海洋低盐度干湿交替环境不同金属镀层对D32钢保护特性研究

目的 探究一种适合于低盐度海域干湿交替环境金属腐蚀防护的金属镀层.方法 以胜利海域低盐度的腐蚀环境为研究对象,以D32钢为基体,通过直流脉冲电流电镀4种金属(Al、Mg、Cu和Zn),镀层厚度为(30±1)μm,通过电化学测试和腐蚀形貌分析研究不同镀层金属的腐蚀动力学过程和点蚀特征,以确定最佳保护金属镀层.结果 在干湿...     

30CrMnSiA镀镉层厚度优化研究

目的基于GJB 594A《金属镀覆层和化学覆盖层选择原则与厚度系列》,综合考虑防腐蚀和疲劳性能,对30CrMnSiA镀镉层厚度进行优化。方法开展30CrMnSiA镀镉5个厚度系列的疲劳试验,计算材料的DFRcutoff,研究镀层厚度对疲劳性能的影响。通过中性盐雾试验,研究镀层厚度对材料抗腐蚀性能的影响规律,最后综合考虑疲劳及抗腐蚀性能,提出优化后的镀镉层厚度范围。结果镀层厚度控制在5~25μm时,材料的DFRcutoff下降幅度在15%以内,厚度超过25μm后基体材料的DFR_(cutoff)值下降20%。在中性盐雾环境下,厚度控制在12~25μm时,能满足海军飞机一般钢结构件抗腐蚀性能的要求,当厚度超过25μm后,继续增加镀层厚度对抗腐蚀性能的提升并不明显。结论镀镉使材料的疲劳性能降低,其抗中性盐雾腐蚀能力与镀层厚度成正比。针对海军飞机使用环境特点,推荐30CrMnSiA钢结构件的镀镉厚度范围为12~18μm,取上限值。     

电镀锌镍合金与热渗锌涂层热带海洋大气环境腐蚀规律对比分析

目的 解决钢铁表面金属涂层在热带海洋大气环境中易腐蚀损伤或失效的问题,选择对热带海洋大气环境耐腐蚀性能优良的金属涂层,提高钢铁工件的使用寿命。方法 在某热带海域进行户外暴露试验,对钢铁试片电镀锌镍合金和热渗锌2种金属涂层的腐蚀规律进行研究。通过扫描电镜、X射线能谱仪、光学显微镜、划格试验等,对锌镍合金镀层和热渗锌涂层的表面形貌、化学成分、截面形貌、涂层厚度及附着力等分别进行观察与测试。结果 电镀锌镍合金镀层主要发生选择性腐蚀和点蚀,在720d内具有较好的腐蚀防护性能。热渗锌层以均匀腐蚀为主,涂层微裂纹促进了腐蚀,在90 d内基体无腐蚀,360～720 d涂层的腐蚀速率较快。结论 在采用的2种金属涂层工艺中,电镀锌镍合金镀层的耐腐蚀性能远优于热渗锌涂层。相对于该热渗锌涂层,电镀锌镍合金镀层更加适合作为钢铁工件金属涂层在该海域大气环境中长期使用。     

钝化

通常我们采用电镀的方法来保护金属材料,提高抗腐蚀性能,延长使用寿命,增加外表的美观。许多镀种,如:镀锌、镉、铜等,在电镀后,为了进一步提高其各种性能,还要进行化学处理,使镀层表面生成一层很薄的、致密的、耐腐蚀的膜,我们把这种化学处理过程叫做钝化。例如,经过镀锌,复盖在钢铁材料表面的锌层,虽然可以保护钢铁基体不被腐蚀,但是锌本身是一种比比活泼的金属,容易被腐蚀,因而     

一种提高硬铬镀层气密性的方法

分析研究了硬铬镀层气密性不佳的原因。为提高电镀硬铬镀层的气密性,采用一种封孔技术对镀层进行后处理。研究表明,用518封孔剂处理后的硬铬镀层,气密性可满足"20 MPa,30 min气密性试验,铬层不出现渗漏气泡"的要求,封孔剂可进入到镀层20～30μm的深度,且耐液压油性能较好。     

高锰铝青铜基体上化学镀Ni-P合金镀层在海水中耐蚀性的研究

在高锰铝青铜基体上施镀了Ni-P舍金镀层,并研究了其在海水中的耐蚀性.结果表明:镀层P质量分数为11.84%,属于高磷镀层,为典型的非晶态结构.Ni-P镀层在静止海水的自腐蚀电位比高锰铝铜舍金基体略负,二者间的电偶作用比较轻微,即使镀层有缺陷,也不会对基体造成腐蚀的加速.Ni-P镀层在静止海水和流动海水中的耐蚀性均优于基体铜合金,且在高流速条件下优势更加明显.此外,Ni-P镀层还具有较好的耐砂侵蚀能力.     

