印刷用铝基材碱洗废液的循环利用

对印刷用铝基材碱洗废液进行了循环利用研究。首先将高COD含量的碱洗废液进行除油脱色处理,通过石灰和硬脂酸的协同效应,使COD含量从26300mg／L降至480mg／L,色度降至60°;然后利用含铝碱性废液通过碳化法制备出结晶度66％的拟薄水铝石产品;最后对分离后的碱性废水按配方要求配制,对铝基材进行除油实验,经5次循环表明,除油效果和对铝基材的腐蚀率均100％达标。     

Controlled release and retarded leaching of pesticides by encapsulating in carboxymethyl chitosan /bentonite composite gel

A novel composite gel composed of carboxymethyl-chitosan (CM-chit) and bentonite (H-bent) was used as the carrier for encapsulating atrazine and imidacloprid to control their release in water and retard their leaching in soil. Strong interactions between CM-chit and H-bent in the composite were confirmed by FT-IR, and good dispersion of pesticides in the carrier was observed by SEM. According to the results of release experiments in water, the CM-chit/H-bent composite carrier showed double advantages of both encapsulation by the polymer and sorption by the bentonite. The time taken for 50 % of active ingredients to be released, t ₅₀, was prolonged to 572 h for atrazine and 24 h for imidacloprid, respectively. The difference between the two pesticides on release behavior was related to their hydrophobicity and water solubility. Leaching experiments through a soil layer showed that this novel carrier reduced the amount of pesticides available for leaching, and would be useful for diminishing the environmental pollution of pesticides.     

八羟基喹啉改性膨润土预处理养殖废水

以八羟基喹啉为改性剂,天然膨润土为原料,制备一种新型吸附剂,并将其应用于养殖废水的预处理中。确定了改性膨润土的最佳制备条件:土液比为4 g/L,改性剂浓度为0.3 g/L,改性时间为50 min,改性温度为50℃。并以扫描电镜方法对改性膨润土行进表征:八羟基喹啉已经有效进入层间,改变了膨润土的性状,提高了吸附效果。优化了改性膨润土处理养殖废水的工艺条件:投土量为1 g/L,pH为4,搅拌时间为30 min,搅拌速度为350 r/min,沉淀时间为40 min。在此优化条件下,改性膨润土对养殖废水的COD去除率最高可达79.18%,且吸附动力学结果满足二级动力学模型。     

微波辅助Fe-H2O2联合处理罗丹明B废水

对微波辅助Fe-H2O2联合处理罗丹明B废水进行了研究,分别考察了废水pH、H2O2加入量、铁粉加入量、初始罗丹明B质量浓度以及反应时间等因素对罗丹明B去除率的影响。实验结果表明,对于100mg/L的罗丹明B废水,当加入50mg/L铁粉、10.0mL/LH2O2,反应12min后,罗丹明B去除率达到98.7%,并且拓宽了反应的pH范围。     

Effects of bulking agent addition on odorous compounds emissions during composting of OFMSW

The effects of rice straw addition level on odorous compounds emissions in a pilot-scale organic fraction of municipal solid waste (OFMSW) composting plant were investigated. The cumulative odorous compounds emissions occurred in a descending order of 40.22, 28.71 and 27.83 mg/dry kg of OFMSW for piles with rice straw addition level at ratio of 1:10, 2:10 and 3:10 (mixing ratio of rice straw to OFMSW on a wet basis), respectively. The mixing ratio of rice straw to OFMSW had a statistically significant effect on the reduction of malodorous sulfur compounds emissions, which had no statistically significant effect on the reduction of VFAs, alcohols, aldehydes, ketones, aromatics and ammonia emissions during composting, respectively. The cumulative emissions of malodorous sulfur compounds from piles with the increasing rice straw addition level were 1.17, 1.08 and 0.88 mg/dry kg of OFMSW, respectively. The optimal mixing ratio of rice straw to OFMSW was 1:5. Using this addition level, the cumulative malodorous sulfur compounds emissions based on the organic matter degradation were the lowest during composting of OFMSW.     

