Gas/particle partitioning of atmospheric PCDD/Fs in a satellite town in Eastern China

Gas/particle partitioning of polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/Fs) in ambient air was investigated in a satellite town in Eastern China from April 2007 to January 2008 comprehending large temperature variations (from 3 to 34 °C, daily average). Molecular weight, molecular structure and ambient temperatures are the three major factors that govern the gas/particle partitioning of atmospheric PCDD/Fs throughout the year. Generally, good agreements were obtained (except for winter) between measured particulate fractions and theoretical estimates of both the Junge–Pankow adsorption model and Harner Bidleman absorption model using different sets of subcooled liquid vapor pressure and octanol–air partition coefficient (K_oa), respectively. Models utilizing estimates, derived from gas chromatographic retention indices (GC-RIs), are more accurate than that of entropy-based. Moreover, during winter, the K_oa-based model using the GC-RIs approach performs better on lower chlorinated PCDD/Fs than that of -based. Furthermore, possible sources of mismatch between measured and predicted values in winter (3–7 °C) were discussed. Gas adsorption artifact was demonstrated to be of minor importance for the phenomena observed. On the other hand, large deviations of slopes (m_r) and intercepts (b_r) in logK_p vs. plots from theoretical values are observed in the literature data and these are found to be linearly correlated with ambient temperatures (P<0.001) in this study. This indicates that the non-equilibrium partitioning of PCDD/Fs in winter may be significantly influenced by the colder temperatures that may have slowed down the exchange between gaseous and particulate fractions.     

CuCoOx/TiO2催化氧化NO性能研究

采用浸渍法制备了CuCoOx/TiO₂催化剂,考察了焙烧温度、反应温度、氧含量、NO浓度和空间速度对催化剂催化氧化NO性能的影响,并考察了催化剂的抗硫抗水性能。XRD、TPR和BET分析表明,350℃焙烧的催化剂具有CuCo₂O₄尖晶石结构,比表面积大,对NO的氧化效果好。在空速为5 000 h^-1,NO进口浓度500 mg/m³,含氧量10%的条件下,反应温度300℃时NO转化率可达79.5%,250℃时NO转化率接近50%。该催化剂具有良好的单独抗SO₂、抗H₂O毒化性能,H₂O和SO₂同时存在时很快失活。该催化剂可用于不同时含H₂O和SO₂的含NO气体催化氧化后再吸收处理。     

沸石改性及其去除水中氨氮的实验研究

通过实验研究了沸石改性条件及其对水中氨氮吸附去除的影响。结果表明,加热改性与无机酸改性不能显著提高沸石对氨氮的吸附量。利用NaOH改性的最佳浓度为1 mol/L,此条件下对氨氮吸附量可提高到650.68 mg/kg,为天然沸石的2.82倍。利用无机盐改性时,对氨氮吸附效果最好的是NaCl改性沸石,其次为KCl改性沸石与CaCl₂改性沸石。随着NaCl溶液浓度和改性时间的增加,改性沸石对氨氮的吸附量显著增加,可达天然沸石的3～4倍;在NaCl浓度为150 g/L与改性时间为18 h条件下,改性沸石对氨氮吸附量可达887.35 mg/kg,为天然沸石的3.84倍。     

联合生物法处理炼油厂含油污泥的研究

大港石化公司采用联合生物法处理含油污泥,对使用好氧、厌氧工艺处理含油污泥的结果进行了探讨。实验结果表明:先进行好氧处理然后脱水再进行厌氧堆肥工艺处理含油污泥,除油率达到97.6%,除磷、钾的指标低于《城镇垃圾农用控制标准》(GB8172-87)的要求外,其他指标均符合该标准要求,且避免了二次污染。     

辽河油田稠油泥砂综合处理工艺的研究*

稠油污泥作为含油污泥的典型代表,其成分极为复杂、处理难度极大,由于目前国内外尚无成熟工艺可完全实现其"减量化、资源化、无害化处理",给油田生产和环境保护带来了严重影响。文章分析了稠油污泥的组成及性质,根据稠油污泥来源不同实施分类预处理,利用热风干化技术将其减量,经热解气化焚烧和热能利用,为实现含油污泥无害化处理进行了有益探索。     

