厌氧产氢ASBR对氮的脱除

在厌氧序批式人工有机污水生物产氢反应器（ASBR）中发现氮“丢失”现象,并对此产氢系统发生脱氮作用的机理和主要影响因素进行了研究。结果表明,在以葡萄糖为发酵底物的厌氧产氢系统中,微生物分别以铵和硫酸盐为电子供体和电子受体发生了硫酸盐型厌氧氨氧化;进水有机物负荷和pH主要通过影响不同种微生物的活性而影响脱氮性能,氨氮和硫酸盐的浓度直接与氮素去除率有关。在最大产氢能力为16m3／（m3·d）、氢气体积百分比为65％的生物制氢系统中,最大脱氮效率约为64％。产氢效率与氮脱除率呈现负相关关系。研究表明,在控制条件下,可以实现高有机物废水厌氧脱除氨态氮,为生活污水直接厌氧脱氮开辟一条新途径。     

厌氧产氢ASBR对氮的脱除

在厌氧序批式人工有机污水生物产氢反应器(ASBR)中发现氮"丢失"现象,并对此产氢系统发生脱氮作用的机理和主要影响因素进行了研究。结果表明,在以葡萄糖为发酵底物的厌氧产氢系统中,微生物分别以铵和硫酸盐为电子供体和电子受体发生了硫酸盐型厌氧氨氧化;进水有机物负荷和pH主要通过影响不同种微生物的活性而影响脱氮性能,氨氮和硫酸盐的浓度直接与氮素去除率有关。在最大产氢能力为16 m3/(m3·d)、氢气体积百分比为65%的生物制氢系统中,最大脱氮效率约为64%。产氢效率与氮脱除率呈现负相关关系。研究表明,在控制条件下,可以实现高有机物废水厌氧脱除氨态氮,为生活污水直接厌氧脱氮开辟一条新途径。     

高氯离子味精尾母液废水厌氧处理研究

味精尾母液废水COD浓度极高同时含有大最氯离子.采用UASB反应器对味精尾母液废水进行处理,其中接种污泥来自啤酒厂UASB反应器.实验表明:当氯离子浓度在4 500 mg/L以下时,对厌氧微生物没有明礁的抑制作用;5 000 mg/L的氯离子浓度可以看作一个抑制限值,但经过驯化后,仍可获得较好的COD去除效果;当氯离子浓度达到8 000mg/L左右时,COD平均去除率在80%以上.     

Removal of organic compounds during treating printing and dyeing wastewater of different process units

Wastewater in Shaoxing wastewater treatment plant (SWWTP) is composed of more than 90% dyeing and printing wastewater with high pH and sulfate. Through a combination process of anaerobic acidogenic [hydraulic retention time (HRT) of 15h], aerobic (HRT of 20h) and flocculation-precipitation, the total COD removal efficiency was up to 91%. But COD removal efficiency in anaerobic acidogenic unit was only 4%. As a comparison, the COD removal efficiency was up to 35% in the pilot-scale upflow anaerobic sludge bed (UASB) reactor (HRT of 15h). GC-MS analysis showed that the response abundance of these wastewater samples decreased with their removal of COD. A main component of the raw influent was long-chain n-alkanes. The final effluent of SWWTP had only four types of alkanes. After anaerobic unit at SWWTP, the mass percentage of total alkanes to total organic compounds was slightly decreased while its categories increased. But in the UASB, alkanes categories could be removed by 75%. Caffeine as a chemical marker could be detected only in the effluent of the aerobic process. Quantitative analysis was given. These results demonstrated that GC-MS analysis could provide an insight to the measurement of organic compounds removal.     

内循环(IC)厌氧反应器处理糖蜜酒精废水的研究

糖蜜酒精废水由于含有高浓度的COD和硫酸盐,一般厌氧反应器无法有效处理.研究了IC反应器处理糖蜜酒精废水的效果.考察其COD及硫酸盐的去除率、沼气的产量和组分等.结果表明,反应器对于COD为5000～10 000 mg/L的中、高浓度废水去除效果良好,当COD在20 000～30 000 mg/L时,在适应了1～2个停留时间后,去除效果达到稳定,去除率在90%左右.实验中最高容积负荷提升至40 kg COD/m3·d左右.本研究中所用的糖蜜酒精废水的COD/SO24-的平均值为61.9,未对反应器的处理效果及产气量产生影响.     

