A Sorptive Slurry Bioscrubber for the Control of Acetone

ABSTRACT

A sorptive slurry bioscrubber adds powdered activated carbon (PAC) to a conventional suspended-growth bioscrubber. The activated carbon increases pollutant removal from the gas phase due to adsorption on carbon. The carbon is bioregenerated in the oxidation reactor and recycled to the scrubbing column. A three-stage, conventional bioscrubber was tested with and without carbon. The experiments showed that the PAC improved the removal efficiency of the system and that bioregeneration occurred. At an inlet gas-phase acetone concentration of 50 ppmv, the steady-state removal increased from 88 to 95% when activated carbon was added to the biological slurry.     

An Integrated Theory for Suspended-Growth Bioscrubbers

An integrated theory is developed to describe the steadystate operation of a suspended-growth bioscrubber for the control of biodegradable, volatile organic gases. The bioscrubber consists of an N-stage absorber and an oxidation reactor. A biomass slurry is circulated between the absorber and the oxidation reactor, t he pollutant is absorbed and partially oxidized in the absorber. Oxidation is completed in the oxidation reactor. Predictions of the theory show that the removal efficiency is a function of Henry's Law constant for the pollutant, the ratio of the liquid flow rate to the gas flow rate, and the number of stages. Since high efficiencies can be achieved for soluble, biodegradable, volatile organic compounds, such systems have the potential to be a low-cost control method.     

聚合氯化铝与粉末活性炭联合强化混凝处理垃圾渗滤液

研究了联合粉末活性炭与聚合氯化铝(PAC)强化混凝对垃圾渗滤液原水的处理效果。结果表明,在原水COD为4 100 mg/L、浊度为147 NTU、UV254为20的条件下,粉末活性炭的加入可以有效增加垃圾渗滤液中有机物的去除率,PAC投加量为0.6 g/L时,投加0.6 g/L粉末活性炭,COD的去除率由21.6%提高到29.1%,UV254去除率由29.8%提高到39.9%,剩余浊度由138 NTU降到133 NTU。该强化混凝过程使原水中溶解性小分子有机物的去除率提高显著,PAC投加量为0.6 g/L时,投加0.6 g/L粉末活性炭,在分子量小于1 kDa的范围内,UV254去除率由2.9%上升为10%。     

粉末活性炭强化常规处理工艺时混凝效能的研究

在水源水质突然变差时,为了保证饮用水水质和水厂的经济低耗运行。以松花江水为原水,采用不同投量的粉末活性炭(PAC)来强化常规处理工艺,通过实验考察了硫酸铝(AS)、聚合氯化铝(PACl)、复合铝铁（PAF）及后2种混凝剂分别与助凝剂高锰酸盐复合药剂（PPC）、活化硅酸配合使用时对浊度和COD_Mn的去除情况。实验结果表明：（1）在进水水质相同的情况下,以浊度和COD_Mn为控制指标,达到同样的处理效果时,制水成本比较的结果为PAF相似文献   

PACT工艺处理PAM生产废水的实验研究

采用粉末活性炭活性污泥工艺(PACT)处理经凹凸棒土预处理后的聚丙烯酰胺(PAM)生产废水。实验考察了粉末活性炭(PAC)的投加对活性污泥处理系统的影响,并探讨了PAC投加量、曝气时间、水力停留时间等参数对降解反应的影响。结果表明:PAC的投加能提高水中溶解氧的利用率,改善污泥沉降性能,增强活性污泥系统对有机物的去除效果;在PAC投加量500 mg/L、曝气10 h的条件下,PACT工艺对PAM生产废水的处理效果良好,COD的去除率为80.8%,BOD5去除率为83.8%,丙烯酰胺(AM)去除率为84.2%。     

Adsorption capacity of powdered activated carbon for 3,5-dichlorophenol in activated sludge

The objectives of this study were to evaluate the performance of powdered activated carbon treatment (PACT) process based on the adsorption capacity of powdered activated carbon (PAC) in activated sludge and the effect of dissolved organic substances in activated sludge on the adsorption capacity of PAC. The DCP adsorption capacity of three PACs originated from different raw materials (coal, soft coal and sawdust) in activated sludge were 29%, 34% and 17% of that of new PAC, respectively. The performance of PACT process for shock loading of 3,5-dichlorophenol (3,5-DCP) was different among PACs in spite of the same adsorption capacity in new PAC. The performance of PACT process for removal of DCP is dependent not on the adsorption capacity of new PAC but on the adsorption capacity of PAC in the aeration tank. Dissolved organic matter (DOM) with molecular weight smaller than 50kDa did not affect the adsorption capacity of PAC for 3,5-DCP in the activated sludge reactor. DOM with molecular weight larger than 50kDa and biofilm developed on the surface of PAC seemed to be responsible for the decreased adsorption capacity of PAC for the DCP.     

