炼油行业泄漏检测与修复技术实践研究

炼油行业排放的大气污染物主要是挥发性有机物,是形成二次污染物的重要前体物,也是引发大气环境问题的重要污染物.以天津某炼油企业泄漏检测与修复技术的工作实践为例,结合炼油行业生产装置的工艺特点,介绍在该行业开展泄漏检测与修复技术时的工作流程,包括设备和管线组件密封点位的建档、检测、泄漏点位的修复、复测以及泄漏量核算方法,对炼油行业开展泄漏检测与修复工作减少挥发性有机物无组织的排放起到借鉴作用.     

A new process to improve short-chain fatty acids and bio-methane generation from waste activated sludge

As an important intermediate product, short-chain fatty acids(SCFAs) can be generated after hydrolysis and acidification from waste activated sludge, and then can be transformed to methane during anaerobic digestion process. In order to obtain more SCFA and methane,most studies in literatures were centered on enhancing the hydrolysis of sludge anaerobic digestion which was proved as un-efficient. Though the alkaline pretreatment in our previous study increased both the hydrolysis and acidification processes, it had a vast chemical cost which was considered uneconomical. In this paper, a low energy consumption pretreatment method, i.e. enhanced the whole three stages of the anaerobic fermentation processes at the same time, was reported, by which hydrolysis and acidification were both enhanced, and the SCFA and methane generation can be significantly improved with a small quantity of chemical input. Firstly, the effect of different pretreated temperatures and pretreatment time on sludge hydrolyzation was compared. It was found that sludge pretreated at 100°C for 60 min can achieve the maximal hydrolyzation. Further, effects of different initial p Hs on acidification of the thermal pretreated sludge were investigated and the highest SCFA was observed at initial p H 9.0with fermentation time of 6 d, the production of which was 348.63 mg COD/g VSS(6.8 times higher than the blank test) and the acetic acid was dominant acid. Then, the mechanisms for this new pretreatment significantly improving SCFA production were discussed. Finally,the effect of this low energy consumption pretreatment on methane generation was investigated.     

Enhanced methane production in an anaerobic digestion and microbial electrolysis cell coupled system with co-cultivation of Geobacter and Methanosarcina

The anaerobic digestion(AD)and microbial electrolysis cell(MEC)coupled system has been proved to be a promising process for biomethane production.In this paper,it was found that by co-cultivating Geobacter with Methanosarcina in an AD–MEC coupled system,methane yield was further increased by 24.1%,achieving to 360.2 m L/g-COD,which was comparable to the theoretical methane yield of an anaerobic digester.With the presence of Geobacter,the maximum chemical oxygen demand(COD)removal rate(216.8 mg COD/(L·hr))and current density(304.3 A/m_3)were both increased by 1.3 and 1.8 fold compared to the previous study without Geobacter,resulting in overall energy efficiency reaching up to 74.6%.Community analysis demonstrated that Geobacter and Methanosarcina could coexist together in the biofilm,and the electrochemical activities of both were confirmed by cyclic voltammetry.Our study observed that the carbon dioxide content in total gas generated from the AD reactor with Geobacter was only half of that generated from the same reactor without Geobacter,suggesting that Methanosarcina may obtain the electron transferred from Geobacter for the reduction of carbon dioxide to methane.Taken together,Geobacter not only can improve the performance of the MEC system,but also can enhance methane production.     

