KOH活化花生壳生物质炭对亚甲基蓝吸附性能研究

以花生壳生物质炭(P-BC)为原料,KOH为活化剂,采用化学活化法制得活化生物质炭(K-BC),通过考察对亚甲基蓝的吸附性能,研究了花生壳生物质炭的最佳活化条件,并利用N2吸附-脱附实验、SEM等对最佳活化条件下的生物质炭进行表征.结果表明,K-BC活化的最佳条件为碱炭比为1.5:1,活化温度为800℃,活化时间为90 min,此时K-BC的比表面积达到597.93 m2/g,总孔容达到0.76 cm3/g.并考察了亚甲基蓝初始浓度、pH等对K-BC吸附亚甲基蓝的影响,随着初始浓度的增加,吸附平衡时间显著延长,亚甲基蓝去除率显著降低;当pH=6时,K-BC对亚甲基蓝的吸附量最大;K-BC对亚甲基蓝的吸附动力学曲线符合伪二阶动力学模型,吸附平衡时K-BC对亚甲基蓝的吸附能力为80~149.95 mg/g.     

表面铜螯合磁性二氧化硅固定化漆酶及其催化降解水中2，4-二氯酚

利用磁性二氧化硅表面接枝的聚丙烯酰胺络合Cu2＋离子,制备了表面铜螯合磁性SiO：材料,采用傅立叶红外光谱（FT．IR）,X射线衍射（XRD）对该磁性材料进行了表征,并通过配位作用固定化漆酶,考察了其对水中2,4-二氯酚（2,4-DCP）的催化降解效能及主要影响因素。结果表明,表面铜螯合磁性SiO：固定化漆酶对2,4-DCP具有较好的催化降解效能,利用8g／L固定化漆酶催化降解50mL初始浓度为24．25mg／L的2,4-DCP,反应12h2,4-DCP去除率达91％;当pH值在3．0～6．0范围内时,2,4-DCP的去除率随反应pH值的增加而升高;2,4-DCP初始浓度在14．39～257．6mg／L范围内时,反应12h,2,4-DCP的去除率均达85％以上;给酶量增加促进2,4-DCP的去除,但过多的给酶量导致单位质量固定化漆酶催化降解2,4-DCP的速率下降;水中硫酸根离子对固定化漆酶催化降解2,4-DCP具有明显的促进作用,而碳酸氢根离子明显抑制反应的进行。     

Abnormal glucose regulation in pyrethroid pesticide factory workers

The purpose of this study was to investigate associations between pyrethroids occupational exposures, and risk of abnormal glucose regulation. Data from total of 3080 subjects in two pesticide factories were used. This was a population-based case-controlled study in China. In total, 18.3% of subjects with impaired glucose regulation (IGR) and 6.5% of subjects with diabetes, and the prevalence of abnormal glucose regulation was 24.8%, 86 subjects had known type 2 diabetes and 114 had newly diagnosed diabetes. The prevalence of subjects with abnormal glucose regulation increased from 21.3% in the controls to 29.3% in the exposures (χ² = 33.182, P < 0.001). Multivariate logistic regression was used to control potential confounders and calculate odd ratios as the estimate of effect. An indication of increased risk for abnormal glucose regulation was noted for exposure to pyrethroids (OR = 1.482, 95%CI = 1.238-1.774). Abnormal glucose regulation is common in subjects exposed to pyrethroids. The present investigation indicates the adverse health effects of pyrethroids are underestimated.     

铈锆比率及过渡金属掺杂对Pd/CexZr1-xO2催化剂性能的影响

采用均相共沉淀法制备了不同铈锆比率的复合氧化物,并用等体积浸渍法制备了其负载的Pd/CexZr1-xO2催化剂。考察了铈锆比率对复合氧化物性质及其负载单Pd催化剂催化氧化柴油机尾气性能的影响。在此基础上,掺杂Mn、Ni和Cu对催化剂进行改性并考察反应活性。利用XRD、BET、H2-TPR和TEM等技术对样品进行表征。结果表明,Ce/Zr为1/1时Pd/CZ催化剂抗烧结性能最佳;过渡金属和铈锆协同作用一定程度上提高了柴油机氧化催化剂(DOC)的催化活性;Cu和Mn的掺杂能有效降低CO、碳氢化合物(HC)和NO的起燃温度,提高柴油机尾气催化氧化性能;Ni对催化性能的改善不明显。     

温度对热水解预处理高含固污泥特性的影响

以含固率为10%的污泥为对象,研究不同温度和时间条件下热水解过程中有机物转化规律对污泥特性的影响。结果表明:随着热水解时间的延长和温度的升高,污泥中挥发性悬浮固体(VSS)的水解率逐渐升高。在热水解时间为20 min时,温度由150℃升高到180℃,VSS水解率由22.9%增至38.4%,污泥中VSS由46.28 g/L降低到40.63 g/L。水解液组分分析表明,溶解性化学需氧量(SCOD)主要组成为蛋白质(50%)、碳水化合物(15%~20%)、可挥发性脂肪酸(15%~20%)。水解液中氮主要以有机氮的形式存在。在热水解条件达到165℃、50 min时,氨氮浓度为1.16 g/L,之后,随着温度的升高和时间的延长,氨氮浓度基本不变。     

Fate and transformation of naphthylaminesulfonic azo dye Reactive Black 5 during wastewater treatment process

