The comparison of growth and nutrient removal efficiency of Chlorella pyrenoidosa in settled and activated sewage

The microscopic green alga, Chlorella pyrenoidosa was grown in settled and activated sewage under two different culture systems, batch and semi-continuous. Good growth was obtained in both types of wastewater and the algal production was comparable to and even higher than that found in commercial Bristol medium. The semi-continuous culture supported more growth than the batch system. There was a close relationship between algal growth and the amount of nutrient removed from both settled and activated sewage. A more rapid drop in NH(4)(+)-N was found in settle rather than activated sewage. The NH(4)(+)-N of settled sewage dropped from its initial 27 to 5 mg litre(-1) in both culture systems. On the other hand, the NO(3)(-)-N of activated sewage started to decrease from Day 2 onwards and the final NO(3)(-)-N concentration was less than 1 mg litre(-1) (over 90% removal efficiency). The amount of total inorganic nitrogen being reduced due to algal culture was similar in both types of sewage. The changes of phosphate content followed the same trend in both sewage, the P concentration increased slightly in the first two days then decreased, especially in the semi-continuous cultures. The final ortho-P in the sewage treated by Chlorella in semi-continuous culture was less than 5 mg litre(-1) (about 62% reduction). Such removal efficiency was slightly lower than those reported in previous studies. In general, the semi-continuous algal culture appeared to be a more suitable and efficient way for wastewater treatment than the batch system. With respect to the total reduction of wastewater inorganic N and P by means of Chlorella cells, there was no significant difference between settled and activated sewage.     

3种载体固定化菌藻共生系统脱氮除磷效果的对比

采用3种不同载体（海藻酸钠、聚乙烯醇、复合载体）,分别将小球藻和栅藻与活性污泥固定成菌藻共生系统,制成菌藻凝胶小球,单独菌、单独藻的凝胶小球,用于处理人工污水。结果表明,（1）复合载体固定的菌藻共生系统氮磷去除效果最好,PVA载体的脱氮除磷效果次于复合载体优于海藻酸钠;（2）固定化菌藻共生系统的脱氮除磷效果明显优于单独固定菌和单独固定藻,固定菌的效果较差;（3）3种载体包埋下的固定化小球藻的脱氮除磷效果均较相同载体固定化的栅藻效果好。     

4种固定化藻类对污水中氮的净化能力研究

取培养至对数末期的藻,采用海藻酸钙凝胶包埋固定,对人工污水进行静态模拟净化试验,研究了蛋白核小球藻、鱼腥藻、双对栅藻和突变衣藻4种藻在固定和悬浮状态下,对污水中的氨氮和硝酸氮的净化效率以及藻类的生长特性。结果表明：固定化藻细胞比悬浮态藻细胞具有生长更趋于稳定、藻类的活性保持时间更长的优势。4种藻类中,小球藻和鱼腥藻在污水中的生长状况更好,较适宜采用海藻酸钙凝胶包埋固定化技术。实验第5 d时,固定化小球藻、鱼腥藻、双对栅藻和衣藻对NH₃-N去除率分别为91.9%、84.8%、68.3%和51.2%;对NO^-₃-N的去除率分别为85.1%、100%、96.9%和65.9%。固定化小球藻对NH₃-N的去除效果最好,而固定化鱼腥藻对NO^-₃-N的去除效果最好。因此,小球藻和鱼腥藻更适用于去除污水中的氮,具有很好的应用前景。     

Performance of different microalgal species in removing nickel and zinc from industrial wastewater

