臭氧氧化法深度处理印染废水二级出水

采用臭氧氧化法深度处理印染废水二级出水,以比臭氧消耗量为基础讨论出水水质的改善情况.实验结果表明:当比臭氧消耗量为6.5 mg/mg 时,出水的吸光度在400 nm处减少90%以上,在254 nm处减少85%以上;出水的溶解性有机碳质量浓度为11.23 mg/L、COD为16.3 mg/L;臭氧分子直接氧化对降低色度和去除有机物起到一定作用,采用臭氧氧化法深度处理印染废水二级出水在技术上是可行的.     

Estimation of critical ratio of bentonite addition to tuff sand

A design method was proposed to determine the critical ratio of bentonite addition, based on a macro void ratio that considers the swelling property of bentonite. The critical ratio of bentonite addition was defined as the ratio corresponding to a macro void ratio of zero. However, when lightweight soil such as tuff sand is mixed with bentonite, the estimated critical ratio of bentonite addition is too high. Several tests on the water absorbing property of tuff sand and its permeability were conducted to confirm the concept of a revised macro void ratio. The revised macro void ratio, which takes into account the swelling of bentonite and the particle pores of lightweight soil, is much smaller than the former macro void ratio for a given ratio of bentonite addition. The estimated critical ratio of bentonite addition to tuff sand that gives a revised macro void ratio of zero is around 18% and is in good agreement with the ratio of bentonite addition beyond which the value of hydraulic conductivity does not decrease markedly.     

Degradation of a Terephthalate-containing Polyester by Thermophilic Actinomycetes and <Emphasis Type="Italic">Bacillus</Emphasis> Species Derived from Composts

We intended to find thermophilic degraders of terephthalate-containing Biomax^® films. Films in mesh bags were buried in composts (inside temperature: approximately 55–60 °C), resulting in the degradation of them in 2 weeks. Fluorescent microscopy of films recovered from composts showed that microorganisms gradually covered the surface of a film during composting. DGGE analysis of microorganisms on the composted film indicated the presence of Bacillus species as main species (approximately 80% of microbial flora) and actinomycetes (approximately 10–20%) as the second major flora. Isolation of Biomax^®-utilizing bacteria was focused on these two genera: two actinomycetes and one Bacillus species were isolated as pure best degraders from the composted polymer films, which were fragmented into small pieces. All the strains were thermophilic and identified, based on their 16S rDNA analyses. Degradation of polymer films was confirmed by (1) accelerated fragmentation of films in composts, compared with a control (no inoculum) and resultant decrease in molecular weights, (2) growth in a powdered Biomax^® medium, compared with a control without powdered Biomax^®, and (3) production of terephthalate in a powdered Biomax^® medium. In this way, we concluded that these bacteria were useful for degradation of thermostable Biomax^® products.     

Aromatization of waste polyolefin pyrolysate over H-ZSM-5 zeolite-supported gallium oxide catalysts

H-ZSM-5 zeolite-supported gallium oxides were studied as aromatization catalysts for polyolefin pyrolysate. The catalysts were prepared by a conventional physical mixing method with a gallium content of 1.0 and 4.5 wt% and were reduced in flowing hydrogen at 585°C. To test their activity, a polyolefin sample was pyrolyzed and passed over a heated catalyst layer; the product was analyzed by gas chromatography/mass spectrometry. A continuous-flow fixed-bed reactor was used for aromatization of a model gas of polyolefin pyrolysate. For chlorine-free sources at 450°C, the catalyst with only 1.0 wt% gallium exhibited activity comparable to a gallium silicate catalyst. For chlorine-contaminated sources, the catalyst with 4.5 wt% gallium sustained catalytic activity for long periods. From the activity test results, it was found that zeolite-supported gallium catalysts prepared by the physical mixing method are suitable for converting polyolefin into aromatic hydrocarbons.     

Separation and recovery of carbon dioxide by a membrane flash process

A novel process for carbon dioxide (CO₂) separation, which was named a membrane flash process, was developed to realize an energy-saving technology and to substitute it for a conventional regenerator. The electric energy for CO₂ recovery in a membrane flash process using aluminum oxide and diethanolamine was lower than the thermal energy of the conventional chemical absorption process. Flashing at elevated temperature by the low temperature energy significantly reduced the electric energy and required much less membrane area. This process has potentiality of low cost capture of CO₂ when the low temperature energy, which is not available for other purposes, can be utilized to elevate flashing temperature.     

Fluoranthene fumigation and exogenous scavenging of reactive oxygen intermediates (ROI) in evergreen Japanese red pine seedlings (Pinus densiflora Sieb. et. Zucc.)