Certain aromatic amines generated by the decolorization of some azo dyes are not removed substantially by conventional anaerobic–aerobic biotreatment. These aromatic amines are potentially toxic and often released in the wastewater of industrial plants. In this study, the fate and transformation of the naphthylaminesulfonic azo dye Reactive Black 5 (RB5) during different phases of a sequencing batch reactor were investigated. The major products of RB5 decolorization during the anaerobic phase include 2-[(4-aminophenyl)sulfonyl]ethyl hydrogen sulfate (APSEHS) and 1-2-7-triamino-8-hydroxy-3-6-naphthalinedisulfate (TAHNDS). During the aerobic phase, APSEHS was hydrolyzed and produced 4-aminobenzenesulfonic acid, which was further degraded via dearomatization. TAHNDS was transformed rapidly via auto-oxidation into TAHNDS_DP-1 and TAHNDS_DP-2, which were not further removed by the activated sludge during the entire 30-day aerobic phase. In contrast, different behaviors of TAHNDS were observed during the anoxic phase. The transformation of TAHNDS was initiated either by deamination or desulfonation reaction. TAHNDS was then converted into 3,5-diamino-4-hydroxynaphthalene-2-sulfonic acid, which was subsequently removed via ring cleavage reaction under aerobic condition. In conclusion, complete degradation of TAHNDS by activated sludge occurs only during anoxic/aerobic processes instead of the conventional anaerobic/aerobic processes.     

改性活性炭对水中铬离子(Ⅵ)的吸附性能

为了研究改性前后活性炭对水中铬离子(Ⅵ)的吸附效果,以磷酸活性炭(PAC)为原料,用10%硝酸改性得到硝酸改性活性炭(N-PAC)及直接蒸发法载铁改性得到载铁活性炭(Fe-PAC)。通过静态吸附研究表明,改性后活性炭对Cr(Ⅵ)的吸附率有较大提高。在常温、自然pH条件下,0.2 g活性炭处理50 mL浓度为100 mg/L的含Cr(Ⅵ)溶液,N-PAC和Fe-PAC对Cr(Ⅵ)的吸附率分别为79.21%和90.59%,都高于原PAC对Cr(Ⅵ)的吸附率49.58%。pH从2.2升高到11.92,Fe-PAC对Cr(Ⅵ)的吸附率从99.86%降低到14.77%,N-PAC则从99.86%降低到3.23%,PAC从97.05%降低到2.53%。温度从25℃升高到70℃,3种活性炭对Cr(Ⅵ)吸附率都有较大提高,都增加到98%以上。且吸附过程较符合Langmuir等温吸附模型。     

微生物絮凝剂与聚合氯化铝复配处理涂料废水的响应面优化

采用响应面分析法对聚合氯化铝(PAC)与污泥生产的微生物絮凝剂复配处理涂料废水的过程进行了优化,设定的响应值为COD和色度去除率。实验分别拟合了关于COD去除率和色度去除率的二次模型,根据响应值的分布情况,确定涂料废水的最佳絮凝条件为微生物絮凝剂浓度47 mg/L,PAC浓度39 mg/L,pH为8.2,CaCl2浓度0.38 g/L,搅拌速度210 r/min。最佳絮凝条件下,微生物絮凝剂对涂料废水中COD和色度的去除率分别达到77.6%和68.9%。     

Characterization of the extracellular biodemulsifiers secreted by Bacillus cereus LH-6 and the enhancement of demulsifying efficiency by optimizing the cultivation conditions

A highly efficient demulsifying strain, LH-6, was isolated from petroleum-contaminated soil and identified as Bacillus cereus by 16S rDNA gene analysis. It achieved 95.61 and 95.40 % demulsifying ratios within 12 h for water-in-oil (W/O) and oil-in-water (O/W) model emulsions, respectively. Fourier transform infrared spectroscopy (FT-IR) and thin-layer chromatography (TLC) detections indicated that the LH-6’s extracellular biodemulsifiers were different types of lipopeptides for the W/O and O/W emulsions. Optimization of the culture medium composition was conducted to improve the biosynthesis and demulsifying efficiency of the biodemulsifier. The optimal carbon source was liquid paraffin, while waste frying oil could also be an alternative carbon source. The optimal nitrogen sources were ammonium sulfate and yeast extract. To further enhance the biodemulsifier efficiency, the optimal cultivation conditions were determined using response surface methodology (RSM) based on central composite rotation design (CCRD). Using the optimized cultivation conditions, the demulsifying ratios increased to 98.23 and 97.65 % for the W/O and O/W model emulsions, respectively.     

好氧颗粒污泥自生动态膜生物反应器处理碱减量印染废水

自生动态膜生物反应器(SFDMBR)接种颗粒污泥启动,研究溶解氧浓度和水力停留时间对该反应器处理碱减量印染废水的影响。自生动态膜生物反应器形成稳定的动态膜后,出水浊度小于10 NTU,系统对浊度的去除率在90%以上,溶解氧和水力停留时间对反应器出水浊度基本无影响。系统对废水色度的去除率随着溶解氧浓度的提高和水力停留时间的延长而增加,但是系统对色度的去除效率一般不超过40%。溶解氧浓度由0.3 mg/L逐渐增大至2.4 mg/L,COD的去除率由40%提升至80%,而当溶解氧浓度大于1.0 mg/L后,UV254的去除率达到95%。水力停留时间在8~48 h时,COD去除效率由65%逐渐上升至85%左右;水力停留时间在8~32 h,UV254去除效率为68%~93%,超过32 h后水力停留时间对UV254去除效率的影响已不明显。