Chemical additives affect sulfate reducing bacteria biofilm properties adsorbed on stainless steel 316L surface in circulating cooling water system

This paper studied the biofilm properties and corrosion behavior of sulfate reducing bacteria (SRB) on stainless steel 316L (SS316L) surface in circulating cooling water system with and without additives including hydroxy ethyl fork phosphonic acid (HEDP), dodecyl dimethyl benzyl ammonium chlotide (1227) and NaClO. Biochemical technique, electrochemical technology, X-ray photoelectron spectroscopy (XPS) and scanning electron microscope (SEM) were used. The results show that the extracellular polymeric substance (EPS) in biofilm attached on the SS316L surface mainly contain proteins and polysaccharides, the contents are 98 ug·cm^-2 and 635ug·cm^-2, respectively. The polysaccharides were cut by 1227 about 80%, while 55% by NaClO. The proteins were reduced by NaClO about 53%, while only 30% by 1227. The potentiodynamic polarization shows that the corrosion potential of SS316L was enhanced from -0.495 V to -0.390 V by the chemical additives, delaying the occurrence of the corrosion. And the corrosion rate was also reduced from 5.19 × 10^-3 mm·a^-1 to 2.42 × 10^-3 mm·a^-1. But NaClO still caused pitting corrosion after sterilizing the bacteria, while 1227 can form a protective film on the surface of SS316L. Though HEDP contribute to the bacteria activity, it can enhance the breakdown potential. XPS results confirmed that 1227 can change the value of C:O in the biofilm attached on metal surface, and NaClO can eliminate the existence of amidogen. This study would provide some recommendations for the selection of chemical additives in the thermal power plant.

Open image in new window

     

电化学方法现场产生H2O2的影响因素及其废水处理应用

建立了以石墨碳棒为阴极,Pt为阳极,饱和甘汞电极为参比电极,Na2SO4为支持电解质溶液的H2O2制备三电极体系。对电流密度、pH值、通氧流量、支持电解质浓度和极间距等主要参数对生成H2O2的影响进行了单因素轮换试验研究,并采用正交试验方法对这些因素进行了分析。结果发现,pH值对生成H2O2的影响最为显著,支持电解质浓度和通氧流量也具有较大影响,极间距影响不明显,电流密度则存在着最佳值。通过试验获得的最优参数组合为:pH=2.00,电流密度=1.02mA·cm-2,通氧流量=0.4L·min-1,支持电解质浓度=0.1mol·L-1,极间距=6cm。在该参数组合条件下,采用电-Fenton法对活性染料RedMX-5B进行脱色和矿化试验,初始Fe2 投量为0.25mmol·L-1,电解180min,脱色率可达90%以上,但矿化率不高(<25%)。因此,提高矿化率是染料废水处理在未来的主要课题。     

单嘧磺隆在小麦田中的残留试验研究

研究了单嘧磺隆的残留分析方法 ,单嘧磺隆在土壤中的消解动态和在土壤、小麦中的最终残留 .土壤经甲醇 /氨水混合液提取 (小麦用丙酮 /水混合液 ) .液液分配及C1 8小柱净化、用带紫外检测器的高效液相色谱仪测定 .单嘧磺隆的最低检出量为 4ng ,在土壤和小麦中的最低检出浓度为 0 0 2mg·kg- 1 .本方法的平均添加回收率为 91 1 7— 1 0 3 8% ,变异系数为 1 47— 1 1 8% .应用上述方法 ,测定了单嘧磺隆在北京、山东两地土壤中的消解动态以及在土壤、小麦中的最终残留 .结果表明 :在北京土壤中的半衰期为 9 2 4d ;在山东土壤中的半衰期为 1 3 5 9d;当按推荐剂量施药 ,小麦收获时 ,在土壤和小麦中 ,北京、山东两地均未检出单嘧磺隆     

城市垃圾焚烧主要工艺段捕集灰中二噁英的分布特征

采用同位素稀释法、高分辨气相色谱/质谱检测垃圾焚烧主要工艺段捕集灰中的二英.垃圾焚烧炉预热器、过热器和布袋除尘器捕集灰中二英(PCDD/Fs)的浓度分别为1025ng·g-1,1249ng·g-1和4670ng·g-1,毒性当量(ITEQ)为0073ng·g-1,0026ng·g-1和811ng·g-1.同时,分析了不同氯原子数取代的二英同系物在预热器、过热器、布袋除尘器捕集灰中的变化和对ITEQ值的贡献.     