Removal of pesticides from surface waters by combined physicochemical processes. Part I: Dodine

The simultaneous action of powdered activated carbon and several coagulant agents on the removal of the fungicide dodine from spiked distilled water, was studied. As coagulants, ferric chloride (FeCl₃) and basic polyaluminium chlorosulfate ([Al(OH)_xCl_y(SO₄)_z]_n) were examined, using polyacrylamide, in certain cases, as coagulant aid (polyelectrolyte). The efficiency of dodine removal was investigated with respect to the added amount of powdered activated carbon (PAC), the pH value, as well as the type and dose of coagulant and polyelectrolyte. The experiments were performed applying the standard jar-test procedure. The initial concentration of dodine was 250 μg/L. At this concentration and pH range 5–8 it was found that a dose of 100 mg/L PAC was necessary to achieve more than 98% removal of dodine, whereas lower removal (91–93%) was obtained applying half the dose of PAC under the same conditions. However, when 10–100 mg/L FeCl₃ were simultaneously added with PAC, the removal efficiency increased to >98%, even with the half PAC dose.     

Effects of earthworm cast and powdered activated carbon on methane removal capacity of landfill cover soils

Landfill gases could be vented through a layer of landfill cover soil that could serve as a biofilter to oxidize methane to carbon dioxide and water. Properly managed landfill cover soil layers may reduce atmospheric CH4 emissions from landfills. In the present study, the effects of earthworm cast and powdered activated carbon (PAC) on the CH4 removal capacity of the landfill cover soil was investigated. For this purpose, column and batch tests were conducted using three different materials: typical landfill cover soil, landfill cover soil amended with earthworm cast, and landfill cover soil amended with PAC. The maximum CH4 removal rate of the columns filled with landfill cover soil amended with earthworm cast was 14.6mol m(-2)d(-1), whereas that of the columns filled with typical landfill cover soil was 7.4mol m(-2)d(-1). This result shows that amendment with earthworm cast could stimulate the CH4-oxidizing capacity of landfill cover soil. The CH4 removal rate of the columns filled with landfill cover soil amended with PAC also showed the same removal rate, but the vertical profile of gas concentrations in the columns and the methanotrophic population measured in the microbial assay suggested that the decrease of CH4 concentration in the columns is mainly due to sorption. Based on the results from this study, amendment of landfill cover soil with earthworm cast and PAC could improve its CH4 removal capacity and thus achieve a major reduction in atmospheric CH4 emission as compared with the same landfill cover soil without any amendment.     

吸附-氧化法应急处理饮用水源突发苯酚污染的研究

以黄浦江上游水源地突发苯酚污染为背景,重点考察了粉末活性炭（PAC）吸附、高锰酸钾（KMnO4）氧化及两者联用技术的除酚效能。结果表明,活性炭及氧化剂种类的选择是影响处理效果的重要因素,微孔发达、比表面积巨大的竹炭对苯酚的去除效果明显优于煤质炭、椰壳炭和木质炭;KMnO4对苯酚的氧化能力强于次氯酸钠和高铁酸钾。增大PAC和KMnO4的投加量,可有效提高对苯酚的去除率;PAC吸附-KMnO4氧化联用技术可大大提高除酚效能,投加50mg／LPAC,2mg／LKMnO4可将初始浓度为250／μg／L和500／μg／L的含酚原水分别处理至18μg／L和66／μg／L,是应对高浓度苯酚突发污染的有效应急措施。     

Immobilized-cell-augmented activated sludge process for treating wastewater containing hazardous compounds.