洪湖、梁子湖水体富营养化研究

2015年3月对洪湖、梁子湖进行了水质监测。依据实测数据,结合洪湖湿地自然保护区和梁子湖林业局监测数据和文献数据,采用综合营养状态指数法对洪湖、梁子湖的富营养化状态进行评价;并根据各因子在综合营养状态指数中所占比重和地表水水质标准,对各因子做了比较。结果表明:洪湖、梁子湖综合营养状态指数分别为57.2、42.5。即洪湖为轻度富营养、梁子湖为中营养;各因子对洪湖、梁子湖富营养化的贡献大致相同,即Chla为首,TP、COD_(Mn)和SD次之、TN最后。     

石化废水易降解成分对活性污泥耗氧抑制毒性评价的干扰因素

为评价某石化混合废水的毒性,采用活性污泥耗氧速率抑制试验研究不同φ(石化废水)对活性污泥中不同菌群的抑制及其影响因素. 结果表明,所用石化废水对活性污泥中的硝化细菌具有明显毒性,其EC₅₀(半抑制效应浓度,以φ计)为9%左右;同时,该废水对异养菌的耗氧具有较强的促进作用,φ(石化废水)为100%时I_H(异养菌耗氧速率抑制率,131%)最高,这种促进作用对R_T(总耗氧速率)测定有显著影响(R=0.991,P<0.05),因此,仅以R_T评价废水毒性容易造成对废水真实毒性的低估. 5种常见易降解基质(乙酸钠、葡萄糖、甲醇、生活污水、丙酸钠)中,ρ(甲醇)为15 mg/L时对异养菌促进效果显著(P<0.05),促进率达50%以上;而在高浓度条件下,乙酸钠、葡萄糖、甲醇、丙酸钠对异养菌均有显著促进作用(P<0.05),R_H(异养菌耗氧速率)最高提高了182%. 研究显示,石化废水中的乙酸盐等易降解成分是活性污泥耗氧速率抑制试验的重要干扰因素.      

Mg/Al金属氧化物的物化性质及吸附特性

为研究微波煅烧和常规煅烧下的Mg/Al金属氧化物的物化性质、吸附特性及机理,通过XRD(X射线衍射)、SEM(扫描电镜)、BET-BJH(比表面积-孔结构)和pH_ZPC(零电荷点)等表征手段分析了微波煅烧对水滑石结构、形貌、纹理性质及表面电荷性质的影响.结果表明:微波煅烧可获得结晶度更高、片状结构更规整的Mg/Al金属氧化物;微波煅烧使Mg/Al金属氧化物的比表面积由184 m2/g增至205 m2/g,孔容和孔径分别由0.245 cm3/g和2.15 nm增至0.263 cm3/g和2.19 nm;pH_ZPC由12.3增至12.6.微波煅烧和常规煅烧下的Mg/Al金属氧化物的对Cr(Ⅵ)吸附的ΔH(标准焓变)分别为42.86和41.23 kJ/mol,E_a(吸附活化能)分别为21.82和22.59 kJ/mol,二者的吸附过程均为化学吸附且受扩散控制,在该研究条件下的二者理论吸附量最大值分别为93.51和90.31 mg/g,微波煅烧提升了Mg/Al金属氧化物吸附能力,但并不显著;微波煅烧使得Mg/Al金属氧化物更易发生结构还原,其对Cr(Ⅵ)的吸附实质就是结构还原过程.研究显示,微波煅烧并没有改变Mg/Al金属氧化物吸附特性和机理.      

鄱阳湖沉积物有机磷形态及对水位变化响应

选取鄱阳湖枯水期不同高程出露表层沉积物,通过研究有机磷含量及形态差异,试图揭示江湖关系变化引起的水位下降对鄱阳湖沉积物有机磷潜在释放风险的影响.结果表明:1鄱阳湖枯水期表层沉积物有机磷含量(115.2~448.3 mg·kg-1)占总磷的19.3%~45.1%,有机磷含量空间分布呈"五河"入湖尾闾区高于湖心区和北部湖区.2鄱阳湖表层沉积物各形态有机磷含量大小顺序为:残渣态有机磷盐酸提取有机磷胡敏酸有机磷碳酸氢钠提取有机磷富里酸有机磷.3水位下降引起的沉积物出露时间延长是引起鄱阳湖不同高程沉积物有机磷形态变化的重要原因.沉积物出露时间越长,碳酸氢钠提取有机磷、盐酸提取有机磷与富里酸有机磷的含量越低,而胡敏酸有机磷和残渣态有机磷含量越高.同时,水位下降引起的沉积物出露时间延长致使活性有机磷和中活性有机磷占总有机磷比例下降,而非活性有机磷占总有机磷比例增加,反映了沉积物出露时间延长可能会促进有机磷形态由活性向非活性转化,在一定程度上能够降低沉积物有机磷的潜在性风险.     

