污水处理一体化装置的研究现状与展望

污水处理一体化装置具有投资省、占地少、能耗低、处理效果好及管理简便等优点,是现代污水处理的新方向,有着广阔的应用前景。本文结合几种典型的污水处理工艺对污水处理一体化装置进行了概括性的介绍与展望。     

贵金属催化剂活性组分分布对催化湿式氧化处理非达霉素提炼废水的影响

采用均匀型和蛋白型Ru/TiO₂催化剂为湿式氧化催化剂,应用于催化湿式氧化非达霉素提炼废水,以出水COD和TOC去除率作为指标来评价2种催化剂的催化活性差异;采用实验室连续评价装置对柱状颗粒催化剂在不同pH、不同废水流量和不同温度下处理非达霉素提炼废水进行了优化评价。结果表明：在265 ℃、pH=4.1、废水流量为10 mL·h⁻¹时,催化剂的催化活性最高,故确定此条件为该废水处理的最优条件;同时对比均匀型和蛋白型2种催化剂,蛋白型催化剂具有更高的催化效率;结合SEM及N₂-物理吸附结果,推断蛋白型催化剂活性组分集中分布在催化剂颗粒的较浅层,有利于降低反应过程中的扩散阻力,提高贵金属活性组分的利用率,进而提高催化剂的催化活性。以上结果对开发高效湿式氧化催化剂,充分利用贵金属活性组分降低催化剂成本具有十分重要的意义。     

浓磷酸预处理废弃棉织物回收葡萄糖和涤纶的优化

为了实现废弃棉织物的高效资源化利用,采用浓磷酸预处理,将棉纤维转化为葡萄糖,并回收高纯度涤纶.以磷酸浓度、磷酸与原料液固比、预处理温度和时间为研究对象,以涤纶回收纯度、葡萄糖收率为考察指标,采用中心组合设计(CCD),建立响应面模型对预处理工艺参数进行优化.并确定了最佳的浓磷酸预处理工艺条件为:磷酸质量分数85%,液固比15:1,预处理时间7 h,预处理温度50℃.在此条件下涤纶回收纯度可达100%,葡萄糖收率可达79.0%,且实验验证值与模型预测值较为接近,模型精度较高.此外,再生纤维素不经干燥直接酶水解,葡萄糖收率可被进一步提高至83.0%.     

Photocatalytic activity of TiO2 films grown on different substrates

Titanium dioxide films were prepared on glass, indium-tin oxide (ITO) glass and p-type monocrystalline silicon and studied for the photocatalytic degradation of rhodamine B in an aqueous medium. Raman, AFM, and XPS spectroscopic investigations of these films indicated that microstructure of titanium oxide films were greatly affected by the substrate materials. Rutile was confirmed to be easily formed on the surface of ITO glass, and TiO2 tended to grow as closely packed particles that were elongated strips with an average size of 20 nm, and had lovely contrast with the perfectly round particles grown on p-type monocrystalline silicon. Charge transfer between the film and silicon substrate was verified by surface photovoltage spectra. This may be the real reason why the films grown on ITO glass and silicon substrates exhibit higher photocatalytic reactivity than the film on glass substrate. Moreover, the different surface properties also seem to be responsible for the different activity.     

Phytoremediation of industrial sludge using vegetation‐assisted dewatering

With the emergence of risk‐based corrective action decisions, there is interest in the use of more natural techniques that may be as protective as the traditional removal, landfill, or capping approaches for impoundment closure. The use of phytoremediation is one of the more promising techniques. This article presents the results of a three‐year field‐pilot phytoremediation study that involved the use of plants to enhance sludge dewatering at an inactive natural gas‐cracking wastewater lagoon. The dewatering was accompanied by contaminant reduction of benzene, toluene, xylene (BTX), and naphthalene concentrations to below the cleanup goals. Meanwhile, the concentration reductions of three or more ring polynuclear aromatic hydrocarbons (PAHs) varied between 30 percent and 60 percent, except for dibenz[a,h]anthracene. The residual PAHs in the sludge are not leaching. Parallel laboratory studies suggest a reduced PAH availability and mobility in the unsaturated zone sludge. © 2002 Wiley Periodicals, Inc.     

