石油石化行业急性中毒事故的现场抢救

石油石化行业工艺复杂,存在的有害因素种类繁多,一旦发生急性中毒其涉及面广、影响大,有时可造成严重危害。文章较为详细地介绍了该行业存在的主要有毒物质以及发生急性中毒事故的必要条件和特点,阐述了有毒物质侵入人体的途径主要为直接接触或通过呼吸,最后针对一般情况、吸入性中毒、直接接触造成危害的情况介绍了相应的现场急救处理措施。     

Adhesive Performance of Sorghum Protein Extracted from Sorghum DDGS and Flour

Distillers dried grains with solubles (DDGS) is the main co-product from grain-based ethanol production. The objective of this research was to compare the adhesive performance of three types of sorghum proteins: acetic acid-extracted sorghum protein from DDGS (PI), aqueous ethanol-extracted sorghum protein from DDGS (PII) and acetic acid-extracted sorghum protein from sorghum flour (PF). Physicochemical properties including amino acid composition, and rheological, thermal and morphological properties also were characterized. Results showed that PI had the best adhesion performance in terms of dry, wet and soak adhesion strength, followed by PF and PII. The wet strength of PI at a concentration of 12% protein assembled at 150 °C was 3.15 MPa, compared to 2.17 MPa and 2.59 MPa for PII and PF, respectively. DSC thermograms indicated that the PF protein isolates contained higher levels of carbohydrates than PI and PII; such non-protein contaminants in the PF isolate could be the reason for its lower adhesion strength than PI. In addition, PI might have more hydrophobic amino acids aligned at the protein-wood interface than PII, which could explain the better water resistance of PI. The optimum sorghum protein concentration and pressing temperature for maximum adhesion strength was 12% and 150 °C. PI had a significantly higher wet strength (3.15 MPa) than unmodified soy protein (1.63 MPa for soy protein). The high percentage of hydrophobic amino acids in PI (57%) was likely a key factor in the increased water resistance of PI compared with soy protein (36% hydrophobic amino acids). These results indicated that sorghum protein has huge potential as an alternative to petroleum-based adhesives.     

PAC/AC吸附对超滤膜去除再生水中有机物影响

研究了粉状活性炭(PAC)和活性焦(AC)吸附对超滤膜(UF)去除再生水中有机物的效能及其对膜污染的影响。结果表明,PAC和AC吸附预处理可有效改善超滤膜出水水质,投量为40 mg/L时,PAC和AC单独吸附对DOC去除率分别为40.2%和32.6%,超滤出水DOC去除率则由直接膜滤时的21.4%提高至47.2%。UF对大于10 kDa的大分子有机物有较好的截留能力,PAC较AC对中小分子有机物的吸附效果更好。三维荧光(3D-EEM)分析显示,原水中溶解性微生物代谢产物和腐殖质类有机物所占比重较大;直接UF对溶解性微生物代谢产物的去除能力较好,投加PAC和AC促进了紫外腐殖酸和类腐殖酸类有机物去除,紫外腐殖酸EEM峰值分别下降51.7%和48.8%,类腐殖酸EEM峰值下降63.0%和59.9%。投加PAC和AC并经0.45 μm膜预过滤可提高超滤膜通量,其在过滤周期内的下降率由直接膜滤时的27.6%分别降至23.5%和24.4%。AC较PAC更为经济,AC-UF可替代PAC-UF作为经济可行的再生水深度净化工艺。     

Cytotoxicity, genotoxicity and ecotoxicity assay using human cell and environmental species for the screening of the risk from pollutant exposure

For the screening of the risk from environmental contamination, the cytotoxic/genotoxic effects of various model pollutants were determined using an in vivo system comprised of human HeLa cells; the ecotoxicity was also determined using the acute and genotoxicity tests on two aquatic sentinel species widely used in biomonitoring, namely, freshwater crustacean, Daphnia magna and larva of aquatic midge, Chironomus tentans. Nonylphenol (NP), bisphenol A (BPA), bis(2-ethylhexyl) phthalate (DEPH) and paraquat dichloride (PQ) were used as the model pollutants. The results showed that exposure of HeLa cells to NP, BPA and DEHP was sufficient for the expression of noticeable genotoxic and cytotoxic effects. Ecotoxicity results showed that, as expected, D. magna was more sensitive than C. tentans to chemical exposure. BPA may exert a genotoxic effect on D. magna and C. tentans, given that DNA strand breaks increased in both species exposed to this compound, whereas NP-induced DNA damage occurred only in C. tentans. In vivo genotoxic data obtained in aquatic sentinel species could provide valuable information for freshwater quality monitoring. From the results of the present study, the use of cytotoxic, genotoxic and ecotoxic tests using human cell system, as well as, biomonitoring species, seems to be relevant for preliminary evaluation of the human health and ecological effects of pollutants and thus, a promising screening tool for environmental monitoring and risk assessment.     