低渗透性多孔介质室内弥散实验及弥散度求解研究

低渗透多孔介质在浅部含隔水层中分布广泛,是地下水污染物迁移的重要载体,然而其弥散度的取值目前研究还不足。针对此问题,以溴化钠为示踪剂开展了低渗透多孔介质的室内弥散实验研究,介质渗透系数为0．048 m/d,通过离子选择电极法测定溴离子浓度,并分别采用解析法和数值法进行了弥散度的求解,解析法和数值法求得的弥散度分别为0．0048 m 与0．0065 m,研究成果可以为低渗透多孔介质中污染物迁移预测提供弥散度值参考。     

可溶性有机质生物改性介导17β-雌二醇生物降解作用

利用元素分析、紫外-可见光谱、三维荧光指数对经过15d生物改性前后腐殖酸的组分和结构进行表征,并比较了生物改性前后3种腐殖酸对17β-雌二醇(E2)的结合作用;而且研究了结合后的腐殖酸介导微生物降解E2的影响.结果表明:经过元素分析后,生物改性前的腐殖酸OLHA、OLFA、OSHA和生物改性后的腐殖酸BLHA、BLFA、BSHA的(N+O)/C值分别为0.801、1.214、0.820和0.629、1.080、0.797;紫外-可见光谱分析生物改性前后的SUVA_(254)指数分别为0.146、0.023、0.073和0.179、0.036、0.011;生物改性前后荧光指数(FI)分别为:0.723、3.385、2.757和0.681、3.017、1.702.上述3种表征手段分析得出腐殖酸的极性是一致的,即改性后的腐殖酸要比改性前的腐殖酸极性小.此外,在30h内5mgC/L的腐殖酸生物改性前后对3mg/L的E2的结合效率分别为31.37%、4.96%、25.86%和37.78%、6.03%、29.92%,明显发现改性后的腐殖酸对E2的结合作用增强;5 mgC/L的腐殖酸生物改性前后对3mg/L的E2的30h内的生物降解效率分别为46.28%、15.96%、38.76%和51.11%、17.30%、44.33%,而且同等浓度下的腐殖酸对E2的结合作用越大其介导微生物降解E2的效果越好.     

Growth inhibition and oxidative damage of Microcystis aeruginosa induced by crude extract of Sagittaria trifolia tubers

Aquatic macrophytes are considered to be promising in controlling harmful cyanobacterial blooms. In this research, an aqueous extract of Sagittaria trifolia tubers was prepared to study its inhibitory effect on Microcystis aeruginosa in the laboratory. Several physiological indices of M. aeruginosa, in response to the environmental stress, were analyzed. Results showed that S. trifolia tuber aqueous extract significantly inhibited the growth of M. aeruginosa in a concentration-dependent way. The highest inhibition rate reached 90% after 6 day treatment. The Chlorophyll-a concentration of M. aeruginosa cells decreased from 343.1 to314.2 μg/L in the treatment group. The activities of superoxide dismutase and peroxidase and the content of reduced glutathione in M. aeruginosa cells initially increased as a response to the oxidative stress posed by S. trifolia tuber aqueous extract, but then decreased as time prolonged. The lipid peroxidation damage of the cyanobacterial cell membranes was reflected by the malondialdehyde level, which was notably higher in the treatment group compared with the controls. It was concluded that the oxidative damage of M. aeruginosa induced by S.trifolia tuber aqueous extract might be one of the mechanisms for the inhibitory effects.