Influence of coagulation mechanisms and floc formation on filterability

Minimizing particles in water is a key goal for improving drinking water quality and safety.The media filtration process,as the last step of the solid–liquid separation process,is largely influenced by the characteristics of flocs,which are formed and controlled within the coagulation process.In a laboratory-based study,the impacts of the physical characteristics of flocs formed using aluminum sulfate on the filtration treatment of two comparative water samples were investigated using a photometric dispersion analyzer and a filterability apparatus.In general,the optimum dosage for maximizing filterability was higher than that for minimizing turbidity under neutral p H conditions.For a monomeric aluminum-based coagulant,the charge neutralization mechanism produced better floc characteristics,including floc growth speed and size,than the sweep flocculation mechanism.In addition,the charge neutralization mechanism showed better performance compared to sweep flocculation in terms of DOC removal and floc filterability improvement for both waters,and showed superiority in turbidity removal only when the raw water had high turbidity.For the different mechanisms,the ways that floc characteristics impacted on floc filterability also differed.The low variation in floc size distribution obtained under the charge neutralization mechanism resulted in the flocs being amenable to removal by filtration processes.For the sweep flocculation mechanism,increasing the floc size improved the settling ability of flocs,resulting in higher filter efficiency.     

LNG储罐安全阀泄漏分析与故障排查

针对16×10~4m~3LNG储罐安全阀泄漏问题,从阀门结构角度对泄漏原因进行了详细的分析,认为主要有三种可能:(1)导阀失效;(2)上阀腔漏气;(3)阀座密封不严。根据分析结论,提出了故障排查的方法以及操作步骤;结合阀门解体检查情况,建立了阀门失效的故障树,从投产、阀门运行维护角度提出了相关建议。     

酸性水储罐安全性研究

为预防酸性水储罐气相空间闪爆事故的发生,取样分析了某炼厂酸性水罐气相空间组成,根据气相组成配制了3种混合可燃气体,利用5 L爆炸极限测试仪测定了混合可燃气体在不同氧含量条件下的爆炸极限,根据爆炸极限数据计算出3种混合可燃气体的极限氧含量。结果表明:随着体系中氧含量增加,爆炸上限明显升高,爆炸下限无明显变化;烃类物质含量高时,混合可燃气体的爆炸上下限均降低,爆炸极限宽度变小;硫化氢和氢气含量高时,混合可燃气体爆炸上下限均升高,爆炸极限宽度变大;3种气相组成的极限氧含量分别为:8.1%、9.9%和10.3%,为防止罐顶气相组成发生闪爆,建议氧含量浓度控制在4%以内,当氧含量浓度到达5%时建议启动氮气联锁进行惰化和稀释。     

微电解-生化法处理大蒜废水工程实例

针对大蒜废水特点,采用了铁屑微电解-UASB-接触氧化工艺进行处理.运行结果表明:在设计进水水质、水量范围内,COD、BOD5、氨氮和ss去除率分别为98%、99%、70%和98%,出水各项指标均达到GB 8978--1996<污水综合排放标准>中的一级排放标准,系统运行费用为1.19元/m3.     

可再生胺类脱硫剂的选择研究

采用哌嗪等二元胺和二乙醇胺为吸收剂,对模拟烟气进行SO2的吸收解吸实验研究,筛选出性能优异的吸收剂,并考察添加剂H2 S O 4对其性能的影响。实验表明:可再生胺类吸收剂脱硫率可接近100%,二元胺吸收剂较醇胺的SO 2吸收量大、pH值随时间变化慢、首次解吸率高;羟乙基支链对胺类吸收剂的抗氧化能力、SO2吸收量和首次解吸率均有影响,环状二元胺比链状二元胺的抗氧化能力好、首次解吸率高;在N-(2-羟乙基)哌嗪溶液中添加硫酸构成N-(2-羟乙基)哌嗪/H 2S O 4脱硫体系后,脱硫率未受影响、SO2吸收量变小、首次解吸率显著提高,具有更好的循环使用性能。     

不同气源压缩气体泡沫灭石油醚火灾性能比较

采用实验室压缩气体泡沫系统,通过缩尺油盘火试验,分别考察基于不同气源的压缩气体泡沫对于石油醚火灾的灭火性能,分析探讨适用于低沸点的石油醚类燃料火灾扑救的气源类型和供气方案。结果表明,在泡沫溶液供给强度为2.5 L/(min·m2)的条件下,压缩氮气泡沫和压缩空气泡沫均可扑灭石油醚火灾,具有良好的抗烧性能;二者相比,压缩氮气泡沫比压缩空气泡沫的控灭火性能和抗烧性能均有一定提升;对于石油醚类的低沸点易燃液体火灾,建议采用以氮气作为气源的压缩氮气泡沫系统;该研究可为压缩气体泡沫系统在石油化工行业工程应用提供技术支撑。     

Removal of trace Cr(VI) from aqueous solution by porous activated carbon balls supported by nanoscale zero-valent iron composites

Environmental Science and Pollution Research - In this study, porous activated carbon balls supported by nanoscale zero-valent iron composites (Fe@PACB-700) were used for the first time for the...     

Soil labile and recalcitrant carbon and nitrogen dynamics in relation to functional vegetation groups along precipitation gradients in secondary grasslands of South China

Environmental Science and Pollution Research - Soil labile and recalcitrant carbon (C) and nitrogen (N) are strongly controlled by plant inputs and climatic conditions. However, the interrelation...     

应用T-RFLP技术研究五氯酚对好氧颗粒污泥中细菌组成的影响

研究了五氯酚(PCP)对好氧颗粒污泥处理生活污水的影响,借助末端限制性酶切片段长度多态性(T-RFLP)技术考察了PCP存在时好氧颗粒污泥细菌组成的变化.结果表明,PCP对氨氮去除率的影响大于对COD去除率的影响,好氧颗粒污泥中微生物的种群数量随着PCP浓度的增加而逐渐减少,氨氮和COD去除率的变化与微生物种群数量变化相吻合.根据对PCP的敏感程度,好氧颗粒污泥中的微生物可分以下几类:①对PCP高度敏感的微生物,可能是Microbacterium或Streptococcus等以及2种未被报道的菌种;②对PCP中度敏感的微生物,可能是Corynebacterium或Nevskia等以及1种未被报道的菌种;③对PCP低度敏感的微生物,可能是Mycoplasma或Exiguobacterium等以及1种未被报道的菌种;④对PCP耐受性强的微生物,这类微生物主要是13个末端限制性片段(69、71、82、175、198、241、229、232、233、240、245、269、449bp)所代表的微生物,PCP浓度为30mg/L时,长度为82bp和175bp的片段的相对面积分别22.7%和13%,所代表的微生物已经演替为优势菌群.     

超重力技术治理火炸药行业氮氧化物的初步研究

火炸药行业排放氮氧化物(NOX)具有浓度高、排放点不集中和间歇排放的特点,采用超重力技术对尾气中高浓度的NOX进行湿法吸收.以清水为吸收剂,研究了进气量、液气比和超重力因子等因素对NOX吸收率的影响.结果表明,单级NOX吸收率可达64.69%(β＝90).超重力旋转填料床具有占地面积小、投资低和操作方便等优点,适宜于火炸药行业吸收NOX.