废聚碳酸酯水解法制双酚A

以1,4-二氧六环为溶剂、NaOH为催化剂,采用废聚碳酸酯(PC)常压水解法制双酚A(BPA).对反应影响因素进行了研究.实验结果表明,在反应温度为100℃、反应时间为8h、m(NaOH):m(水+溶剂)=1:33、m(溶剂):m(PC)=4:1、m(水):m(PC)=1:1的最佳反应条件下,PC水解率大于98%,BPA收率大于95%.     

Methanolysis and Hydrolysis of Polycarbonate Under Moderate Conditions

Alkali-catalyzed methanolysis and hydrolysis of polycarbonate (PC) in a solvent in which PC can substantially dissolve such as N-methyl-2-pyrrolidone, 1,4-dioxane, tetrahydrofuran and so on were studied. Reaction conditions were optimized for the purpose of recycling PC in the form of bisphenol A and carbon carbonate. The results showed that both the methanolysis and hydrolysis of PC could take place under moderate conditions. Under the conditions of reaction temperature 40 °C, m(PC):m(MeOH) = 1:1, m(PC):m(NaOH) = 50:1, reaction time 35 min and using tetrahydrofuran as solvent, the methanolysis conversion of PC was almost 100% and the yield of bisphenol A was over 95%. Moreover, under the conditions of reaction temperature 100 °C, m(PC):m(H₂O) = 1:0.7, m(PC):m(NaOH) = 10:1, reaction time 8 h and using 1,4-dioxane as solvent, the hydrolysis conversion of PC was almost 100% and the yield of bisphenol A was over 94%.     

Evaluation of environmental feasibility of steel pipe sheet pile cutoff wall at coastal landfill sites

An evaluation method that can express the local leakage of leachate from joint sections in steel pipe sheet pile (SPSP) cutoff walls is discussed in this study. In particular, the evaluation of environmental feasibility (containment of leachates containing toxic substances) considering a three-dimensional arrangement and hydraulic conductivity distribution of the joint sections in the SPSP cutoff wall is compared with an evaluation that uses the equivalent hydraulic conductivity. This equivalent hydraulic conductivity assumes that the joint section and the steel pipe are integrated; therefore, the hydraulic conductivity is substituted with a uniform permeable layer. However, in an evaluation that employs the equivalent hydraulic conductivity, it is difficult to consider the local leakage of leachate containing toxic substances from the joint sections in the SPSP cutoff wall. It was established that evaluations of the environmental feasibility of SPSP cutoff walls with joint sections must take into account the local leakage of leachates containing toxic substances from the joint sections. Also, it was clarified that technologies that lower the hydraulic conductivities of joint sections in SPSP cutoff walls and also facilitate the use of sparser joint arrangements contribute significantly to increasing the environmental feasibility of SPSP cutoff walls at landfill sites.     

Removal of Cr(VI) from simulative contaminated groundwater by iron metal

The Cr(VI) removal from simulative contaminated groundwater using zero-valent iron (Fe⁰) filings, Fe⁰ powder and nanoscale Fe⁰ in batch experimental mode was studied. Cr(VI) is a primary pollutant of some soils and groundwater. Zero-valent iron, an important natural reductant, could transform Cr(VI) to Cr(III) which is much less toxic and immobile. The Cr(VI) removal percentage was 87% at a metal to solution ratio of 6 g l⁻¹ for commercial iron powder (200 mesh) in 120 min, and 100% Cr(VI) was removed when the metal to solution ratio was 10 g l⁻¹. The results demonstrates that the Cr(VI) removal percentage was affected apparently by pH, the amount of Fe powder and the reaction temperature. The Cr(VI) removal percentage with nanoscale Fe⁰ was much higher than those with Fe⁰ filings or Fe⁰ powder at the same reaction time. Electrochemical analysis of the reaction process led to the conclusion that the Cr(VI) trended to form Cr(III) hydroxide under the reaction conditions. The kinetics analysis showed that Cr(VI) reduction by Fe⁰ could be described as a pseudo-first-order kinetics model.     

粒径对镁粉爆炸特性的影响

在简要分析了镁粉爆炸的过程和特性基础上,结合在20 L球型爆炸测试装置中对粒径D50为6,47,104,173 μm镁粉的爆炸特性实验数据,着重分析了粒径对镁粉爆炸特性所产生的影响.实验结果表明,随着粒径的增大,镁粉的爆炸危险性随之减小.     

烟花爆竹在生产过程中的安全管理

烟花生产企业人群知识水平低,认识程度不高;同时,在管理上,缺乏正确引导,一些主管部门没有为企业建立长远的引导规划意识,只是见事说事,按程序办事,现在烟花企业形式不容乐观。作为一个烟花企业,应从以下几点进行安全与质量的管理完善。     

爆炸物冲击波的人体防护研究

针对爆炸物爆炸冲击波、破片或子弹冲击、高温高压气体热辐射等复杂环境下的人体伤害威胁,本文从人员损伤研究和防护材料研究两方面综述了国内外研究进展,最后为开展人体有效防护研究工作提出了几点建议.     

化学毒剂的个人防护装备发展及使用概况

本文介绍了各类防毒服和防毒面具的发展历史、各国的研究情况,对装备的穿戴情况和时机作了简要的概括.最后对未来个人防护装备发展趋势进行展望,阐明了未来装备发展的重点和方向.     

周年磷肥旱季集中底施对玉-稻轮作磷肥效应的影响

春玉米-晚稻水旱轮作是近年来南方稻区种植制度变化下出现的新型两熟制模式。明确两季作物间磷肥的合理分配对玉-稻轮作作物产量与磷素利用效率的影响,对玉-稻轮作养分高效与高产协同实现,及丰富对水旱轮作前后季作物养分利用关系的认识具有理论意义。采用春玉米-水稻周年轮作田间试验,根据晚稻季磷肥前移至玉米季做底肥施用的比例及周年施磷量,设置7个磷肥施用处理,分别为两季作物均不施磷(P_0)、两季作物均按常规方法施磷(P_1)、1/3晚稻季磷肥前移(P_2)、2/3晚稻季磷肥前移(P_3)、全部晚稻季磷肥前移(P_4)、全部晚稻季磷肥前移且周年总施磷量减少15%(P_5)、全部晚稻季磷肥前移且周年总施磷量减少30%(P_6),分析了不同施磷处理作物产量、磷素吸收量及磷素利用效率的变化。与P_1相比,P_3与P_4处理显著提高了晚稻花后干物质的分配比例及晚稻产量,且其周年产量分别提高了4.87%和6.74%;P_5处理晚稻产量与P_1处理差异不显著,但P_6显著降低了晚稻产量。晚稻季磷肥前移施用明显促进了玉米及晚稻对磷素的吸收,显著降低了磷素的表观盈余量。与P_1处理相比,P_2、P_3、P_4处理两季作物周年土壤磷素依存率分别减少了11.63%、26.47%与22.08%。从磷肥利用效率看,P_4处理的磷肥周年累积回收效率、农学利用效率、偏生产力及磷肥产量贡献率均显著高于P_1处理,分别提高了102.46%、194.83%、6.73%与176.16%。与P_1处理相比,P_5处理周年磷肥产量贡献率及农学利用效率差异不显著,但分别提高了其磷肥回收效率与偏生产力32.56%和58.05%。玉米季施用的磷肥对晚稻有明显的后效作用,且比晚稻季施用磷肥具有更高的磷肥利用效率。所以在春玉米免耕复种晚稻时,可将晚稻季的磷肥全部前移至玉米季施用,并可减少15%周年施磷量。