A novel bioaugmentation scheme called immobilized-cell-augmented activated sludge (ICAAS) was developed. Offline enricher reactors were used to maintain immobilized acclimated cells applied to augment completely mixed activated sludge (CMAS) treating a pentachlorophenol (PCP) pulse loading. Cellulose triacetate (CA) and powder activated carbon (PAC) combined with CA (PAC + CA) were the two media types used for entrapping the PCP-degrading culture. With ICAAS at 5% by volume augmentation, PCP removal of 73.1 and 75.1% via biodegradation, volatilization, and adsorption onto suspended cells, entrapped cells, and media was achieved for the systems with CA and PAC + CA media, respectively, while PCP removal in a control CMAS, which had a comparable level of combined PCP adsorption onto suspended cells and volatilization as the ICAAS, was 48.7%. Results further showed that the immobilized cells retained their PCP-degrading ability when they were fed with the inducer (PCP) once every 20 days.     

Production of sugarcane bagasse-based activated carbon for formaldehyde gas removal from potted plants exposure chamber

Agricultural wastes such as rice straw, sugar beet, and sugarcane bagasse have become a critical environmental issue due to growing agriculture demand. This study aimed to investigate the valorization possibility of sugarcane bagasse waste for activated carbon preparation. It also aimed to fully characterize the prepared activated carbon (BET surface area) via scanning electron microscope (SEM) and in terms of surface functional groups to give a basic understanding of its structure and to study the adsorption capacity of the sugarcane bagasse-based activated carbon using aqueous methylene blue (MB). The second main objective was to evaluate the performance of sugarcane bagasse-based activated carbon for indoor volatile organic compounds removal using the formaldehyde gas (HCHO) as reference model in two potted plants chambers. The first chamber was labeled the polluted chamber (containing formaldehyde gas without activated carbon) and the second was taken as the treated chamber (containing formaldehyde gas with activated carbon). The results indicated that the sugarcane bagasse-based activated carbon has a moderate BET surface area (557 m²/g) with total mesoporous volume and microporous volume of 0.310 and 0.273 cm³/g, respectively. The prepared activated carbon had remarkable adsorption capacity for MB. Formaldehyde removal rate was then found to be more than 67% in the treated chamber with the sugarcane bagasse-based activated carbon. The plants’ responses for this application as dry weight, chlorophyll contents, and protein concentration were also investigated.

Implications: Preparation of activated carbon from sugarcane bagasse (SCBAC) is a promising approach to produce cheap and efficient adsorbent for gas pollutants removal. It may be also a solution for the agricultural wastes problems in big cities, particularly in Egypt. MB adsorption tests suggest that the SCBAC have high adsorption capacity. Formaldehyde gas removal in the plant chambers indicates that the SCBAC have potential to recover volatile gases. The results confirmed that the activated carbon produced from sugarcane bagasse waste raw materials can be used as an applicable adsorbent for treating a variety of gas pollutants from the indoor environment.     

可吸附有机卤化物的深度处理实验研究

可吸附有机卤化物（AOX）是人为污染的重要标志之一,北京高碑店污水处理厂二级出水中约90％的AOX为可吸附有机氧化物（AOCl),研究了自氧氧化,粒状活性炭吸附,粉末活性炭吸附3种深度处理工艺对二级出水中AOX的去除作用,臭氧的氧化反应最多可去除约38％的AOX,粒状活性炭床可运行3200床体积,吸附容量为0.14mgAOX/g GH-16型活性炭,投加木质粉末活性炭200mg/L及25mg/L的聚合氯化铝,能去除24．7％的AOX。     

Modeling sorbent injection for mercury control in baghouse filters: I--model development and sensitivity analysis

A two-stage mathematical model for Hg removal using powdered activated carbon injection upstream of a baghouse filter was developed, with the first stage accounting for removal in the ductwork and the second stage accounting for additional removal caused by the retention of carbon particles on the filter. The model shows that removal in the ductwork is minimal, and the additional carbon detention time from the entrapment of the carbon particles in the fabric filter enhances the Hg removal from the gas phase. A sensitivity analysis on the model shows that Hg removal is dependent on the isotherm parameters, the carbon pore radius and tortuosity, the C/Hg ratio, and the carbon particle radius.     

