高效絮凝菌的培养条件优化

从呼和浩特市污水处理厂筛选分离了1株高效絮凝剂产生菌YS2,通过培养条件优化试验确定了该菌株产絮凝剂的最佳培养条件:碳源为蔗糖、氮源为脲、N/C为2.5∶1、初始pH值为6.0、培养温度为30℃。絮凝试验表明:该菌株产生的生物絮凝剂对高岭土悬浊液有良好的絮凝效果,絮凝率达到95%。絮凝活性分布试验表明其絮凝活性全部存在于离心沉降物中,而上清液没有絮凝活性。16S rDNA测序鉴定其为克雷伯氏菌G。     

Denitrification and phosphorus uptake by DPAOs using nitrite as an electron acceptor by step-feed strategies

Denitrifying phosphorus accumulating organisms (DPAOs) using nitrite as an electron acceptor can reduce more energy. However, nitrite has been reported to have an inhibition on denitrifying phosphorus removal. In this study, the step-feed strategy was proposed to achieve low nitrite concentration, which can avoid or relieve nitrite inhibition. The results showed that denitrification rate, phosphorus uptake rate and the ratio of the phosphorus uptaken to nitrite denitrified (anoxic P/N ratio) increased when the nitrite concentration was 15 mg·L^-1 after step-feeding nitrite. The maximum denitrification rate and phosphorus uptake rate was 12.73 mg NO2-–N·g MLSS-1?h-1 and 18.75 mg PO43-–P·g MLSS-1?h-1, respectively. These rates were higher than that using nitrate (15 mg·L^-1) as an electron acceptor. The maximum anoxic P/N ratio was 1.55 mg PO43--P?mg NO2--N-1. When the nitrite concentration increased from 15 to 20 mg NO2--N?L-1 after addition of nitrite, the anoxic phosphorus uptake was inhibited by 64.85%, and the denitrification by DPAOs was inhibited by 61.25%. Denitrification rate by DPAOs decreased gradually when nitrite (about 20 mg·L^-1) was added in the step-feed SBR. These results indicated that the step-feed strategy can be used to achieve denitrifying phosphorus removal using nitrite as an electron acceptor, and nitrite concentration should be maintained at low level (<15 mg·L^-1 in this study).     

氮缺乏引起的非丝状菌活性污泥膨胀

采用SBR法处理啤酒废水,研究了进水中不同有机物与总氮的比值(以BOD/N计)条件对活性污泥膨胀的影响.结果表明,在进水BOD/N为100/4的条件下,污泥的沉降性能良好;在进水BOD/N分别为100/3和100/2时,均发生由高含水率的粘性菌胶团过量生长引起的非丝状菌膨胀.在进水BOD/N为100/0.94的条件下,发生的非丝状菌膨胀最为严重.试验中还研究了氮缺乏条件下污泥微生物对氮源和磷源的利用率以及COD去除率的变化.     

Anoxic phosphorus removal in a pilot scale anaerobic-anoxic oxidation ditch process

The anaerobic-anoxic oxidation ditch (A²/O OD) process is popularly used to eliminate nutrients from domestic wastewater. In order to identify the existence of denitrifying phosphorus removing bacteria (DPB), evaluate the contribution of DPB to biological nutrient removal, and enhance the denitrifying phosphorus removal in the A²/O OD process, a pilot-scale A²/O OD plant (375 L) was conducted. At the same time batch tests using sequence batch reactors (12 L and 4 L) were operated to reveal the significance of anoxic phosphorus removal. The results indicated that: The average removal efficiency of COD, NH₄⁺, PO₄³⁻, and TN were 88.2%, 92.6%, 87.8%, and 73.1%, respectively, when the steady state of the pilotscale A²/O OD plant was reached during 31–73 d, demonstrating a good denitrifying phosphorus removal performance. Phosphorus uptake took place in the anoxic zone by poly-phosphorus accumulating organisms NO₂⁻ could be used as electron receptors in denitrifying phosphorus removal, and the phosphorus uptake rate with NO₂⁻ as the electron receptor was higher than that with NO₃⁻ when the initial concentration of either NO₂⁻ or NO₃⁻ was 40 mg/L.     

