Modeling and model performance evaluation of sewage sludge gasification in fluidized-bed gasifiers using Aspen Plus

A model was developed to simulate the sewage sludge gasification in an atmospheric fluidised bed gasifier using Aspen Plus. The model here presented was based on the Gibbs free energy minimisation and the restricted equilibrium method was used to calibrate it against previously published experimental data obtained in a lab-scale gasification plant. A sensitivity analysis of the model was carried out by modifying parameters such as the temperature, equivalence ratio (ER) and the steam-to-biomass ratio. The modeled results were in good agreement with the experimental data (especially when air was used as gasifying agent) and reproduced satisfactorily the experimental trends found for the gas composition, the carbon conversion (Xc) and the cold gas efficiency (CGE) under different gasification conditions. Operating at higher temperatures increased the production of H₂ and CO, as well as the Xc and the CGE. The increase in ER produced higher Xc, yet the CGE experienced slight changes due to a decrease in the lower heating value of the resulting syngas, as well as the oxidation of combustible gases. The use of air+steam as gasifying agent increased the H₂ content of the produced gases but decreased the accuracy of the model.

Implications: Gasification is an available alternative to produce energy as well as several raw materials from sewage sludge. The syngas obtained from this technology totally depends on the type of gasifier and the operation conditions, which can be optimized with the help of models. In this work, a relatively simple model was built using ASPEN PLUS. Despite its simplicity, the outputs of the model are in good agreement with experimental results what makes its use interesting for assessing scaling-up possibilities from lab-scale to pilot-scale gasification processes.     

Hepatitis E Virus (Genotype 3) in Slurry Samples from Swine Farming Activities in Italy

Hepatitis E virus (HEV) is an emergent causative agent of acute hepatitis, transmitted by fecal–oral route. Infection with HEV is a global cause for morbidity and mortality throughout the world: it mainly causes large outbreaks in endemic areas and sporadic autochthonous cases in industrialized countries where HEV infections seem to be an emergent zoonotic disease. Infection of porcine livestock and its relationship with the human cases have been demonstrated. The present study describes an investigation on the prevalence and diversity of HEV in pig slurry in Italy. Slurry samples (24) were collected from ten farms located in North Italy during 2015 and analyzed for HEV, using four broad-range nested PCR assays targeting ORF1 (MTase), ORF2 (capsid) genes, and ORF2/3 regions. Overall, 18 samples (75%) were positive for HEV RNA, and characterized as genotype 3. Nine samples could be subtyped by ORF2 sequencing: Eight belonged to subtype 3f, while one sequence could not be characterized by blast analysis and phylogenetic analysis and may actually represent a new subtype. Furthermore, similarity of 99% was found between 3f Italian HEV sequences of human and swine origins. Real-Time PCR assay was also performed, in order to obtain quantitative data on positive samples. Two swine slurry samples were positive, containing 600 and 1000 UI per mL of sewage. The results of this study show that HEV strains belonging to zoonotic genotype 3 are widely present in swine excreta, and have high degree of identity with strains detected in autochthonous HEV cases. Improving swine farming operations safety and increasing operators’ awareness of the zoonotic potential connected with the handling of swine effluents turn out to be key points in order to reduce the environmental and sanitary problem represented by the possible dissemination of HEV to water bodies.     

Integrated waste management in a zone of northern Italy: compost production and use, and analytical control of compost, soil, and crop

Agricultural soils of two Italian maize farms were treated for five years with an industrially produced high-quality compost. Cattle manure and the usual mineral fertilizer were used for comparison purposes. The effects of the organic and mineral fertilizer treatments were studied by analyzing the compost and manure, cultured soils, and harvested material. The grain yield was also determined. Organic fertilization improved soil pH, CEC, content of organic matter and NPK. Soil respiration and N mineralization were found to be higher than in the purely mineral-treated soil. Plant K take-up was improved, whereas grain yield was not affected. It was confirmed that organic fertilization, particularly compost use, maintained and increased soil fertility. The study demonstrated the feasibility of using in loco analytical facilities to follow the entire recycling process-from waste to compost production-and the use of the final product in the field.     

