普光净化厂加氢进料燃烧炉耐火衬里安全改造

介绍了天然气净化厂尾气处理单元加氢进料燃烧炉的结构及衬里形式,以及燃烧炉使用初期出现部分衬里损坏、下沉,甚至脱落的现象,导致燃烧炉外壁超温,影响装置正常生产;提出改造方案,解决了大型加氢进料燃烧炉衬里存在的问题。     

一种应用于大型储罐的雷击电流监测分析方法

介绍了剩磁法原理和剩磁检测依据标准,使用雷电流发生器和高斯计对磁钢棒的剩磁状况进行了初步的试验研究。     

炼化企业变更管理研究

阐述了炼化企业变更管理系统的6个环节：识别潜在的变更、评估可能的影响、变更审批、变更实施、变更验收和变更追踪,并提出了确保变更质量的保障措施。     

乌粱素海不同粒径沉积物吸附磷实验研究

通过研究乌粱素海不同粒径沉积物对磷的吸附动力学曲线和吸附等温曲线,模拟了乌粱素海不同粒级沉积物对磷的吸附过程。研究显示：沉积物对磷的吸附动力学过程包括快吸附和慢吸附,0～45 min内各粒级吸附速率均较高,且不同粒级沉积物对磷吸附的粒度效应明显。二级动力学方程是描述乌粱素海沉积物磷吸附动力学的最优方程,Langmuir...     

Fenton试剂深度处理阿维菌素废水

采用Fenton试剂对阿维菌素废水好氧处理出水进行深度处理,通过正交和单因素试验,考察了初始反应pH值、H2O2投加量、FeSO4投加量和反应时间对废水COD去除率的影响。试验结果表明,最佳反应条件为初始反应pH值3.0、30%H2O2投加量5‰、0.5 mol/L FeSO4投加量1%和反应时间40 min,COD去除率达75%以上,出水ρ(COD)<120 mg/L,可满足GB 21903-2008《发酵类制药工业水污染物排放标准》表2的排放标准要求。     

Characterization of a salt-tolerant bacterium Bacillus sp. from a membrane bioreactor for saline wastewater treatment

High salt concentrations can cause plasmolysis and loss of activity of cells, but the salt-torlerant bacterium can endure the high salt concentrations in wastewater. In this research 7 salt-torlerant bacteria, which could survive in dry powder products and could degrade organic contaminants in saline wastewater, were isolated from a membrane bioreactor. The strain NY6 which showed the fastest growth rate, best property for organic matter degradation and could survive in dry powder more than 3 months was selected and characterized. It was classified as Bacillus aerius based on the analysis of the morphological and physiological properties as well as the 16 S rRNA sequence and Neigh borjoining tree. The strain NY6 could survive in the salinity up to 6% and the optimal growth salinity is2%; it belongs to a slightly halophilic bacterium. The capability of its dry powder products for COD removal was 800 mg COD/(g·day) in synthesized saline wastewater with salinity of 2%. According to salt-tolerant mechanism research, when the salinity was below 2%, the stain NY6 absorbed K+and Na+to maintain osmotic equilibrium, and when the salinity was above 2%, the NY6 kept its life by producing a large amount of spores.     

Dry deposition of PM10 over the Yellow Sea during Asian dust events from 2001 to 2007

Dry deposition velocities and fluxes of PM10during Asian dust events over the Yellow Sea from 2001 to 2007 were investigated using observation data in Qingdao, China and Jeju, Korea. The dry deposition velocities of PM10 during dust events over the Yellow Sea ranged from 0.19 to 8.17 cm/sec, with an average of 3.38 cm/sec. Dry deposition fluxes of PM10during dust events over the Yellow Sea were in the range of 68.5–2647.1 mg/(m2·day), with an average of 545.4 mg/(m2·day), which is 2–10 times higher than those reported by other studies for both dust and non-dust periods. It was estimated that 2.6 × 1011–48.7 × 1011g dust particles deposit to the Yellow Sea during dust events through dry deposition every year. Compared with the results in previous studies, it was found that the dry deposition of PM10over the Yellow Sea during dust events in the years with high frequency of dust could account for a large or overwhelming fraction of the annual total dry deposition. Backward air mass trajectory analysis showed that dust events influenced Jeju mainly originated from the desert regions located in Mongolia and Inner Mongolia, China. There were 119 backward trajectories influenced both Qingdao and Jeju during 15 dust events from 2001 to 2007, accounting for 61.3% of the total trajectories of 194, indicating that Qingdao and Jeju were usually on the same pathway of dust transport downwind from source areas.     

钻井噪声特性分析与噪声治理

通过对钻井井场噪声源的分布及特性进行现场勘察分析得知:井场区域内各种设备产生的高强度噪声在70～110dB(A)之间,以中低频噪声为主,主要以柴油发电机房为中心,以球面波形式向四周辐射,对井场作业人员及周围250m范围内的居民和环境产生不同程度的噪声危害。为了有效控制噪声对作业人员及井场周围环境的危害,提出了对重点噪声源、噪声传播途径采取隔声、吸声、消声等降噪措施来降低噪声污染。     

Effect of bulk density of coking coal on swelling pressure

Coking coals are the important raw materials for the iron and steel industries and play an important role on its sustainable development, especially on the stamp-charging coke making with the characteristics of increasing the bulk density. There is a significance on the reasonable usage of the coking coal resource with the reduced production cost, improved efficiency of the economy to develop the stamp-charging coke making technology. Important effects of the density of coking coal on the coking and caking properties were investigated. In the article, the maximum values of swelling pressure and variation of Laowan gas coal and Xinjian 1/3 coking coal, Longhu fat coal and Didao coking coal, which were mined at Shenyang and Qitaihe respectively, were investigated under different bulk densities during the coking. The results showed that when the values of density increased from 0.85 ton/m³ to 1.05 ton/m³, for the Laowan gas coal, swelling pressure variation and even the maximum value changed slightly. The swelling pressure was 3.63 KPa when the density was improved to 1.05 ton/m³; for the Xinjian 1/3 coking coal, the values of swelling pressure changed significantly and the maximum values was 82.88 KPa with the density improved to 1.05 when the coal was heated to 600°C. The coke porosity, which was investigated by automatic microphotometer, decreased from 47.4% to 33.1% with the increasing of the density from 0.85 ton/m³ to 1.05 ton/m³, and the decreased value was 14.3%. Meanwhile, the pore structures of four cokes were characterized by an optical microscope.     

某地加油站土壤地下水现状调查与分析

通过对某地10个加油站所在场地土壤及地下水现场采样、实验室检测,分析加油站对土壤与地下水污染原因,结合国家政策法规以及加油站土壤地下水调查现状,针对加油站污染状况提出加强加油站土壤及地下水污染隐患排查力度、强化加油站土壤地下水方面日常管理、污染加油站风险管控及修复工作、加快推进防渗池及双层罐等设施改造工作等建议。