甘氨酸母液脱色废活性炭的微波-Fenton试剂氧化法再生

采用微波-Fenton试剂氧化法对甘氨酸母液脱色过程中产生的废活性炭进行再生,考察了废活性炭再生率的影响因素,并用SEM对再生活性炭进行了表征.实验结果表明,在Fenton试剂中n(H2O2)∶n(Fe2+)为24∶1、H2O2的浓度为25 mmol/L、溶液pH为3、反应温度为55℃、反应时间为18 min、微波功率为600 W时,废活性炭的再生率可达到75.80％.     

酸洗废液制备高纯氧化铁红

以钢板酸洗废液为原料,采用铁粉预处理、除杂、合成、水洗、干燥、煅烧等工序制备高纯氧化铁红.最佳工艺条件为:预处理温度80℃,预处理时间3h,铁粉加入量为理论值的1.5倍;除杂温度65 ℃,聚丙烯酰胺加入量60 mg/L;米用将FeC12溶液和饱和NH4HCO3溶液同时滴加入反应器的方式进行沉淀反应;煅烧温度800℃.在此工艺条件下处理酸洗废液,可制得纯度为99.3％的高纯氧化铁红.     

可发性聚苯乙烯仓库消防安全评价研究

对火灾因素多样,且相互间又具有不确定性和模糊性的仓库火灾危险性分析,可应用层次分析法和模糊评价法相结合而形成的一种评价模式。该模式主要通过运用模糊层次综合评价法并结合层次分析法确定各指标的权重分配,对企业安全状况进行评价,经过专家咨询,将各因素层次化,最终得出模糊评价结果。笔者将该模式应用于实例,对可发性聚苯乙烯仓库进行消防安全研究,实例验证了该模式的可行性,并得知该仓库当前的消防安全程度为"临界的",应当采取适当的消防控制措施。通过理论分析和案例应用,证明该方法既能够充分体现评价因素和评价过程的模糊性,又尽量减少个人主观臆断所带来的弊端,更符合客观实际,其评价结果更可信,可靠。     

Identification and characterization of Fe3O4/peroxodisulfate advanced oxidation products from sulfameter

Sulfonamides (SAs) are one of the most widely used antibiotics and their residuals in the environment could cause some negative environmental issues. Advanced oxidation such as Fenton-like reaction has been widely applied in the treatment of SAs polluted water. Degradation rates of 95%-99.7% were achieved in this work for the tested 8 SAs, including sulfisomidine, sulfameter (SME), phthalylsulfathiazole, sulfamethoxypyridazine, sulfamonomethoxine, sulfisoxazole, sulfachloropyridazine, and sulfadimethoxine, in the Fe₃O₄/peroxodisulfate (PDS) oxidation system after the optimization of PDS concentration and pH. Meanwhile, it was found that a lot of unknown oxidation products were formed, which brought up the uncertainty of health risks to the environment, and the identification of these unknown products was critical. Therefore, SME was selected as the model compound, from which the oxidation products were never elucidated, to identify these intermediates/products. With liquid chromatography-high resolution tandem mass spectrometry (LC-HRMS/MS), 10 new products were identified, in which 2-amino-5-methoxypyrimidine (AMP) was confirmed by its standard. The investigation of the oxidation process of SME indicated that most of the products were not stable and the degradation pathways were very complicated as multiple reactions, such as oxidation of the amino group, SO₂ extrusion, and potential cross-reaction occurred simultaneously. Though most of the products were not verified due to the lack of standards, our results could be helpful in the evaluation of the treatment performance of SAs containing wastewater.     

Surface clogging process modeling of suspended solids during urban stormwater aquifer recharge

Aquifer recharge,which uses urban stormwater,is an effective technique to control the negative effects of groundwater overexploitation,while clogging problems in infiltration systems remain the key restricting factor in broadening its practice.Quantitative understanding of the clogging process is still very poor.A laboratory study was conducted to understand surface physical clogging processes,with the primary aim of developing a model for predicting suspended solid clogging processes before aquifer recharge projects start.The experiments investigated the clogging characteristics of different suspended solid sizes in recharge water by using a series of one-dimensional fine quartz sand columns.The results showed that the smaller the suspended particles in recharge water,the farther the distance of movement and the larger the scope of clogging in porous media.Clogging extents in fine sand were 1 cm,for suspended particle size ranging from 0.075 to 0.0385 mm,and 2 cm,for particles less than 0.0385 mm.In addition,clogging development occurred more rapidly for smaller suspended solid particles.It took 48,42,and 36 hr respectively,for large-,medium-,and small-sized particles to reach pre-determined clogging standards.An empirical formula and iteration model for the surface clogging evolution process were derived.The verification results obtained from stormwater recharge into fine sand demonstrated that the model could reflect the real laws of the surface clogging process.     

东北严寒地区村镇环境现状调查研究

在城乡一体化发展背景下,农村内部现代化进程不断加快,而与之配套的社会公共服务设施与管理体制尚不健全,使得农村环境污染不断加剧.经问卷调研,东北严寒地区村镇环境突出的问题是水体和空气污染严重,垃圾围村现象普遍,工业企业生产及道路交通使得噪声污染加剧,工业企业污染较重.探究环境污染形成机制包括:农村粗放的经济发展模式、农民生活形式现代化和模式传统化的矛盾、农民环保意识薄弱以及城乡二元化体制结构使得东北严寒地区村镇环境不断恶化.文章最后提出了针对性的对策建议.     

烟气脱硫剂制浆系统一体化设计及应用

石灰石粉制浆系统是石灰石-石膏湿法烟气脱硫工艺中脱硫剂浆液干式制备系统的一个主要部分。针对石灰石粉制浆系统传统设计的不足,提出了石灰石浆液罐与粉仓一体化设计的优化方案,具有节省投资、占地小、设计简单紧凑、系统可靠和寿命长的优点,尤其适合我国老小燃煤机组烟气脱硫改造工程。目前已成功应用于多个烟气脱硫工程。     

石灰石-石膏湿法脱硫系统改造

某电厂300 MW机组由于燃用煤种与设计煤种差别很大,其实际燃煤的含硫量远远超过设计值,造成烟气中SO2排放量成倍增加,不能达标排放,需对其已有脱硫系统进行技术改造,主要是对吸收塔、氧化空气系统、石膏脱水、石灰石浆液供给系统、事故浆液排放系统进行了扩容改造。吸收塔浆液池增高壳体采用塔内立杆倒拉的方法进行顶升安装,上部1.8 m层喷淋层壳体采用吊装。改造后实际运行表明:脱硫率超过96%的设计值,其他指标均达到设计要求,工程改造后每年减排SO2 6.4万t,减排粉尘358 t,每年可节省排污费支出4 032万元,具有显著的社会和经济效益。     

冷冻分离法去除水中污染物的对比研究

分别以含Ca2＋、Mg2＋、Na＋等无机离子水样和含有溴氨酸（1-氨基-4-溴-蒽醌-2-磺酸钠）的水溶液、UIImann缩合反应产生废水为研究对象,采用静态渐进冷冻法分别在人工条件下进行实验,分析并对比了冷冻法对水体中污染物的去除效果和规律。结果表明：冷冻法可以有效去除水体中各种污染物,由于污染物自身结构不同,冷冻法对污染物分离有选择性,对有机物的去除高于无机离子,对单一污染物去除高于复杂废水。