Formation of PCDDs and PCDFs during the combustion of polyvinylidene chloride

In laboratory-scale combustion of polyvinylidene chloride (PVDC) with a quartz tubular furnace designed and fabricated to provide the desired combustion temperature and mixing state of combustion gas with air, it was found that at 800 degrees C or higher the level of polychlorinated dibenzo-p-dioxins/polychlorinated dibenzofurans [corrected] (PCDDs/PCDFs) resulting from PVDC combustion was no higher than that from heating air alone, and thus far below the levels which resulted from PVDC combustion at 750 degrees C or lower. The results provide the first laboratory confirmation of the relation between PVDC incineration temperature and PCDD/PCDF formation, and of the primary importance of high temperature, turbulence for mixing between air and combustion gas, and sufficient residence time, as governing factors for the minimization of PCDD/PCDF formation in municipal solid waste incinerators.     

In-field measurements of PCDD/F emissions from domestic heating appliances for solid fuels

Within this project the emissions into the atmosphere of polychlorinated dibenzo-p-dioxins and -furans (PCDD/F) of 30 domestic heating appliances in Austrian households were tested. The appliances were single stoves (kitchen stove, continuous burning stove and tiled stove) and central heating boilers for solid fuels up to a nominal heat input of 50 kW. A main objective of this survey was to determine the PCDD/F emissions of domestic heating units under routine conditions. Therefore, the habitual combustion conditions used by the operators were not influenced. The original fuels and lightning supports were used and the operation of the units was carried out by the householders according to their usual practice. The data obtained were used to calculate in-field PCDD/F-emission factors. Most of the appliances have shown PCDD/F emissions within a concentration range of 0.01-0.3 ng TEQ/MJ. Modern fan-assisted wood heating boilers with afterburning and units for continuously burning of wood chips and wood pellets had the lowest emissions. High emissions were caused by unsuitable heating habits such as combustion of wastes and inappropriate operation of the appliances. There were only small differences between single stoves and central heating boilers or between wood and coal-fired appliances. The emission factors calculated are higher than those cited in literature, which are mainly derived from trials on test stands under laboratory conditions.     

Effect of arsenic-contaminated irrigation water on agricultural land soil and plants in West Bengal, India

Total arsenic withdrawn by the four shallow tubewells, used for agricultural irrigation in the arsenic-affected areas of Murshidabad district per year is 6.79 kg (mean: 1.79 kg, range: 0.56-3.53 kg) and the mean arsenic deposition on land per year is 5.02 kg ha(-1) (range: 2-9.81 kg ha(-1)). Mean soil arsenic concentrations in surface, root of plants, below ground level (0-30 cm) and all the soils, collected from four agricultural lands are 14.2 mg/kg (range: 9.5-19.4 mg/kg, n = 99), 13.7 mg/kg (range: 7.56-20.7 mg/kg, n = 99), 14.8 mg/kg (range: 8.69-21 mg/kg, n = 102) and 14.2 mg/kg (range: 7.56-21 mg/kg, n = 300) respectively. Higher the arsenic in groundwater, higher the arsenic in agricultural land soil and plants has been observed. Mean arsenic concentrations in root, stem, leaf and all parts of plants are 996 ng/g (range: <0.04-4850 ng/g, n = 99), 297 ng/g (range: <0.04-2900 ng/g, n = 99), 246 ng/g (range: <0.04-1600 ng/g, n = 99) and 513 ng/g (range: <0.04-4850 ng/g, n = 297) respectively. Approximately 3.1-13.1, 0.54-4.08 and 0.36-3.45% of arsenic is taken up by the root, stem and leaf respectively, from the soil.     

T cell-derived IL-5 production is a sensitive target of 2,3,7,8-tetrachlorodibenzo-p-dioxin (TCDD)

