城市污水石灰法深度处理工艺中有毒物质的变化规律

分别采用7-乙氧基异酚恶唑酮．脱乙基酶（EROD）活性测定法，重组人激素受体基因的酵母测试和Q67发光菌试验方法，对北京市某生活污水处理厂的进水、二沉出水以及经过石灰法深度处理后的出水中的类二恶英物质、类雌激素物质和急性毒性物质进行了分析。进水中的三类生物毒性效应物质中的急性毒性物质，可通过活性污泥法基本去除，而对类雌激素物质和类二恶英物质的去除率分别为76％和52％。经过石灰沉淀法的深度处理后，可使上述两类物质的总去除率达到95％和68％。出水中的雌激素当量水平与欧洲国家污水处理厂出水水平相当，而类二恶英物质的总浓度低于美国EPA饮用水中二恶英的最大允许浓度。展示了生物毒性测试方法在排水生态风险和工艺评价方面的应用潜力。     

HCHs and DDTs in sediment-dwelling animals from the Yangtze Estuary, China

HCHs and DDTs in sediment-dwelling animals including mollusks and crabs from the Yangtze Estuary were determined by GC-ECD. Levels of t-HCH were in the range of 1.2-5.5 ng g(-1) and averaged 3.5 ng g(-1) in mollusks, while t-DDT concentrations ranged from 26.0 to 68.8 ng g(-1), with a mean of 34.5 ng g(-1). In crabs t-HCH concentrations varied from 2.0 to 25.7 ng g(-1) and averaged 13.8 ng g(-1), whereas the concentrations of t-DDT were in the range of 1.5-24.8 ng g(-1) with a mean value of 5.9 ng g(-1). The HCHs and DDTs levels depend on geographical position and sources, showing the high levels at fresh water area in the estuary, such as XP, CM and LHK sites, and lower at brackish water area, such as FX site, and little difference between species. Results also indicate there was no significant relationship between t-HCH (t-DDT) concentrations and lipid contents both in mollusks and crabs because of non-equilibrium state under a specific estuarine dynamics; smaller individuals accumulated more HCHs and DDTs than larger individuals of mollusks at LHK site, showing different uptake rate for these pesticides; moreover, HCHs and DDTs levels were lower in female crab bodies than male crab bodies suggesting that the release of spawning. BSAFs (Biota- Sediment Accumulation Factors) from sediment-dwelling animals for HCHs and DDTs show a significant "one high with two low" and "one low with two high" effect in the Yangtze Estuary.     

Combined glassification of EAF dust and incinerator fly ash

Stainless steelmaking dust contains large amount of heavy metals, such as Cr and Ni. If these hazardous materials are not treated properly, they will cause detrimental secondary contamination. Preliminary study on recycling stainless steelmaking dust employed the thermal molten technology. Glass-ceramics were formed by combination stainless steel dust and incinerator fly ash with the ratio of 1:9. The major phases were Augite, Akermanite, and Donathite. It was found that the glass-ceramics shows the best characteristic at 900 degrees C after 5 h of heat treatment. This product can be used as building materials or refractory materials.     

青霉菌HHE-P7利用酱油废水产生微生物絮凝剂的研究

研究了微生物絮凝剂产生菌HHE-P7在酱油废水中产生微生物絮凝剂的絮凝特性。实验表明，酱油废水由于碳源丰富，是一种良好的培养基。HHE-P7菌最佳培养条件为：COD20000mg／L，K2HP041．0g／L，培养3d。最佳絮凝条件为在1L高岭土水中投加10～15mL微生物絮凝剂（MBF7），pH调至9，则絮凝率为90％以上；微生物絮凝荆在水系中主要起吸附架桥的作用。     

Optimizing electron spin resonance detection of hydroxyl radical in water

The parameters affecting the electron spin resonance (ESR) detection of hydroxyl free radical in water are studied and optimized. The hydroxyl radical is generated by the Fenton reaction with iron (II) ammonium sulfate and hydrogen peroxide reacting in a phosphate buffer using N-tert-butyl-alpha-phenylnitron as the spin trap. The concentrations of Fe²⁺, H₂O₂, and phosphate buffer are the parameters studied. The Taguchi method and the orthogonal experiment design were used to evaluate the effects of these parameters on the ESR signal intensity. By the analysis of the signal-to-noise ratio and the analysis of variance, the order of importance of the various parameters on the hydroxyl radical formation is determined for optimal ESR detection of hydroxyl radical. The results will help the development of water purification technologies using hydroxyl free radical as a green oxidant.     

Spatial distribution and ecological risk assessment of sediment metals in a highly industrialized coastal zone southwestern Taiwan

Spatial variations of Cr, Cu, Hg, Ni, Pb, and Zn in the surface sediments from 34 stations of the Kaohsiung coastal zone southwestern Taiwan were studied to address the current pollution status, sediment quality, and potential ecological risk. The study revealed that the concentrations of sediment metals in Kaohsiung Harbor were alarmingly high compared to the other region of Kaohsiung coast. The concentrations of Cr, Cu, Hg, Ni, Pb, and Zn in the harbor sediments were as high as 351, 247, 1.93, 61.8, 60.9, and 940 mg kg⁻¹, respectively. The current situation of metal pollution was assessed by different pollution indices and results showed moderate to severe enrichment of Cu, Hg, and Zn in the harbor sediments. According to the degree of contamination, pollution load index, and contamination severity index, the sediments from the inner Kaohsiung Harbor show high degree and high severity of metal contamination, while the rest of Kaohsiung coastal areas show uncontaminated or low-level pollution. Results of mean ERM quotient and potential ecological risk index also indicated that the harbor sediments posed a 49% probability of biological toxicity and very high ecological risk. The toxic units indicated that the negative biological effects of the six metals in the harbor sediments were Zn > Cu > Cr > Ni > Hg > Pb. In contrast to Kaohsiung Harbor as a trap where considerable amount of anthropogenic metal loadings accumulated in sediments, low metal concentrations were observed in most Kaohsiung coastal sediments. It probably resulted from the limited fine-grained sediment deposition. In the wave-dominated Kaohsiung coastal zone, fine-grained sediments associated with polluted metals tend to be easily resuspended and transported offshore via waves and wave-induced currents. The results of this study can provide valuable information for river and coastal zone management.