Generation of reactive oxygen intermediates (ROI) such as O(2)(-), H(2)O(2), and *OH is known to be a major mechanism of damage in biological systems. This study investigated and compared effectiveness of scavenging ROI generated in fluoranthene (FLU) pre-fumigated Japanese red pine seedlings. Three kinds of eco-physiological assessments were used to express the impact of the different fumigants used inside the green house. Gas exchange measurements showed negative changes induced by 10 microM FLU on Japanese pine seedlings during a 10 d exposure period whilst no negative change was found during a 5 d exposure period. Moreover, during a 14 d FLU exposure incorporating ROI scavengers, results revealed that chlorophyll fluorescence, needle chemical contents and needle dry mass per unit area of the seedlings were affected. The negative effects of FLU on the conifer were dependent on both the dose and period of FLU fumigation. Peroxidase (PERO), superoxide dismutase (SOD) and mannitol (MANN) were all effective scavengers of ROI. MANN scavenged *OH, the most lethal of the ROI. For practicable use, MANN is more economical, and may be the best ROI scavenger among the three considered. It can be concluded that efficient scavenging of ROI in biological systems is important to mitigate the negative effects of FLU on Japanese red pine trees.     

Effect of complexation with humic substances on diffusion of metal ions in water

Most studies on diffusion of metal ions in various water-rock systems have dealt with free ions (hydrated ions). However, it is often the case that metal ions are dissolved as complexed species such as with humic substances (HS) in natural waters. Hence, we need to study the diffusion behavior of these complexes in order to understand fully the diffusion phenomenon in natural. In this study, the diffusion coefficients of free metal ions (M(z+)) and their complexes with HS (M-HS) were compared to understand the effect of complexation with HS on the diffusion of metal ions such as Co(2+), Cd(2+), and rare earth elements (REE(3+)). Although the diffusion coefficients of free metal ions depend on ionic potential, such dependence was not observed in the presence of HS. Comparing the diffusion coefficients of metal complexes with ethylenediaminetetraacetate (EDTA), fulvic acid, and humic acid showed that the molecular weight (MW), or the size of the ligand, is of primary importance for the diffusion of M-HS. As a consequence, the diffusion coefficients of all REE(3+) were similar in the presence of HS, while they were different in the absence of HS due to the different size of each REE(3+). The similarity among the diffusion coefficients of REE-HS was caused by the much larger size of HS compared with each ion. However, the distribution coefficients of M-HS were not similar among REE(3+), Cd(2+), and Co(2+). REE(3+) and Cd(2+) which have higher affinities for larger MW fraction in HS diffused slower than Co(2+) which favors smaller MW fraction. The results show that the affinity for different MW fractions among HS controls the diffusion of M-HS, which must be important to predict precisely the diffusion behavior of metal ions bound to HS in natural systems.     

In vitro effect of agriculture pollutants and their joint action on Pseudokirchneriella subcapitata acid phosphatase

Acid phosphatase plays important roles in algae metabolism such as availability and recycling of inorganic phosphate, autophagic digestive processes and fertilization. Chemicals released into the environment from agriculture activities may impair algae phosphatase activity. The aim of this work was to evaluate the in vitro effect of twenty-four organic compounds and six metals used as pesticides, or present as contaminants in sewage sludge, on the acid phosphatase activity extracted from Pseudokirchneriella subcapitata. Results demonstrated that only the linear surfactant alkyl benzenesulphonate (LAS) and the heavy metals Hg(2+), Al(3+) and Cu(2+) markedly altered (50%) the enzyme activity. Join action inhibition studies indicated that Hg(2+) was more potent inhibitor than Al(3+) or LAS, and that the Hg(2+)+Al(3+) and Hg(2+)+LAS mixtures have, respectively, additive and slight antagonism effects. Copper, which demonstrated an activator effect when preincubated with the enzyme, behaved as a slight antagonist for the inhibitor effect of Hg(2+).     

Determination of PCDD/Fs and dioxin-like PCBs in fish oils for feed ingredients by congener-specific chemical analysis and CALUX bioassay

The present research was intended to determine the suitability of the CALUX assay as a screening method for dioxins in fish oil used as a feed ingredient in Japan. Alteration of TEQ in fish oil according to newly proposed toxic equivalency factors (TEF) is also discussed. In the analysis, polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/Fs) and dioxin-like polychlorinated biphenyls (DL-PCBs) in 41 fish oil samples were determined by using high-resolution gas chromatography/high-resolution mass spectrometry (HRGC/HRMS) and CALUX bioassay. The mean TEQ values derived from 1998 WHO-TEF of PCDD/Fs and DL-PCBs were 2.6 and 9.9 pg g(-1) (ww), respectively. The levels of TEQ derived from the recently re-evaluated 2005 WHO-TEF were slightly lower than those of the former in both groups. Notably, the contribution of mono-ortho DL-PCBs to total 2005 WHO-TEQ was considerably decreased compared to the case of 1998 WHO-TEQ, resulting from the reduction in its TEF values, while the non-ortho DL-PCBs contribution was increased. The mean TEQ determined by CALUX assay for PCDD/Fs was approximately three times higher, whereas DL-PCBs was approximately two times lower than WHO-TEQ determined by HRGC/HRMS; the sum of PCDD/Fs and DL-PCBs was very similar by both methods. The correlation coefficients of TEQ between the CALUX assay and HRGC/HRMS analysis were 0.84, 0.89, and 0.90 for PCDD/Fs, DL-PCBs, and the sum, respectively. These results suggest that the CALUX assay is a very useful method for the screening of dioxin-related compounds in fish oils.