An anaerobic bioreactor allows the efficient degradation of HCH isomers in soil slurry

The insecticide gamma-hexachlorocyclohexane (gamma-HCH or lindane), which has been extensively used for agricultural and medical purposes, presents high persistence and toxicity to the environment and low solubility. This study intends to assess the efficiency of an anaerobic reactor to degrade HCH isomers contained in soil slurry cultures. This study was developed in two phases: experiments in flasks to optimize the process parameters, and assessment of the slurry process in the anaerobic slurry reactor operated for an approximate period of a year. The influence of different environmental conditions was evaluated: the HCH concentration (25-100 mg HCH kg-1), the type of substrate (volatile fatty acids or starch), the sludge concentration (2-8 g VSS l-1) and the replacement of spiked soil to simulate a fed-batch operation (10-50%). The best results were obtained when the reactor was operated with a sludge concentration of 8 g VSS l-1, starch concentration of 2 g COD l-1 and soil replacements of 10-20%. Under these conditions, alpha- and gamma-HCH were completely degraded after 10d while nearly 90% beta- and delta-HCH were removed only after 50 d. According to the obtained results related to the total degradation of the HCH isomers and the degradation rates, especially high for alpha- and gamma-HCH, the anaerobic slurry reactor appears to be a good alternative for the degradation of the HCH isomers present in polluted soil.     

厌氧-好氧接触氧化处理汽车脱脂废水研究

采用厌氧UASB-好氧接触氧化工艺对汽车脱脂废水进行连续处理实验研究。结果表明,在脱脂废水进水COD浓度为6 000 mg/L,厌氧水力停留时间为3.4 d,好氧水力停留时间为2.5 d条件下,COD总去除率平均为93%,厌氧段平均值为38%。厌氧段可以提高出水的可生化性,厌氧-好氧接触氧化工艺效果要明显优于好氧工艺。     

ICSTD反应器处理污泥的启动试验研究

新型内循环污泥浓缩消化反应器（ICSTD）处理污泥的启动运行试验采用某污水处理厂二沉池好氧活性污泥进行驯化培养,使反应器正常启动运行。在日处理量为50 L/d,进泥含水率为99.23％～99.46％,进泥VS/TS为0.65～0.73,进泥COD为4 115～5 780 mg/L,反应器容积负荷为1.31 kg COD/(m³·d)时,排泥含水率在96.2％～97.3％,排泥VS/TS为0.48～0.57,COD去除率在95％以上,出水pH在6.6～7.1,且上清液澄清。试验结果表明： ICSTD反应器处理污泥的启动试验,采用直接培养污泥启动的方式培养厌氧污泥历时66 d,能较快地培养厌氧污泥且运行稳定,对污泥的浓缩消化起到较好的作用,同时对反应器后续运行的消化效果提供了一个良好的条件。     

微米级负载型TiO2催化剂在光催化-膜分离反应器中的应用

基于光催化．膜分离三相流化床反应器的结构特点及膜分离特性,以微米级MCM-41分子筛为载体,采用原位生成法制备微米级负载型TiO2催化剂。针对微米级负载型TiO2催化剂在光催化一膜分离反应器中的分布特性、悬浮特性、分离特性及膜污染特性进行研究。结果表明,曝气量一定的情况下,微米级负载型TiO2催化剂在光催化一膜分离反应器中具有良好的悬浮特性,且优于纳米TiO2。随着催化剂投加量的增加,悬浮浓度也随之增加。光催化反应器底部曝气0．3m。／h、催化剂投加量为1g／L时为宜。膜分离器中催化剂悬浮浓度明显低于光催化反应器;该微米级催化剂与纳米TiO2相比具有不粘附、不堵塞膜孔等优良特性,能够有效降低膜污染,延长分离膜使用寿命。膜底曝气为0．1m3／h时,反应器连续运行5h（未加反冲洗）后,微米级负载型TiO2催化剂和纳米TiO2对膜组件的污染程度分别为膜通量衰减率4．3％和37．4％。反应器连续运行72h,膜组件依然具有很好的分离特性。     

The negative rejection of H+ in NF of carbonate solution and its influences on membrane performance

Nanofiltration (NF) experiments were conducted with simulated solution containing bicarbonate hardness and with three membranes: NF90, NF270 and NF-. The operating pressure was kept at 1.0 MPa, the water sample temperature was kept at 25 degrees C, the velocity on membrane surface was approximately 1 m s(-1) and the feeding pH values were 6.0, 6.5, 7.0, 7.5 and 8.0. Except for sampling, both the concentrate and the permeate were cycled to the feeding tank in order to keep the concentration constant. Experimental results demonstrated that the flux of NF90 membrane was slightly affected by the feeding pH, while the flux of NF270 and NF membranes was augmented when the feeding was acidified. The permeate pH of each membrane was always lower than the concentrate pH, indicating that the H(+) was negative rejected. This phenomenon was observed not only in the filtration of carbonate solution, but also in the filtration of the NaCl solution and the tap water. It is assumed that the small positive H(+) can easily permeate the NF membranes having negative charges. The more charges the membrane has, the more H(+) is negative rejected. High permeability of H(+) can speed decomposition of HCO(3)(-) into CO(3)(2-) and then accelerate CaCO(3) crystallization on membrane surface, which is unfavorable for membrane performances. In NF processes, it is better to considerate the membrane's selection and the feeding's pretreatment simultaneously, and it is beneficial for preventing scaling when selecting the membranes with less negative charges if only the water qualify can meet the demands.     