曝气量和曝气时长对好氧颗粒污泥活性恢复的影响

采用啤酒废水,在SBR中对在4℃的冰箱中储存8周的好氧颗粒污泥进行活性恢复。设置曝气时长分别为150 min和270 min,曝气量分别为0.1 m3/h和0.2 m3/h,考察了曝气时长和曝气量对好氧颗粒污泥活性恢复的影响。实验结果表明,好氧颗粒污泥在4℃冰箱中储存8周后,其颜色、粒径无明显变化;设置较长曝气时间(270 min)、较大曝气量(0.2 m3/h)时,颗粒污泥平均沉降速率、MLSS和SVI恢复最快,且对COD处理效果也恢复较快。而短曝气时间(150 min)、小曝气量(0.1 m3/h)有利于好氧颗粒污泥对氨氮去除效果的恢复。     

PVDF/PMMA与PVDF/TPU共混膜抗污染性能研究及应用

观察新型五孔PVDF共混改性纤维膜SEM形貌特征,采用逐级通量法测定PVDF/PMMA和PVDF/TPU共混改性膜的临界通量,研究在次临界和超临界通量下A(PVDF/PMMA)与B(PVDF/TPU)2种管式膜组件的过滤和抗污染性能,并在次临界通量下处理地表水。结果表明,PVDF共混改性膜具有优良的微观结构,且膜B性能较好;膜A、B的临界通量分别为12 L/(m2.h)和10 L/(m2.h);膜组件B比膜组件A抗污染性能好。次临界通量下膜组件的运行比超临界通量下的稳定。与采用单独超滤处理某市地表水相比,2种膜组件采用混凝+超滤工艺的运行处理效果更好,且膜组件B比膜组件A处理效果佳。     

Ozonation of azo dye Acid Red 14 in a microporous tube-in-tube microchannel reactor: decolorization and mechanism

Despite the great success of time-weighted average passive sampling of hydrophobic contaminants, such as PCBs and PAHs, the sampling of polar organic compounds still presents a challenge because the equilibrium between water and most sampling phases is attained in a relatively short time. In this study, we proposed a new time-integrative sampler using in situ solvent extraction (TISIS) for polar organic chemicals. The sampler was composed of a 15 cm poly(dimethylsiloxane) (PDMS) tubing, with an internal diameter of 0.5 mm and wall thickness of 0.5 mm, through which an extraction solvent (acetonitrile) was passed. Four polar organic contaminants, caffeine, atrazine, diuron and 17α-ethynylestradiol, were chosen for the evaluation of the performance of the sampler. Without the use of in situ solvent extraction, the PDMS tubing when exposed to a constant aqueous concentration of the four model compounds was able to linearly accumulate those compounds for less than 12 h and equilibrium between the PDMS tubing and water was attained in 2 d under our laboratory conditions. However, TISIS when exposed to a constant aqueous concentration was able to linearly accumulate all the model compounds without any exposure time limitation. The measured sampling rates at three different extraction flow rates (0.2, 0.5, 1.5 mL min⁻¹) were similar, regardless of the chemicals, indicating that the overall mass transfer from aqueous solution to the extraction solvent was most likely dominated by partitioning to the PDMS tubing and the internal diffusion within PDMS. In addition, a pulsed exposure experiment confirmed that TISIS operated in a time-integrative mode when the environmental concentration was highly fluctuated.     

玉米秸秆添加比例对污泥堆肥中Cu和Zn形态的影响

采用BCR连续提取法研究了玉米秸秆添加比例对污泥堆肥中Cu和Zn形态的影响.结果表明:重金属不同形态分配比例的变化能够准确反映重金属形态之间的转化规律;堆肥处理重金属总量不会变化,只是不稳定形态之间相互转化,Cu和Zn被大幅"浓缩",玉米秸秆比例越大,"浓缩效应"越明显;玉米秸秆比例增加有助于酸溶态Cu向可氧化态转化,...     

新型五孔超滤膜处理城市污水的研究

新型五孔中空纤维膜与传统的城市污水处理系统集成处理城市污水.结果表明:COD、NH3-N和TP的平均去除率分别为95.66%、99.02%和81.08%,出水UV254＜0.2 cm,BOD5＜2 mg/L,平均浊度为0.10 NTU,未检测出粪大肠杆菌和SS;出水水质可达到回用水要求,可省略后续的深度处理工艺,彻底消...