选钼中间矿浓缩溢流水回收及钼精矿干燥粉尘治理

介绍了德兴铜矿对选钼中间矿浓缩溢流水循环利用所采取的措施和所取得的成果。对原钼精矿干燥除尘系统存在问题进行了整治,达到了预期效果。     

故障树分析法在高炉炉前灼伤事故中的应用

应用故障树分析法能系统地分析高炉炉前灼伤的原因,在故障村图上,因果关系明确,并能找出事故发生的主要原因,从而制定措施,以有效地预防事故的发生。     

实施ISO 9000标准是个体防护装备生产企业发展的必经之路

1 我国个体防护装备生产企业标准化管理现状 标准化法在我国已实施多年，但是为数众多的小型个体防护装备生产企业实行标准化管理的只占行业总数的9．85％，且标准化管理水平较低，尤其是基础管理标准化工作薄弱的现象非常明显，已成为影响企业发展的最大障碍。因此，企业实行标准化管理，是企业做大做强、可持续发展的必经之路。     

添加剂对烟气脱硫的强化作用

采用鼓泡式烟气脱硫反应装置,研究了己二酸、硫酸镁、无机盐A和无机盐B等4种添加剂的脱硫强化作用。实验结果表明:4种添加剂均能较明显地提高脱硫浆液的脱硫率,且添加无机盐A和无机盐B的脱硫效果更好;随着添加剂加入量的增加,脱硫率逐渐提高,综合考虑,本实验适宜的添加剂加入量为1.0 g/L。现场实际应用中加入质量比为1∶1的无机盐A和无机盐B作为复合添加剂,在使用2台循环泵、烟气流量约1 020 km3/h、初始SO2质量浓度由2 981 mg/Nm3增加至约3 843 mg/Nm3的条件下,脱硫率仍由81.79%提高到89.92%。     

Consultant Guide/1986

ABSTRACT

To obtain annual odor emission profiles from intensive swine operations, odor concentrations and emission rates were measured monthly from swine nursery, farrowing, and gestation rooms for a year. Large annual variations in odor concentrations and emissions were found in all the rooms and the impact of the seasonal factor (month) was significant (P < 0.05). Odor concentration was low in summer when ventilation rate was high but high in winter when ventilation rate was low, ranging from 362 (farrowing room in July) to 8934 (nursery room in December) olfactory unit (OU) m^?3. This indicates that the air quality regarding odor was significantly better in summer than that in winter. Odor emission rate did not show obvious seasonal pattern as odor concentration did, ranging from 2 (gestation room in November) to 90 (nursery room in April) OU m^?2 sec^?1; this explains why the odor complaints for swine barns have occurred all year round. The annual geometric mean odor concentration and emission rate of the nursery room was significantly higher than the other rooms (P < 0.05). In order to obtain the representative annual emission rate, measurements have to be taken at least monthly, and then the geometric mean of the monthly values will represent the annual emission rate. Incorporating odor control technologies in the nursery area will be the most efficient in reducing odor emission from the farm considering its emission rate was 2 to 3 times of the other areas. The swine grower-finisher area was the major odor source contributing 53% of odor emission of the farm and should also be targeted for odor control. Relatively positive correlations between odor concentration and both H₂S and CO₂ concentrations (R ² = 0.58) means that high level of these two gases might likely indicate high odor concentration in swine barns.

IMPLICATIONS The emissions of air pollutants including odors, greenhouse gases, and toxic gases have become a major environmental issue facing animal farms in the U.S.A. and Canada. To ensure the air quality in the vicinity of intensive livestock farms, air dispersion models have been used to determine setback distances between livestock facilities and neighboring residences based on certain air quality requirement on odor and gases. Due to the limited odor emission data available, none of the existing models can take account of seasonal variations of odor emissions, which may result in great uncertainties in setback distance calculations. Therefore, the obtained seasonal odor and gas emission rates by this study can be used by the government regulatory organizations and researchers in air dispersion modeling to get improved calculation of setback distances.     

A sensitive monoclonal antibody-based enzyme-linked immunosorbent assay for chlorpyrifos residue determination in Chinese agricultural samples

A monoclonal antibody-based competitive antibody-coated enzyme-linked immunosorbent assay (ELISA) was developed and optimized for determining chlorpyrifos residue in agricultural products. The IC₅₀ and IC₁₀ of this ELISA were 3.3 ng/mL and 0.1 ng/mL respectively. The average recoveries in six agricultural products were between 79.5% and 118.0%, with the intra-assay coefficient of variation being less than 8 %. The limit of detection for all tested products was 30 ng/g. To the best of our knowledge, this assay has the best specificity among all the published research on ELISAs for chlorpyrifos.     

