混凝-IBAC深度处理焦化废水的试验研究

以哈尔滨某气化厂焦化废水为目标,探讨混凝-固定化生物活性炭(IBAC)工艺对哈尔滨气化厂焦化废水进行深度处理的净化效能及其可行性.采用筛选、驯化的脱酚菌,对活性炭(GAC)进行固定,使之形成固定化生物活性炭.当该工艺进水COD＜800 mg/L时,出水COD在100 mg/L以下,平均去除率在80%左右;当进水总酚在200 mg/L以下时,出水的总酚含量基本在20 mg/L以下;当进水氨氮浓度在75 mg/L以下时,出水氨氮浓度在25 mg/L以下.焦化废水中各污染物指标经混凝-IBAC工艺深度处理后可达污水综合排放标准(GB 8978-1996)的二级标准.     

混凝-Fenton-BAF深度处理垃圾渗滤液中试研究

针对经过SBR处理后,难以再进一步生化降解的垃圾渗滤液,提出混凝-Fenton-曝气生物滤池(BAF)工艺进行深度处理.首先利用混凝去除SBR出水的悬浮性有机物,降低Fenton试剂的处理成本;然后采用Fenton试剂进行氧化处理,既降低垃圾渗滤液的COD值,又提高其可生化性,最后通过BAF工艺去除有机物,实验结果表明,在SBR出水COD为600～800 mg/L的情况下,最终出水的COD低于80 mg/L,处理成本仅为2.6元/t.     

Influence of metal oxides on PCDD/Fs formation from pentachlorophenol

Chlorophenols (ClPhs) are considered as important precursors for PCDD/Fs formation. The influences of series of metal oxides including MgO, Al2O3, CaO, BaO, TiO2, V2O5, MnO2, Fe2O3, Co3O4, CuO, Ag2O, ZnO, HgO, SnO, PbO, La2O3, CeO2, and Eu2O3 on PCDD/Fs formation from pentachlorophenol (PCP) were investigated in a laboratory-scale reactor. The results indicated that most of the above metal oxides have obvious suppressing effects on the total amount of PCDD/Fs formation from precursor PCP except for CuO, ZnO, MnO2, TiO2 and Co3O4 with promotion effects at 280 degrees C for 2 h. Although MgO, Al2O3, Fe2O3, PbO, La2O3 and Eu2O3 could reduce the amount of octachlorinated dibenzo-p-dioxin (OCDD), they promote the formation of more toxic 1,2,3,4,6,7,8-HpCDD at the same time. The total suppressing efficiencies of several metal oxides including CaO, BaO, PbO, Ag2O, HgO and SnO which have lower Z/r (charge to radius ratio) <2 are all over 90%. The theories of generalized acid-base and atomic parameter (Z/r) were used to speculate the effecting mechanisms. The factors including time and temperature on suppressing efficiencies of CaO, BaO and PbO have also been studied in the present paper. The results showed that the total suppressing efficiencies of CaO, BaO and PbO increase with the increase of heated time and temperature.     

臭氧催化氧化工艺深度处理印染废水

采用正交实验对催化剂NiO/γ-A12O3的制备条件进行优化,并探讨臭氧催化氧化法对于印染废水的深度处理效能.结果表明,最优的催化剂制备条件为:浸渍液浓度为3％、浸渍时间为4h、灼烧温度为450℃、灼烧时间为3h.臭氧催化氧化反应15 min时,COD浓度由84.22 mg/L降低至50.00 mg/L以下;氨氮浓度由10.88 mg/L降低至5.01 mg/L;色度去除率达到69％,明显高于单纯臭氧氧化的反应效率.     

