蒽醌染料中间体催化强化偶氮染料生物脱色

考察了醌还原菌群利用6种蒽醌染料中间体对偶氮染料生物脱色的催化强化作用.结果表明,溴氨酸(1-氨基-4-溴蒽醌-2-磺酸, BAA)的催化强化效果最好;游离态菌群以BAA作为氧化还原介体可催化强化多种偶氮染料的生物脱色,其中对酸性大红3R脱色的适宜条件为pH 6～9之间;外加葡萄糖浓度400～600 mg/L;BAA浓度19～34.2 mg/L,染料起始浓度≤900 mg/L.在此条件下,最大脱色率约为95%、达到最大脱色率的时间<7 h.同时发现,投加氧化还原介体BAA浓度为38～57mg/L时,固定化菌群降解酸性大红3R(180 mg/L)的最大脱色率在14 h内达到93%;在不补加BAA的情况下,固定化菌群经7次循环使用后,脱色率仍保持在85%以上.     

醌化合物强化偶氮染料的生物脱色

考察了醌还原菌群利用氧化还原介质对偶氮染料脱色的强化作用.结果表明,该菌群以AQDS(2,6-二磺酸蒽醌)作为氧化还原介质可强化多种偶氮染料的生物脱色,其中,对活性艳红KE-3B脱色的适宜条件为pH6～9;外加葡萄糖浓度0.05%～0.10%;AQDS浓度10～100mg/L;染料起始浓度≤600mg/L.在此条件下,最大脱色率约为90%,达到最大脱色率的时间<18h.该菌群能以多种蒽醌染料中间体作为氧化还原介质强化偶氮染料活性艳红KE-3B的生物脱色.     

固定化蒽醌对偶氮染料生物降解促进作用研究

采用非水溶性蒽醌固定化技术对偶氮染料生物降解促进作用进行了研究,对比了海藻酸钙,聚乙烯醇-硼酸,聚乙烯醇-海藻酸钙和琼脂4种固定化技术,探讨了溶解氧对脱色过程的影响和固定化蒽醌系统脱色广谱性.研究结果表明,固定化蒽醌可提高多种偶氮染料生物厌氧脱色速度1.5～2倍和降低偶氮染料脱色过程氧化还原电位-10～-15 mV;经4次循环使用后,其加速作用仍保持在90%以上;固定化蒽醌微生物系统具有很强抗氧冲击能力.     

氧化还原介体厌氧催化酸性红B生物脱色研究

研究了筛选出的四种结构相似的醌类氧化还原介体对酸性红B厌氧脱色的促进作用,并以催化效果最佳的蒽醌-2-磺酸钠为醌介体模型,探讨了醌介体催化酸性红B厌氧生物降解路径。在35℃中温厌氧条件下,采用间歇批量实验法,测定不同体系中醌介体催化酸性红B脱色效果。结果表明:①在酸性红B浓度为150mg·L-1,醌介体浓度为0.16mmol/L,反应时间为4h时,结构相似的四种醌介体均可促进酸性红B脱色,反应效率提高了1.6².4倍,其大小顺序为AQS>2,7-AQDS>AQDS>α-AQS;②AQS在催化酸性红B降解过程中与传统厌氧微生物降解路径保持一致。     

高盐条件下染料酸性橙7的生物降解特性

对偶氮染料废水厌氧-好氧生物处理中的高盐度抑制生物活性和芳香胺自氧化问题,通过多种强化策略,考察了NaCl为100g/L时酸性橙7(AO7)的生物降解特性.结果表明,加入葡萄糖(0.5g/L)、蛋白胨(1g/L)和酵母粉(0.5g/L)有利于高盐条件下AO7的生物降解.进水中加入酸性红B对AO7的脱色有加速作用.耐盐污泥中加入蒽醌形成的蒽醌-污泥自固定化体系可以促进AO7脱色,当蒽醌浓度为100mg/L时,AO7最大脱色率约为92%.以活性炭毡作为生物载体,厌氧和好氧体系均可实现稳定运行,且体系污泥沉降性良好,脱色速率达26.67mg/(L×h),且可有效抑制脱色中间产物1-氨基-2-萘酚的好氧自氧化,使COD去除率始终保持在90%以上.     

醌还原酶 醌类化合物对偶氮染料脱色的作用

外加醌类化合物作介体,利用细菌胞内的醌还原酶考察基因工程菌Escherichia coli YB对偶氮染料的脱色能力,以及甲基氢醌预处理对E. coli JM109和厌氧污泥脱色的影响.结果表明,介体2羟基1,4萘醌（lawsone,LQ）的存在对胞内过量表达醌还原酶AZR的E. coli YB的脱色能力有显著的促进作用,0.2 mmol·L^-1 LQ存在下,苋菜红（1 mmol·L^-1）在2 h内可脱色75%.LQ存在时E. coli YB对高浓度的染料也有脱色效果,8 h可使苋菜红（5 mmol·L^-1）脱色50%左右.与LQ相比,甲萘醌作为介体对脱色的促进效果较差,2.5 mmol·L^-1甲萘醌存在下脱色70%需12 h.LQ存在时E. coli YB对苋菜红的重复脱色能力稳定,12 h内能完成4次重复脱色.LQ的存在对于结构较复杂的2种偶氮染料酸性大红GR和活性艳红K2BP的脱色也有促进作用,在最适LQ浓度下,分别在9 h和30 h脱色70%.甲基氢醌预处理对E. coli JM109和厌氧污泥的脱色能力都有促进作用.预处理后在LQ存在下,E. coli JM109在5 h可脱色苋菜红（1 mmol·L^-1）80%左右,而污泥可在11 h脱色75%以上.     

