Smooth surface fabrication in mask projection based stereolithography

The surface finish is critical for applications such as optics, micro-fluid flow and mechanical assembly, in which optical lenses, fluidic channels and rotating components are all required to be smooth. However, the stair-stepping effect is well known in the layer-based additive manufacturing processes, in which a three-dimensional model is approximated by a set of two-dimensional layers. Consequently the fabricated surfaces have poor surface finishes especially those that are close to the horizontal plane. In this paper, a novel approach for achieving improved surface finish is presented for the mask-image-projection-based stereolithography (MIP-SL) process. Theoretical models and parameter characterization are presented for the developed methods. Accordingly, the process planning and calibration approaches for fabricating smooth up-facing surfaces in the MIP-SL process have been developed. Multiple test cases based on various types of curved surfaces have been performed. A comparison of the build results based on the traditional and the newly developed approaches illustrates the effectiveness of our method.     

光催化膜反应器的设计及其在水处理中的应用

作为一种新型的水处理装置,光催化膜反应器具有反应迅速、降解效率高、降解彻底、无二次污染等特点,在节水减排、微污染水处理、中水回用等方面具有重要的应用价值。总结目前国内外各种不同类型的光催化膜反应器的设计、特点及在水处理中的应用情况,并对其今后的发展提出建议。     

养殖废水新型处理技术中试

针对畜禽养殖污染废水传统处理方法效率不高、噪声较大等缺点进行改进,采用"水解酸化池-塔式膜生物反应器-悬浮澄清池"工艺进行处理,结果表明:COD、氨氮去除率分别为97.5%和91%,出水水质可达GB 18596—2001《畜禽养殖污染物排放标准》。     

巢湖流域水资源可持续性评价方法研究

水资源可持续性评价模型(WRSEM,Water Resource Sustainability Evaluation Model)能够定量地评价流域水资源的可持续性,是流域水资源管理的一个有效工具。本文为了科学地衡量巢湖流域水资源开发、利用和管理的可持续性,构建了巢湖流域水资源可持续性评价模型和评价指标体系。巢湖流域水资源可持续性评价指标体系由4个一级指标(经济效率、社会公平、环境保护和保障能力)和20个二级指标构成。最后根据相对权重综合计算得到流域水资源可持续性指数。评价结果表明了巢湖流域水资源可持续性的程度,同时研究结果为巢湖流域水资源管理及其相关政策制定提供了科学依据。     

城市再生水景观利用水华识别和预警方法探讨

城市再生水景观回用的主要问题是水体富营养化导致水华的暴发。为了抑制藻类的大规模生长,需要提前采取预防措施,以便将有可能爆发水华的藻类及时杀死或除去。目前,人们已经对景观水体中常见藻类的生长规律做了深入的研究,发现水体中藻数量(藻密度)的多少与水体的pH值和DO值的变化有密切而相对稳定的关系。通过在线实时监控pH值和DO值,找到△pH、△DO与藻类生长之间的关系,并结合pH、DO、温度、正磷酸盐和总氮等指标,实现实时识别和预测水华爆发的目的。     

TiO2/硅藻土光催化氧化降解甲基橙的研究

使用经过预处理的硅藻土做载体,采用溶胶-凝胶法制备硅藻土负载二氧化钛光催化剂,利用XRD和EDS对其进行表征.通过分析光催化反应的主要影响因素,研究了硅藻土负载二氧化钛光催化剂对甲基橙的催化降解效果.结果表明：负载3次,在550℃焙烧2h,制备出的负载型催化剂催化活性较高,催化剂上的TiO2为锐钛矿结构.当催化剂投加量为lg/L,溶液初始浓度为15 mg/L,pH为3,H2O2为2 mmol/L时,对甲基橙的降解效果达到最佳.     

电厂燃煤锅炉颗粒物分段去除效率及成因分析

选取某大型发电企业进行实测,根据测试数据计算颗粒物去除装置对颗粒物的分段去除效率。结果表明:静电除尘器除尘效率为99.91%、湿法脱硫装置除尘效率为60.51%、湿法脱硫装置出口相对静电除尘器进口的颗粒物去除效率为99.61%、湿法脱硫装置出口颗粒物浓度是静电除尘器出口颗粒物浓度的4.18倍。此外,也依据计算结果并结合实际情况分析了影响各除尘段颗粒物去除效率的主要成因,这些成因主要包括各除尘段功能、脱硫剂与脱硫副产品的颗粒物、脱硫装置运行平稳性等,期望本研究成果能对电厂燃煤锅炉大气污染控制设施关系调整、重新设计及大气环境污染治理思路调整提供重要科学依据与指导。     

Unregulated emissions from diesel engine with particulate filter using Fe-based fuel borne catalyst

The alteration and formation of toxic compounds and potential changes in the toxicity of emissions when using after-treatment technologies have gained wide attention. Volatile organic compound（VOC）, carbonyl compound and particle-phase polycyclic aromatic hydrocarbon（PAH） emissions were tested at European Steady State Cycle（ESC） to study unregulated emissions from a diesel engine with a fuel-borne catalyst and diesel particulate filter（FBC–DPF）. An Fe-based fuel-borne catalyst was used for this study. According to the results, brake specific emissions of total VOCs without and with DPF were 4.7 and4.9 mg/kWh, respectively, showing a 4.3% increase. Benzene and n-undecane emissions increased and toluene emission decreased, while other individual VOC emissions basically had no change. When retrofitted with the FBC–DPF, total carbonyl compound emission decreased 15.7%, from 25.8 to 21.8 mg/kWh. The two highest carbonyls, formaldehyde and acetaldehyde, were reduced from 20.0 and 3.7 to 16.5 and 3.3 mg/kWh respectively. The specific reactivity（SR） with DPF was reduced from 6.68 to 6.64 mg/kWh. Total particle-phase PAH emissions decreased 66.4% with DPF compared to that without DPF. However, the Benzo[a]pyrene equivalent（BaPeq） with DPF had increased from 0.016 to 0.030 mg/kWh.Fluoranthene and Pyrene had the greatest decrease, 91.1% and 88.4% respectively. The increase of two- and three-ring PAHs with DPF indicates that the fuel-borne catalyst caused some gas-phase PAHs to adsorb on particles. The results of this study expand the knowledge of the effects of using a particulate filter and a Fe-based fuel-borne catalyst on diesel engine unregulated emissions.     

中─高级变质相中水热流体的形成与作用

固体地壳中流体是普遍存在的，中—高级变质相中的矿物并非只发生晶体塑性变形，溶解和溶移作用在非糜棱岩化岩石中占主导地位，因为高温高压环境下存在的水热流体，在变质变形作用中起着至关重要的作用。在周围分布有网络状进进剪切带的递进缩短带中，与应交梯度有直接关系的单个矿物的位错密度梯度在其晶体边缘形成，产生了化学位梯度，从而使矿物边缘发生溶解。变形分解作用是产生这一过程的动力，并为流体汇聚形成水热循环系统提供了空间。     

气相色谱法测定工业废水中的氯代苯类

本文提供了测定工业废水中12种氯苯的简便方法:ECD-GC法.水样用石油醚萃取、经硅胶柱净化,使氯苯与六六六、DDT等完全分离.采用SF-96改性的有机皂土填充柱,可在恒温下将12个氯苯完全分离.当水中氯苯浓度在10mg/250ml(一氯苯)和0.00126mg/250ml(1,2,3,5-四氯苯)之间时,方法的回收率为93.5％.最大相对标准偏差小于4％.