镀液循环流量对封闭循环电沉积Ni-SiC复合镀层的影响

目的 研究封闭式镀液循环装置中不同镀液循环流量对Ni-SiC复合镀层的影响规律,优化镀液循环流量参数.方法 以Q235管状工件为待镀基体,以添加SiC颗粒的改良瓦特镀液为母液,在自主研发的封闭式镀液循环电镀装置中以0.3、0.5、0.7 m3/h的镀液循环流量于管件内壁制备Ni-SiC复合镀层,通过SEM检测、XRD测试、硬度测试和摩擦磨损性能测试等手段,对各Ni-SiC复合镀层宏微观形貌、厚度、成分、结构、硬度和耐磨性进行分析研究.结果 在0.5 m3/h流量条件下,镀层厚度为32.98μm,SiC颗粒含量为15.37％,镀层晶粒尺寸和硬度分别为10.84 nm和704HK0.245,该条件下制备的Ni-SiC复合镀层具有最佳耐磨性,摩擦系数为0.41,体积磨损率仅2.83×10–5 mm3/Nm.结论 在不同镀液循环流量参数下,采用该封闭式循环电镀装置,均可制得均匀完整的Ni-SiC复合镀层.随镀液循环流量的升高,镀层厚度和SiC颗粒体积含量均降低,镀层颜色金属光泽增强,镀层晶粒尺寸先减小、后增大,镀层硬度则先升高、后降低.     

离子镀铝与离子液体电镀铝涂层性能对比研究

目的对比研究离子镀铝和离子液体电镀铝两种涂层的性能。方法针对高强度钢表面环保表面处理的需求,对比研究300M钢表面离子镀铝和离子液体电镀铝两种涂层,采用扫描电子显微镜(SEM)、能谱(EDS)等对两种涂层的表面、断面微观形貌和成分进行表征;采用原子力显微镜(AFM)对两种涂层表面三维形貌和粗糙度进行观察和测量;采用电偶腐蚀测试两种涂层与铝合金的电偶腐蚀性能;采用缺口试样拉伸方法检测两种涂层对300M钢基体氢脆性能的影响;采用5%Na Cl人工海水周浸试验的方法检测两种涂层的耐蚀性能,与电镀镉钛镀层进行对比,采用电化学方法对涂层试验前后的阻抗谱特性进行检测分析。结果两种涂层表面形貌存在较大差异,离子镀铝经过致密化处理后,表面为均匀的圆饼状形貌,致密度很高,粗糙度约为0.88μm,而离子液体电镀铝涂层表面则为圆顶状的凸起物组成,没有明显的孔洞缺陷,粗糙度约为0.71μm;电偶腐蚀测试显示,两种涂层都能够与铝合金相容连接;缺口试样的拉伸试验结果显示,两种涂层的对基体的氢脆性能没有影响;腐蚀试验结果显示,两种涂层对于300M钢基体都具有良好的保护效果,与传统的电镀镉钛相当,具备了未来替代镉类镀层的潜质。结论两种涂层均匀致密,没有明显的气孔、裂纹等缺陷,电偶腐蚀性能优异,对300M钢基体都不会产生氢脆隐患,耐蚀性能优异。     

SIMP钢在高温液态铅铋合金中的腐蚀行为

目的 研究SIMP钢在不同溶解氧浓度的高温液态铅铋合金中长期浸泡后腐蚀产物的变化规律。方法 在550 ℃静态液态铅铋合金(饱和氧状态和贫氧状态)中对SIMP钢进行500、1 000、2 000、3 500、5 000 h的腐蚀试验。通过观察腐蚀后试样的表面和截面形貌,进行物化分析,对比不同时间下腐蚀层厚度以及腐蚀产物结构的变化,得出溶解氧浓度和浸泡时间的变化对腐蚀产物的影响规律。结果 在贫氧环境中,SIMP钢的腐蚀类型主要为氧化腐蚀,氧化腐蚀产物具有双层结构,外层为Fe-Cr尖晶石氧化层,内层为富铬氧化物与基体的混合物层;在饱和氧环境,SIMP钢腐蚀产物则具有3层结构,外层为Fe3O4磁铁矿层,中层为Fe-Cr尖晶石氧化层,最内层为富铬氧化物与基体的混合物层。结论 溶解氧浓度和浸泡时间的变化对腐蚀产物的结构和厚度产生了显著影响,SIMP钢在贫氧环境中呈现出优异的耐腐蚀性能。     