醌基修饰PVA海绵的制备、表征及加速偶氮染料生物脱色研究

非水溶性氧化还原介体催化强化污染物降解是目前环境领域研究的热点,通过合成实验开发出醌基功能基团接枝聚乙烯醇海绵(PVA)载体,从而制备出含有醌基的高分子介体材料,并进行偶氮染料生物降解研究.醌基修饰PVA海绵中醌基含量是0.08 mmol·g-1,其中最佳胺化时间为6 h,最佳胺化温度是30℃,最佳接醌时间是2 h,最佳接醌温度为40℃.通过元素分析与扫描电镜表明醌基基团已经成功固定到PVA表面.合成的以PVA为载体的醌基高分子介体材料对偶氮染料进行生物降解,实验表明醌基修饰PVA具有高效的催化活性和良好的催化稳定性.多次循环使用后仍能保持较高的生物脱色催化性能,使得其在水污染处理方面具有良好的实际应用前景.     

低强度超声对醌介导偶氮染料脱色的影响

厌氧条件下,微生物的代谢速率很缓慢。而低强度超声辐照则可以有效促进微生物的活性,进而增强生化反应速率。基于此,文章采用低强度超声预处理耐盐醌还原菌群,研究在富盐环境下其对醌介导偶氮染料的厌氧生物脱色速率的影响。研究结果表明,低强度超声(辐射频率40 kHz)处理耐盐醌还原菌群的最佳条件为超声强度0.15 W/cm2,超声时间3 min。在50 g/L NaCl存在条件下,处理后的耐盐醌还原菌群能够使蒽醌-2-磺酸钠、蒽醌-2,6-二磺酸钠、2-羟基-1,4-萘醌和2-甲基-1,4-萘醌介导的偶氮染料酸性大红3R脱色速率分别提高8.8%,23.0%,4.2%及20.4%。通过透射电镜分析推测,低强度超声可能是通过增大生物细胞壁的比表面积来提高其传质能力,从而提高醌介导的偶氮染料脱色速率。     

直接大红4BE的磷钨酸均相光催化还原脱色

以磷钨酸(H3PW12O40,PW12)为光催化剂,异丙醇(Isopropanol)作为电子给体的条件下对偶氮染料直接大红4BE进行均相光催化还原脱色研究,考察PW12用量、IS浓度、直接大红4BE和盐浓度等因素的影响,结果表明杂多蓝(PW1-2)对直接大红4BE具有明显的还原脱色作用.pH=2.0,直接大红4BE初始浓度50 mg·L-1,PW12浓度为600 mg·L-1,IS浓度为0.13mol·L-1,50 min直接大红4BE的脱色率可达到90.39%.4BE的光催化还原脱色速率随PW12和IS浓度的增加而增加,最后趋于恒定;直接大红4BE初始浓度增加,其光反应一级速率常数降低;PW12、IS和4BE浓度之间存在交互影响.离子强度增加,4BE脱色速率减小,表现为负的盐效应,推测4BE与光反应生成的杂多蓝(PW1-2)进行复合,然后发生电子转移引起偶氮染料还原脱色和杂多蓝氧化复原.本研究结果表明PW12/IS/UV能够有效用于偶氮染料直接大红4BE的还原脱色处理.     

偶氮染料循环伏安行为和生物厌氧脱色相关性研究

对4种结构相似偶氮染料的循环伏安特性研究及其生物厌氧脱色速率实验,结果表明,所选结构相似染料的生物脱色速率最快的是酸性黄-Bis(E_r=-616.75 mV),速率为0.012 09 mol·(L·h)^-1,依次是酸性黄-11[E_r=-593.25 mV,0.010 40mol·(L·h)^-1],酸性黄-4[E_r=-513 mV,0.007 575 mol·(L·h)^-1],且脱色速率与其循环伏安图中的还原峰电位间存在线性关系.研究还表明,电化学方法在一定程度上可对生物体系发生生化反应进行部分模拟和预测.     

Biodegradation of azo dyes by genetically engineered azoreductase

A azoreductase gene with 537 bp was obtained by PCR amplification from Rhodobacter sphaeroides ASI. 1737. The enzyme,with a molecular weight of 18.7 kD, was efficiently expressed in Escherichia coli and its biodegradation characteristics for azo dyes were investigated. Furthermore, the reaction kinetics and mechanism of azo dyes catalyzed by the genetically engineered azoreductase were studied in detail. The presence of a hydrazo-intermediate was identified, which provided a convincing evidence for the assumption that azo dyes were degraded via an incomplete reduction stage.     