酿造废水处理的优化工艺组合

酿造废水属于高浓度有机废水，要将其处理达到排放标准，必须经过多种处理工艺的组合才能办到。通过物化处理、生化处理的实验室研究，我们得出了资源化和净化相结合的优化工艺组合，使酿酒废水的排放达到规定的排放标准，且运行费用和收益基本持平，解决了环保工程与经济效益间的矛盾。     

楼板对钢筋混凝土框架结构受力性能影响

汶川8级地震震害调查发现,这次地震中现浇钢筋混凝土框架结构多发生"强梁弱柱"型破坏,这与规范中"强柱弱梁"抗震设计原则相悖。为探究其原因,采用ABAQUS软件对钢筋混凝土带楼板框架和空框架结构进行了侧向加载情况的性能分析。通过对比纵向梁端钢筋应力变化和柱端钢筋应力变化,以及分析不同侧向位移对应的楼板钢筋的应力变化情况,指出楼板对梁端抗负弯矩能力的增强有很大贡献。研究了节点类型、楼板钢筋材性、侧向位移、梁高、梁跨和板厚等因素对纵向梁端处楼板有效宽度的影响规律,提出了负弯矩作用下梁端处楼板有效宽度的取值方法。     

共基质下微生物燃料电池同步脱色甲基橙与产电性能

采用双室方形微生物燃料电池(MFC),以葡萄糖作为共基质,研究了共基质浓度对典型偶氮染料甲基橙在MFC阳极室中脱色效率及同步产电的影响。结果表明,在0~1.5 g/L浓度范围内,共基质浓度越大,甲基橙脱色率、COD去除率和最大输出电压越高。在共基质浓度为1.5 g/L,进水甲基橙为300 mg/L的条件下,8 h的脱色率高达95%,且在1 000 Ω外电阻下,最大输出电压达到662 mV;在无共基质条件下,8 h内对300 mg/L甲基橙的脱色率仅为7.5%,最大输出电压仅达到140 mV。厌氧对照实验表明,甲基橙在MFC中可以实现加速脱色,反应8 h后甲基橙在MFC中的脱色率提高了57%。该研究为开发新型MFC降解偶氮染料废水技术提供了理论依据。     

颗粒计数法在高锰酸钾强化常规工艺运行优化中的应用

以引黄水库水为实验原水,通过颗粒计数和浊度的联用检测优化评估了高锰酸钾强化常规处理工艺中的各制水环节的处理效果。结果表明,絮凝出水>10 μm颗粒数和过滤出水2~7 μm颗粒数的可作为水厂运行管理的依据,滤后水的颗粒物数量变化比浊度更灵敏准确地反映滤池运行状况;在高锰酸钾强化预处理的最佳投加量为0.8 mg/L时,原常规工艺沉淀对颗粒总数的去除率提高20.55%,滤后颗粒总数减少56.40%,显著降低了"两虫"穿透滤池的风险。     

基于可靠性研究的内压薄壁容器两个重要系数

应用应力-强度干涉模型,建立了确定钢制内压薄壁容器安全系数与试验压力系数的方法;根据钢制内压薄壁容器静强度在不同操作时的最小许用可靠度系数,研究了其安全系数与试验压力系数的关系。研究表明:①屈服与抗拉安全系数应分别不小于1.45与1.70;②试验压力系数在气压试验与液压试验时应分别不大于1.10与1.25。     

吴忠市新灌区生态经济类型

本文应用主分量分析法,对吴忠新灌区生态经济类型进行了初步划分与研究。分析结果表明,该区可划分为五个明显不同的生态经济类型区,各区的生态条件、经济、环境均存在较大差异,故此,在制定其发展方向及开发措施时,应区别对待。