利用钢铁盐酸酸洗废液在填料塔中制备FeCl3

以钢铁盐酸酸洗废液为原料,亚硝酸钠为催化剂,氧气为氧化剂,在填料塔中催化氧化制备三氯化铁。考察了反应温度、催化剂加入量和添加方式、循环流量等对制备三氯化铁的影响。实验结果表明,在优化的工艺条件为料液预热温度为60 ℃、催化剂加入量为钢铁盐酸酸洗废液总质量的0.30%、料液循环流量6.0 m³/h的条件下,反应80~120 min,酸洗废液中的Fe²⁺完全氧化为Fe³⁺。     

Polarity effect of pulsed corona discharge for the oxidation of gaseous elemental mercury

The effect of polarity on the oxidation of Hg⁰ was examined in the presence of O₂ via a pulsed corona discharge (PCD). The experimental result showed no difference in the energy yield of Hg⁰ oxidation at both positive and negative PCDs (∼8 μg Hg W h⁻¹ at following conditions: total flow rate = 2 L min⁻¹ (Hg⁰ = 50 μg N m⁻³, O₂ = 10%, and N₂ balance), temperature = 150 °C, and specific energy density = 5-15 W h N m⁻³). This suggests that the positive PCD process used to control gaseous air pollutants may play an essential key role in Hg⁰ oxidation because it consumes enough energy (∼15 W h N m⁻³) but an electrical precipitator could not because it consumes less energy (∼0.3 W h N m⁻³) to oxidize Hg⁰.     

Column study of Cr(VI) removal by cationic hydrogel for in-situ remediation of contaminated groundwater and soil

Column experiments were conducted for examining the effectiveness of the cationic hydrogel on Cr(VI) removal from groundwater and soil. For in-situ groundwater remediation, the effects of background anions, humic acid (HA) and pH were studied. Cr(VI) has a higher preference for being adsorbed onto the cationic hydrogel than sulphate, bicarbonate ions and HA. However, the adsorbed HA reduced the Cr(VI) removal capacity of the cationic hydrogel, especially after regeneration of the adsorbents, probably due to the blockage of adsorption sites. The Cr(VI) removal was slightly influenced by the groundwater pH that could be attributed to Cr(VI) speciation. The 6-cycle regeneration and reusability study shows that the effectiveness of the cationic hydrogel remained almost unchanged. On average, 93% of the adsorbed Cr(VI) was recovered in each cycle and concentrated Cr(VI) solution was obtained after regeneration. For in-situ soil remediation, the flushing water pH had an insignificant effect on the release of Cr(VI) from the soils. Multiple-pulse flushing increased the removal of Cr(VI) from the soils. In contrast, more flushing water and longer operation may be required to achieve the same removal level by continuous flushing.     

PCDDs and PCDFs in sewage sludges from two wastewater treatment plants in Beijing, China

The levels of polychlorinated dibenzo-p-dioxins (PCDDs) and dibenzofurans (PCDFs) were analyzed by an isotope-dilution high-resolution mass spectrometric in 16 sewage sludges, sampled from 2004 to 2009, from two municipal wastewater treatment plants (WWTPs) in Beijing. Total toxicity equivalent (TEQ) values were evaluated using the toxicity equivalent factors proposed by International for PCDD/Fs. The I-TEQs for these sewage sludges were from 0.97 to 15.0 pg g⁻¹ dry weight (dw) with a mean value 4.43 pg g⁻¹ dw, indicating that all I-TEQs were below Chinese legislation limit value regulated for agricultural use in soils.The results from limited samples (16 samples) showed that the levels of PCDD/Fs might be correlated with the sludge age. Meanwhile, the temporal trends of PCD/Fs suggested that the I-TEQs may correlate with rainfall in the present study.     

