A real-time optimization method for economic and effective operation of electrostatic precipitators

ABSTRACT

Electrostatic precipitators (ESP) have been considered as the main particulate matter (PM) removal facility in the energy industry. This paper presents a real-time optimization method for a one-chamber industrial ESP in an ultra-low emission power plant with an intelligent optimization system (IOS). The IOS seeks to optimize the energy consumption of ESP subject to the outlet concentration requirement in real-time. A coordination control logic is designed to regulate the optimized operation set points with varying operation conditions. The operation optimized by the IOS is compared with the operations under PID (proportion-integral-derivative) and manual control. The results show that the IOS improves the emission compliance rate from 95% of manual control to 100% and the medium concentration is tuned to be 46.6% closer to the emission target. Furthermore, a good balance between emission and energy consumption is achieved, with 35.50% energy conservation for the same emission upper limit of 30 mg/m³. These results prove that the IOS significantly contributes to the efficient operation and economic PM removal by ESP for the energy industry.     

Toxicity of arsenate and arsenite on germination, seedling growth and amylolytic activity of wheat

Effects of different concentrations of arsenite and arsenate (0-16 mg/l) on seed germination, relative root length and shoot height, arsenic accumulation in young seedlings, alpha-amylase, beta-amylase and total amylolytic activity in wheat were investigated in order to elucidate the toxicity of arsenic in the early developmental stage. Germination percentages of different wheat varieties had different responses to arsenic species and decreased significantly with increasing arsenic concentrations except Duokang 1. Relative root length (RRL) and relative shoot height (RSH) of wheat seedlings decreased with increasing concentrations of arsenite and arsenate. The relative root lengths were correlated with the relative shoot heights for arsenite (r2 = 0.79) and arsenate (r2 = 0.77). Arsenic uptake by seedlings increased with the increasing concentrations of arsenite or arsenate and followed the Michaelis-Menten kinetics function. The average total amylolytic activity and beta-amylase activity had no significant difference comparable to that of controls at the concentration 2 mg/l arsenite or arsenate, but decreased apparently when the concentration was higher than 2 mg/l. Whereas the alpha-amylase activity decreased with increasing concentrations of arsenite or arsenate over the whole concentration range. Arsenite decreased all the endpoints more remarkably than arsenate. In comparison, shoot height and root length were more sensitive to arsenic than other endpoints and might be used as indicators for arsenic toxicity.     

Treatment of refectory oily wastewater by electro-coagulation process

Electro-coagulation was used to treat refectory wastewater with high oil and grease contents. Different operational conditions were examined, including pH, current density, reaction time, conductivity, electrode distance and inlet concentration. The optimum current density was 10-14 A m(-2) within 30 min depending on the wastewater properties tested. Conductivity had little effect on the treatment efficiency. Although the addition of extra salts (e.g., sodium chloride) to the wastewater did not help increase the pollutant removal efficiency, it could save the power consumption significantly. The COD(Cr) and oil removal efficiency descended with increasing electrode distance. The optimal electrode distance was determined to be 10 mm for this equipment in consideration of the treatment cost and efficiency together. The pH effect on the performance of the electro-coagulation process was not very significant in the range of 3-10. The removal efficiency of oil and COD(Cr) under normal condition exceeded 95% and 75%, respectively.     

采用泥回流处理彩色显像管含氟废水

本文通过中和、混凝沉降法除氟过程,研究了彩色显像管工业废水除氟的适宜工艺条件。现场试验表明:应用泥回流处理技术,采用高效絮凝剂处理含氟废水,排放废水氟含量可稳定在4-6mg/L之间,低于排放标准（10mg/L）,同时废水处理的成本大大降低。     

二步法腈纶生产废水的处理试验

本试验采用混凝 -A/O系统组合工艺处理二步法腈纶废水 ,该系统处理效果良好 ,出水水质符合排放标准 ,可直接排入水体。A/O系统试验装置总容积 80L ,水力停留时间 5 8— 70h ,缺氧池与好氧池的容积比为 1∶3 ,回流比 ( 2—3 )∶1,COD和BOD总去除率分别约为 84%和 98%。     

微波加热对活性炭表面基团及其对SO2吸附性能的影响

采用了微波加热技术,通过在不同微波功率和辐射时间条件下对不同粒径活性炭进行改性,研究了改性前后活性炭的表面化学基团、元素组成的变化,以及对SO2吸附性能的影响.结果表明,经过微波改性后活性炭的SO2吸附性能大为提高,微波功率是影响改性活性炭脱硫性能的主要因素.活性炭经微波热处理后,酸性基团发生分解,表面含氧量减少,碱性特征增强,是吸附性能增加的主要原因之一.     

Methane fluxes from tundra soils and snowpack in the maritime Antarctic

Methane fluxes were measured from three exposed tundra sites and four snowpack sites on the Fildes Peninsula in the maritime Antarctic in the summertime of 2002. The average fluxes at two normal tundra sites were −15.3 μg m⁻² h⁻¹ and −14.3 μg m⁻² h⁻¹, respectively. The fluxes from tundra site with fresh penguin dropping addition showed positive values with the average of 36.1 μg m⁻² h⁻¹, suggesting that the deposition of fresh droppings greatly enhanced CH₄ emissions from the poor Antarctic tundra during penguin breeding periods. The summertime variation in CH₄ flux was correlated with surface ground temperature and the precipitation. The correlation between the flux and PT₀, which is the product of the precipitation and surface ground temperature, was quite strong. The diurnal cycle of CH₄ flux from the tundra soils was not obtained due to local fluky weather conditions. The fluxes through four snowpack sites were also obtained by the vertical CH₄ concentration gradient and their average fluxes were −46.5 μg m⁻² h⁻¹, −28.2 μg m⁻² h⁻¹, −46.4 μg m⁻² h⁻¹ and −17.9 μg m⁻² h⁻¹, respectively, indicating that tundra soils under snowpack also consume atmospheric CH₄ in the maritime Antarctic; therefore these fluxes could constitute an important part of the annual CH₄ budget for Antarctic tundra ecosystem.     

深床过滤机理及其在水处理中的应用研究与进展

深床过滤既有过滤功能,又具生物处理作用,具有良好的应用前景;本文阐述了深床过滤的最新研究动向,深床过滤过程的数学模型的构建方法,国内外利用深床过滤技术处理微污染水源水、城市生活污水及污水深度处理的实验研究状况.     

农林生物质在含铬废水处理中的应用

农林生物质作为低成本吸附剂在环境污染治理中日益受到重视。综述了农林生物质在含铬废水处理中的应用研究进展，分析了生物质处理含铬废水的机理、影响因素，指出了生物质法处理含铬废水的发展方向。     

Adsorption of nitrosamines in acidic solution by zeolites

Adsorption of N-nitrosopyrrolidine (NPYR) by zeolite NaZSM-5, Hbeta and NaZSM-11 in acidic solution with pH of 1 was investigated. The NPYR uptake process obeyed the first-rate Lagegren kinetic equation describing adsorption, and the equilibrium data were fitted to the Langmuir or Freundlich adsorption equation. Zeolite ZSM-5, Hbeta and NaZSM-11 possessed a higher adsorption capacity than amorphous silica or ordered mesoporous siliceous SBA-15, implying their potential application for adsorption of nitrosamines in gastric juice to anti-cancer.