高速公路跨线桥地震反应的智能磁流变控制

探讨了高速公路跨线桥智能磁流变控制的效果，并与主动控制、磁流变（MR）阻尼器的passive-off控制及passive-on控制时的减震控制效果进行了系统的比较分析。研究中MR阻尼器的半主动控制算法选用限幅最优控制算法，其主控制器采用H2／LQG方法来设计，并基于原系统的降阶模型来设计MR阻尼器的最优控制力。仿真分析结果表明，采用MR阻尼器对高速公路跨线桥进行控制，可以有效地减小结构的动力反应，明显改善其抗震安全性。MR阻尼器在passive-off控制及passive-on控制时等效为被动摩擦阻尼器，其控制效果与适用范围均有限；MR阻尼器的半主动控制力可以出色地追踪主动控制力时程，其控制效果与主动控制时非常接近，因此可以作为主动控制的替代方案。     

新疆主要自然灾害及其减灾策略

新疆是一个自然灾害较多的地区,地震灾害、地质灾害、气象灾害、洪水灾害都比较频繁。本文在概述、分析上述灾害的基础上,提出了减轻自然灾害的策略。     

北京市机动车行驶工况研究

利用GPS对北京市乘用车、公交车和重型卡车进行实际道路工况数据采集,并进行了工况解析,提取了北京市典型行驶工况。结果表明,乘用车和公交车由于多运行于市区,车辆运行速度较低,怠速、加减速比例较高。重型卡车由于白天只能在五环外运行,匀速运行比例和平均速度均较高。与国外工况相比,北京市的轻重型车在平均速度、加速度和减速度、工况行驶比例均有比较大的偏差。     

DNA同源性分析最终确定新疆中华根瘤菌（Sinorhizobium xinjiangensis）为一独立种

针对S.xinjiangensis分类地位的争议,从新疆再次分离获得34株快生大豆根瘤菌,在16SrDNAPCR-RFLP分析和SDS全细胞蛋白电泳分群的基础上,进行了16SrDNA全序列相似性和DNA同源性分析.所测4个菌株和S.fredii模式菌株USDA205的16SrDNA全序列有很高的相似性.而DNA同源性分析说明新分离的菌株代表与原定的S.xinjiangensis为一个DNA同源群.其模式菌株CCBAU110与S.fredii的2株参比菌株USDA194、2048之间的DNA同源性分别为31.5%和28.7%.S.fredii的模式菌株USDA205与新分离的菌株代表及原定的S.xinjiangensis的模式菌株和2个参比菌株之间的DNA同源性为20.8%～39%,远低于70%.属于种水平上的差异.按照国际细菌分类委员会以DNA同源性≥70%且△Tm≤5℃作为定种的标准,S.xinjiangensis是Sinorhizobium属中不同于S.fredii的一个独立的种.表3参20     

SDG-based HAZOP analysis of operating mistakes for PVC process

As modern chemical plants are becoming more complex and bigger in scale, the associated chance of things going wrong is also increasing rapidly. Due to the flammable, explosive, toxic and corrosive nature of chemical process, any single accident may trigger a major catastrophe that brings tremendous environmental, social and economical loss. In order to prevent any accident from happening, hazard and operability (HAZOP) analysis has been brought in to monitor chemical process and provide early warning for signs of accident. However, most existing HAZOP is carried out manually, and there are always obstacles in terms of cost overrun and incompleteness of the analysis. To address the difficulties in current HAZOP method, this paper proposes a signed digraph (SDG)-based HAZOP analysis method. It is used to identify the most likely operating mistakes that may cause certain process variable deviating from its normal value, which is the main source of safety concern. A case study on polyvinyl chloride (PVC) plant is presented to demonstrate the effectiveness of SDG-based HAZOP analysis method in providing complete analysis result.