A series of batch experiments was conducted to compare the ability of 11 microalgal species of the same cell density in removing nickel (Ni) and zinc (Zn) from synthetic wastewater. These included Chlorella vulgaris (commercially available), Chlorella sorokiniana and Scenedesmus quadricauda (isolates from polluted water of Wuhan, China), and eight different isolates from Hong Kong. The Wuhan isolate of Scenedesmus removed most Ni, probably due to its large biomass. Nickel concentration was reduced from an initial 30 to 0.9 mg/l after 5 min (97% Ni removal), and further declined to 0.4 mg/l after 90 min of treatment. In wastewater containing 30 mg/l Ni and 30 mg/l Zn, more than 98%, Ni and Zn were removed simultaneously at the end of 5 min treatment, indicating that the presence of Zn in wastewater did not affect Ni removal by this Scenedesmus isolate. The second most effective species for Ni removal was an isolate, tentatively identified as Chlorella miniata, Ni concentration was reduced to 10 mg/l after 90 min, and was only slightly interfered by the presence of Zn. In terms of metal removal per unit biomass or unit surface area of algal cells, C. miniata was the best species in removing Ni and Zn. At the other extreme, one Hong Kong isolate (Synechocystis sp.) did not remove any Ni and only achieved 40% Zn removal. Performance of the other isolates was comparable with the commercial C. vulgaris, less than 50% Ni was removed after 5 h of treatment and Ni removal was significantly reduced by the presence of Zn. All algae tested were found to be viable, showing these 11 species could tolerate a mixture of 30 mg/l Ni and 30 mg/l Zn in wastewater.     

2种新分离微藻的生长、氮磷去除和营养特性的比较研究

为了解2种新分离微藻的净化和资源化潜力,研究比较了其生长、氮磷去除和营养特性。结果表明,栅藻和月牙藻的最大生物量（干重）分别为0．78g／L和0．53g／L;最大生物量（干重）增长速率分别为0．05g／（L·d）和0．03g／（L·d）。培养至第23天,栅藻和月牙藻对TN的去除率分别为85．1％和72．5％;对TP的去除率为82．6％和79．7％,但栅藻较月牙藻更易释放较多的No2--N进入藻液。稳定期时,栅藻、月牙藻的粗蛋白质含量和粗蛋白产量（干重）分别为31．8％、19．2％和0．24g／L、0．09g／L;粗脂含量和粗脂产量（干重）分别为7．81％、9．26％和0．06g／L、0．05g／L。综上,与月牙藻相比,栅藻具有明显的生长、氮磷去除和营养优势,在进行水产养殖废水的净化和资源化利用上可作为优选藻种。     

Effect of immobilized microalgal bead concentrations on wastewater nutrient removal

A unicellular green microalga, Chlorella vulgaris, entrapped in calcium alginate as algal beads were employed to remove nutrients (N and P) from simulated settled domestic wastewater. A significantly higher nutrient reduction was found in bioreactors containing algal beads (at concentrations ranging from 4 to 20 beads ml(-1) wastewater) than the blank alginate beads (without algae). A complete removal of NH(4)(+)-N and around 95% reduction of PO(4)(3-)-P was achieved within 24 h of treatment in bioreactors having the optimal algal bead concentration (12 beads ml(-1), equivalent to 1:3 algal beads:wastewater, v/v). The NH(4)(+)-N removal was significantly lower at low (around 4 beads ml(-1)) and high (>15 beads ml(-1)) algal bead concentrations. On the other hand, the effect of bead concentration on phosphate removal was less obvious, and bead concentrations ranging from 8 to 20 beads ml(-1) showed comparable percentages of phosphate reduction. Algal uptake and adsorption on alginate gels were found to be the major processes involved in the removal of N and phosphate in the present study. In addition, NH(4)(+)-N could be lost via ammonia volatilization while PO(4)(3-)-P was removed by chemical precipitation, as alkaline pH was recorded in the immobilized microalgal treatment system.     