The immune system is one of the organs most vulnerable to the toxicity of 2,3,7,8-tetrachlorodibenzo-p-dioxin (TCDD). Among the various immunotoxic effects of TCDD, the thymus involution and suppression of IgM antibody production are well known sensitive reactions of the thymocytes and B cells affected by TCDD. Recently, we reported that TCDD greatly inhibits the production of type-2 helper T (Th2) cell-derived cytokines, especially IL-5, by the splenocytes in mice immunized with ovalbumin (OVA). In the present study, we investigated the dose-dependency of these TCDD immunotoxic effects in OVA-immunized mice to identify the most sensitive target. Mice of two age groups, 6 weeks old and 3 weeks old, were dosed with 0.3, 1.0, or 3.0 microg TCDD/kg and immunized with OVA using alum as an adjuvant. Seven days later, the thymus weight, thymocyte population, antigen-specific IgM in the plasma, and IL-5 production by the splenocytes were examined. Among them, IL-5 production was significantly suppressed by all three doses of TCDD and reduced to about 30% by even a small dose of 0.3 microg TCDD/kg in both age groups. The thymus weight was significantly reduced by 1.0 microg or 3.0 microg TCDD/kg, but IgM production was not affected by up to 3.0 microg/kg of TCDD in both age groups. Taken together, the Th2 cell-derived IL-5 production was the most sensitive endpoint detecting TCDD toxicity among those examined. Our results also suggest that effector T cells are targets more vulnerable to TCDD toxicity than thymocytes or antibody-producing B cells in the OVA-immunized mice.     

De novo formation characteristics of dioxins in the dry zone of an iron ore sintering bed

The objectives of this work are to understand the details of the mechanism of dioxin formation in the part of a sintering bed termed the dry zone, and to obtain ideas on how to prevent their formation. Sinter mixtures of various composition types were heated in a packed bed reactor, and dioxins in the outlet gas and in the sinter mixture residue were measured. The dioxin formation potential of a simple sinter mixture composed of iron ore, coke and limestone was markedly lower than that of fly ash from a municipal solid waste incinerator (MSWI). In consideration of this result, a series of experiments were conducted using a sinter mixture impregnated with CuCl2. Experimental results showed that dioxin formation was temperature-dependent in the range of 300-550 degrees C, with the maximum observed at around 300 degrees C, which was quite similar to that of fly ash from the MSWI. The homologue distribution of PCDD/Fs in gas and solid reflected the possible difference in carbonaceous materials in coke and activated coke. Gaseous hydrogen chloride acted as a chlorinating reagent for dioxin formation.     

pH dependence of ferrous sorption onto two smectite clays

This work examines the abilities of two smectite minerals (SWa-1 and Wyoming montmorillonite) to adsorb ferrous iron at concentrations from 0.037 mM (2 ppm) to 2.5 mM (240 ppm) over a range of pHs from 4.0 to 8.0. Both sorption isotherm and sorption edge data are presented. Ferrous sorption (Fe(aq)2+ = 0.1 mM) to both SWa-1 and Wyoming montmorillonite over the pH range 4.0-6.75 is relatively constant at approximately 1000 l kg(-1) for both minerals. Sorption in this pH range is attributed to the cation exchange capacity of the clay along the basal surfaces. At pH values above 6.75 the amount of ferrous iron sorbed increases dramatically. At pH 8, sorption (Fe(aq)+ = 0.1 mM) reaches 6600 l kg(-1) and 8000 l kg(-1) for Swa-1 and Wyoming montmorillonite respectively. This is attributed to the specific interaction between ferrous ions and surface sites along mineral edges. The overriding geochemical implication is that in reduced sediments containing more than a few percent clay, the pool of sorbed ferrous iron is vast. This pool of reduced iron is both redox labile and bio-available and is not readily indicated by simple measurement of dissolved Fe2+.     

Biodegradation and toxicity of wastewater from industry producing mineral fibres for thermal insulation

The water chemistry, toxicity, and biodegradation of wastewater from an industry producing mineral fibres for thermal insulation were studied. Values for COD, BOD5, suspended solids, and phenol exceeded permissible values for the wastewater discharged into a nearby river and acute toxicity was also detected. Consequently, the effluent should be treated in a municipal wastewater treatment plant so its ready biodegradability was investigated. We found that the wastewater was readily biodegradable, therefore we assume it can be treated in the wastewater treatment plant as the ratio of the wastewater flow rate and the minimal total inflow into the sewage treatment plant would be one to at least 30.     