Reconsideration on the effect of nitrogen on mixed culture polyhydroxyalkanoate production toward high organic loading enrichment history

Effect of nitrogen on mixed culture PHA production was reconsidered. Enrichment history of PHA accumulating culture was discussed. Higher PHA content and biomass growth were achieved in presence of nitrogen. Enrichment strategy toward higher PHA accumulation was investigated. Microbial community succession in PHA accumulation phase was investigated. In most of the operating strategies for mixed microbial cultures polyhydroxyalkanoate (PHA) production, moderate organic loads and low nitrogen concentrations are used, however, the real waste streams contain variable concentrations of carbon and nitrogen. To evaluate the effect of enrichment history on PHA producer and production the various carbon and nitrogen levels were utilized during the accumulation phase. Different operating strategies were applied in three sequencing batch reactors (SBRs) subjected to aerobic dynamic feeding. The maximum PHA production of the enriched cultures under nutrient excess, limitation and starvation (Cmol/Nmol ratio of 8, 40 and ∞, respectively) was evaluated in batch assays. A higher PHA content and biomass growth were achieved in the nutrients presence in comparison to the nutrient starvation condition. The cultures from the SBR treated under short sludge retention time, high organic loading rate, short cycle length (SBR#3) and nutrient excess reached the maximum PHA content (54.9%) and biomass increase (38.9%). Under nutrient limitation, the negative biomass growth was observed under nutrient starvation because of the sampling loss. The succession of microbial communities in SBRs and batch assays was analyzed using terminal restriction fragment length polymorphism. The SBR#3 had the best overall PHA production performance considering its high PHA content and productivity in all nutrient content, it indicates that nitrogen has a substantial impact on PHA yield especially when high organic loading rate enrichment history is involved.     

Characterization of submicron particles during autumn in Beijing, China

In this study, we performed a highly time-resolved chemical characterization of nonrefractory submicron particles(NR-PM_1) in Beijing by using an Aerodyne high-resolution time-of-flight aerosol mass spectrometer(HR-ToF-AMS). The results showed the average NR-PM_1 mass concentration to be 56.4 ± 58.0 μg/m~3, with a peak at 307.4 μg/m~3. Due to the high frequency of biomass burning in autumn, submicron particles significantly increased in organic content, which accounted for 51% of NR-PM_1 on average. Secondary inorganic aerosols(sulfate + nitrate + ammonium) accounted for 46% of NR-PM_1, of which sulfate,nitrate, and ammonium contributed 15%, 20%, and 11%, respectively. To determine the intrinsic relationships between the organic and inorganic species, we used the positive matrix factorization(PMF) model to merge the high-resolution mass spectra of the organic species and NO+and NO_2~+ions. The PMF analysis separated the mixed organic and nitrate(NO+and NO_2~+) spectra into four organic factors, including hydrocarbon-like organic aerosol(HOA), oxygenated organic aerosol(OOA), cooking organic aerosol(COA), and biomass burning organic aerosol(BBOA), as well as one nitrate inorganic aerosol(NIA) factor. COA(33%) and OOA(30%) contributed the most to the total organic aerosol(OA) mass, followed by BBOA(20%) and HOA(17%). We successfully quantified the mass concentrations of the organic and inorganic nitrates by the NO+and NO2+ions signal in the organic and NIA factors. The organic nitrate mass varied from 0.01-6.8 μg/m~3, with an average of 1.0 ±1.1 μg/m~3, and organic nitrate components accounted for 10% of the total nitrate mass in this observation.     

浅谈水质在线监测仪器的维护与质量控制管理

通过对水质自动监测系统的日常维护与质量控制管理，从水质自动监测系统的维护、室内外质量控制管理、综合分析与控制管理等方面进行分析，提出了保证自动监测系统准确性控制措施，为水质自动监测系统管理提供参考。     

中国危险废物和医疗废物焚烧处置行业二（口恶）排放水平研究

通过调研全国危险废物和医疗废物焚烧处置设施,对包含二噁英排放水平的设施按处置对象、炉型和处理量分类,并作系统分析和研究.结果表明现有危险废物焚烧设施烟气中二噁英的浓度比医疗废物低,达标率为74.19%;危险废物选用回转窑处置效果较好,达标率为66.67%;而医疗废物选用回转窑或热解炉,要综合考虑处置规模、生产成本和二英排放总量等因素;危险废物介于10~30 t·d-1和医疗废物介于10~20 t·d-1的处置设施要尤其注意二噁英的排放问题;医疗废物焚烧飞灰中二噁英的均值浓度为危险废物6倍以上,仅有16.67%满足填埋要求.二者烟气中二英的浓度分布以1,2,3,4,6,7,8-HpCDF、2,3,7,8-TCDF和OCDD为主.     

臭氧对枯草芽孢杆菌孢子的灭活研究

隐孢子虫灭活困难,给饮用水安全带来了挑战。实验以枯草芽孢杆菌孢子(ATCC6633)作为隐孢子虫的指示菌,研究了臭氧浓度、浊度、有机物、温度等因素对臭氧灭活枯草芽孢杆菌孢子的影响。研究表明,臭氧对枯草芽孢杆菌孢子的灭活与CT值相关,臭氧浓度对消毒效果影响较小;降低浊度、有机物含量,能提高臭氧对枯草芽孢杆菌孢子的灭活效率;温度降低,为保证一定的消毒效率,所需的CT值越大。研究结果为水厂合理控制运行参数提供了借鉴。