     

短程硝化过程2种亚硝酸盐氧化菌抑制策略探讨

为维持短程硝化稳定,保证亚硝酸盐高效积累,需要对污水处理系统亚硝酸盐氧化菌(NOB)的性质进行深入了解。分别对Nitrospira以及Nitrobacter的动力学参数,以及在活性污泥系统、生物膜系统、颗粒污泥系统中2菌属特性进行比较。经分析后认为,Nitrospira相对于Nitrobacter比增长速率较低,对O2,NO2-底物亲和性较好,适宜生长于低浓度环境中,是A2/O、短程硝化-厌氧氨氧化工艺中的主要NOB菌属;Nitrobacter则适宜在高浓度环境中生长。在颗粒污泥系统中,NOB主要处于污泥内部,由于缺乏O2,NO2-更容易被淘汰出反应器。通过对比短程硝化主要控制参数,认为NOB的抑制策略包括：在活性污泥系统中维持合理的污泥龄(SRT)以及游离氨(FA)浓度;在生物膜系统中对溶解氧(DO)以及水力停留时间(HRT)进行联合控制;在颗粒污泥系统中维持适量剩余NH4+-N,并淘洗出掺杂其中的絮状污泥。此外,利用“饱食饥饿”效应间歇曝气并维持较低的曝停比同样有利于阻止亚硝酸盐被NOB进一步氧化,保证短程硝化稳定运行。     

Fenton法降解垃圾渗滤液中的溶解性有机质

垃圾渗滤液是一种高浓度难降解废水,含有大量有毒物质和溶解性有机质（dissolved organic matter, DOM）,可生化性差。Fenton试剂（Fe2++H2O2）能产生活性极强的羟基自由基（·OH）,能快速氧化渗滤液中DOM和微量有机物质。本研究采用Fenton法处理垃圾渗滤液,结果表明,在优化的处理条件下,渗滤液COD和TOC去除率分别为65%和42%,其中混凝作用去除的COD和TOC分别为20%和21%。进一步通过紫外可见光谱扫描、SUVA254、E3/E4等指标评价,发现Fenton法可以有效降低渗滤液中的DOM含量,大分子有机物的含量明显减少,而分子量小的有机物含量相对增加,反应体系中溶解性有机物分子量随着反应的进行而降低,腐殖化程度降低。利用GC-MS定性出渗滤液原液中47种有机物,该类有机物在Fenton反应后上清液中未再检出,但5种物质（邻苯二甲酸二（2-乙基己）酯、植酮、角鲨烯、麥角甾烷醇和二氢胆固醇）在沉淀的铁泥中检出。研究发现不同pH值、H2O2和Fe2+浓度条件下,残留的COD与DOM、TOC和UV254存在显著的相关关系（R2> 0.9）。本研究结果为改进垃圾渗滤液处理工艺和探索DOM在Fenton过程中的降解行为提供科学依据。     

氧化硫硫杆菌JJU-1生物淋滤去除污泥中的重金属

将前期分离得到的嗜酸性氧化硫硫杆菌JJU-1（Thiobacillus thiooxidans JJU-1）接种于污水处理厂污泥中,进行为期7 d的生物淋滤实验,对淋滤过程中的pH值、氧化还原电位（ORP）和重金属去除率进行检测。研究结果表明：氧化硫硫杆菌JJU-1不同接种量处理浸出液的pH下降幅度不同,当接种量为15%时,浸出液pH下降最快,其ORP达到最大值（444 mV）,Cu、Cd和Pb的去除率分别高达79.2%、96.6%和93.4%。添加能源物质S可以明显降低淋滤液的pH,当能源物质S投入量增加到12 g·L-1时,淋滤7 d后,浸出液的pH下降至1以下,浸出液的ORP在S添加量为16 g·L-1时达到最大值（477 mV）,20 g·L-1 S粉添加量条件下,Cr、Cu和Pb的去除率最大,分别为98.8%、74.3%和85.8%;然而,添加能源物质S对Cd的浸出无明显影响。以上研究结果表明,氧化硫硫杆菌JJU-1在去除污泥中重金属方面有着广阔的前景。     

Ti-Si-Ox脱硝催化剂载体的组分优化及其性能研究

采用挤出成型法制备系列Ti-Si-Ox复合氧化物催化剂载体,研究了Ti-Si-Ox催化剂载体组分配比、酸量、比表面积与脱硝性能和抗压强度的关系。采用XRD、Raman spectra、N2-BET、Py-IR以及XPS等表征技术对催化剂载体进行表征。结果表明：Ti/Si元素摩尔比为9∶1时Ti0.9Si0.1Ox催化剂载体的轴向抗压强度适中且脱硝催化活性最高;在5 000 h-1空速条件下,催化剂载体最高脱硝活性在400 ℃时达到99.0%且起燃温度降至260 ℃;另外,Ti0.9Si0.1Ox催化剂载体的比表面积为75.4 m2·g-1,介孔最可几分布为8.1 nm,轴向抗压强度为1.4 MPa,符合工业应用条件,即Ti-Si-Ox载体具有较好的工业应用前景。