Behavior of dioxin during thermal remediation in the zone combustion process

In the previous study, a new process concept for the thermal remediation of particulate/powder materials contaminated by polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/Fs) has been verified. It leads to removal efficiencies of more than 99.9% in the soil contaminated by PCDD/Fs in terms of toxicity equivalent quantity (TEQ). However, details of the reactions and phenomena during the process, i.e., decomposition, vaporization, reformation and trap of PCDD/Fs and their relating compounds, have not sufficiently been clarified yet. The present study aims to examine experimentally the transport and fate of PCDD/Fs in the process. In the experiment, a laboratory-scale process simulator and a soil sample preliminary mixed with octachlorinated dibenzo-p-dioxin spiked by carbon-13 isotope (13C-OCDD) were used. The distribution of 13C-OCDD in the soil bed during the process was measured by applying a quench technique that rapidly cools-down the bed. Further, the total amount of 13C-OCDD discharged with outlet gas was measured. Using the obtained data, mass balance of 13C-OCDD in the process was estimated. The results show that about 99% of 13C-OCDD preliminary admixed with the soil was decomposed rather than released to the outlet gas. Only a trace amount of 13C-OCDD remained in the treated soil. In addition, a very small amount of other congeners having the 13C-cycles was detected in the treated soil and outlet gas although its TEQ values are not significant. These were probably formed by dechlorination reactions occurring in the process.     

Brominated flame retardants and other organobromines in Norwegian predatory bird eggs

A set of 62 unhatched eggs was collected from six different predatory bird species throughout Norway after incubation period was completed. They were analysed for PBDE, PBB, TBBP A and naturally occurring halogenated compounds. BDE 47, 99 and 153 were the dominating congeners, with species dependent PBDE patterns. BDE 153 was observed as the most abundant congener in eggs of peregrine falcon, golden eagle and merlin. The highest PBDE level (sum of nine congeners) was found in eggs of white-tailed sea eagle with up to 800ng/gww (median sumPBDE: 184ng/gww), followed by eggs of peregrine falcon and osprey (median sumPBDE: 155 and 105ng/gww, respectively). Golden eagle eggs showed the lowest concentration of all species (median sumPBDE: 3ng/gww). The levels in the peregrine falcon are similar to those found earlier in the Baltic region [Lindberg, P., Sellstrom, U., Haggberg, L., de Wit, C.A., 2004. Higher brominated diphenyl ethers and hexabromocyclododecane found in eggs of peregrine falcons (Falco peregrinus) breeding in Sweden. Environmental Science & Technology. 38 (1), 93-96]. The differences between species are not fully explainable, due to lack of data from the major food species. BB 101 and 153 were found in eggs of all investigated bird species. Especially in samples of white-tailed sea eagle, peregrine falcon and goshawk additional unknown penta- and hexabrominated biphenyls were detected. TBBP A was detected in all of eight eggs analysed sampled from four different bird of prey species. The naturally occurring halogenated compounds Q1, the dibromotrichloro monoterpene MHC-1, and 2,4,6-tribromoanisole (TBA) were detected in all of seven analysed samples except for one peregrine falcon egg.     

Arsenic and other heavy metals in soils from an arsenic-affected area of West Bengal,India

Domkal is one of the 19, out of 26 blocks in Murshidabad district where groundwater contains arsenic above 0.05 mg/l. Many millions of cubic meters of groundwater along with arsenic and other heavy metals are coming out from both the hand tubewells, used by the villagers for their daily needs and shallow big diameter tubewells, installed for agricultural irrigation and depositing on soil throughout the year. So there is a possibility of soil contamination which can moreover affect the food chain, cultivated in this area. A somewhat detailed study was carried out, in both micro- and macrolevel, to get an idea about the magnitude of soil contamination in this area. The mean concentrations (mg/kg) of As (5.31), Fe (6740), Cu (18.3), Pb (10.4), Ni (18.8), Mn (342), Zn (44.3), Se (0.53), Mg (534), V (44.6), Cr (33.1), Cd (0.37), Sb (0.29) and Hg (0.54) in fallow land soils are within the normal range. The mean As (10.7), Fe (7860) and Mg (733) concentrations (mg/kg) are only in higher side whereas Hg (0.17 mg/kg) is in lower side in agricultural land soils, compared to the fallow land soils. Arsenic concentrations (11.5 and 28.0 mg/kg respectively) are high in those agricultural land soils where irrigated groundwater contains high arsenic (0.082 and 0.17 mg/l respectively). The total arsenic withdrawn and mean arsenic deposition per land by the 19 shallow tubewells per year are 43.9 kg (mean: 2.31 kg, range: 0.53-5.88 kg) and 8.04 kg ha(-1) (range: 1.66-16.8 kg ha(-1)) respectively. For the macrolevel study, soil arsenic concentration decreases with increase of distance from the source and higher the water arsenic concentration, higher the soil arsenic at any distance. A proper watershed management is urgently required to save the contamination.