Evaluation of a model for leaf to fruit transfer of radionuclides in processing tomato plants using an independent set of data

Because of their varied possibilities of consumption, tomatoes are an important component of the human diet. This paper presents results of the evaluation of a dynamic model (Ventomod) for the short-term behaviour of radionuclides deposited on tomato plants following a direct contamination event. To check its forecasting capability in assessing the risk of radionuclide contamination of the human diet, it has been tested with an independent dataset on the leaf to fruit transfer of 134Cs in a typical Hungarian tomato variety, "Dwarf of Kecskemet". Data obtained from this pot experiment were used to evaluate model behaviour. Model constants were varied according to the differences between the Hungarian dataset and the one used to calibrate it. Results show that the model output well reproduces the observed activity of fruits for various levels of contamination and at different contamination dates. The main part of this report summarises the experimental protocol, compares the experimental results with model predictions generated by Ventomod and makes recommendations for both updating model parameters and undertaking further experimental work.     

Cesium-134 and strontium-85 in strawberry plants following wet aerial deposition

The understanding of the processes that control the behavior of radionuclides in crops can support policymakers to take actions to protect the environment and safeguard human health. Data concerning the behavior of radionuclides in fruits are limited. Strawberry (Fragaria x ananassa Duchesne) plants were contaminated on the aboveground part by sprinkling an aqueous solution of 134Cs and 85Sr at three growing stages: predormancy, anthesis, and beginning of ripening. Intercepted activity was more affected by the posture and physical orientation of leaves rather than by leaf area or biomass. Fruit interception ranges from 0.2 to 1.2% of the sprinkled activity. Translocation coefficients from leaf to fruit are on the order of 10(-4) for 134Cs and 10(-5) for 85Sr. Translocation reaches its highest intensity between anthesis and ripening. If deposition occurs when plants are bearing fruits, the fruit activity will be affected by the activity initially deposited on the fruit surfaces. This is important for 85Sr as it is not translocated in the phloem. The loss of the dead leaves at the resumption of growth causes high plant decontamination, but a fraction of both radionuclides remains in the storage organs, roots, and shoots, which is retranslocated to fruits in the following spring. The values of the environmental half-time, t(w), after deposition at predormancy are 114 d for 134Cs and 109 d for 85Sr. Cesium-134 tends to be allocated to fruits, while 85Sr remains in leaves and crowns. Translocation of radionuclides to roots results in soil contamination.     

Ozone differentially affects physiological and biochemical responses of two clover species; Trifolium repens and Trifolium pratense

The effect of acute ozone exposure (150 ppb for 3 h) on two clover species, white clover (Trifolium repens L.) and red clover (Trifolium pratense L.) was investigated through the analysis of 10 different physiological and biochemical parameters. Twenty-four hours after fumigation, visible symptoms of injury on leaves were observed only in red clover, but from the biochemical point of view, both species revealed significant ozone-induced modifications. A decrease in the photosynthetic efficiency as well as an increase in the de-epoxidation index and a decrease in the redox state of ascorbate were detected only in T. pratense leaves; no significant change in pigment content was found in either of the two species. On the other hand, both white and red clover showed, although to different extents, significant decreases in the activities of the antioxidant enzymes peroxidase and ascorbate peroxidase. Multivariate statistical analysis revealed not only that ozone affects both species, but also that they differentially respond to the pollutant, confirming the higher sensitivity of Trifolium pratense to ozone exposure.     

Alternatives to gas flaring: a multi-criteria decision approach applied to a case study in Russia

During recent years, the issue of gas flaring has become an increasingly relevant problem for the international community. The claim to more sustainable development offers a renewed prospective in the observation of gas flaring and emphasizes that recovering the associated gas could induce economic, environmental and social benefit. The true core of the issue, as is widely accepted, is not a lack of appropriate technologies, but in the number of criteria involved, which makes it difficult to identify a list of alternatives and connecting all the involved stakeholders in the negotiation process. The complexity of this problem can be mitigated using a decision-making method. The objective of the present work is to identify and formulate a supportive decision system based on the Analytic Hierarchy Process. Application of the model to a real case underlines the strengths and weaknesses of the model, leading to the conclusion that a selection of the most sustainable alternatives needs to be based on a number of criteria that need to be recognized and agreed amongst the stakeholders.