Enhanced sludge solubilization by microbubble ozonation

A microbubble ozonation process for enhancing sludge solubilization was proposed and its performance was evaluated in comparison to a conventional ozone bubble contactor. Microbubbles are defined as bubbles with diameters less than several tens of micrometers. Previous studies have demonstrated that microbubbles could accelerate the formation of hydroxyl radicals and hence improve the ozonation of dyestuff wastewater. The results of this study showed that microbubble ozonation was effective in increasing ozone utilization and improving sludge solubilization. For a contact time of 80 min, an ozone utilization efficiency of more than 99% was obtained using the microbubble system, while it gradually decreased from 94% to 72% for the bubble contactor. The rate of microbial inactivation was obviously faster in the microbubble system. At an ozone dose of 0.02 g O₃ g⁻¹ TSS, about 80% of microorganisms were inactivated in the microbubble system, compared with about 50% inactivation for the bubble contactor. Compared to the bubble contactor, more than two times of COD and total nitrogen, and eight times of total phosphorus content were released from the sludge into the supernatant by using the microbubble system at the same ozone dosage. The application of microbubble technology in ozonation processes may provide an effective and low cost approach for sludge reduction.     

沼泽红假单胞菌W12对活性黑5的厌氧脱色和降解作用

从处理印染废水的厌氧移动床生物膜反应器（moving bed biofilm reactor, MBBR）中分离到一株具有高效脱色活性的沼泽红假单胞菌W12。经实验确定W12对活性黑5（reactive black 5,RB5）脱色的适宜条件为：pH＜10;有光照;谷氨酸盐或乳酸盐作为碳源,当乳酸钠为碳源时浓度应＞500 mg/L;盐度不超过5％;RB5浓度不大于700 mg/L。紫外可见光谱扫描结果表明,RB5的脱色和降解过程生成芳香胺类化合物,这些中间产物可进一步降解。此外发现,RB5诱导生成的胞外代谢物能提高W12的脱色活性。     

错流式生物滴滤床净化甲苯废气

采用焦化厂污泥为菌源驯化甲苯降解菌,接种错流式生物滴滤床,净化含甲苯废气。研究了生物滴滤床的挂膜启动和长期运行情况,填料和营养液对滴滤床去除能力的影响,并对长期运行的压降进行了观察分析。反应器挂膜启动需要6 d时间,稳定运行的平均去除效率为95％,单位体积最大去除负荷为251 g/(m³·h)。结果表明,采用错流式生物滴滤床可以有效去除甲苯废气;以比表面积大的生物陶粒作为填料以及定期适量更换营养液,均有助于提高生物滴滤床的去除能力;错流式生物滴滤床具有压降小、气液分布均匀的特点。     

基于BP神经网络的垃圾焚烧过程故障诊断

应用BP神经网络方法,建立了垃圾焚烧过程故障诊断的模型.该方法采用梯度下降法训练网络权值,利用最优停止法对网络进行了优化,避免了过拟合现象.提高了BP神经网络的训练速度和泛化能力.并以实际焚烧过程工况数据进行性能检验,检验结果表明了该BP网络具有较高的诊断精度.     

碱熔融法合成NaA和NaX型粉煤灰沸石的品质表征

以粉煤灰为原料采用碱熔融法合成了2种单一沸石矿物种的NaA和NaX型沸石,并对产物的结构、性能和应用指标进行了详细表征.经x射线衍射和IR光谱分析,表明合成产物是无杂晶生成的NaA和NaX型沸石相;在扫描电镜观察下,产物分别具有NaA和NaX型沸石的立方体和八面体晶体骨架结构.DTA分析表明了合成产物中沸石水的存在,且产物热稳定性较好.通过对比,粉煤灰合成的NaA和NaX型沸石的比表面积达到了相应商品沸石的66.9%和83.6%;孔容为41.1%和70.2%;阳离子交换容量(CEC,cation exchange capacity)为82.93%和84.31%.通过比较化学组成表明,大规模应用合成产物不会对环境造成危害.     

