During composting the humification of organic matter will have a significant effect on the physicochemical form of existence of heavy metals. Therefore the present study was conducted to investigate the effect of co-composting sewage sludge with lime on heavy metal speciation and the changes in DTPA extractable metals. Metal speciation was conducted to evaluate the redistribution of Cu, Mn, Ni, Pb and Zn in sewage sludge composted with lime. Sewage sludge was mixed with sawdust in 2:1 (w/w fresh weight) and then composted with lime at 0%, 0.63%, 1% or 1.63% (dry weight) for 100 days. The lime addition did not cause any changes in the different forms of Cu and Mn, but the composting process caused transformations of residual form of Cu and Mn into oxidizable and reducible form, respectively. For Ni, the reducible form was mainly transformed into residual form and lime addition decreased this transformation. Major transformation of different forms of Pb was not found, however the residual form of Pb increased with lime addition. The predominant residual form of Zn was mainly transformed into oxidizable form and the lime addition reduced this transformation. Addition of lime to sewage sludge during composting resulted in lower DTPA extractable metal contents. Therefore, lime is a suitable material to co-compost with sewage sludge to reduce the availability of heavy metals. 相似文献
The major limitation of soil application of sewage sludge compost is the total heavy metal contents and their bioavailability to the soil-plant system. This study was conducted to determine the heavy metal speciation and the influence of changing the physico-chemical properties of the medium in the course of composting on the concentrations, bioavailability or chemical forms of Cu, Zn, Pb and Ni in sewage sludge. Principal physical and chemical properties and FTIR spectroscopical characterization of sludge compost during treatment show the stability and maturity of end product. The total metal contents in the final compost were much lower than the limit values of composts to be used as good soil fertilizer. Furthermore, it was observed by using a sequential extraction procedure in sludge compost at different steps of treatment, that a large proportion of the heavy metals were associated to the residual fraction (70-80%) and more resistant fractions to extraction X-NaOH, X-EDTA, X-HNO3 (12-29%). Less than 2% of metals bound to bioavailable fractions X-(KNO3+H2O). Heavy metal distribution and bioavailability show some changes during composting depending on the metal itself and the physico-chemical properties of the medium. Bioavailable fractions of all elements tend to decrease except Ni-H2O. Zn and mainly Cu present more affinity to organic and carbonate fractions. In contrast, Pb is usually preferentially bound to sulfide forms X-HNO3. Nickel shows a significant decrease of organic form. Significant degrees of correlation were found between heavy metal fractions and changes of some selected variables (e.g. pH, ash, organic matter, humic substance) during the course of composting. Mobile fractions of metals are poorly predictable from the total content. The R2 value was significantly increased by the inclusion of other variables such as the amount of organic matter (OM) and pH. 相似文献
The effects of incorporating a synthetic zeolite (Zeolite P) in a range of concentrations (0.1-1.0 w:w) into an experimental horticultural compost, derived from sewage sludge, have been investigated. The impact of zeolite treatment on time-related changes of the labile zinc, copper, iron and manganese pools within the compost was compared to lime incorporation (5% w:w) and to a proprietary unamended peat-based compost. Addition of 0.5% and 1.0% zeolite significantly reduced labile zinc over a 90 day period. The highest zeolite treatment was more effective than liming; 0.5% zeolite was as effective as lime. Plant growth trials measuring transfer of metals to ryegrass (Lolium perenne L. cv Elka) in successive harvests demonstrated that both 1.0% zeolite and 5% lime treatment caused significant reduction in total metal transfer from soil-plant over a 116 day growth period. It is concluded that the use of synthetic zeolite as an amendment for compost of this type significantly reduces potential for soil metal mobility and soil-plant transfer. 相似文献