不同破损程度下军用车辆镀锌钢板腐蚀行为研究

目的研究军用车辆不同破损程度下的镀锌板腐蚀行为。方法以3.5%Na Cl溶液为实验介质,利用开路电位、电化学阻抗谱及动电位极化曲线技术进行研究。结果镀锌钢板的开路电位比基板低约0.3 V,镀层腐蚀速度随着破损率的增加逐渐增大,基板的腐蚀速度最低。结论镀锌层的腐蚀对破损试样基体起重要的保护作用。     

Toxic effects of acetochlor, methamidophos and their combination on nifH gene in soil

Toxic effects of two agrochemicals on nifH gene in agricultural black soil were investigated using denaturing gradient gel electrophoresis （DGGE） and sequencing approaches in a microcosm experiment. Changes of soil nifH gene diversity and composition were examined following the application of acetochlor, methamidophos and their combination. Acetochlor reduced the nifH gene diversity （both in gene richness and diversity index values） and caused changes in the nifH gene composition. The effects of acetochlor on nifH gene were strengthened as the concentration of acetochlor increased. Cluster analysis of DGGE banding patterns showed that nifH gene composition which had been affected by low concentration of acetochlor （50 mg/kg） recovered firstly. Methamidophos reduced nifH gene richness that except at 4 weeks. The medium concentration of methamidophos （150 mg/kg） caused the most apparent changes in nifH gene diversity at the first week while the high concentration of methamidophos （250 mg/kg） produced prominent effects on nifH gene diversity in the following weeks. Cluster analysis showed that minimal changes of nifH gene composition were found at 1 week and maximal changes at 4 weeks. Toxic effects of acetochlor and methamidophos combination on nifH gene were also apparent. Different nifH genes （bands） responded differently to the impact of agrochemicals： four individual bands were eliminated by the application of the agrochemicals, five bands became predominant by the stimulation of the agrochemicals, and four bands showed strong resistance to the influence of the agrochemicals. Fifteen prominent bands were partially sequenced, yielding 15 different nifH sequences, which were used for phylogenetic reconstructions. All sequences were affiliated with the alpha- and beta-proteobacteria, showing higher similarity to eight different diazotrophic genera.     

Arsenic uptake by arbuscular mycorrhizal maize （Zea mays L.） grown in an arsenic-contaminated soil with added phosphorus

The effects of arbuscular mycorrhizal (AM) fungus (Glomus mosseae) and phosphorus (P) addition (100 mg/kg soil) on arsenic (As) uptake by maize plants (Zea mays L.) from an As-contaminated soil were examined in a glasshouse experiment.Non-mycorrhizal and zero-P addition controls were included.Plant biomass and concentrations and uptake of As,P,and other nutrients,AM colonization,root lengths,and hyphal length densities were determined.The results indicated that addition of P significantly inhibited root colonization and development of extraradical mycelium.Root length and dry weight both increased markedly with mycorrhizal colonization under the zero-P treatments,but shoot and root biomass of AM plants was depressed by P application.AM fungal inoculation decreased shoot As concentrations when no P was added,and shoot and root As concentrations of AM plants increased 2.6 and 1.4 times with P addition,respectively.Shoot and root uptake of P,Mn,Cu,and Zn increased,but shoot Fe uptake decreased by 44.6%,with inoculation, when P was added.P addition reduced shoot P,Fe,Mn,Cu,and Zn uptake of AM plants,but increased root Fe and Mn uptake of the nonmycorrhizal ones.AM colonization therefore appeared to enhance plant tolerance to As in low P soil,and have some potential for the phytostabilization of As-contaminated soil,however,P application may introduce additional environmental risk by increasing soil As mobility.     

Impact of atrazine and nitrogen fertilizers on the sorption of chlorotoluron in soil and model sorbents

Sorption of chlorotoluron in ammonium sulfate, urea and atrazine multi-solutes system was investigated by batch experiments. The results showed application of nitrogen fertilizers to the soil could affect the behavior of chlorotoluron. At the same concentration of N, sorption of chlorotoluron decreased as the concentration of atrazine increased on the day 0 and 6 in soil, respectively. The sorption of chlorotoluron increased from 0 to 6 d when soils were preincubated with deionized water, ammonium sulfate and urea solution for 6 d. That indicated incubation time was one of the most important factors for the sorption of chlorotoluron in nitrogen fertilizers treatments. The individual sorption isotherms of chlorotoluron in rubbery polymer and silica were strictly linear in single solute system, but there were competition sorption between pesticides or between pesticides and nitrogen fertilizers. That indicated the sorption taken place by concurrent solid-phase dissolution mechanism and sorption on the interface of water-organic matter or water-mineral matter.     