利用沉水植物生长期收割进行富营养化水体生态管理的实地研究

在以再生水为补水水源的圆明园玉玲珑水域进行沉水植物收割实验,自2011年4—12月间每隔半个月监测一次水质。结果表明,通过在生长期收割沉水植物,玉玲珑水体TP、SRP、TN、NH4+-N、NO3--N和COD的平均浓度可维持在0.1、0.04、0.86、0.1、0.32和18 mg/L左右,水质保持在Ⅲ类至Ⅳ类地表水之间;与之对照的不收割沉水植物的玉玲珑进水口水域,9月沉水植物开始死亡腐烂,TP、SRP、TN、NH4+-N最高分别可达0.5、0.1、2.4和0.60 mg/L;作为对照的另一以挺水植物为主的水域,水质普遍劣于有大量沉水植物生长的水域,TP、SRP、TN、NH4+-N最高分别可达1.2、0.60、6.1和0.61mg/L。圆明园的实地实验表明,沉水植物有很强的净化水质作用,通过生长期收割,能够进一步强化其水质净化作用,可以作为一项对富营养化水体进行生态管理的有效措施进行推广。     

不同来源高浓度有机废水的集中处理

按照水质情况,将多种来源于不同工业生产过程中的高浓度有机废水划分为高悬浮固体乳化液废水、难生化高浓度有机废水、高悬浮固体不含油有机废水、含铬有机废水和杂质含量较少的乳化液废水5类,分别采用酸化破乳/Fen-ton氧化/混凝/絮凝、Fenton氧化/混凝/絮凝、混凝/絮凝、还原/混凝/絮凝、震动膜过滤技术作为生化预处理技术,并通过小试和中试验证了各技术的效果。实验结果表明,按照上述分类结果,采用不同预处理技术可以得到良好的效果,废水水质明显改善,满足继续生化处理的基本条件。各预处理生产装置处理效果稳定,同时生化系统已经稳定运行120天以上,COD去除率超过90%,出水经过低剂量的Fenton试剂处理后可达到《污水排入城镇下水道水质标准》(CJ343-2012)。     

焚烧法处理环己酮生产中的皂化液

用环已烷氧化生产环已酮的生产过程中会产生大量的皂化液 ,它含有大量的有害物质 ,是一种难处理的高污染有机废水。某石化厂在借鉴造纸行业的黑液焚烧技术的基础上 ,采用焚烧法来处理皂化液 ,并得到副产蒸气和回收了碳酸钠 ,实现了皂化液的无害化与资源化 ,具有良好的社会效益、环境效益和经济效益 ,每处理 1t皂化液可盈利 10 0～ 2 0 0元     

中国南方某城市自来水厂处理工艺对多环芳烃的去除效果研究

讨论了中国南方某城市自来水厂饮用水中的多环芳烃残留规律以及现有净水工艺对多环芳烃的去除效果。研究结果表明,该自来水厂饮用水中检出多环芳烃以2~4环芳烃为主,强致癌性高环数多环芳烃均在检出限以下,且多环芳烃总量未超出中国供水行业标准(2000年)的相关限值。各处理工艺段中,砂滤过程对多环芳烃的去除效果最好,相较于原水对多环芳烃总量的去除率可达64%。     

玻纤布上胶车间有机溶剂废气净化处理

介绍了工厂有机溶剂废气处理方案和设计及实际运行效果,具有简单经济、净化彻底的特点.     

Effect of bound residues of metsulfuron-methyl in soil on rice growth

A pot experiment was conducted to appraise the hazards of bound residues of metsulfuron-methyl in soil at six levels (0, 0.050, 0.089, 0.158, 0.281, and 0.500 mg kg(-1)) to the growth of four rice varieties (Xiushui 63, Eryou 810, Liangyoupeijiu, and Zhenong 952). The morphological characteristics of rice roots like root number, total length, surface area of rice roots, and rice biomass were determined. The results showed that the bound residues of metsulfuron-methyl in soil impacted the growth of rice. Root number, total length of roots, surface area of roots, and biomass were restrained by bound residues of metsulfuron-methyl in soil. The inhibition rate of root growth increased from 69.46-81.32% to 85.18-95.97% with the increasing of levels of bound residues of metsulfuron-methyl from 0.05 mg kg(-1) to 0.50 mg kg(-1). The number of rice roots could be taken as a sensitive index to screen the rice varieties endurable to bound residues of metsulfuron-methyl in soil and to predict the potential hazards of bound residues of metsulfuron-methyl in soil to rice. The level of bound residues of metsulfuron-methyl in soil causing the root numbers decreased by 50% (IC50) followed the order of Xiushui 63 < Eryou 810 < Liangyoupeijiu < Zhenong 952.