The contents of heavy metals and their bioavailability to the soil-plant system were the major limitation to the application of sewage sludge compost in soil. This study was conducted to determine the evolution of heavy metal speciation in the course of an aerobic composting, and investigate the influence of changes of composting process parameters including pH, temperature and organic matter (OM) content on distribution of heavy metal speciation in composted sludge. The sequential extraction procedure developed by Tessier et al. was used in sludge compost to determine the heavy metal speciation. Results showed that, during composting, (1) the contents of the residue fraction for Pb, Zn and Cd were decreased but those for Ni and Cr were increased; the Cu residue fraction was almost constant; (2) the contents of the total mobile fractions (including fractions 1-4) for Zn and Pb were significantly increased, but the increase of those for Cu and Ni were not so remarkable; (3) there were significant degrees of correlation between heavy metal fractions and changes of some selected parameters (for example, pH, composting temperature, and OM content). Only the content of the total mobile fractions for Cu could be predictable from its total content. For the prediction of the total mobile fractions of Zn, Ni, Cd and Cr, the R(2) value was significantly increased by the inclusion of other variables such as pH, temperature and OM content. 相似文献
Use of sewage sludge, a biological residue produced from sewage treatment processes in agriculture is an alternative disposal technique of waste. To study the usefulness of sewage sludge amendment for palak (Beta vulgaris var. Allgreen H-1), a leafy vegetable and consequent heavy metal contamination, a pot experiment was conducted by mixing sewage sludge at 20% and 40% (w/w) amendment ratios to the agricultural soil. Soil pH decreased whereas electrical conductance, organic carbon, total N, available P and exchangeable Na, K and Ca increased in soil amended with sewage sludge in comparison to unamended soil. Sewage sludge amendment led to significant increase in Pb, Cr, Cd, Cu, Zn and Ni concentrations of soil. Cd concentration in soil was found above the Indian permissible limit in soil at both the amendment ratios.
The increased concentration of heavy metals in soil due to sewage sludge amendment led to increases in heavy metal uptake and shoot and root concentrations of Ni, Cd, Cu, Cr, Pb and Zn in plants as compared to those grown on unamended soil. Accumulation was more in roots than shoots for most of the heavy metals. Concentrations of Cd, Ni and Zn were more than the permissible limits of Indian standard in the edible portion of palak grown on different sewage sludge amendments ratios. Sewage sludge amendment in soil decreased root length, leaf area and root biomass of palak at both the amendment ratios, whereas shoot biomass and yield decreased significantly at 40% sludge amendment. Rate of photosynthesis, stomatal conductance and chlorophyll content decreased whereas lipid peroxidation, peroxidase activity and protein and proline contents, increased in plants grown in sewage sludge-amended soil as compared to those grown in unamended soil.
The study clearly shows that increase in heavy metal concentration in foliage of plants grown in sewage sludge-amended soil caused unfavorable changes in physiological and biochemical characteristics of plants leading to reductions in morphological characteristics, biomass accumulation and yield. The study concludes that sewage sludge amendment in soil for growing palak may not be a good option due to risk of contamination of Cd, Ni and Zn and also due to lowering of yield at higher mixing ratio. 相似文献
Background, aim, and scope Composting is an effective treatment process to realize sludge land application. However, nitrogen loss could result in the
reduction of nutrient value of the compost products and the stabilization effect of composting on heavy metal concentration
and mobility in sludge has been shown to be very limited.
Materials and methods Laboratory-scale experiments were carried out to investigate the effects of bamboo charcoal (BC) on nitrogen conservation
and mobility of Cu and Zn during sludge composting.
Results The result indicated that the incorporation of BC into the sludge composting material could significantly reduce nitrogen
loss. With 9% BC amendment, total nitrogen loss at the end of composting decreased 64.1% compared with no BC amendment (control
treatment). Mobility of Cu and Zn in the sludge may also have been lessened, based on the decline in diethylenetriaminepentaacetic
acid-extractable Cu and Zn contents of composted sludge by 44.4% and 19.3%, respectively, compared to metal extractability
in the original material.
Discussion Ammonia adsorption capability of BC might be the main reason for the retention of nitrogen in sludge composting materials.
Decrease of extractable Cu2+ and Zn2+ in the composting material mainly resulted from the adsorption of both metals by BC.
Conclusions Incorporation of BC into composting material could significantly lessen the total nitrogen loss during sludge composting.