Degradation of metabolites accumulated of benzo[a]pyrene by coupling Penicillium Chrysogenum with KMnO4

Several main metabolites of benzo[a]pyrene （BaP） formed by Penicillium chrysogenum, Benzo[a]pyrene-1,6-quinone （BP 1,6- quinone）, trans-7,8-dihydroxy-7,8-dihydrobenzo[a]pyrene （BP 7,8-diol）, 3-hydroxybenzo[a]pyrene （3-OHBP）, were identified by high-performance liquid chromatography （HPLC）. The three metabolites were liable to be accumulated and were hardly further metabolized because of their toxicity to microorganisms. However, their further degradation was essential for the complete degradation of BaP. To enhance their degradation, two methods, degradation by coupling Penicillium chrysogenum with KMnO4 and degradation only by Penicillium chrysogenum, were compared; Meanwhile, the parameters of degradation in the superior method were optimized. The results showed that （1） the method of coupling Penicillium chrysogenum with KMnO4 was better and was the first method to be used in the degradation of BaP and its metabolites; （2） the metabolite, BP 1,6-quinone was the most liable to be accumulated in pure cultures; （3） the effect of degradation was the best when the concentration of KMnO4 in the cultures was 0.01% （w/v）, concentration of the three compounds was 5 mg/L and pH was 6.2. Based on the experimental results, a novel concept with regard to the bioremediation of BaP-contaminated environment was discussed, considering the influence on environmental toxicity of the accumulated metabolites.     

Potential of plant polyphenol oxidases in the decolorization and removal of textile and non-textile dyes

In this study an effort has been made to use plant polyphenol oxidases; potato （Solanum tuberosum） and brinjal （Solanum melongena）, for the treatment of various important dyes used in textile and other industries. The ammonium sulphate fractionated enzyme preparations were used to treat a number of dyes under various experimental conditions. Majority of the treated dyes were maximally decolorized at pH 3.0. Some of the dyes were quickly decolorized whereas others were marginally decolorized. The initial first hour was sufficient for the maximum decolorization of dyes. The rate of decolorization was quite slow on long treatment of dyes. Enhancement in the dye decolorization was noticed on increasing the concentration of enzymes. The complex mixtures of dyes were treated with both preparations of polyphenol oxidases in the buffers of varying pH values. Potato polyphenol oxidase was significantly more effective in decolorizing the dyes to higher extent as compared to the enzyme obtained from brinjal polyphenol oxidase. Decolorization of dyes and their mixtures, followed by the formation of an insoluble precipitate, which could be easily removed simply by centrifugation.     

Removal of heavy metals from sewage sludge by low costing chemical method and recycling in agriculture

ＲｅｍｏｖａｌｏｆｈｅａｖｙｍｅｔａｌｓｆｒｏｍｓｅｗａｇｅｓｌｕｄｇｅｂｙｌｏｗｃｏｓｔｉｎｇｃｈｅｍｉｃａｌｍｅｔｈｏｄａｎｄｒｅｃｙｃｌｉｎｇｉｎａｇｒｉｃｕｌｔｕｒｅＷｕＱｉｔａｎｇ，ＮｙｉｒａｎｄｅｇｅＰａｓｃａｓｉｅ，ＭｏＣｅｈｕｉＦ...     

Isolation and preliminary characterization of a 3-chlorobenzoate degrading bacteria