Modeling Sorbent Injection for Mercury Control in Baghouse Filters: I—Model Development and Sensitivity Analysis

Abstract

A two-stage mathematical model for Hg removal using powdered activated carbon injection upstream of a bag-house filter was developed, with the first stage accounting for removal in the ductwork and the second stage accounting for additional removal caused by the retention of carbon particles on the filter. The model shows that removal in the ductwork is minimal, and the additional carbon detention time from the entrapment of the carbon particles in the fabric filter enhances the Hg removal from the gas phase. A sensitivity analysis on the model shows that Hg removal is dependent on the isotherm parameters, the carbon pore radius and tortuosity, the C/Hg ratio, and the carbon particle radius.     

Determination of the adsorptive capacity and adsorption isotherm of vapor-phase mercury chloride on powdered activated carbon using thermogravimetric analysis

This study investigated the use of thermogravimetric analysis (TGA) to determine the adsorptive capacity and adsorption isotherm of vapor-phase mercury chloride on powdered activated carbon (PAC). The technique is commonly applied to remove mercury-containing air pollutants from gas streams emitted from municipal solid waste incinerators. An alternative form of powdered activated carbon derived from a pyrolyzed tire char was prepared for use herein. The capacity of waste tire-derived PAC to adsorb vapor-phase HgCl2 was successfully measured using a self-designed TGA adsorption system. Experimental results showed that the maximum adsorptive capacities of HgCl2 were 1.75, 0.688, and 0.230 mg of HgCl2 per gram of powdered activated carbon derived from carbon black at 30, 70, and 150 degrees C for 500 microg/m3 of HgCl2, respectively. Four adsorption isotherms obtained using the Langmuir, Freundlich, Redlich-Peterson, and Brunauer-Emmett-Teller (BET) models were used to simulate the adsorption of HgCl2. The comparison of experimental data associated with the four adsorption isotherms indicated that BET fit the experimental results better than did the other isotherms at 30 degrees C, whereas the Freundlich isotherm fit the experimental results better at 70 and 150 degrees C. Furthermore, the calculations of the parameters associated with Langmuir and Freundlich isotherms revealed that the adsorption of HgCl2 by PAC-derived carbon black favored adsorption at various HgCl2, concentrations and temperatures.     

硝基苯酚类的快速吸附与降解

以对硝基苯酚(PNP)和邻硝基苯酚(ONP)为主要研究对象,采用粉末活性炭和Fenton试剂快速吸附与降解PNP和ONP溶液,使其浓度降至生活饮用水准许浓度(分别为0.02 mg/L和0.06 mg/L)以下,并比较2种物质的处理效果,为硝基苯酚的水体污染治理和废水处理中的深度降解提供依据。结果表明,用粉末活性炭吸附浓度为1 mg/L和4 mg/L的PNP溶液60 min后,浓度低于0.02 mg/L,长时间跟踪监测,污染物浓度仍控制在0.02 mg/L以下,在pH<6时,粉末活性炭吸附PNP的效果较好;用Fenton试剂处理浓度为10 mg/L的PNP溶液70 min后,可完全降解PNP。粉末活性炭吸附12 mg/L的ONP溶液时,效率高于吸附PNP;Fenton试剂处理浓度为12 mg/L的ONP时,与PNP的处理效果相当。     

不同工艺对含高浓度腐殖酸地下水处理的可行性

针对内蒙古农村地区高腐殖酸地下水的处理问题,分别对（pH调节）-PAC强化混凝、高锰酸钾预氧化／混凝、活性炭吸附／混凝、Fenton氧化等技术处理的可行性进行了研究,同时利用三维荧光和高效体积排阻色谱分析处理前后水中有机物的组成变化特征。有机分析结果显示,水中的有机物为腐殖酸类物质,分子量分别为1600和3500,腐殖酸类物质为水中色度的主要贡献者。原水PAC强化混凝、高锰酸钾预氧化／PAC混凝对有机物的去除效果不佳,处理前后水样DOC浓度无明显变化,而pH调节．PAC强化混凝、微米活性炭吸附和Fenton氧化均能有效去除有机物。将原水pH调节至6．5,经300mg／LPAC混凝后出水DOC降至5．99mg／L。活性炭投加量为0．6g／L时,DOC降至7．6mg／L,然后采用60mg／LPAC混凝出去高度分散而不易沉降的小颗粒活性炭。此外,当反应初始pH值为3,过氧化氢投加量为0．5％（v／v）,亚铁和双氧水摩尔比为0．05时,出水DOC降至5．6mg／L,氧化后有小分子有机物生成。     