Dissipation of carbendazim and chloramphenicol alone and in combination and their effects on soil fungal:bacterial ratios and soil enzyme activities

The dissipation of carbendazim and chloramphenicol alone and in combination and their effects on soil fungal:bacterial ratios and soil enzyme activities were investigated. The results revealed that carbendazim dissipation was little affected by chloramphenicol, whereas chloramphenicol dissipation was found to be retarded significantly by the presence of carbendazim. The inhibitory effect of carbendazim on the fungal:bacterial ratios was increased by the presence of chloramphenicol, and the inhibitory effect of chloramphenicol on neutral phosphatase was increased by the presence of carbendazim. Carbendazim increased soil catalase and urease activities, but this increase was partially diminished by the presence of chloramphenicol. Little interaction was observed between carbendazim and chloramphenicol with regard to their influence on soil invertase. The results obtained in this study suggest that combinations of fungicides and antibiotics may alter the compounds’ individual behaviors in soil and their effects on soil enzymes.     

A study on the reaction characteristics of vanadium-impregnated natural manganese oxide in ammonia selective catalytic reduction

This study investigated the effect of adding vanadium (V) to natural manganese oxide (NMO) in ammonia (NH3) selective catalytic reduction (SCR). The addition of V to NMO decreased the catalytic activity at low temperatures by blocking the active site. However, the enhancement of catalytic activity was achieved by controlling NH3 oxidation at high temperatures. From the NH3 temperature programmed desorption and oxygen on/off test, it was confirmed that the amount of Lewis acid site and active lattice oxygen of the catalyst affects the catalytic performance at low temperature.     

利用甘蔗渣制备微生物絮凝剂的预处理方法研究

通过对甘蔗渣进行不同的预处理,确定了提高纤维素酶糖化率和酱油曲霉发酵液絮凝率的方法.利用正交实验对固液比、颗粒粒径、溶剂浓度和预处理时间及其交互作用进行考察,确定较优的工艺方案.结果表明,在相同条件下,碱处理能够有效提高纤维素酶的糖化率,处理后甘蔗渣的酶解液中还原性糖浓度和酱油曲霉发酵液的絮凝率分别为3.46 g/L和...     

曝气强度对同时硝化反硝化（SND）脱氮过程中N2O排放的影响

为了控制污水脱氮中N2O排放,在不同曝气强度下研究了好氧硝化段同时硝化反硝化（SND）系统的N2O排放特性,并采用PCR—DGGE技术分析微生物群落特征。结果发现,随着曝气强度的增强,系统总氮去除率下降,但脱氮中N2O—N所占比例则上升,实验中从低到高3个曝气强度下,总氮去除率分别为80．01％、65．28％和58．62％,脱氮中N2O—N所占的比例为1．89％、7．84％和9．20％。PCR—DGGE分析显示,和低曝气强度下相比中、高曝气强度下系统微生物群落发生明显变化,但中曝气强度和高曝气强度下系统微生物群落表现出较高相似性。这表明,不同曝气强度下系统N2O排放受到氮素转化和微生物群落变化的影响。适宜曝气强度不仅提高总氮去除率,还可有效控制N2O排放。     

铁炭微电解法预处理超高盐榨菜腌制废水

超高盐榨菜腌制废水是高盐、高氮磷及高有机物废水,目前常采用生物方法进行处理,但因高污染物浓度及高盐度影响,处理效果不够理想;因此,选用铁炭微电解法对超高盐榨菜腌制废水进行预处理。通过静态烧杯实验,研究了反应时间、初始pH、铁炭体积比和铁水体积比对COD和氨氮去除率的影响。单因素实验的最佳处理条件：原水pH4～4．5,反应时间为30min,铁炭体积比为1：1,铁水体积比为2：1,出水COD和氨氮的去除率分别为57．29％和53．11％,盐度由原水的6．62％下降为3．63％,去除率达45．17％,pH由原水4．01升高为6．38。正交实验结果表明,影响COD和氨氮去除率的因素从大到小的顺序为：铁水体积比、初始pH、反应时间、铁炭体积比。实验表明,采用铁炭微电解法能够对超高盐榨菜腌制废水中的COD和氨氮进行有效去除,出水的pH升高和盐度下降,能满足后续生物处理的预处理要求。     

亚铁蓝法处理含氰废水的工程应用

文中综述了氰化物的危害和含氰废水的来源以及目前处理含氰废水的方法。以工程实例重点介绍亚铁蓝法处理此废水的应用。亚铁蓝法除氰可分二级进行,第一级在中性条件总氰去除率达到80%以上,第二级直接在一级出水加碱调pH至8～9沉淀即可,通过二级处理总氰去除率达到95%左右。