A study was conducted to compare the diversity of 2-, 3-, and 4-chlorobenzoate degraders in two pristine soils and one contaminated sewage sludge. These samples contained strikingly different populations of mono-chlorobenzoate degraders. Although fewer cultures were isolated in the uncontaminated soils than contaminated one, the ability of microbial populations to mineralize chlorobenzoate was widespread. The 3- and 4-chlorobenzoate degraders were more diverse than the 2-chlorobenzoate degraders. One of the strains isolated from the sewage sludge was obtained. Based on its phenotype, chemotaxonomic properties and 16S rRNA gene, the organism S-7 was classified as Rhodococcus erythropolis. The strain can grow at temperature from 4 to 37℃. It can utilize several （halo）aromatic compounds. Moreover, strain S-7 can grow and use 3-chlorobenzoate as sole carbon source in a temperatures range of 10-30℃ with stoichiometric release of chloride ions. The psychrotolerant ability was significant for bioremediation in low temperature regions. Catechol and chlorocatechol 1,2-dioxygenase activities were present in cell free extracts of the strain, but no （chloro）catechol 2,3- dioxygenase activities was detected. Spectral conversion assays with extracts from R. erythropolis S-7 showed accumulation of a compound with a similar UV spectrum as chloro-cis,cis-muconate from 3-chlorobenzoate. On the basis of these results, we proposed that S-7 degraded 3-chlorobenzoate through the modified ortho-cleave pathway.     

Single and joint effects of pesticides and mercury on soil urease

The influence of two pesticides including chlorimuron-ethyl and furadan and mercury （Hg） on urease activity in 4 soils （meadow burozem and phaeozem） was investigated. The soils were exposed to various concentrations of the two pesticides and Hg individually and simultaneously. Results showed that there was a close relationship between urease activity and organic matter content in soil. Chlorimuron-ethyl and furadan could both activate urease in the 4 soils. The maximum increment of urease activity by chlorimuronethyl was up to 14%-18%. There was almost an equal increase （up to 13%-21%） in the urease activity by furadan. On the contrary, Hg markedly inhibited soil urease activity. A logarithmic equation was used to describe the relationship （P〈0.05） between the concentration of Hg and the activity of soil urease in the 4 tested soils. Semi-effect dose （ED50） values by the stress of Hg based on the inhibition of soil urease in the 4 soils were 88, 5.5, 24 and 20 mg/kg, respectively, according to the calculation of the corresponding equations. The interactive effect of chlorimuron-ethyl or furadan with metal Hg on soil urease was mainly synergic at the highest tested concentrations.     

Organochlorine pesticides in soils under different land usage in the Taihu Lake region, China

A field study was conducted in the Taihu Lake region, China in 2004 to reveal the organochlorine pesticide concentrations in soils after the ban of these substances in the year 1983. Thirteen organochlorine pesticides (OCPs) were analyzed in soils from paddy field, tree land and fallow land. Total organochlorine pesticide residues were higher in agricultural soils than in uncultivated fallow land soils. Among all the pesticides, ΣDDX (DDD, DDE and DDT) had the highest concentration for all the soil samples, ranging from 3.10 ng/g to 166.55 ng/g with a mean value of 57.04 ng/g and followed by ΣHCH, ranging from 0.73 ng/g to 60.97 ng/g with a mean value of 24.06 ng/g. Dieldrin, endrin, HCB and α-endosulfan were also found in soils with less than 15 ng/g. Ratios of p,p'-(DDD DDE)/DDT in soils under three land usages were: paddy field ＞ tree land ＞ fallow land, indicating that land usage inlfuenced the degradation of DDT in soils. Ratios of p,p'-(DDD DDE)/DDT ＞1, showing aged residues of DDTs in soils of the Taihu Lake region. The results were discussed with data from a former study that showed very low actual concentrations of HCH and DDT in soils in the Taihu Lake region, but according to the chemical half-lives and their concentrations in soils in 1980s, the concentration of DDT in soils seemed to be underestimated. In any case our data show that the ban on the use of HCH and DDT resulted in a tremendous reduction of these pesticide residues in soils, but there are still high amounts of pesticide residues in soils, which need more remediation processes.     

Alterations of organ histopathology and metallolhionein mRNA expression in silver barb, Puntius gonionotus during subchronic cadmium exposure

Common silver barb,Puntius gonionotus,exposed to the nominal concentration of 0.06 mg/L Cd for 60 d,were assessed for histopathological alterations(gills,liver and kidney),metal accumulation,and metallothionein(MT)mRNA expression.Fish exhibited pathological symptoms such as hypertrophy and hyperplasia of primary and secondary gill lamellae,vacuolization in hepatocytes,and prominent tubular and glomerular damage in the kidney.In addition,kidney accumulated the highest content of cadmium,more than gills and liver.Expression of MT mRNA was increased in both liver and kidney of treated fish.Hepatic MT levels remained high after fish were removed to Cd-free water.In contrast,MT expression in kidney was peaked after 28 d of treatment and drastically dropped when fish were removed to Cd-free water.The high concentrations of Cd in hepatic tissues indicated an accumulation site or permanent damage on this tissue.