聚硅酸硫酸氯化铝铁絮凝剂的制备及絮凝性能

以粉煤灰为原料制备了无机高分子絮凝剂聚硅酸硫酸氯化铝铁(PSiAFCS),用PSiAFCS处理以硅藻土为原料配制的模拟废水.实验结果表明,在n(Al3+):n(SO4-2)=11、PSiAFCS加入量为2.5mg/L、废水pH为6.0～11.0,温度为60℃、静置时间为20 min、废水初始浊度为50.00～500.00 NTU的范围内,PSiAFCS的絮凝效果良好,浊度去除率大于96%.PSiAFCS对赣江水的浊度去除效果优于聚硅酸氯化铝铁(PSiAFC)和聚合氯化铝(PAC).PSiAFCS加入量为2.5 mg/L时,水样的剩余浊度最低,为0.52 NTU,浊度去除率达98.27%,达到GB5749-2006<生活饮用水卫生标准>中浊度小于1.00 NTU的要求.     

SDG-based HAZOP analysis of operating mistakes for PVC process

As modern chemical plants are becoming more complex and bigger in scale, the associated chance of things going wrong is also increasing rapidly. Due to the flammable, explosive, toxic and corrosive nature of chemical process, any single accident may trigger a major catastrophe that brings tremendous environmental, social and economical loss. In order to prevent any accident from happening, hazard and operability (HAZOP) analysis has been brought in to monitor chemical process and provide early warning for signs of accident. However, most existing HAZOP is carried out manually, and there are always obstacles in terms of cost overrun and incompleteness of the analysis. To address the difficulties in current HAZOP method, this paper proposes a signed digraph (SDG)-based HAZOP analysis method. It is used to identify the most likely operating mistakes that may cause certain process variable deviating from its normal value, which is the main source of safety concern. A case study on polyvinyl chloride (PVC) plant is presented to demonstrate the effectiveness of SDG-based HAZOP analysis method in providing complete analysis result.     

秸秆焚烧对北京市空气质量的影响

用火焰原子吸收光谱法测试了北京市两个采样点 1 #站 (十三陵站 ,清洁对照点 )和 5#站 (天坛站 ,居民生活区 )1 1 0个大气颗粒物样品中的水溶性钾 ,以表征秸秆焚烧颗粒物。 1 #站水溶性钾的质量浓度年均值为 1 .2 1 μg/m3,其中以1 998年 6月份浓度 (3 .0 7μg/m3)最高 ,是 5月份 (1 .0 2μg/m3)的 3倍 ;5#站水溶性钾的质量浓度年均值为 1 .94μg/m3,6月份 (4 .2 2 μg/m3)最高 ,是 5月份 (1 .97μg/m3)的 2 .1倍。数据分析结果表明 1 998年 6月份麦收季节存在以秸秆焚烧为主的生物质燃烧现象 ,使大气颗粒物中有机碳浓度水平升高 ,并对北京市的空气质量带来负面影响     

确定压力容器安全系数原则

压力容器安全系数与材料参数紧密相关,确定材料许用应力值时,需要同时考虑材料抗拉强度和屈服强度更为合理;奥氏体不锈钢材料具有非常好的应变强化能力和韧性,为充分发挥奥氏体不锈钢材料优良性能,选取奥氏体不锈钢材料许用应力值时,需要特殊考虑。压力容器安全系数的选取建立在经验基础上,在保障压力容器安全性前提条件下,为节省材料和降低成本,随着理论研究深入和科学实验的进步,压力容器安全系数有所降低,这是科学设计和实用成功经验结合的结果。     

浅谈外墙保温材料对建筑防火的影响

本文通过对几种外墙保温材料及国内外外墙保温技术的介绍,从中分析出引起建筑耐火极限降低的原因,找到在目前条件下,最适合外墙保温的材料及技术,以降低火灾的发生。