藻类对偶氮染料的降解及定量结构-生物降解性研究

通过研究普通小球藻（ Chlorella vulgaris） 、蛋白核小球藻（Chlorella pyrenoidosa） 、斜生栅藻（Scenedes nusobliquus） 对偶氮染料的降解作用,筛选出优势藻种并优化降解条件;对单偶氮染料进行了定量结构—生物降解性相关关系（QSBR） 研究．3 种藻均能利用偶氮染料为其生长的唯一 C、 N 源,使染料脱色,蛋白核小球藻具有更强的脱色能力;且藻在无 N 环境中的脱色率明显高于无 C 和正常环境;pH 值对染料脱色影响较大,最佳pH值为中性;不同结构的单偶氮染料生物降解性相差很大,脱色率为9.1 ％ （89.9 ％ , QSBR 研究表明, 偶氮键的最低未占据轨道能量是控制生物降解的主要因素,而脱色率与染料的分子量无关．     

Continuous treatment of azo acid dyes by photo-dependent denitrifying sludge

Simultaneous removals of dye and nitrate by photo-dependent denitrifying sludge(PDDS)have been demonstrated in a continuousflow bench-scale reactor.The best C/N for the degradation of azo dyes by PDDS was 1.5.The specific removal rate of azo dye AB92 decreased with a decrease in hydraulic retention time and increased with a decrease in solids retention time.The degradation rate of TOC decreased with a decrease in hydraulic retention time.AB92,which has nitro and hydroxyl substitutions in non-para positions,was uniquely degraded.During continuous flow treatment experiments using PDDS,complete degradation of azo dyes AB92 and AO20 at influent concentrations of 40mg/L and 30mg/L,respectively,was achieved with an HRT of 16.     

Decolorization and bio degradation metabolism of azo dyes by Pseudomonas S-42

A bacterial strain was isolated from activated sludge and has been identified as Pseudomonas sp. S-42 capable of decolorizing azo dyes such as Diamira Brilliant Orange RR (DBO-RR), Direct Brown M (DBM), Eriochrome Brown R (EBR) and so on. The growing cells, intact cells, cell-free extract and purified enzyme of strain S-42 could decolorize azo dyes under similar conditions at the optimum pH 7.0 and temperature of 37℃. The efficiencies of decolorization for DBO-RR, DBM, EBR with intact cells stood more than 90%. When the cell concentration was 15mg (wet)/ml and the reaction time was 5 hours, the decolorizing activities of intact cells for above three azo dyes were 1.75, 2.4, 0.95 μg dye/mg cell, respectively. Cell-free extract and purified enzyme belonged to azoreductase with molecular weight about 34000±2000 and Vmax and Km values for DBO-RR of 13μmol/mg protein/nun and 54μmol, respectively. The results from the detection of the biodegradation products of DBO-RR by spectrophotometric and NaNO2 reac     

Quinone-mediated decolorization of sulfonated azo dyes by cells and cell extracts from Sphingomonas xenophaga

The effects of various quinone compounds on the decolorization rates of sulfonated azo dyes by Sphingomonas xenophaga QYY were investigated. The results showed that anthraquinone-2-sulfonate (AQS) was the most effective redox mediator and AQS reduction was the rate-limited step of AQS-mediated decolorization of sulfonated azo dyes. Based on AQS biological toxicity tests, it was assumed that AQS might enter the cells to kill them. In the cytoplasmic extracts from strain QYY, AQS effectively increased decolorization rates of sulfonated azo dyes than other quinone compounds. In addition, we found a NADH/FMN-dependent AQS reductase using nondenaturing polyacrylamide gel electrophoresis (Native-PAGE).     

凹凸棒负载TiO2对偶氮染料和纺织废水光催化脱污

通过浸渍的方法 ,制备了天然粘土矿石凹凸棒负载的P2 5TiO2 固化催化剂 .实验了催化剂的负载量和煅烧温度对催化剂活性的影响 .研究了最佳固化催化剂对 5种生物难降解的偶氮染料和纺织废水的太阳光催化脱污 .结果证实该固定化催化剂能利用太阳能光催化脱污偶氮染料及毛纺织废水 ,而且具有高的稳定性 ,可重复使用     

Decolorization of azo dyes with high salt concentration by salt-tolerant mixed cultures under anaerobic conditions

Because the lack of detailed study of biological decolorization in high salt dye wastewater, it is still difficult to evaluate the biological treatment on high-salinity dye wastewater. The experiments were carried out to study the salt-tolerant bacteria, which is useful in the treatment of high-salinity colored wastewater. Simulated wastewater containing 5-150 g/L salt （NaCI） and 50-2000 mg/L Reactive Brilliant Red K-2BP was treated with three salt-tolerant mixed cultures （CAS, TAS, DSAS）, which were under a gradually acclimated procedure. With the increase of concentrations of salt and dye, the decolorization became low. The abilities of decolorization of dyes wastewater by three mixed cultures （CAS, TAS, DSAS） were studied, CAS and DSAS mixed cultures showed more active for the treatment of high-salinity colored wastewater than TAS mixed cultures. The results suggested that there might be a simple process for the high salt wastewater treatment, which could be incorporated into conventional activated sludge plants.