Minimizing leakage from a smelter off-gas system by enhanced control

The off-gas handling system is a vital component of a smelter and it is essential that it operates in accordance with environmental regulations. A key feature of the off-gas management system is maintaining a slightly negative system pressure to prevent gas leakage, such as SO₂, out into the work and external environments. To enhance sustainable development, there is also growing interest in capturing and reusing the significant amount of heat and CO₂ contained within off-gas. The potential incorporation of heat and CO₂ recovery systems places importance on enhancing control to minimize the risk of both gas leakage and disturbance of the smelting process. With these requirements in mind, an easily implementable feedforward control enhancement to existing control schemes is proposed to help provide improved performance.     

“十二五”地表水国家环境监测网络吉林省水环境国控监测点位布设的构想

根据国家环境质量监测网络,对“十二五”地表水环境质量监测断面调整工作要求,吉林省在辖区内所有水环境质量监测断面及采样点基础上,完成了松花江流域和辽河流域国控监测断面的优化调整工作。在此过程中,如何从国家尺度上,既能充分反映吉林省水环境质量状况,又能满足国家对地表水环境管理需求进行了深入思考。本文以吉林省为例,在确定国控监测断面及采样点的布设中．提出了自己的构想和建议。     

Beyond hypoxia：Occurrence and characteristics of black blooms due to the decomposition of the submerged plant Potamogeton crispus in a shallow lake

Organic matter-induced black blooms(hypoxia and an offensive odor) are a serious ecosystem disasters that have occurred in some large eutrophic shallow lakes in China. In this study, we investigated two separate black blooms that were induced by Potamogeton crispus in Lake Taihu, China. The main physical and chemical characteristics, including color- and odor-related substances, of the black blooms were analyzed. The black blooms were characterized by low dissolved oxygen concentration(close to 0 mg/L), low oxidation-reduction potential, and relatively low pH of overlying water. Notably higher Fe2+and∑S2-were found in the black-bloom waters than in waters not affected by black blooms. The black color of the water may be attributable to the high concentration of these elements, as black FeS was considered to be the main substance causing the black color of blooms in freshwater lakes. Volatile organic sulfur compounds, including dimethyl sulfide, dimethyl disulfide, and dimethyl trisulfide, were very abundant in the black-bloom waters. The massive anoxic degradation of dead Potamogeton crispus plants released dimethyl sulfide, dimethyl disulfide, and dimethyl trisulfide, which were the main odor-causing compounds in the black blooms. The black blooms also induced an increase in ammonium nitrogen and soluble reactive phosphorus levels in the overlying waters. This extreme phenomenon not only heavily influenced the original lake ecosystem but also greatly changed the cycling of Fe, S, and nutrients in the water column.     

中国石化炼油企业QHSE管理体系典型建过程研究

总结了中国石化炼油企业构建QHSE管理体系的典型步骤和内容,描述了体系构建各阶段的工作和要求,并提出了构建QHSE管理体系过程中的关注要点.     

碱改性净水污泥对水中氨氮的吸附效能研究

采用氢氧化钠浸渍法改性净水污泥,研究了碱改性净水污泥对水中NH+4的去除性能.同时,考察了模拟废水pH、吸附剂投加量、NH+4初始浓度、吸附温度及吸附时间对吸附性能的影响.结果表明,当pH为弱酸性或中性,投加碱改性净水污泥20 g·L-1时,在室温下对初始浓度为50 mg·L-1的NH+4模拟废水振荡吸附120 min,可达到氨氮排放二级标准.将实验数据分别用吸附等温模型和动力学模型进行拟合,发现净水污泥对NH+4的吸附符合Langmuir模型和二级动力学模型,且净水污泥对氨氮的吸附包括静电吸引和离子交换两种作用机理.     

有限空间作业人员生理状态监测设备研制

为监测有限空间作业人员异常生理状况,进而保障有限空间作业安全与作业人员生命健康,在分析手腕处6个测量位置信号质量的基础上,获得最佳信号采集位置,并结合事故成因,从光电容积脉搏波(PPG)信号中提取心率、脉搏周期、振幅等生理参数作为评价指标,研制一款针对有限空间特殊作业人群的手腕处脉动生理信息监测设备;并进行系统稳定性测...     

黄孢原毛平革菌处理染料废水过程中细胞结构损伤效应研究

利用透射电子显微镜观察分析白腐真菌(黄孢原毛平革菌)在处理染料废水活性艳红X-3B过程中,染料和盐度对黄孢原毛平革菌的细胞结构产生的毒性作用.结果表明:活性艳红X-3B染料对黄孢原毛平革菌产生生物毒性作用,且随着染料浓度的增加,细胞受损伤程度不断加深.加入100 mg/L的染料活性艳红X-3B后,黄孢原毛平革菌菌丝细胞形态发生变化,出现质壁分离现象;染料浓度进一步加大,菌丝细胞超微结构受到损伤逐渐严重.染料废水中的盐度对黄孢原毛平革菌细胞也会造成损伤,且损伤程度随盐度增大而增大.NaCl浓度为3 g/L时,菌丝细胞发生质壁分离;而当NaCl加入量高于8 g/L时,细胞膜受损,线粒体、细胞核呈现空泡化,表现为受到不可逆的损伤.染料和盐双因子对黄孢原毛平革菌细胞的损伤效应表现为其损伤程度与单因子作用一致,且染料的影响作用占主导.     

温度和pH值对活性污泥法脱氮除磷的影响

温度和pH值是影响污水脱氮除磷效果的2个重要因素.试验采用连续搅拌槽式反应器(continuous stirred tank reactor,CSTR),通过对不同温度和pH值条件下的硝化、反硝化、释磷和吸磷反应速率的测定,总结出温度和pH值对活性污泥生化反应速率的影响规律.试验表明,硝化和反硝化速率随温度的升高而加快.在5℃和33℃时,硝化速率分别为0.01 kg NH4 -N/(kg VSS·d)和0.28 kg NH4 -N/(kg VSS·d);在5℃和30℃时,反硝化速率分别为0.097 kg NO3--N/(kg VSS·d)和0.476 kg NO3--N/(kg VSS·d);但温度对吸磷和释磷速率的影响不大.pH值对硝化、反硝化、吸磷和释磷速率均有显著影响,在pH值为7.74时,硝化速率为0.095 kg NO3--N/(kg VSS·d);而在pH值为4.9和10.08时,硝化速率仅为0.005 kg NO3--N/(kg VSS·d)和0.006 kg NO3--N/(kg VSS·d).在pH值为7.85时,反硝化速率达到最大值0.36 kg NO3--N/(kg VSS·d);而在偏酸性和碱性条件下,反硝化速率显著下降.     

Pig carcass composting using a forced aeration system during different seasons: a field study

Journal of Material Cycles and Waste Management - Composting has been recognized as an environmentally acceptable method for treating animal carcasses. This field-scale study was designed to...     

生物材料治理镉污染研究进展

近年来,生物材料以其经济、有效和无二次污染等特点,在重金属废水处理和土壤修复方面显示出了众多的优势·可替代传统的镉污染处理方法.综述了目前国内外生物材料在处理镉污染方面的研究进展,并对今后应用生物材料治理镉污染提出了一些建议.