实际污水与模拟污水活性污泥系统的特性差异

实验中经常采用人工配置的模拟生活污水,为了研究其与实际生活污水活性污泥系统的特性差异,采用2个序批式间歇反应器(SBR)进行平行实验(厌氧、好氧方式运行),系统地考察了在进水主要组分和运行参数相同的情况下,不同原水对活性污泥系统脱氮、除磷、比好氧速率、污泥絮体形态和出水水质等方面的影响。结果表明,模拟污水系统的硝化活性强于实际污水系统,两者的平均硝化速率分别为7.43 mg NH4+-N/(L.h)和5.55 mg NH4+-N/(L.h)。在前置厌氧段,模拟污水系统的释磷量比实际污水系统高出36.45%。两者在后续好氧阶段都能够充分吸磷。模拟污水系统的平均比好氧速率(SOUR)高达64.54 mg O2/(g MLSS.h),而实际污水系统的则只有32.81 mg O2/(g MLSS.h)。模拟污水系统的污泥絮体疏松,粒径小,形状不规则,沉降性差,沉后出水平均悬浮物浓度(SS)为20 mg/L;而实际污水系统的污泥絮体则密实、粒径大,沉降性好,沉后水十分清澈,SS几乎检测不出。     

Effects of propanil, tebufenozide and mefenacet on growth of four freshwater species of phytoplankton: a microplate bioassay

The Albufera Natural Park situated in Valencia (Spain), with a very rich flora and fauna is surrounded by rice fields in which pesticide spraying is a regular practice. With this in mind, the sensitivity of four algal species, Scenedesmus acutus, Scenedesmus subspicatus, Chlorella vulgaris and Chlorella saccharophila to pesticides propanil, tebufenozide and mefenacet was studied using single species toxicity tests. Organisms were exposed to different concentrations of these herbicides and the algal growth was measured in a microplate reader at 410 nm, at 0, 24, 48 and 72 h. Tebufenozide appeared to be the most inhibitory to Scenedesmus and Chlorella species growth. 72 h EC50 of propanil, tebufenozide and mefenacet ranged from 0.29 to 5.98 mg/l, 0.12 to 0.15 mg/l and from 0.25 to 0.67 mg/l, respectively for the four algal species. The two species of Chlorella were more tolerant than the two species of Scenedesmus.     

Microalgae growth using high-strength wastewater followed by anaerobic co-digestion

Integration of algal biofuel production to wastewater anaerobic digestion infrastructure has the potential to increase biogas production, decrease high and variable internal nitrogen loads, and improve sludge digestibility and dewaterability. In this research, two species of microalgae, Spirulina platensis and Chlorella sp., were grown on sludge centrate and a centrate and nitrified wastewater effluent mixture. Harvested algae were co-digested with waste activated sludge (WAS) at varying ratios. High-growth (6.8 g m(-2) x d(-1)), nitrogen (36.5 g m(-3) x d(-1)), and phosphorus (6.5 g m(-3) x d(-1)) uptake rates were achieved with Chlorella on centrate. No growth was observed with S. platensis under the same conditions; however, both organisms grew well on the centrate and effluent mixture. Co-digestion of algae with WAS improved volatile solids reduction. Although co-digestion with S. platensis improved biosolids dewaterability, Chlorella had a slight negative effect on dewaterability compared to WAS alone. The efficiency of energy conversion from photons to biogas generated from Chlorella was estimated at 1.4%.     

固定化菌藻系统对污水处理厂出水的深度处理

将海藻酸钠固定化活性污泥和小球藻制成颗粒小球,以自制的流化床反应器对重庆市某污水处理厂出水进行深度处理,探讨了系统对氨氮、TP、COD的去除效果,实验结果表明:在HRT=12 h,溶解氧浓度为3.0 mg/L左右,pH值为6.2至8.0之间,环境室温条件下,系统对氨氮、TP、COD均有较好的去除效果,系统稳定运行后对氨氮、TP、COD去除率基本维持在60%、60%和30%以上,出水氨氮、TP、COD浓度基本维持在8、0.5和40 mg/L以下,出水浓度达到了《城镇污水处理厂污染物排放标准》(GB 18918-2002)的一级A标准。这项研究显示固定化菌藻胶球系统在污水处理厂出水的深度处理中具有潜在的应用前景。     

Repeated use of two Chlorella species, C. vulgaris and WW1 for cyclic nickel biosorption.