基因工程菌厌氧膜生物反应器中膜污染的研究

应用基因工程菌Escherichia coli JM109与厌氧管式膜生物反应器结合,处理模拟染料废水。利用膜截留防止Escherichia coli JM109流失,厌氧膜生物反应器中Escherichia coli JM109可以达到20 g/L左右。在高菌体浓度下,测定了管式膜截留高浓度基因工程菌的临界通量,描述了在低于和高于临界通量条件下透膜压力(TMP)变化情况。考察了错流速度对膜污染的影响。分析了基因工程菌的胞外聚合物(EPS)代谢特性,试验结果为特殊菌与膜过程结合提供了膜污染控制的借鉴。     

Biodegradation of catechol (2-hydroxy phenol) bearing wastewater in an UASB reactor

The present study deals with the biodegradation of catechol through co-metabolism with glucose in aqueous solution as primary substrate in an upflow anaerobic sludge blanket (UASB) reactor. Batch studies indicated that the 1000mgl(-1) glucose concentration was sufficient to cometabolize and degrade catechol in an aqueous solution up to a concentration of 1000mgl(-1). The reactor operated at 35+/-2 degrees C, and at a constant hydraulic retention time of 8h with a gradual stepwise increase in catechol concentration from 100 to 1000mgl(-1) along with glucose as a cosubstrate. The results showed that the catechol was successfully mineralized in an UASB reactor in which microbial granulation was achieved with only glucose as the substrate. The reactor showed > or = 95% COD removal efficiency with 500-1000mgl(-1)catechol concentration in the feed and a glucose concentration of 1500mgl(-1) as a cosubstrate. Similar efficiency was obtained at a constant catechol concentration of 1000mgl(-1) with 500-1000mgl(-1) glucose concentration. Once the reactor got acclimatized with catechol, higher concentrations of catechol can be mineralized with a minimum amount of glucose as the cosubstrate without affecting the performance of the UASB reactor.     

Biological solubilization and mineralization as novel approach for the pretreatment of food waste

The performance of a garbage disposal system to solubilize and mineralize food wastes through biological solubilization was evaluated through the examination of the effects of operational conditions like water supply volume, water supply frequency and aeration on the amount of waste solubilized, mineralized and accumulated in the reactor. The biological solubilization process consisted of a solubilization reactor and a circulation tank. Food waste and fresh water were supplied into the solubilization reactor with support media. Wastewater from the solubilization reactor was discharged to the circulation tank and water in the circulation tank was periodically pumped back to the solubilization reactor. In case of the total food waste loading of 16 kg m(3-1) d(-1), little carbon (0-5.7%) accumulated in the reactor as long as the system was kept under aerobic condition through large volume of water supply (higher than 3.5 lh(-1)) or applying aeration in the circulation tank. However, 42% of the loaded carbon accumulated under anaerobic condition in low water supply (less than 1.8 lh(-1)). The rest of the waste was either solubilized or mineralized. The aeration in the circulation tank, therefore, was effective to provide similar solubilization and mineralization as the large volume of water supply. However, frequency of feeding at the large volume of water supply had no significant effect on the amount of waste solubilization and mineralization.     

Ca2+对上流式多级厌氧反应器处理蔗渣渗滤液的影响

研究了上流式多级厌氧反应器(UMAR)处理蔗渣渗滤液过程中Ca2+浓度对反应器运行特性和颗粒污泥性质的影响。结果表明,对于蔗渣渗滤液而言,进水中低浓度的Ca2+浓度(80～300 mg/L)对颗粒污泥产甲烷活性无抑制,COD去除率最高可达93.3%;Ca2+浓度达到500 mg/L以上时,对厌氧颗粒污泥的活性有抑制作用;随着Ca2+浓度进一步升高,抑制作用加强,污泥灰分明显升高,活性成分下降,COD去除效率明显降低,污泥粘结沉积在反应器底部,导致系统内循环出现障碍。因此,在实际生产中应减少废水中Ca2+的引入量。     

中试螺旋式自循环厌氧反应器处理安乃近制药废水的稳定性能

以制药废水实验了50m3螺旋式厌氧反应器（SPAC反应器）的稳定性。采用AugmentedDickey—Fuller（ADF）单位根检验表明,螺旋式反应器具有良好的启动和运行稳定性。负荷冲击实验显示,SPAC反应器具有较好的耐浓度冲击能力和耐水力冲击能力,所能耐受的最大浓度冲击强度大于60000（mg·h）／L（进水浓度提升2倍）,所能耐受的最大水力冲击强度为300（m3·h）／d（进水流量提升50％）。SPAC反应器还具备受扰恢复能力。在反应液pH低于5．74,出水浓度、COD去除率和容积COD去除速率（VRR）分别为3500mg／L、22．30％和2．52kg／（m3·d）的工况下,经过30d恢复,出水浓度、COD去除率和VRR的恢复程度达到80％～90％。     