Characteristics of penicillin bacterial residue

A hybrid selective noncatalytic reduction/selective catalytic reduction (SNCR/SCR) system that uses two types of technology, low-temperature SCR process and SNCR process, was designed to develop nitrogen oxide (NO_x) reduction technology. SCR was conducted with space velocity (SV) = 2400 hr^?1 and hybrid SNCR/SCR with SV = 6000 hr^?1, since the study focused on reducing the amount of catalyst and both achieved 98% NO_x reduction efficiency. Characteristics of NO_x reduction by NH₃ were studied for low-temperature SCR system at 150 °C using Mn-V₂O₅/TiO₂ catalyst. Mn-added V₂O₅/TiO₂ catalyst was produced, and selective catalyst reduction of NO_x by NH₃ was experimented. NO_x reduction rate according to added Mn content in Mn-V₂O₅/TiO₂ catalyst was studied with varying conditions of reaction temperature, normalized stoichiometric ratio (NSR), SV, and O₂ concentration. In the catalyst experiment according to V₂O₅ concentration, 1 wt.% V₂O₅ catalyst showed the highest NO_x reduction rate: 98% reduction at temperature window of 200~250 °C. As a promoter of the V₂O₅ catalyst, 5 wt.% Mn was added, and the catalyst showed 47~90% higher efficiency even with low temperatures, 100~200 °C. Mn-V₂O₅/TiO₂ catalyst, prepared by adding 5 wt.% Mn in V₂O₅/TiO₂ catalyst, showed increments of catalyst activation at 150 °C as well as NO_x reduction. Mn-V₂O₅/TiO₂ catalyst showed 8% higher rate for NO_x reduction compared with V₂O₅/TiO₂ catalyst in 150 °C SCR. Thus, (5 wt.%)Mn-(1 wt.%)V₂O₅/TiO₂ catalyst was applied in SCR of hybrid SNCR/SCR system of low temperature at 150 °C. Low-temperature SCR hybrid SNCR/SCR (150 °C) system and hybrid SNCR/SCR (350 °C) showed 91~95% total reduction rate with conditions of SV = 2400~6000 hr^?1 SCR and 850~1050 °C SNCR, NSR = 1.5~2.0, and 5% O₂. Hybrid SNCR/SCR (150 °C) system proved to be more effective than the hybrid SNCR/SCR (350 °C) system at low temperature.

Implications:?NO_x control is very important, since they are the part of greenhouse gases as well as the cause of acid rain and ozone hole. A technology, so-called hybrid SNCR/SCR process, was tested using Mn-V₂O₅/TiO₂ monolithic catalyst for NO_x reduction, and the method is promising. The results of this study would provide some ideas to parties such as policy makers, environmental engineers, and so on.     

Bioaccumulation and uptake routes of perfluoroalkyl acids in Daphnia magna

Perfluoroalkyl acids (PFAs), one kind of emerging contaminants, have attracted great attentions in recent years. However, the study about their bioaccumulation mechanism remains scarce. In this research, the bioaccumulation of six kinds of PFAs in water flea Daphnia magna was studied. The uptake rates of PFAs in D. magna ranged from 178 to 1338 L kg^?1 d^?1, and they increased with increasing perfluoroalkyl chain length; the elimination rates ranged from 0.98 to 2.82 d^?1. The bioaccumulation factors (BAFs) of PFAs ranged from 91 to 380 L kg^?1 in wet weight after 25 d exposure; they increased with increasing perfluoroalkyl chain length and had a significant positive correlation with the n-octanol/water partition coefficients (log K_ow) of PFAs (p < 0.05). This indicated that the hydrophobicity of PFAs plays an important role in their bioaccumulation. The BAFs almost kept constant when the PFA concentrations in aqueous phase increased from 1 to 10 μg L^?1. Scenedesmus subspicatus, as the food of D. magna, did not significantly affect the bioaccumulation of PFAs by D. magna. Furthermore, the body burden of PFAs in the dead D. magna was 1.08–2.52 times higher than that in the living ones, inferring that the body surface sorption is a main uptake route of PFAs in D. magna. This study suggested that the bioaccumulation of PFAs in D. magna is mainly controlled by their partition between organisms and water; further research should be conducted to study the intrinsic mechanisms, especially the roles of protein and lipid in organisms.     

双氯芬酸的吸附去除过程与机制

研究了非甾体抗炎药双氯芬酸的吸附去除过程与机制。对吸附处理效果较好的活性炭与纳米羟基氧化铁（α-FeOOH）进行了比表面积、Zeta电位等表面特性的表征,研究比较了双氯芬酸在活性炭与α—FeOOH2种材料上的吸附去除效果与吸附机制。结果表明,在相同的实验条件下,活性炭与α-FeOOH对双氯芬酸吸附去除率可分别达到97．9％和84．3％;双氯芬酸在活性炭上的吸附主要是由于活性炭较大的比表面积与疏水分配作用,在α-FeOOH上的吸附主要是由于静电引力作用;活性炭与α-FeOOH对双氯芬酸的吸附去除效果均随pH的升高而降低;在pH=6时,活性炭与α-FeOOH对双氯芬酸钠的吸附等温线均符合Langmuir方程,单位饱和吸附量分别为109．98mg／g和58．96mg／g;活性炭对双氯芬酸具有更强的吸附能力。     

自燃煤矸石山覆盖材料压缩及压实特性实验

自燃煤矸石山表面构建覆盖层,需要具备一定的低渗透性能以有效阻隔空气,防止煤矸石山内部发生自燃。本研究通过室内实验,测定煤矸石山构建覆盖层涉及的碾压材料包括黄土、粉煤灰及掺有粉煤灰的混合土样的界限含水率、一维压缩特性及压实特性,揭示和分析7种覆盖材料配方的压缩压实特性,表明覆盖材料通过碾压可有效阻隔空气,起到阻燃作用;将粉煤灰掺人到一般黄土材料中,可减缓混合土样击实曲线的陡峭性,从而降低材料在碾压中对含水率的敏感度。实验旨在为进行煤矸石山覆盖层碾压提供科学的实验数据及设计参数。