Two living Chlorella species were used to remove nickel from solution containing 30 micrograms Ni ml-1 in 10 successive cycles. The present study also examined the continued viability of these two algal species after repeated exposure to nickel. The two species of Chlorella were Chlorella vulgaris (commercially available) and WW1 (indigenous species isolated from domestic sewage and was tentatively identified as Chlorella miniata). The nickel removal percentage of WW1 cells was maintained at around 85% in the first five cycles, then declined slightly from the fifth cycle onwards, and finally achieved around 70% removal at the end of the 10th cycle. On the contrary, the removal efficiency of C. vulgaris declined from 50 to 30% during the 10 cycles of nickel bisorption. At the end of these 10 successive cycles, WW1 accumulated a substantial amount of Ni2+ (the cumulative cellular Ni concentration was 0.92% dry w.), while the value was only 0.17% in the case of C. vulgaris. These results suggest that the local isolate, WW1, had more consistent and satisfactory ability for removing Ni than the commercial C. vulgaris. Both algal species were still capable of dividing after each nickel treatment cycle, suggesting that the cells were not killed even when significant amounts of nickel were adsorbed/absorbed. However, Ni exposure adversely affected the physiological activity of algal cells as reflected by the decline in division rate and chlorophyll-a activity in both species. Such negative effects became more obvious as the number of cyclic treatments was increased. Nevertheless, WW1 cells appeared to recover from nickel treatment when re-cultivated in commercial medium for 2 weeks.     

原核小球藻USTB-01去除化肥厂废水中总氮的研究

采用1株异养原核小球藻USTB-01对化肥厂废水中总氮的去除进行了研究。结果表明,添加一定量的磷酸盐和碳酸钠特别是葡萄糖分别作为磷、无机碳和有机碳源,不仅可以明显促进原核小球藻USTB-01的生长,而且可以大幅度提高废水的总氮去除效率。在4 d时间内原核小球藻USTB-01的生长从OD680 nm0.5增加到3.6,提高到7倍,而废水中总氮的浓度从125 mg/L降低到10.3 mg/L,去除率达到了93.1%,处理后的废水可以达标排放。不仅在高含氮废水的处理,而且在利用废水中的氮培养原核小球藻USTB-01的废水资源化利用方面均具有重要的意义。     

Performance of mixed algae for treatment of slaughterhouse wastewater and microbial community analysis

This study investigated organic matter (OM) and nutrient removal efficiency of mixed algal species from slaughterhouse wastewater (SWW) by using photo-bioreactor. For this purpose, different dilution multiples of 10, 4, and 2 were applied to the SWW, and pure wastewater was finally used for algal cultivation. OM and nutrient removal performance in an algal photo-bioreactor were severely affected by the dilution ratio. After 7 days of cultivation, the highest removal percentages of total organic carbon (TOC), total nitrogen (TN), and total phosphorus (TP) were 89.6, 70.2, and 96.2 %, respectively. Furthermore, the changes in eukaryotic algae and cyanobacterial species in the algal photo-bioreactors were investigated using polymerase chain reaction (PCR) and denaturing gradient gel electrophoresis (DGGE) techniques. The results indicated that cyanobacterial species were more efficient than eukaryotic species in removing nutrients from the SWW. This study suggests that mixed algal photo-bioreactors could be used efficiently in the treatment of SWW.