内循环厌氧反应器的启动及影响因素

采用内循环(IC)厌氧反应器,以生产淀粉和酒精的混合废水为处理对象,研究了中温条件下IC反应器的启动及影响因素。结果表明:接种厌氧消化污泥进行培养,逐渐提高进水有机负荷,运行105 d后,可实现IC反应器的启动;当进水COD浓度为11 500 mg/L,有机容积负荷为6.13 kg COD/(m3·d),COD去除率能到达95%左右;水力停留时间对启动过程没有影响,而温度和温度波动影响COD去除率;VFA比pH更能准确快速地反眏出反应器内部环境的变化,防止反应器的酸化;反应器内污泥实现颗粒化,并且具有良好的沉降性。     

两相厌氧流化床中优势菌种降解硝基苯废水的特性

构建了从强化传质与优势菌相结合的两相厌氧流化床生物降解体系,考察了水力停留时间(HRT)与上流速度2种水力特征以及共基质、pH、进水浓度等主要过程因素对优势菌种降解硝基苯的影响.结果显示,反应器在HRT为36h、上流速度为4 m/h时获得较好的处理效果;菌种需要pH 7.5的条件下以葡萄糖为共基质降解硝基苯,且两者的最佳质量比约为6;当进水硝基苯浓度为50～345 mg/L时,对硝基苯平均降解率和降解速率分别达到91.1%和120.9 mg/(L·d),且可耐受2.5倍以内的浓度负荷冲击.由此表明良好的反应器水力条件及优势菌种的结合可使高毒性的硝基苯在厌氧条件下有效地降解.     

Performance of CSTR–EGSB–SBR system for treating sulfate-rich cellulosic ethanol wastewater and microbial community analysis

Performance and microbial community composition were evaluated in a two-phase anaerobic and aerobic system treating sulfate-rich cellulosic ethanol wastewater (CEW). The system was operated at five different chemical oxygen demand (COD)/SO₄ ²⁻ ratios (63.8, 26.3, 17.8, 13.7, and 10.7). Stable performance was obtained for total COD removal efficiency (94.5%), sulfate removal (89.3%), and methane production rate (11.5 L/day) at an organic loading rate of 32.4 kg COD/(m³·day). The acidogenic reactor made a positive contribution to net VFAs production (2318.1 mg/L) and sulfate removal (60.9%). Acidogenic bacteria (Megasphaera, Parabacteroides, unclassified Ruminococcaceae spp., and Prevotella) and sulfate-reducing bacteria (Butyrivibrio, Megasphaera) were rich in the acidogenic reactor. In the methanogenic reactor, high diversity of microorganisms corresponded with a COD removal contribution of 83.2%. Moreover, methanogens (Methanosaeta) were predominant, suggesting that these organisms played an important role in the acetotrophic methanogenesis pathway. The dominant aerobic bacteria (Truepera) appeared to have been responsible for the COD removal of the SBR. These results indicate that dividing the sulfate reduction process could effectively minimize sulfide toxicity, which is important for the successful operation of system treating sulfate-rich CEW.

     

絮凝剂对高速厌氧反应器污泥颗粒化的强化作用

以考察絮凝剂对厌氧反应器中活性污泥性能的影响为目的,将聚合氯化铝(PAC)、聚丙稀酰胺(PAM)、聚季铵盐3种不同类型絮凝剂以不同投加量添加到反应器中,采用生物化学甲烷势(BMP)和厌氧毒性测定(ATA)分析方法,评价了3种絮凝剂的厌氧生物可降解性以及3种絮凝剂对厌氧污泥产甲烷活性、沉降性能等方面的促进或抑制作用。确定以聚季铵盐作为厌氧污泥颗粒化促进剂,建议采用多次投加方式,反应器中聚季铵盐质量浓度以10-50mg／L为宜。     

合成聚硅酸硼镁硫酸铁的正交实验研究

研究了用硅酸钠、硼砂、硫酸镁和硫酸铁为原料,制备聚硅酸硼镁硫酸铁（PSBMFS）混凝剂的方法及合成条件。通过正交实验,考查了硅酸活化pH值、缩聚反应时间和陈化时间等合成条件;同时考察了B/Si摩尔比、Mg/Si摩尔比和Fe/Si摩尔比等影响因素。结果表明：PSBMFS具有良好的混凝性能和脱色效果,能有效去除印染废水中的色度和COD,2种污染因子的去除率分别可达95.9%和67.9%。