Mobility of heavy metals in the sludge composting material could also be reduced by the addition of BC.
Recommendations and perspectives Bamboo charcoal could be an effective amendment for nitrogen conservation and heavy metal stabilization in sludge composts.
Further research into the effect of BC-amended sludge compost material on soil properties, bioavailability of heavy metals,
and nutrient turnover in soil needs to be carried out prior to the application of BC-sludge compost in agriculture. 相似文献
Soluble salts are enriched in sewage sludge compost because of their inherent derivation. Accordingly, the content of soluble salt in sludge compost is usually much higher than most seedlings can tolerate. To determine whether sludge compost is suitable for use as a nursery substrate, some experiments were conducted. Reduction of the electrical conductivity (EC) value could improve seed germination in saturated extract from sludge compost. In addition, water elution and mixing dilution with raw soil were all shown to be able to alleviate saline inhibition on seed germination and seedling growth, including stem diameter, seedling height, and above-ground weight. Overall, salinity is a crucial problem when sewage sludge compost is reused as a nursery substrate, and some effective and convenient approaches to reduce salt should be served prior to its reuse.
Implications: Sewage sludge after being composted is usually reused as organic fertilizer or plant substrate. However, salt is the main problem during its reclamation. What is the highest salt level the seedling can tolerate? Which types of salts are effective in salinity of sludge-amended substrate? Meanwhile, can the salinity be reduced through water elution or soil mixing dilution? This paper is the first to investigate the salinity and its reduction of sewage sludge compost prior to its use in the development of nursery substrate.相似文献
The environmental impact of sewage sludges depends on the availability and phytotoxicity of their heavy metal. The influence of representative sludges (dewatered anaerobic, pelletization, and composted sludge) on the availability of heavy metals, and their effects on seed germination were compared. The total heavy metal concentrations were below the maximum permitted for land-applied waste and the differences among them were small. The DTPA-extracted metal concentrations were rather different. The sequential extraction of the compost showed a slight increase in Cd and Cu availability, and a decrease in the availability of Fe, Mn, Ni and Zn. Pelletization increased the availability of Ni and slightly reduced that of Cr. The dewatering sludge led to greater availability of Cr and Mn but reduced the concentration of Cd. The three different sludges also affected seed germination and root elongation in different ways. The most serious adverse effects were caused by the dewatered sludge extract. 相似文献
High values of pH may represent a limitation for the agricultural use of the composts, not only when used as soil-less substrate but also as soil amendment in high pH soils. The addition of elemental S during the maturation phase of the composting process was evaluated as suitable method to reduce pH of the composts under the organic agriculture regulations. A compost prepared with two phase olive mill waste (OMW) and sheep litter (SL) was used to study the effect of elemental sulphur addition on the pH of the composting mixture. Initially, different bench scale experiments were designed in order to study the influence of moisture, sulphur concentration, and incubation temperature on the sulphur oxidation rate and thus on the pH of the compost. A concentration of 0.5% in sulphur (dry weight basis) and moisture of 40% were proposed as the optimum conditions to decrease the compost pH by 1.1 units without increasing in EC to levels that may suppose a limitation for its agricultural use. Finally, these optimum experimental conditions found at bench scale were tested at full scale in a commercial composting plant treating the same organic materials by windrowing. The pH values of the composting mixture were reduced by one unit after 2 weeks following the addition of elemental S causing no negative effects on the final compost quality. 相似文献
The potential of composting and aeration to remove bis(2-ethylhexyl) phthalate (DEHP) from municipal sewage sludge was studied with two dewatered sludges: raw sludge and anaerobically digested sludge. Composting removed 58% of the DEHP content of the raw sludge and 34% of that of the anaerobically digested sludge during 85 days stabilisation in compost bins. A similar removal for the anaerobically digested sludge was achieved in a rotary drum in 28 days. Less than 1% of DEHP was removed with the compost leachate. Although DEHP removal was greater from raw sludge compost than anaerobically digested sludge compost, the total and volatile solids removals were on the same level in the two composts. In the aeration of raw sludge at 20 degrees C the DEHP removals were 33-41% and 50-62% in 7 and 28 days, respectively. Both composting and aeration are concluded to have the potential to reduce the DEHP contents typically found in sewage sludges to levels acceptable for agricultural use. 相似文献