     

Enantioselectivity in toxicity and degradation of dichlorprop-methyl in algal cultures

Enantioselectivity in the toxicity and degradation of the herbicide dichlorprop-methyl (2,4-DCPPM) in algal cultures was studied. Enantioselectivity was clearly observed in the toxicity of racemic 2,4-DCPPM and its two enantiomers. R-2,4-DCPPM showed low toxicity to Chlorella pyrenoidosa and Chlorella vulgaris, but higher toxicity to Scenedesmus obliquus. The observed toxicity was ranked: R-2,4-DCPPM>S-2,4-DCPPM>Rac-2,4-DCPPM; the toxicity of R-2,4-DCPPM was about 8-fold higher than that of Rac-2,4-DCPPM. Additionally, 2,4-DCPPM was quickly degraded, in the initial 12 h, and different algae cultures had different enantioselectivity for the 2,4-DCPPM enantiomers. There was no significant enantioselectivity for 2,4-DCPPM in Chlorella vulgaris in the initial 7 h. However, racemic 2,4-DCPPM was degraded by Scenedesmus obliquus quickly, in the initial 4 h, much quicker, in fact, than the S- or R-enantiomers (racemate>R->S-), indicating that the herbicide 2,4-DCPPM was absorbed enantioselectively by Scenedesmus obliquus. The rapid formation of 2,4-DCPP suggested that 2,4-DCPPM adsorbed by algal cells was catalytically hydrolyzed to the free acid, a toxic metabolite. The production rates of 2,4-DCPP were as follows: Scenedesmus obliquus>Chlorella pyrenoidosa>Chlorella vulgaris, consistent with the degradability of 2,4-DCPPM. Scenedesmus obliquus had quick, but different, degradative and uptake abilities for R-, S-, and Rac-2,4-DCPPM. The R- and S- enantiomers were not hydrolyzed in the first 12 h, while both enantiomers were hydrolyzed slowly after that. These results indicate that some physical and chemical properties of compounds are of importance in determining their enantioselective toxicity and degradation. The ester and its metabolite likely played an important role in enantioselective toxicity to the three algae.     

Effects of bensulfuron-methyl and cinosulfuron on growth of four freshwater species of phytoplankton

The acute toxicity of sulfonylurea herbicides bensulfuron-methyl and cinosulfuron was tested on the five species of freshwater phytoplankton: Scenedesmus acutus, Scenedesmus subspicatus, Chlorella vulgaris and Chlorella saccharophila. Herbicide concentrations eliciting a 50% growth reduction over 96 h (EC50) ranged from 8 to 104 mg/l for cinosulfuron and from 0.015 to 6.2 mg/l for bensulfuron-methyl. The pesticides bensulfuron-methyl, atrazine and benthiocarb were more toxic than cinosulfuron, chlorsulfuron, molinate, fenitrothion and pyridaphenthion in a toxicity study with the same algal species. The transformation of effective concentrations of bensulfuron-methyl and cinosulfuron and other pesticides, obtained from toxicity measurements, into percent of the saturation level in water is used as a first evaluation of potential hazard to aquatic systems. The herbicides cinosulfuron, methyl-bensulfuron, atrazine and chlorsulfuron were more dangerous than the herbicides benthiocarb and molinate and than the insecticides fenitrothion and pyridaphenthion, in a study of hazard evaluation. The two species of Chlorella were more tolerant to both herbicides than the two species of Scenedesmus. A potential environmental hazard of sulfonylurea herbicides to aquatic systems has to be expected even at low environmental concentrations.     

大坦沙污水厂承接粪便污水的脱氮除磷研究

广州市大坦沙污水处理厂采用A²/O工艺,合并处理城市生活污水和粪便污水,由于粪便污水的污染物含量高和水量不稳定等特点,对水厂的运行有不利的影响。实践表明：通过控制好氧池溶解氧、延长好氧段的水力停留时间、增大回流比和提高MLSS与污泥龄等措施,该厂取得较好的脱氮除磷效果,实现出水COD、总氮、氨氮和总磷达标排放。     