Preparation of sulfurized powdered activated carbon from waste tires using an innovative compositive impregnation process

The objective of this study is to develop an innovative compositive impregnation process for preparing sulfurized powdered activated carbon (PAC) from waste tires. An experimental apparatus, including a pyrolysis and activation system and a sulfur (S) impregnation system, was designed and applied to produce sulfurized PAC with a high specific surface area. Experimental tests involved the pyrolysis, activation, and sulfurization of waste tires. Waste-tire-derived PAC (WPAC) was initially produced in the pyrolysis and activation system. Experimental results indicated that the Brunauer-Emmett-Teller (BET) surface area of WPAC increased, and the average pore radius of WPAC decreased, as water feed rate and activation time increased. In this study, a conventional direct impregnation process was used to prepare the sulfurized PAC by impregnating WPAC with sodium sulfide (Na2S) solution. Furthermore, an innovative compositive impregnation process was developed and then compared with the conventional direct impregnation process. Experimental results showed that the compositive impregnation process produced the sulfurized WPAC with high BET surface area and a high S content. A maximum BET surface area of 886 m2/g and the S content of 2.61% by mass were obtained at 900 degrees C and at the S feed ratio of 2160 mg Na2S/g C. However, the direct impregnation process led to a BET surface area of sulfurized WPAC that decreased significantly as the S content increased.     

Operational characteristics of effective removal of H2S and NH3 waste gases by activated carbon biofilter

Simultaneous removal of hydrogen sulfide (H2S) and ammonia (NH3) gases from gaseous streams was studied in a biofilter packed with granule activated carbon. Extensive studies, including the effects of carbon (C) source on the growth of inoculated microorganisms and gas removal efficiency, product analysis, bioaerosol emission, pressure drop, and cost evaluation, were conducted. The results indicated that molasses was a potential C source for inoculated cell growth that resulted in removal efficiencies of 99.5% for H2S and 99.2% for NH3. Microbial community observation by scanning electron microscopy indicated that granule activated carbon was an excellent support for microorganism attachment for long-term waste gas treatment. No disintegration or breakdown of biofilm was found when the system was operated for 140 days. The low bioaerosol concentration emitted from the biofilter showed that the system effectively avoided the environmental risk of bioaerosol emission. Also, the system is suitable to apply in the field because of its low pressure drop and treatment cost. Because NH3 gas was mainly converted to organic nitrogen, and H2S gas was converted to elemental sulfur, no acidification or alkalinity phenomena were found because of the metabolite products. Thus, the results of this study demonstrate that the biofilter is a feasible bioreactor in the removal of waste gases.     

Powdered activated carbon coupled with enhanced coagulation for natural organic matter removal and disinfection by-product control: application in a Western Australian water treatment plant

The removal of organic precursors of disinfection by-products (DBPs), i.e. natural organic matter (NOM), prior to disinfection and distribution is considered as the most effective approach to minimise the formation of DBPs. This study investigated the impact of the addition of powdered activated carbon (PAC) to an enhanced coagulation treatment process at an existing water treatment plant on the efficiency of NOM removal, the disinfection behaviour of the treated water, and the water quality in the distribution system. This is the first comprehensive assessment of the efficacy of plant-scale application of PAC combined with enhanced coagulation on an Australian source water. As a result of the PAC addition, the removal of NOM improved by 70%, which led to a significant reduction (80-95%) in the formation of DBPs. The water quality in the distribution system also improved, indicated by lower concentrations of DBPs in the distribution system and better maintenance of disinfectant residual at the extremities of the distribution system. The efficacy of the PAC treatment for NOM removal was shown to be a function of the characteristics of the NOM and the quality of the source water, as well as the PAC dose. PAC treatment did not have the capacity to remove bromide ion, resulting in the formation of more brominated DBPs. Since brominated DBPs have been found to be more toxic than their chlorinated analogues, their preferential formation upon PAC addition must be considered, especially in source waters containing high concentrations of bromide.