Two crops of Brassica juncea (L.) Czern. were grown in a field experiment, at the site affected by the toxic spillage of acidic, metal-rich waste in Aznalcóllar (Seville, Spain), to study its metal accumulation and the feasibility of its use for metal phytoextraction. The effects of organic soil amendments (cow manure and mature compost) and lime on biomass production and plant survival were also assessed; plots without organic amendment and without lime were used as controls. Plots, with or without organic amendment, having pH < 5 were limed for the second crop. Soil acidification conditioned plant growth and metal accumulation. The addition of lime and the organic amendments achieved higher plant biomass production, although effects concerning metal bioavailability and accumulation were masked somewhat by pH variability with time and between and within plots. Tissue metal concentrations of B. juncea were elevated for Zn, Cu and Pb, especially in leaves of plants from plots with low pH values (maxima of 2029, 71 and 55 microg g(-1), respectively). The total uptake of heavy metals in the plants was relatively low, emphasising the problems faced when attempting to employ phytoextraction for clean-up of pluri-contaminated sites. 相似文献
This study examined the use of two composts derived from green waste and sewage sludge, amended with minerals (clinoptilolite or bentonite), for the remediation of metal-contaminated brownfield sites to transform them into greenspace. Soils contaminated with high or low levels of metals were mixed with the mineral-enhanced composts at different ratios and assessed by leaching tests, biomass production and metal accumulation of ryegrass (Lolium perenne L.). The results showed that the green waste compost reduced the leaching of Cd and Zn up to 48% whereas the composted sewage sludge doubled the leachate concentration of Zn. However, the same soil amended with composted sewage sludge showed an efficient reduction in plant concentrations of Cd, Cu, Pb or Zn by up to 80%. The results suggest that metal immobilisation and bioavailability are governed by the formation of complexes between the metals and organic matter. The amendment with minerals had only limited effects. 相似文献
When sewage sludge is incorrectly applied, it may adversely impact agro-system productivity. Thus, this study addresses the reaction of Cucumis sativus L. (cucumber) to different amendment rates (0, 10, 20, 30, 40 and 50 g kg?1) of sewage sludge in a greenhouse pot experiment, in which the plant growth, heavy metal uptake and biomass were evaluated. A randomized complete block design with six treatments and six replications was used as the experimental design. The soil electrical conductivity, organic matter and Cr, Fe, Zn and Ni concentrations increased, but the soil pH decreased in response to the sewage sludge applications. As approved by the Council of European Communities, all of the heavy metal concentrations in the sewage sludge were less than the permitted limit for applying sewage sludge to land. Generally, applications of sewage sludge of up to 40 g kg?1 resulted in a considerable increase in all of the morphometric parameters and biomass of cucumbers in contrast to plants grown on the control soil. Nevertheless, the cucumber shoot height; root length; number of leaves, internodes and fruits; leaf area; absolute growth rate and biomass decreased in response to 50 g kg?1 of sewage sludge. All of the heavy metal concentrations (except the Cu, Zn and Ni in the roots, Mn in the fruits and Pb in the stems) in different cucumber tissues increased with increasing sewage sludge application rates. However, all of the heavy metal concentrations (except the Cr and Fe in the roots, Fe in the leaves and Cu in the fruits) were within the normal range and did not reach phytotoxic levels. A characteristic of these cucumbers was that all of the heavy metals had a bioaccumulation factor <1.0. All of the heavy metals (except Cd, Cu and Zn) had translocation factors that were <1.0. As a result, the sewage sludge used in this study could be considered for use as a fertilizer in cucumber production systems in Saudi Arabia and can also serve as a substitute method of sewage sludge disposal.
The effects of different sewage sludge amendment rates on the heavy metal bioaccumulation, growth and biomass of cucumbers