Applications of open-path Fourier transform infrared for identification of volatile organic compound pollution sources and characterization of source emission behaviors

An open-path Fourier transform infrared spectroscopy (OP-FTIR) system was set up for 3-day continuous line-averaged volatile organic compound (VOC) monitoring in a paint manufacturing plant. Seven VOCs (toluene, m-xylene, p-xylene, styrene, methanol, acetone, and 2-butanone) were identified in the ambient environment. Daytime-only batch operation mode was well explained by the time-series concentration plots. Major sources of methanol, m-xylene, acetone, and 2-butanone were identified in the southeast direction where paint solvent manufacturing processes are located. However, an attempt to uncover sources of styrene was not successful because the method detection limit (MDL) of the OP-FTIR system was not sensitive enough to produce conclusive data. In the second scenario, the OP-FTIR system was set up in an industrial complex to distinguish the origins of several VOCs. Eight major VOCs were identified in the ambient environment. The pollutant detected wind-rose percentage plots that clearly showed that ethylene, propylene, 2-butanone, and toluene mainly originated from the tank storage area, whereas the source of n-butane was mainly from the butadiene manufacturing processes of the refinery plant, and ammonia was identified as an accompanying reduction product in the gasoline desulfuration process. Advantages of OP-FTIR include its ability to simultaneously and continuously analyze many compounds, and its long path length monitoring has also shown advantages in obtaining more comprehensive data than the traditional multiple, single-point monitoring methods.     

应用陶粒过滤-陶瓷膜组合对止咳糖浆制药废水深度处理的试验研究

止咳精浆制药废水经生物接触氧化一体化废水处理装置处理后,其出水中COD、BOD和氨氮等主要污染物质均不能达标排放.在实验室中采用陶粒过滤-陶瓷膜组合对经一体化处理装置处理后的制药废水进行深度处理,在陶粒柱反应器选用粒径为1～2 mm的陶粒滤料,陶瓷膜反应器选用孔径为2～3/μm陶瓷膜的条件下对水样进行测试.废水经陶粒过滤-陶瓷膜组合处理后,其BOD、COD、SS和氨氮指标均可稳定达标排放.     

由粉煤灰合成单一的沸石及其对Cr(Ⅵ)的吸附研究

以粉煤厌为原料采用两步法合成了2种单一沸石矿物种的NaA和NaX型沸石,并对产物的结构和性能进行了详细表征.2种沸石产物的吸附性能比较结果表明,NaA型沸石优于NaX型沸石.在静态吸附条件下,研究了NaA型沸石吸附水溶液中Cr(Ⅵ)的相关参数(溶液pH值、吸附温度和吸附时间),并用Langmuir和Freundlich等温吸附线对吸附结果进行拟和.结果表明:Cr(Ⅵ)的吸附行为符合Langmuir方程;饱和吸附量为47.78 mg/g.NaA型沸石对Cr(Ⅵ)的吸附是物理和化学吸附两种行为共同作用的结果.     

Seasonal and particle size-dependent variations in gas/particle partitioning of PCDD/Fs

This study monitored particle size-dependent variations in atmospheric polychlorinated dibenzo-p-dioxins and dibenzofurans (PCDD/Fs). Two gas/particle partitioning models, the subcooled liquid vapor pressure (P(L)(0)) and the octanol-air partition coefficient (K(OA)) model, were applied to each particle sizes. The regression coefficients of each fraction against the gas/particle partition coefficient (K(P)) were similar for separated particles within the same sample set but differed for particles collected during different periods. Gas/particle partitioning calculated from the integral of fractions was similar to that of size-segregated particles and previously measured bulk values. Despite the different behaviors and production mechanisms of atmospheric particles of different sizes, PCDD/F partitioning of each size range was controlled by meteorological conditions such as atmospheric temperature, O(3) and UV, which reflects no source related with certain particle size ranges but mixed urban sources within this city. Our observations emphasize that when assessing environmental and health effects, the movement of PCDD/Fs in air should be considered in conjunction with particle size in addition to the bulk aerosol.     

乳酸和复合脂肪酸抑制奶牛对环境污染的效果分析

将20头荷斯坦产奶奶牛随机分为对照组和试验Ⅰ～Ⅲ组,对照组饲喂全混日粮(TMR),试验Ⅰ组每头奶牛每天饲喂TMR加150.0 g复合脂肪酸,试验Ⅱ组每头奶牛每天饲喂TMR加150.0 g乳酸,试验Ⅲ组每头奶牛每天饲喂TMR加150.0 g复合脂肪酸/乳酸(质量比为1∶1),分析探讨了复合脂肪酸和乳酸对奶牛粪尿、氮、总磷排泄量和CH4释放量的影响.结果表明,相比对照组,试验Ⅲ组1头奶牛1年CH4释放量减少30.64 kg,粪尿、氮、总磷排泄量分别减少1.43 t、28.32 kg和2.36 kg,标准乳(FCM)提高3.28%.在奶牛饲料中添加乳酸和复合脂肪酸的混合酸,能有效抑制奶牛对土壤、水体及空气的污染,显著提高奶牛的生态效益和经济效益.