新型高效台车式退火炉研制

退火炉采取小燃烧室,对工件实行侧下加热、强化绝热措施复合炉衬、二次均热风管、扩张室沉降等五项措施.目的是为了提高炉的热效率和炉温的均匀度.在耗煤量较低的情况下能保持较高的燃烧室强度.有利于强化燃烧和减少蓄散热损失.实行扩张室沉降,在不加任何除尘装置的条件下烟尘排放浓度达到了国家标准新规定的排放要求,而且大大改善了工人的劳动条件.     

硝基芳烃化合物诱发细胞微核的比较研究

利用蚕豆根法细胞和人在淋巴细胞的微核试验对６种硝基芳烃化合物的致突变性进行比较研究，结果表明，邻二硝基苯、间二硝基苯、２，４－二硝基甲苯，２，６－二硝基甲苯，对硝基氯苯和对硝基溴苯均能诱发两咱细胞的微核率增加，除了对硝基溴苯外均具有明显剂量一效应关系。引进标准剂量概念比较５种硝基芳烃人合物的致突变性，结果表明，致突变性强弱依次为２，４－二硝基甲苯〉对硝基氯苯〉间二硝基苯〉２，６－二硝基甲苯〉邻二硝     

以DO、ORP、pH作为两段SBR工艺的实时控制参数

介绍了在传统SBR脱氮工艺的基础上 ,开发的用于处理COD和氮浓度较高的工业废水的两段SBR系统 (TSSBR) .根据传统SBR工艺在反应过程中 ,当COD不再被降解 ,而硝化反应又没有开始时 ,DO迅速大幅度升高以及pH曲线上出现的拐点 ,可以将COD降解与硝化反应分割开 ,先后在不同的反应器内进行 ,分别命名为SBR1和SBR2 ,避免高COD浓度对硝化反应的冲击 ,提高处理效率 .利用在线检测的DO、ORP和pH参数实时控制SBR1、SBR2各个生化过程的反应时间 ,解决了两段SBR系统的自动控制问题 ,可以使系统长期稳定运行 ,保证出水水质 ,节约能耗 .采用实时控制策略 ,并控制系统温度在 3 0℃左右 ,可将SBR2的硝化反应控制在亚硝酸型硝化结束 .采用该工艺处理石化废水 ,COD去除率达到 90 %～ 95 % ,3 0℃时的比硝化反应速率达到 0 3kg(NH4 N) (kg(MLSS)·d) ,出水已检测不出氨氮和硝态氮     

炼油污水处理场技术改造

对广州石化炼油新污水处理场现状进行了分析 ,针对存在问题 ,通过更换原有设备 ,增加新设备对其进行了技术改造 ,大大地提高了外排污水合格率     

活性污泥法的多变量最优控制Ⅰ.基础理论与DO浓度对运行费用的影响

在现有的关于活性污泥法最优控制研究的基础上，首次提出了以两个最重要的控制参数污泥排放量和溶解氧浓度（ＤＯ）为控制变量、以出水水质为约束条件、以运行费用为性能指标的活性污泥法多变量最优控制的研究问题，并着重进行了基础研究．首先建立了最优控制所必要的基本状态方程与性能指标的泛函表达式．然后通过计算研究了在满足同一出水质量前提下控制不同的ＤＯ浓度时所需要的运行费用．结果表明，ＤＯ为０９ｍｇ／Ｌ时所需运行费用最少，这与主张应当维持ＤＯ浓度大于２ｍｇ／Ｌ的传统观点相比相差甚远；衰减速率常数Ｋｄ不受ＤＯ影响的假设也不合理．     

用溶解氧浓度作为SBR法过程和反应时间控制参数

进行了以DO作为SBR法过程和反应时间控制参数的试验研究。结果表明,无论使曝气量或初始污泥浓度大幅度变化,还是逐渐或突然改变初始有机物浓度等各种试验条件,都会在反应阶段开始不久出现所谓平衡DO浓度现象;当有机物达到其难降解浓度时DO浓度迅速地大幅度升高。因此,在目前还没有简易、快速的有机物浓度传感器的情况下,DO不仅可作为反应时间的指示性控制参数,而且也能可靠地作为反应阶段的过程控制参数。