碳氮磷比例失调城市污水的同步脱氮除磷

为解决现行同步脱氮除磷工艺处理南方地区碳、氮、磷比例失调城市污水中,因C/N、C/P偏低,碳源不足而降低脱氮除磷效率的难题,试验以碳源偏低的广州市城市污水为研究对象,采用厌氧/好氧交替运行的SBR系统,通过对厌氧、好氧时段的合理调控,在无需额外添加碳源的条件下,有机物、氨氮、总氮和总磷的平均去除率分别可达90%、72%、41%和99%,不仅能使有机物和氮的出水指标达到国家排放标准,而且总磷出水浓度能达0.5 mg/L以下。通过进一步分析同步高效脱氮除磷的影响因素和控制条件,得出合理污泥龄的控制是实现同步脱氮除磷的关键,厌氧/好氧交替运行的方式不仅强化了磷的释放和吸收,而且降低了碳源偏低和硝酸盐对同步脱氮除磷影响的结论。     

低曝气下PAC强化SBR工艺同步脱氮除磷

采用序批式反应器(SBR)处理模拟生活污水,研究不同曝气量(30、24、18和12 L/h)下活性污泥同步脱氮除磷规律,并在最佳曝气量下,比较了粉末活性炭-序批式反应器(PAC-SBR)和SBR的脱氮除磷效率,分析了低曝气下PAC-SBR的运行特性和优越性。实验结果表明,当曝气量为24 L/h时,SBR内出水效果较好,其COD、TN和TP的平均去除率分别可以达到90.02%、81.13%和88.12%。在这个最佳曝气量下,PAC-SBR具有明显的优势,其COD、TN和TP的平均去除率均高于SBR,并且PAC-SBR具有较好的污泥沉降性能和较高的活性污泥浓度。在PAC-SBR中,活性污泥以PAC作为微生物载体强化了生物降解效果,并改善了低曝气下污泥絮体的结构,促使反应器内先后形成缺氧-厌氧-微氧/缺氧-缺氧的环境,利于同步硝化反硝化和反硝化聚磷,提高了PAC-SBR的同步脱氮除磷效率。     

双泥膜法SBR脱氮除磷效果研究

通过实验室小试,以人工模拟生活污水为研究对象,考察了基于反硝化除磷理论开发的双泥膜法SBR工艺的脱氮除磷效果。长期试验结果表明：双泥膜法SBR工艺能使硝化菌和除磷菌各自在最佳的环境中生长,解决了传统工艺中脱氮和除磷的矛盾,节省了碳源和能源,并取得了稳定高效的脱氮除磷效果。在进水C∶N∶P为25∶5∶1,换液比为75%的情况下,系统对COD,TP和NH⁺₄-N的平均去除率分别为89.13%、96.12%和86.78%。     

Improving nitrogen removal in two modified decentralized wastewater systems

Efficient nutrient removal in decentralized wastewater treatment systems is a challenging task. To improve the removal of organic matter and nitrogen from wastewater, two types of bioreactors using membrane-aerated biofilm reactor (MABR) and microbial fuel cell (MFC) techniques were evaluated. During more than 250 days of continuous-flow reactor operation, both reactors showed consistently high chemical oxygen demand removal (>86%). At an influent ammonium-nitrogen (NH4(+)-N) concentration of 30 mg N/L, the average effluent NH4(+)-N concentrations were 6.2 and 0.5 mg N/L for the MABR and MFC reactor, respectively, while the effluent nitrate-nitrogen (NO3(-)-N) concentrations were 5.4 mg/ L in the MABR and 19.2 mg/L in the MFC-based reactor. The overall total inorganic nitrogen removal efficiencies were 64% and 36% for the MABR and MFC reactor, respectively. At the measured dissolved oxygen concentrations of 5.2 and 0.23 mg/L in the aerobic/anoxic zone of the MFC and MABR, respectively, a specific oxygen uptake rate of 0.1 g O2/g VSS-d, resulting from ammonia oxidation, was detected in the settled sludge of the MFC, while no nitrifying activity of the sludge from the MABR was detected. Molecular microbial analysis demonstrated a link between the bacterial community structure and nitrifying activity. The relatively high abundance of Nitrosomonas europaea was associated with its detectable nitrification activity in the settled sludge of the MFC. The results suggest that MABR and MFC techniques have the potential to improve organic and nitrogen removal in decentralized wastewater systems.