燃气气体热值可达4600kJ／m^3，燃气焦油含量为2．0g／m^3。另外，对灰渣中的金属成分也进行了分析。试验结果表明：下吸式气化炉是处理复杂城市生活垃圾的一种有效手段。